2019 CITROEN BERLINGO VAN bonnet

187
Opening
F Open the left-hand front door.
F
P
ull the release lever, located at the bottom
of the door aperture, towards you.
F

L
ift the safety catch and raise the bonnet. F

U
nclip the stay
from its housing
and place it in the
support slot to hold
the bonnet open.
Closing
F Take the stay out of the support slot.
F C lip the stay in its housing.
F

L
ower the bonnet and release it near the
end of its travel.
F

P
ull on the bonnet to check that it is fully
latched.
Because of the presence of electrical
equipment under the bonnet, it is
recommended that exposure to water
(rain, washing, etc.) be limited.
Engines
Petrol
Diesel
These engines are examples provided as a
guide.
The locations of the dipstick and engine oil filler
cap may vary.
1. Screenwash fluid reservoir.
2. Engine coolant reservoir.
3. Brake fluid reser voir.
4. Battery.
5. Fusebox.
6. A i r f i l t e r.
7. Engine oil dipstick.
8. Engine oil filler cap.
Checking levels
Check all of these levels regularly, in line with
the manufacturer's service schedule. Top them
up if necessary, unless other wise indicated.
If a level drops significantly, have the
corresponding system checked by a CITROËN
dealer or a qualified workshop.The Diesel circuit is under very high
pressure.
All work on this circuit must be carried out
only by a CITROËN dealer or a qualified
workshop.
The liquid must comply with the
manufacturer's recommendations and with
the vehicle's engine.
7
Practical information

188
Take care when working under the bonnet,
as certain areas of the engine may be
extremely hot (risk of burns) and the
cooling fan could start at any time (even
with the ignition off).
Used products
Avoid prolonged contact of used oil or
fluids with the skin.
Most of these fluids are harmful to health
or indeed very corrosive.Do not discard used oil or fluids into
sewers or onto the ground.
Take used oil to a CITROËN dealer or a
qualified workshop and dispose of it in
the containers reser ved for this purpose.
Engine oil level
The check is carried out either when
the ignition is switched on using the
oil level indicator in the instrument
panel for vehicles equipped with an
electric gauge, or using the dipstick. To ensure that the reading is correct, your
vehicle must be parked on a level sur face
with the engine stopped for more than
30


minutes.
It is normal to top up the oil level between
two ser vices (or oil changes). CITROËN
recommends that you check the level, and top
up if necessary, every 3,000 miles (5,000 km).
Checking using the dipstick
The location of the dipstick is shown in the
corresponding underbonnet layout view.
F

T
ake the dipstick by its coloured grip and
pull it out completely.
F

W
ipe the end of the dipstick using a clean
non-fluffy cloth.
F

R
efit the dipstick and push fully down, then
pull it out again to make the visual check:
the correct level is between marks A and B .A = MA X
B = MIN
If you find that the level is above the A mark or
below the B mark, do not star t the engine .
- I f the level is above the MAX mark (risk of
damage to the engine), contact a CITROËN
dealer or a qualified workshop.
-

I
f the level is below the MIN mark, you must
top up the engine oil.
Oil grade
Before topping up the oil or changing the oil,
check that the oil is the correct grade for your
engine and conforms to the manufacturer's
recommendations.
Topping up the engine oil level
The location of the oil filler cap is shown in the
corresponding underbonnet layout view.
Practical information

196
Running out of fuel
(Diesel)
On vehicles fitted with Diesel engines, the fuel
system must be primed if you run out of fuel.
If the engine does not start first time, do not
keep trying, but start the procedure again from
the beginning.For more information on Misfuel
prevention (Diesel) , refer to the
corresponding section.
BlueHDi engines
F Fill the fuel tank with at least five litres of Diesel fuel.
F

S
witch on the ignition (without starting the
engine).
F

W
ait around 6 seconds and switch off the
ignition.
F

R
epeat the operation 10 times.
F

O
perate the starter to run the engine.
Other engines
F Fill the fuel tank with at least five litres of Diesel fuel.
F

O
pen the bonnet.
F

I
f necessary, unclip the cover to access the
priming pump. F

O
perate the priming pump
repeatedly until resistance is felt
(there may be resistance on the
f i r st p r e s s).
F
O
perate the starter to start the engine (if the
engine does not start at the first attempt,
wait around 15 seconds before trying
again).
F
I
f the engine does not start after a few
attempts, operate the priming pump again
then start the engine.
F
P
ut the cover back in place and clip it in.
F
C
lose the bonnet again.
Tool kit
Access to the tools
With temporary puncture repair
kit
The kit is located under the right-hand front
seat.
With spare wheel
The jack is located under the right-hand front
seat.
The tools are located under the left-hand front
seat.
Details of the tool kit
1.
Chock to immobilise the vehicle.
2. Removable towing eye.
3. To r x k e y.
Permits removal of the rear lamps in order
to change a bulb.
F

F

or easier access, move the seat(s)
forward.
In the event of a breakdown

205
Light-emitting diodes (LED)
For the replacement of this type of bulb,
you must contact a CITROËN dealer or a
qualified workshop.
Halogen bulbs
To ensure good quality lighting, check
that the bulb is correctly positioned in its
housing.In some weather conditions (e.g. low
temperature or humidity), the presence
of misting on the internal sur face of the
glass of the headlamps and rear lamps is
normal; it disappears after the lamps have
been on for a few minutes.
Types of bulb
Various types of bulb are fitted to your vehicle.
To remove them:
Ty p e A
Ty p e B Ty p e C
Ty p e D
Halogen bulbs must be changed with the
lamp off for a few minutes (risk of severe
burns). Do not touch the bulb directly, use
a lint-free cloth.
When each operation has been
completed, check the operation of the
lighting.
All glass bulb: pull gently as it is fitted by
pressure.
Bayonet bulb: press on the bulb then turn it
anti-clockwise. Halogen bulb: release the retaining spring from
its housing.
Halogen bulb: turn the bulb anti-clockwise.
Opening the bonnet /Access to bulbs
With the engine warm, proceed with
caution – risk of burns!
Take care with objects or clothing that
could be caught in the blades of the
cooling fan – risk of strangulation!
After changing a bulb
When refitting, close the protective cover
very carefully to guarantee the sealing of
the lamp.
8
In the event of a breakdown

214
Access to the battery
The battery is located under the bonnet.
F O pen the bonnet using the interior release
lever, then the exterior safety catch.
F

S
ecure the bonnet stay.
For more information on the Bonnet and
the Engine , refer to the corresponding
sections.
Starting using another
battery
When your vehicle's battery is flat, the engine
can be started using a backup battery (external
or from another vehicle) and jump leads or a
battery booster. Never try to start the engine by connecting
a battery charger.
Never use a 24
V or higher battery
b o o s t e r.
First check that the backup battery has
a nominal voltage of 12 V and a capacity
at least equal to that of the discharged
battery.
The two vehicles must not be in contact
with each other.
Switch off all the electrical consumers
on both vehicles (audio system, wipers,
lighting, etc.).
Make sure that the jump leads are not
close to moving parts of the engine (fan,
belts, etc.).
Do not disconnect the (+) terminal while
the engine is running.
The battery (-) terminal is not accessible.
A remote earth point is provided at the front of
the vehicle. F
S
tart the engine of the vehicle with the
good battery and leave it running for a few
minutes.
F
O
perate the starter on the broken down
vehicle and let the engine run.
If the engine does not start straight away,
switch off the ignition and wait a few moments
before trying again.
F
W
ait for it to return to idle.
F
D
isconnect the jump lead cables in reverse
order .
F
A
llow the engine to run for at least
30 minutes, by driving or with the vehicle
stationary, so that the battery reaches an
adequate state of charge.
Some functions, including Stop & Start,
are not available if the battery is not
sufficiently charged.
F
C
onnect the red cable to the (+) terminal of
flat battery A (at the metal elbow), then to
the (+) terminal of backup battery B or the
b o o s t e r. F

C
onnect one end of the green or black
cable to the (-) terminal of backup battery
B or the booster (or an earth point on the
other vehicle).
F
C
onnect the other end of the green or black
cable to earth point C on the broken down
vehicle.
In the event of a breakdown

226
Identification markings
Different visible markings for the identification
and localisation of your vehicle.
A. Vehicle Identification Number (VIN),
under the bonnet.
This number is engraved on the chassis near
the right-hand front wheel arch.
B. Vehicle Identification Number (VIN) on
the windscreen lower cross member.
This number is recorded on a label, visible
through the windscreen.-

t
he vehicle identification number (VIN),
- t he maximum authorised weight (gross
vehicle weight),
-

t
he maximum authorised weight with trailer
(gross train weight),
-

t
he maximum weight on the front axle,
-

t
he maximum weight on the rear axle.
D. Tyre/paint label.
This label on the middle door pillar, driver's
side, contains the following information:
-

t
he tyre pressures, unladen and laden,
-

t
he tyre sizes (including the load index and
speed rating),
-

t
he spare tyre inflation pressure,
-

t
he paint colour code.The vehicle may be originally equipped
with tyres with higher load and speed
indices than those indicated on the label,
without affecting inflation pressure.
C. Manufacturer's label.
This tamperproof label on the middle door
pillar, right or left-hand side, contains the
following information:
-

t
he name of the manufacturer,
-

t
he European Whole Vehicle Type Approval
number,
Technical data

227
AABS ........................................................................\
.... 94
Accessories ........................................................ 91,
1 25
Access to the 3rd row
................................................. 61
Access to the spare wheel

......................................2

01
Active Safety Brake
.................................... 18,

15
6 -15 8
AdBlue
® ................................................. 23, 31, 19 2-193
AdBlue® tank ............................................................ 193
Additive, Diesel ................................................... 21,
19 1
Adjusting headlamp beam height
............................. 87
Ad

justing head restraints
.......................................... 62
Ad

justing seats
.................................................... 56,


61
Ad

justing the air distribution .................................71
-7

2
Adjusting the air flow


............................................ 71
-7

2
Adjusting the date
........................................... 36,


17,


32
A

djusting the height and reach of the steering wheel


......................................................... 53
Adjusting the lumbar support


.................................... 56
Adjusting the temperature
.................................... 71-7

2
Adjusting the time
.......................................... 36,


17,


33
Adv

anced Grip Control ......................................... 97
-
9
8
Advice on driving


.............................................. 120 -121
Airbags


............................................... 19,

10
3,

10
5,

10
7
Airbags, curtain
............................................... 10

5,

10
8
Airbags, front


..................................... 104 -105,

10
7-108
Airbags, lateral


................................................. 104 -105
Air conditioning


.............................................. 71,

72,


75
A

ir conditioning, automatic

....................................... 79
Air conditioning, dual-zone automatic


.................71
-7

2
Air conditioning, electronic (with display screen)
...... 75
A

ir conditioning, manual

..........................70
-71,


74,


79
A

ir intake

............................................................... 71
-7

3
Alarm


.................................................................... 49,

51
A

nti-lock braking system (ABS) ................................94
Anti-slip regulation (ASR)


......................................... 94
Anti-theft/Immobiliser


.............................................. 126
Apple CarPlay connection


................................... 12,

18
A

rmrest

...................................................................... 57
Armrest, front


............................................................. 63
Assistance, emergency braking


.......................94,

15
8
Assistance call ...................................................... 92 -9 3
Audio streaming (Bluetooth) ........................9,
9,
2 5- 26
BBattery .............................................. 185, 19 0, 21 3 -216
Battery, 12 V .............................................................213
Battery, charging
...................................................... 2

15
Battery, remote control


..................................44
-45,


78
B

lind spot detection

......................................... 162,

16
4
BlueHDi
.............................................................. 31,


19
6
Bluetooth (hands-free)


...................1 0
-11,


1
3
-
14,

2
7 -
2
8
Bluetooth (telephone)


................................13
-

15,

2
7 -
2
8
Bonnet


............................................................... 18 6 -187
Boot lid
................................................................. 40,

43
B

rake discs

....................................................... 191-192
Brake lamps


............................................................. 209
Brakes


......................................................... 14,

19
1-192
Braking, automatic emergency


..................18,

15
6 -15 8
Braking, emergency


................................................ 129
Braking assistance system


.......................................94
Brightness


................................................................... 16
Bulbs


........................................................................\
205
Bulbs (changing)


............................................... 204-206
Bulbs (changing, type)
............................................. 20

5
CCable, audio ............................................................... 25
Cable, Jack ................................................................ 25
C
ap, fuel filler .................................................... 18 0 -181
Capacity, fuel tank


............................................ 18 0 -181
CD


...................................................................... 9,

9,


25
C

D, MP3
............................................................ 9,


9,


25
C

entral locking

..................................................... 38,

40
C

hanging a bulb
............................................... 20

4-208
Changing a fuse
................................................ 21

1-213Changing a wheel
.....................................
19
6 -197
,
20
0
Changing a wiper blade

.......................................
88
-89
C
hanging the remote control battery ........................
44
Charger, wireless ....................................................... 66
Checking the engine oil level

....................................
30
Checking the levels

..........................................
187-189
Checking tyre pressures (using the kit)

...........
197-19 9
Checks

......................................................
187,
19
0 -192
Checks, routine ................................................. 19 0 -192
Child lock

..................................................................
11 9
Child lock, electric

....................................................
11 9
Children

......................................................
113,
11
5 -117
Children (safety)
....................................................... 11
9
Child seats

...........
102-103 ,
10
6 -107
,
111
,

11
3
,
11
6 -11 8
Child seats, conventional
......................................... 111
C
hild seats, i-Size ....................................................
117
Child seats, ISOFIX

...........................................
115 -117
CITROËN Connect Nav ...............................................
1
CITROËN Connect Radio
............................................ 1
Cl
osing the doors

................................................
38,
40
C
ollision Risk Alert
.....................................
18,

15
6 -157
Configuration, vehicle

...............................................
29
Connection, Bluetooth ..............11,
1
3
-
15
,
21-2
2
,
2
7 -
2
8
Connection, MirrorLink ....................................11
-1
2
,
19
C
onnection, Wi-Fi network

.......................................
22
Control, back-up boot release ..................................
43
Control, back-up door release ...................................
42
Control, heated seats
................................................ 58
C
ontrol stalk, lighting

...........................................
81,
83
C
ontrol stalk, wipers .............................................
87 -9 0
Cour tesy lamp, front ..................................................80
Cour tesy lamp, rear
...................................................80
Courtesy lamps
......................................................... 80
C

over, luggage

..........................................................69
Cruise control


............................142,

1
4 5 -151,

15
4 -15 6
Cruise control, adaptive


...................................148 -149
Cruise control, adaptive with Stop function ........................................... 142,

1
4 8 -151,

15
4
Cruise control by speed limit recognition


................142
Cup holder
................................................................. 63
.
Alphabetical index

229
JJack .................................................................... 200, 25
J ump starting ............................................................ 214
KKey ................................................................. 37, 40, 45
K ey, electronic ............................................ 37,
12 5 -126
Keyless Entry and
Starting


............................. 37
-
4
0,

42,


45-4
6,

12
3,

12
5
Key with remote control
..................................37,

40,


42
K

it, hands-free

................................ 1 0
-11,


1
3
-
14,

2
7 -
2
8
Kit, temporary puncture repair


.........................19 6 -19 9
LLabels .................................................................... 4, 61
L abels, identification ............................................... 226
Lamps, front


...................................................... 206-208
Lamps, parking


.......................................................... 83
Lamps, rear


.............................................................. 209
Lane Depar ture Warning System, Active

.........2

0, 159
LEDs - Light-emitting diodes


............................83,

20
5
Level, brake fluid
..................................................... 189
Level, Diesel additive


....................................... 19 0 -191
Level, engine coolant


...................................28
-3

0,

18
9
Level, engine oil
.......................................... 30,


18
8 -189
Level, screenwash fluid
..................................... 88,


18
9
Levels and checks
............................................ 187-189
Light-emitting diodes - LEDs


............................83,

20
5
Lighting
....................................................................... 81
L

ighting, cornering ................................................ 86
-87
L

ighting, guide-me home
.......................................... 84
L

ighting, welcome ...................................................... 84
Loading


.................................................................... 185
Load reduction mode
.............................................. 18

5
Locating your vehicle


................................................. 42
Locking
........................................................... 37,


40,


45
Locking from the inside .............................................46
L ow fuel level .................................................... 18 0 -181
Lumbar
....................................................................... 56
MMarkings, identification ........................................... 226
Mat ..................................................................... 63,
12 3
Memorising a speed


......................................... 15 5 -15 6
Menu
........................................................................\
... 12
M

enu, main

................................................................... 4
Menus (audio)


................................................... 4
-
5,


4
-
5
M

essages
.................................................................. 30
M

essages, quick ........................................................ 30
Mirror, child surveillance
........................................... 54
M

irror, rear view

......................................................... 54
Mirrors, door


.................................. 53
-5

4,

75,


16
2,

16
4
Misfuel prevention


.................................................... 181
Mountings, ISOFIX


........................................... 114,

11
6
MP3 CD
........................................................................\
9
NNet ........................................................................\
. 6 9- 70
Net, high load retaining ............................................. 68
N
umber plate lamps

................................................. 210
OObstacle detection .................................................. 166
Oil, engine ......................................................... 188 -189
Oil change


......................................................... 188 -189
Oil consumption


................................................ 188 -189
Opening the bonnet


.......................................... 18 6 -187
Opening the boot


........................................................ 37
Opening the doors


...................................................... 37
Opening the fuel filler flap
.......................................18 0
PPads, brake ....................................................... 19 1-192
Paint colour code ..................................................... 226
Park Assist
................................................................ 17

1
Parking brake


........................................... 126,

19
1-192
Parking brake, electric
............. 16,


20,


24-2
5,

1
26 -129
Parking sensors, audible and visual


.......................166
Parking sensors, front


............................................. 167
Parking sensors, rear


.............................................. 166
Petrol
................................................................. 22

0-221
Plates, identification
................................................ 2

26
Player, Apple
® .................................................. 10, 9, 26
P
layer, MP3 CD ..................................................... 9,
25
P
l aye r, U S B ......................................................... 7,

9,


25
P

ower steering
............................................................ 15
P

re-heater, Diesel
...................................................... 18
P

ressures, tyres
.............................. 19

1,

20
0,

20
4,

2
26
Pre-tensioning seat belts
................................. 10

2-103
Priming the fuel system


........................................... 19 6
Profiles
................................................................. 16,


31
P

rogrammable cruise control
................................. 1

45
Protecting children


....104 ,

10
6 -108,

111,


11
3,

11
5 -11 8
Puncture ............................................................ 197-2 0 0
RRadio ................................................. 4 -5, 6- 7, 9, 23, 25
R adio, digital (Digital Audio Broadcasting - DA B)


................................................................ 6,

8,


24
R

ange, AdBlue

..................................................... 31
-3

2
RDS


................................................................... 7,

2
3
-24
R

ear screen, demisting

.............................................. 75
Recharging the battery


............................................ 215
Recirculation, air
................................................... 71-7

3
Reduction of electrical load

....................................18

5
Regeneration of the particle filter
............................ 19

1
Reinitialisation of the under-inflation detection system


.................................................... 17 7
Reinitialising the remote control


...............................44
Reminder, key in ignition


.......................................... 124
.
Alphabetical index