2019 CHEVROLET LOW CAB FORWARD ABS

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500/5500 Series (GMNA-
Localizing-U.S.-12407814) - 2019 - crc - 12/13/17
290 Vehicle Care
Fuse and Relay Location–Cab InteriorFuse locations:
No. Description Rating
1 RR P / WINDOW 25A
2 – –
3 ROOM LAMP, AUDIO 10A
4 DOOR LOCK 15A
5 TRAILER BRAKE 15A
6 P/ WINDOW 25A
7 ABS 10A
8 WIPER 25A
9 H / LAMP LO (LH) 10A
10 LAMPS (BATT) 10A 11 H / LAMP LO (RH) 10A
12 BRAKE LAMPS 10A
13 STARTER 10A
14 H / LAMP HI (LH) 10A

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500/5500 Series (GMNA-
Localizing-U.S.-12407814) - 2019 - crc - 12/13/17
Vehicle Care 325
.Follow specific instructions on
cleaner labels.
General Cleaning of Soiled or
Water Spotted Fabric Type
Trim with Foam Type Cleaner
Vacuum the area thoroughly to
remove any loose dirt.
Always clean a whole trim panel or
section. Mask surrounding trim
along stitch or welt lines.
Use suds on a clean sponge. Do
not brush wet suede. Do not
saturate the material or rub it
harshly. Immediately after cleaning,
remove suds with a sponge and
rinse with a clean wet sponge. Wipe
off remaining residue with a slightly
damp absorbent towel or cloth.
Immediately after wiping, force-dry
the fabric with an air hose. A heat
dryer or heat lamp may be used.
Use caution with a heat dryer or
lamp to help prevent damage.
When trim materials with a sheen or
luster finish are dry, wipe the fabric
lightly with a soft, dry, clean cloth to
restore its sheen or luster. For suede, raise nap with a dry scrub
brush and vacuum to remove any
final traces of residue.
Spot Cleaning Fabric Type
Trim with Solvent Type Cleaner
Before trying to remove a spot or
stain from fabric, try to find out the
type and age of the spot or stain.
Some spots or stains can be
removed with water or a mild soap
solution. Spots or stains should
always be removed as soon as
possible.
Some types of stains or soilage,
such as lipstick, inks, and grease,
are very difficult (sometimes
impossible) to remove completely.
When cleaning this type of stain or
soilage, be sure not to enlarge the
soiled area.
.
Gently scrape excess stain from
the trim material with a clean,
dull knife or scraper. Use very
little cleaner, light pressure, and
clean cloths, preferably
cheesecloth. Cleaning should
start at the outside of the stain feathering towards the center.
Keep changing to a clean
section of cloth.
. When you clean a stain from
fabric, immediately dry the area
with an air hose, heat dryer,
or heat lamp to help prevent a
cleaning ring. Use caution with
heat dryer or lamp to help
prevent fabric damage.
. If a ring forms, immediately
repeat the cleaning operation
over a slightly larger area with
emphasis on feathering towards
its center. If a ring still remains,
mask off surrounding trim
sections and clean the entire
soiled area with a foam type
cleaner.
See “Removal of Specific
Stains.”
Removal of Specific Stains
Greasy or Oily Stains –Includes
grease, oil, butter, margarine, shoe
polish, coffee with cream, chewing
gum, cosmetic creams, vegetable
oils, wax crayon, tar, and asphalts.

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500/5500 Series (GMNA-
Localizing-U.S.-12407814) - 2019 - crc - 12/13/17
Service and Maintenance 335
maintenance intervals and may
cause a problem with engine
durability.
(3)Refer to "Air Cleaner Indicator
Light" under Engine Air Cleaner/
Filter 0253.
(4) Initial check at 1 040 km
(650 miles) is required.
(5) Be sure to discard used grease
seal, and always use new grease
seal for installation.
Explanation of Complete
Vehicle Maintenance Schedule
The following is a brief explanation
of each of the services listed in the
preceding Complete Vehicle
Maintenance Schedule.
1. Engine Noise : These
components have an effect on the
control of noise emissions. Service Interval Maintenance procedure
Engine
Every 16 000 km (10,000 miles) Inspect sound absorption materials for
tears, broken out sections or
attachment. Repair or replace as
necessary.
Cooling System
Every 16 000 km (10,000 miles) Inspect fan, shroud and radiator for
attachment, tears or cleanliness.
Replace as necessary.
Air intake system
Every 24 000 km (1,500 miles) Inspect all ducts, hoses and intake
silencers for leaks or chafing. Repair or
replace as necessary.
Exhaust system
Every 16 000 km (10,000 miles) Inspect silencer, pipes, gaskets, clamps
and mounting for exhaust gas leaks or
looseness. Repair or replace as
necessary.
Cab
Every 16 000 km (10,000 miles) Inspect sound absorption materials for
tears, broken out sections or
attachment. Repair or replace as
necessary.
2. Valve Lash : Incorrect valve
clearance will result in increased
engine noise and lower engine
output, thereby adversely affecting
engine performance. Retorque rocker shaft bracket nuts before
checking and adjusting valve
clearance.
Check and adjust valve clearance
every 80 000 km (50,000 miles) or
12 months whichever occurs first.

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500/5500 Series (GMNA-
Localizing-U.S.-12407814) - 2019 - crc - 12/13/17
Index 373
IndexA
Accessories andModifications . . . . . . . . . . . . . . . . . . 240
Add-On Electrical Equipment . . . 236
Additional Maintenance and Care . . . . . . . . . . . . . . . . . . . . . . 346
Adjustments Seat, Initial Drive . . . . . . . . . . . . . . . 38
Agreements Trademarks and License . . . . . 129
Air Cleaner/Filter, Engine . . . . . . . 253
Air Conditioning . . . . . . . . . . . . . . . . 131
Air Filter, Passenger Compartment . . . . . . . . . . . . . . . . . 135
Air Vents . . . . . . . . . . . . . . . . . . . . . . . 134
AM-FM Radio . . . . . . . . . . . . . . . . . . . . 97
Antenna Fixed Mast . . . . . . . . . . . . . . . . . . . 102
Antilock Brake System (ABS) . . . 216
Warning Light . . . . . . . . . . . . . . . . . . . 76
Appearance Care Exterior . . . . . . . . . . . . . . . . . . . . . . . 317
Interior . . . . . . . . . . . . . . . . . . . . . . . . 323
Assistance Program,
Roadside . . . . . . . . . . . . . . . . . . . . . . 367
Audio Bluetooth . . . . . . . . . . . . . . . . . . . . . .118 Audio Players
CD . . . . . . . . . . . . . . . . . . . . . . . . . . . 102
Automatic Transmission . . . . . . . . . . . . . . . . . 205
Transmission Fluid . . . . . . . . . . . 251
Automatic Transmission Selector Lever . . . . . . . . . . . . . . . . 214
Shift Lock Control Function
Check . . . . . . . . . . . . . . . . . . . . . . . 274
Automatic Transmission Fluid Temperature Warning Light . . . . . 78
Automatic Transmission Overdrive Off . . . . . . . . . . . . . . . . . . 215
Auxiliary Devices . . . . . . . . . . . . . . . . . . . . . . . .117
Axle, Rear . . . . . . . . . . . . . . . . . 271, 272
B
Battery - North America . . . . 269, 311
Battery Warning Light . . . . . . . . . . . . 73
Biodiesel . . . . . . . . . . . . . . . . . . . . . . . 228
Blade Replacement, Wiper . . . . . 275
Bluetooth
Overview . . . . . . . . . . . . . . . . . . . . . 121
Bluetooth Audio . . . . . . . . . . . . . . . . 118
Brake Exhaust . . . . . . . . . . . . . . . . . . . . . . 222
System Warning Light . . . . . . . . . . 74

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500/5500 Series (GMNA-
Localizing-U.S.-12407814) - 2019 - crc - 12/13/17
Index 377
Lamps (cont'd)License Plate . . . . . . . . . . . . . . . . . 286
Malfunction Indicator (Check
Engine) . . . . . . . . . . . . . . . . . . . . . . . 73
Roofmarker . . . . . . . . . . . . . . . . . . . 284
Sidemarker . . . . . . . . . . . . . . . . . . . 284
Lap Belt . . . . . . . . . . . . . . . . . . . . . . . . . 48
Lighting Illumination Control . . . . . . . . . . . . . 95
Lights Antilock Brake System(ABS) Warning . . . . . . . . . . . . . . . . 76
Automatic Transmission Fluid Temperature . . . . . . . . . . . . . 78
Battery Warning . . . . . . . . . . . . . . . . 73
Brake System Warning . . . . . . . . . 74
Check Engine (Malfunction Indicator) . . . . . . . . . . . . . . . . . . . . . . 73
Cruise Control . . . . . . . . . . . . . . . . . . 82
Daytime Running Lamps (DRL) . . . . . . . . . . . . . . . . . . 81
Diesel Exhaust Fluid (DEF) . . . . . 80
Engine Oil Level Indicator . . . . . . 79
Engine Oil Pressure . . . . . . . . . . . . 79
Engine Shutdown Warning . . . . . 80
Exhaust Brake . . . . . . . . . . . . . . . . . . 77
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 93
High-Beam On . . . . . . . . . . . . . . . . . . 81 Lights (cont'd)
High/Low Beam Changer . . . . . . . 93
Idle Shutdown . . . . . . . . . . . . . . . . . . 80
Overdrive Off . . . . . . . . . . . . . . . . . . . 78
Reduced Engine Power . . . . . . . . 81
Seat Belt Reminders . . . . . . . . . . . . 72
Service Transmission
Warning . . . . . . . . . . . . . . . . . . . . . . . 77
Service Vehicle Soon . . . . . . . . . . . 74
Wait to Start . . . . . . . . . . . . . . . . . . . . 79
Loading the Vehicle . . . . . . . . . . . . . . 58
Locks Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Power Door . . . . . . . . . . . . . . . . . . . . . 33
M
Maintenance and CareAdditional . . . . . . . . . . . . . . . . . . . . . 346
Maintenance Schedule . . . . . . . . . 327
Recommended Fluids andLubricants . . . . . . . . . . . . . . . . . . . 349
Malfunction Indicator Lamp . . . . . . 73
Messages Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 86
Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . . 33 Heated . . . . . . . . . . . . . . . . . . . . . . . . . 34
N
New Vehicle Break-In . . . . . . . . . . . 165
Noise Control System . . . . . . . . . . 272
O
Odometer . . . . . . . . . . . . . . . . . . . . . . . . 70Trip . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 70
Oil Engine . . . . . . . . . . . . . . . . . . . . . . . . 245
Pressure Light . . . . . . . . . . . . . . . . . . 79
Online Owner Center . . . . . . . . . . . 365
Operating Temperature . . . . . . . . . 171
Outlets
Power . . . . . . . . . . . . . . . . . . . . . . . . . . 67
Overdrive Off . . . . . . . . . . . . . . . . . . . 215
Overdrive Off Light . . . . . . . . . . . . . . 78
Overheating, Engine . . . . . . . . . . . . 259
Owner Checks and Services . . . . 340
P
Parking
Brake . . . . . . . . . . . . . . . . . . . . . . . . . 220
Over Things That Burn . . . . . . . 176
Passenger Compartment Air Filter . . . . . . . . . . . . . . . . . . . . . . . . . . 135
Pedals . . . . . . . . . . . . . . . . . . . . . . . . . . 166
Perchlorate Materials Requirements, California . . . . . . 240