2019 CHEVROLET TAHOE transfer case

Chevrolet Tahoe/Suburban Owner Manual (GMNA-Localizing-U.S./Canada/
Mexico-12460269) - 2019 - CRC - 9/11/18
Service and Maintenance 409
Footnotes—Maintenance
Schedule Additional Required
Services - Severe
(1) Or every two years, whichever
comes first. More frequent
passenger compartment air filter
replacement may be needed if
driving in areas with heavy traffic,
poor air quality, high dust levels,
or environmental allergens.
Passenger compartment air filter
replacement may also be needed if
there is reduced airflow, window
fogging, or odors. Your GM dealer
can help determine when to replace
the filter.
(2) Visually check all fuel and vapor
lines and hoses for proper
attachment, connection, routing, and
condition.
(3) Or every four years, whichever
comes first. If driving in dusty
conditions, inspect the filter at each
oil change or more often as needed. (4)
Do not directly power wash the
transfer case and/or front/rear axle
output seals. High pressure water
can overcome the seals and
contaminate the transfer case fluid.
Contaminated fluid will decrease the
life of the transfer case and/or axles
and should be replaced.
(5) Or every five years, whichever
comes first. See Cooling System
0 317.
(6) Or every 10 years, whichever
comes first. Inspect for fraying,
excessive cracking, or damage;
replace, if needed.
(7) Replace brake fluid every five
years. See Brake Fluid 0324.
(8) Or every 12 months, whichever
comes first. See Wiper Blade
Replacement 0330.Special Application
Services
.
Severe Commercial Use
Vehicles Only: Lubricate chassis
components every oil change.
. Have underbody flushing service
performed. See "Underbody
Maintenance" in Exterior Care
0 391.

Chevrolet Tahoe/Suburban Owner Manual (GMNA-Localizing-U.S./Canada/
Mexico-12460269) - 2019 - CRC - 9/11/18
414 Service and Maintenance
UsageFluid/Lubricant
Key Lock Cylinders, Hood Hinges,
Power Assist Steps, and Outer Liftgate
Handle Pivot Points Multi-Purpose Lubricant, Superlube (GM Part No. 12346241, in
Canada 10953474).
Rear Axle SAE 75W-85 Synthetic Axle Lubricant (GM Part No. 19300457, in
Canada 19300458).
Transfer Case (Four-Wheel Drive) DEXRON-VI Automatic Transmission Fluid. Weatherstrip Conditioning Weatherstrip lubricant (GM Part No. 3634770, in Canada 10953518) or equivalent.
Weatherstrip Squeaks Synthetic Grease with Teflon, Superlube (GM Part No. 12371287, in Canada 10953437).
Windshield Washer Automotive windshield washer fluid that meets regional freeze protection
requirements.

Chevrolet Tahoe/Suburban Owner Manual (GMNA-Localizing-U.S./Canada/
Mexico-12460269) - 2019 - CRC - 9/11/18
418 Technical Data
Vehicle Data
Capacities and Specifications
The following approximate capacities are given in metric and English conversions. SeeRecommended Fluids and
Lubricants 0413 for more information.
Application Capacities
Metric English
Air Conditioning Refrigerant For the air conditioning system refrigerant type and charge amount, see the refrigerant label under thehood. See your dealer for more information.
Cooling System 16.8 L 17.8 qt
Engine Oil with Filter 7.6 L 8.0 qt
Fuel Tank Short Wheelbase 98.4 L 26.0 gal
Long Wheelbase 119.2 L 31.5 gal
Transfer Case Fluid 1.5 L 1.6 qt
Wheel Nut Torque 190 Y140 lb ft
All capacities are approximate. When adding, be sure to fill to the approximate level, as recommended in this
manual. Recheck fluid level after filling.

Chevrolet Tahoe/Suburban Owner Manual (GMNA-Localizing-U.S./Canada/-
Mexico-12460269) - 2019 - CRC - 9/11/18
Index 451
FluidAutomatic
Transmission . . . . . . . . . . . 313, 316
Brakes . . . . . . . . . . . . . . . . . . . . . . . . 324
Four-Wheel Drive Transfer Case . . . . . . . . . . . . . . . 239
Power Steering . . . . . . . . . . . . . . . 323
Washer . . . . . . . . . . . . . . . . . . . . . . . 323
Fog Lamps . . . . . . . . . . . . . . . . . . . . . 188 Bulb Replacement . . . . . . . . . . . . 334
Folding Mirrors . . . . . . . . . . . . . . . . . . 57
Forward Automatic Braking . . . . . 267
Forward Collision Alert
(FCA) System . . . . . . . . . . . . . . . . . 265
Four-Wheel Drive . . . . . . . . . . 239, 326
Frequency Statement Radio . . . . . . . . . . . . . . . . . . . . . . . . . 431
Front Axle . . . . . . . . . . . . . . . . . . . . . . 327
Front Fog Lamp Light . . . . . . . . . . . . . . . . . . . . . . . . . . 162
Front Seats
Adjustment . . . . . . . . . . . . . . . . . . . . . 66
Heated and Ventilated . . . . . . . . . . 73
Front Turn Signal Lamps . . . . . . . 334
Fuel Additives . . . . . . . . . . . . . . . . . . . . . 274
Economy Driving . . . . . . . . . . . . . . . 27 Fuel (cont'd)
Filling a Portable Fuel
Container . . . . . . . . . . . . . . . . . . . 277
Filling the Tank . . . . . . . . . . . . . . . 276
Foreign Countries . . . . . . . . . . . . 274
Gauge . . . . . . . . . . . . . . . . . . . . . . . . 149
Low Fuel Warning Light . . . . . . . 161
Management, Active . . . . . . . . . . 229
Prohibited Fuels . . . . . . . . . . . . . . 274
Recommended . . . . . . . . . . . . . . . 273
Top Tier . . . . . . . . . . . . . . . . . . . . . . 273
Full-Size Spare Tire . . . . . . . . . . . . 380
Fuses Engine Compartment Fuse
Block . . . . . . . . . . . . . . . . . . . . . . . . 338
Fuses and Circuit Breakers . . . 337
Instrument Panel Fuse Block . . . . . . . . . . . . . . . . . . . 342, 345
Rear Compartment Fuse Block . . . . . . . . . . . . . . . . . . . . . . . . 347
G
Garage Door Opener . . . . . . . . . . . 180Programming . . . . . . . . . . . . . . . . . 180
Gas Strut(s) . . . . . . . . . . . . . . . . . . . . 331
Gauges Engine CoolantTemperature . . . . . . . . . . . . . . . . 151 Gauges (cont'd)
Engine Oil Pressure . . . . . . . . . . 150
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . 149
Odometer . . . . . . . . . . . . . . . . . . . . . 149
Speedometer . . . . . . . . . . . . . . . . . 149
Tachometer . . . . . . . . . . . . . . . . . . . 149
Trip Odometer . . . . . . . . . . . . . . . . 149
Voltmeter . . . . . . . . . . . . . . . . . . . . . 152
Warning Lights and
Indicators . . . . . . . . . . . . . . . . . . . 144
General Information Service and Maintenance . . . . . 401
Towing . . . . . . . . . . . . . . . . . . . . . . . . 278
Vehicle Care . . . . . . . . . . . . . . . . . . 300
Glass Replacement . . . . . . . . . . . . . 331
Glove Box . . . . . . . . . . . . . . . . . . . . . . 128
GM Mobility Reimbursement Program . . . . . . . . . . . . . . . . . . . . . . . 425
H
Halogen Bulbs . . . . . . . . . . . . . . . . . . 333
Hazard Warning Flashers . . . . . . . 187
Head Restraints . . . . . . . . . . . . . . . . . 65
Head-up Display . . . . . . . . . . . . . . . . 167
Headlamps . . . . . . . . . . . . . . . . . . . . . 333
Aiming . . . . . . . . . . . . . . . . . . . . . . . . 332
Automatic . . . . . . . . . . . . . . . . . . . . . 186
Bulb Replacement . . . . . . . . . . . . 333

Chevrolet Tahoe/Suburban Owner Manual (GMNA-Localizing-U.S./Canada/-
Mexico-12460269) - 2019 - CRC - 9/11/18
Index 453
Lap Belt . . . . . . . . . . . . . . . . . . . . . . . . . 91
Lap-Shoulder Belt . . . . . . . . . . . . . . . 86
LATCH SystemReplacing Parts after aCrash . . . . . . . . . . . . . . . . . . . . . . . 122
LATCH, Lower Anchors and Tethers for Children . . . . . . . . . . . 114
LED Lighting . . . . . . . . . . . . . . . . . . . . 333
Level Control Automatic . . . . . . . . . . . . . . . . . . . . . 249
Liftgate . . . . . . . . . . . . . . . . . . . . . . . . . . 47
Lighting
Entry . . . . . . . . . . . . . . . . . . . . . . . . . 190
Exit . . . . . . . . . . . . . . . . . . . . . . . . . . . 191
Illumination Control . . . . . . . . . . . 189
LED . . . . . . . . . . . . . . . . . . . . . . . . . . 333
Lights Airbag Readiness . . . . . . . . . . . . . 153
Antilock Brake System(ABS) Warning . . . . . . . . . . . . . . 158
Brake System Warning . . . . . . . 157
Charging System . . . . . . . . . . . . . 155
Check Engine (Malfunction
Indicator) . . . . . . . . . . . . . . . . . . . . 155
Cruise Control . . . . . . . . . . . . . . . . 162
Door Ajar . . . . . . . . . . . . . . . . . . . . . 162
Flash-to-Pass . . . . . . . . . . . . . . . . . 186
Front Fog Lamp . . . . . . . . . . . . . . 162 Lights (cont'd)
High-Beam On . . . . . . . . . . . . . . . . 161
High/Low Beam Changer . . . . . 185
Hill Descent Control . . . . . . . . . . 158
Lane Keep Assist . . . . . . . . . . . . . 159
Low Fuel Warning . . . . . . . . . . . . 161
Seat Belt Reminders . . . . . . . . . . 153
Security . . . . . . . . . . . . . . . . . . . . . . 161
StabiliTrak OFF . . . . . . . . . . . . . . . 159
Tire Pressure . . . . . . . . . . . . . . . . . 160
Tow/Haul Mode . . . . . . . . . . . . . . . 158
Traction Control System
(TCS)/StabiliTrak . . . . . . . . . . . . 160
Traction Off . . . . . . . . . . . . . . . . . . . 159
Locking Rear Axle . . . . . . . . . . . . . . 249
Locks Automatic Door . . . . . . . . . . . . . . . . . 46
Delayed Locking . . . . . . . . . . . . . . . . 45
Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
Lockout Protection . . . . . . . . . . . . . . 46
Power Door . . . . . . . . . . . . . . . . . . . . . 45
Safety . . . . . . . . . . . . . . . . . . . . . . . . . . 46
Loss of Control . . . . . . . . . . . . . . . . . 206
Low Fuel Warning Light . . . . . . . . . 161
Low-Profile Tires . . . . . . . . . . . . . . . . 350
Lower Anchors and Tethers
for Children (LATCH
System) . . . . . . . . . . . . . . . . . . . . . . . 114 Lumbar Adjustment . . . . . . . . . . . . . . 68
Front Seats . . . . . . . . . . . . . . . . . . . . . 68
M
Magnetic Ride Control . . . . . . . . . . 249
MaintenanceRecords . . . . . . . . . . . . . . . . . . . . . . 416
Maintenance and Care Additional . . . . . . . . . . . . . . . . . . . . . 410
Maintenance Schedule . . . . . . . . . 403 Recommended Fluids andLubricants . . . . . . . . . . . . . . . . . . . 413
Transfer Case . . . . . . . . . . . . . . . . 239
Malfunction Indicator Lamp . . . . . 155
Manual Mode . . . . . . . . . . . . . . 234, 236
Memory Features . . . . . . . . . . . . . . . . 12
Memory Seats . . . . . . . . . . . . . . . . . . . 70
Messages Engine Power . . . . . . . . . . . . . . . . 171
Vehicle . . . . . . . . . . . . . . . . . . . . . . . 171
Vehicle Speed . . . . . . . . . . . . . . . . 171
Mirror Child-View . . . . . . . . . . . . . . . . . . . . . . 59
Mirrors Automatic DimmingRearview . . . . . . . . . . . . . . . . . . . . . . 59
Blind Spot . . . . . . . . . . . . . . . . . . . . . . 58
Convex . . . . . . . . . . . . . . . . . . . . . . . . . 56

Chevrolet Tahoe/Suburban Owner Manual (GMNA-Localizing-U.S./Canada/-
Mexico-12460269) - 2019 - CRC - 9/11/18
Index 457
T
Tachometer . . . . . . . . . . . . . . . . . . . . . 149
TaillampsBulb Replacement . . . . . . . . . . . . 335
Text Telephone (TTY) Users . . . . 424
Theft-Deterrent Systems . . . . . . . . . 55
Immobilizer . . . . . . . . . . . . . . . . . . . . . 55
Third-Row Seats . . . . . . . . . . . . . . . . . 79
Throttle, Adjustable . . . . . . . . . . . . . 220
Time . . . . . . . . . . . . . . . . . . . . . . . . . . . . 138
Tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . 348 All-Season . . . . . . . . . . . . . . . . . . . . 349
All-Terrain . . . . . . . . . . . . . . . . . . . . 350
Buying New Tires . . . . . . . . . . . . . 364
Chains . . . . . . . . . . . . . . . . . . . . . . . . 368
Changing . . . . . . . . . . . . . . . . . . . . . 371
Designations . . . . . . . . . . . . . . . . . 351
Different Size . . . . . . . . . . . . . . . . . 366
Full-Size Spare . . . . . . . . . . . . . . . 380
If a Tire Goes Flat . . . . . . . . . . . . 369
Inspection . . . . . . . . . . . . . . . . . . . . 362
Low Profile . . . . . . . . . . . . . . . . . . . 350
Pressure . . . . . . . . . . . . . . . . . 355, 356
Pressure Light . . . . . . . . . . . . . . . . 160
Pressure Monitor Operation . . 358
Pressure Monitor System . . . . . 357
Rotation . . . . . . . . . . . . . . . . . . . . . . 362
Sidewall Labeling . . . . . . . . . . . . . 350 Tires (cont'd)
Terminology and Definitions . . 352
Uniform Tire Quality
Grading . . . . . . . . . . . . . . . . . . . . . 366
Wheel Alignment and Tire Balance . . . . . . . . . . . . . . . . . . . . . 367
Wheel Replacement . . . . . . . . . . 368
When It Is Time for New Tires . . . . . . . . . . . . . . . . . . . . . . . . 363
Winter . . . . . . . . . . . . . . . . . . . . . . . . 349
Top Tier Fuel . . . . . . . . . . . . . . . . . . . 273
Tow/Haul Mode . . . . . . . . . . . . . . . . . 238
Tow/Haul Mode Light . . . . . . . . . . . 158
Towing Driving Characteristics . . . . . . . . 278
Equipment . . . . . . . . . . . . . . . . . . . . 289
General Information . . . . . . . . . . 278
Recreational Vehicle . . . . . . . . . . 385
Trailer . . . . . . . . . . . . . . . . . . . . . . . . 283
Trailer Sway Control (TSC) . . . 296
Vehicle . . . . . . . . . . . . . . . . . . . . . . . 385
Traction Control System
(TCS)/StabiliTrak Light . . . . . . 160
Off Light . . . . . . . . . . . . . . . . . . . . . . 159
Traction Control/Electronic Stability Control . . . . . . . . . . . . . . . 246 Trailer
Sway Control (TSC) . . . . . . . . . . 296
Towing . . . . . . . . . . . . . . . . . . . . . . . . 283
Transfer Case . . . . . . . . . . . . . . . . . . 239
Transmission Automatic . . . . . . . . . . . . . . . . . . . . . 231
Fluid, Automatic . . . . . . . . . 313, 316
Transportation Program, Courtesy . . . . . . . . . . . . . . . . . . . . . . 427
Trip Odometer . . . . . . . . . . . . . . . . . . 149
Turn and Lane-Change Signals . . . . . . . . . . . . . . . . . . . . . . . . 187
Turn Signal Bulb Replacement . . . . . . . . . . . . 335
U
Uniform Tire Quality Grading . . . 366
Universal Remote System . . . . . . 180Operation . . . . . . . . . . . . . . . . . . . . . 182
Programming . . . . . . . . . . . . . . . . . 180
Using This Manual . . . . . . . . . . . . . . . . 2
V
Vehicle
Alarm System . . . . . . . . . . . . . . . . . . 53
Canadian Owners . . . . . . . . . . . . . . . 2
Control . . . . . . . . . . . . . . . . . . . . . . . 204
Identification Number (VIN) . . . 417
Load Limits . . . . . . . . . . . . . . . . . . . 215