2019 CHEVROLET LOW CAB FORWARD headlamp

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500/5500 Series (GMNA-
Localizing-U.S.-12407814) - 2019 - crc - 12/13/17
282 Vehicle Care
8. Remove the rubber boot (2).Push the right side of the
clip (1) that holds the bulb (3)
in place and slide it upwards to
disengage the clip.9. Remove the bulb (1) from thesocket (2) and replace with a
new one.
10. After replacing the bulb, reverse steps 1-8 to install.
Do not touch the glass of the bulb
with your hand. Soiling the glass will
cause the bulb to blow out.
When attaching the rubber boot,
press in both the outside and inside
circumference of it. Make sure that
the rubber boot, the headlamp
assembly, and the bulb are securely
installed without any raised section. If the rubber boot is not firmly in
place, water could get inside the
headlamp and lead to a breakdown.
Replacing Parking Lamps
1. Refer to
“Replacing the
Headlamps” and remove the
headlamp assembly.
2. Pull the bulb out from the parking lamp socket and
replace with a new one.

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500/5500 Series (GMNA-
Localizing-U.S.-12407814) - 2019 - crc - 12/13/17
Service and Maintenance 343
Front
1. Roofmarker Lamp(Identification/
Clearance Lamp)
2. Front Turn Signal Lamp
3. Side Turn Signal Lamp/ Sidemarker Lamp
4. Cornering Lamp
5. Side Reflector
6. Headlamp/Parking Lamp
Rear
1. Rear Turn Signal Lamp
2. Back-up Lamp
3. License Plate Lamp
4. Taillamp/Stoplamp
Lubrication
One of the most important items of
good vehicle care is the lubrication
of all necessary points with the
Right Lubricant, at the Right Time
and in the Right Way. It is the
owner's responsibility to maintain
proper lubrication practices as
recommended in the following
pages. Greasing Chassis Components
The type (characteristics) of the
grease specified for use with a
chassis component differs from that
of the grease specified for use with
another component. Be sure to use
only the specified grease for each
component and perform greasing
according to the Maintenance
Schedule.
King pins (left and right)

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500/5500 Series (GMNA-
Localizing-U.S.-12407814) - 2019 - crc - 12/13/17
Service and Maintenance 347
one side, unusual sounds when
braking, increased brake pedal
travel or harder pedal. The front and
rear brakes are attached to an auto
adjuster mechanism. If there are no
defects, as the pedal travel is
properly maintained, adjustments
are not necessary. Check regularly
that the brake fluid reservoir
(left-hand side of the instrument
panel) or HBB reservoir (5500HD,
5500XD models: left side behind the
cab) is properly filled and check for
fluid leaks. Any of these conditions
could indicate the need for brake
system inspection and/or service.
G: Exhaust System :Be alert for
any changes in the sound of the
exhaust system or any smell of
fumes. These are signs the system
may be leaking. Have it checked
and/or repaired at once. (Refer to
"Engine Exhaust Emissions Caution
(Carbon Monoxide)" under Engine
Exhaust 0177).
H: Windshield Wipers and
Washers : Check operation and
condition of the wiper blades. Check
the flow of the washer spray. I: Defroster :
Turn the outlet
selector knob to "Defroster" and the
fan speed control knob to the fully
clockwise position. Then check the
airflow from the ducts at the inside
base of the windshield.
J: Rearview Mirrors and Sun
Visors : Check that friction joints
hold mirrors and sun visors in place.
K: Horn : Sound the horn, now and
then, to be sure it works.
L: Lap-Shoulder Belts : Check the
seat belt system (including webbing,
buckles, latch plates and anchors)
for proper operation, and for
damage.
M: Seat Adjusters : When
adjusting the driver's manual seat,
be sure the seat adjusters latch by
pushing the seat forward and
backward. Do not attempt to adjust
the seat when the vehicle is in
motion.
N: Lamps : Check panel lighting,
warning lamps, indicator lamps and
interior lamps. On the outside,
check: license plate lamps, side
marker lamps, reflectors on outside mirrors, headlamps, parking lamps,
identification and clearance lamps,
taillights, brake lamps, turn signals,
cornering lamps, backup lamps and
hazard warning flashers. Have
headlamp aim checked immediately
if beams seem improperly aimed.
O: Glass, Mirrors, Lights and/or
Reflectors Condition :
Look for
broken, scratched, dirty or damaged
glass, mirrors, lamps or reflectors
that could reduce the view or
visibility, or cause injury. Replace,
clean or repair promptly.
P: Door Latches : Check that doors
close, latch and lock tightly. Check
for broken, damaged or missing
parts that might prevent tight
latching.
Q :Tilt Cab (Driving Position) : Be
sure the tilt lever is down and
locked.
R: Fluid Leaks : Check for fuel,
water, oil or other fluid leaks by
looking at the surface beneath the
vehicle after it has been parked for

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500/5500 Series (GMNA-
Localizing-U.S.-12407814) - 2019 - crc - 12/13/17
374 Index
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . 263Antilock . . . . . . . . . . . . . . . . . . . . . . . 216
Exhaust Light . . . . . . . . . . . . . . . . . . . 77
Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . 268
Parking . . . . . . . . . . . . . . . . . . . . . . . 220
Braking . . . . . . . . . . . . . . . . . . . . . . . . . 143
Break-In, New Vehicle . . . . . . . . . . 165
Bulb Replacement Headlamp Aiming . . . . . . . . . . . . . 277
Headlamps . . . . . . . . . . . . . . . . . . . 277
Headlamps and Front TurnSignal . . . . . . . . . . . . . . . . . . . . . . . 280
Interior Lamps . . . . . . . . . . . . . . . . 287
License Plate Lamps . . . . . . . . . 286
Roofmarker Lamps . . . . . . . . . . . 284
Sidemarker Lamps . . . . . . . . . . . 284
Taillamps, Turn Signal, Stoplamps, and Back-up
Lamps . . . . . . . . . . . . . . . . . . . . . . 286
Buzzers, Warning . . . . . . . . . . . . . . . . 91
C
Cab Tilting . . . . . . . . . . . . . . . . . . . . . . 243
California Perchlorate MaterialsRequirements . . . . . . . . . . . . . . . 240 California
Proposition
65 Warning . . . . . . . . . .240, 269, 311,
Back Cover
Capacities and Specifications . . . . . . . . . . . . . . . . . 357
Carbon Monoxide
Engine Exhaust . . . . . . . . . . . . . . . 177
Winter Driving . . . . . . . . . . . . . . . . 151
Cargo Lamp . . . . . . . . . . . . . . . . . . . . . 96
Caution, Danger, and Warning . . . . 3
CD Player . . . . . . . . . . . . . . . . . . . . . . 102
Check Engine Light (MalfunctionIndicator) . . . . . . . . . . . . . . . . . . . . . . 73
Child Restraints
Systems . . . . . . . . . . . . . . . . . . . . . . . . 51
Cleaning Exterior Care . . . . . . . . . . . . . . . . . 317
Interior Care . . . . . . . . . . . . . . . . . . 323
Climate Control Systems . . . . . . . 131
Air Conditioning . . . . . . . . . . . . . . 131
Heating . . . . . . . . . . . . . . . . . . . . . . . 131
Cluster, Instrument . . . . . . . . . . . . . . 69
Cold Weather Operation . . . . . . . . 230
Collision Damage Repair . . . . . . . 368
Compartments Storage . . . . . . . . . . . . . . . . . . . . . . . . . 54 Control of a Vehicle . . . . . . . . . . . . . 139
Coolant
Engine . . . . . . . . . . . . . . . . . . . . . . . . 253
Engine Temperature Gauge . . . . 72
Cooling . . . . . . . . . . . . . . . . . . . . . . . . . 131
Cornering Lamps . . . . . . . . . . . . . . . . 95
Cover Engine . . . . . . . . . . . . . . . . . . . . . . . . 245
Covers Winter . . . . . . . . . . . . . . . . . . . . . . . . 172
Cruise Control . . . . . . . . . . . . . . . . . . 223
Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82
Cupholders . . . . . . . . . . . . . . . . . . . . . . 56
Customer Assistance . . . . . . . . . . . 365 Offices . . . . . . . . . . . . . . . . . . . . . . . . 365
Text Telephone (TTY)Users . . . . . . . . . . . . . . . . . . . . . . . 365
Customer Information Publications OrderingInformation . . . . . . . . . . . . . . . . . . 370
Customer Satisfaction
Procedure . . . . . . . . . . . . . . . . . . . . . 364
D
Damage Repair, Collision . . . . . . . 368
Danger, Warning, and Caution . . . . 3
Daytime Running Lamps (DRL)Indicator Light . . . . . . . . . . . . . . . . . . 81

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500/5500 Series (GMNA-
Localizing-U.S.-12407814) - 2019 - crc - 12/13/17
376 Index
FuelBiodiesel . . . . . . . . . . . . . . . . . . . . . 228
Cold Weather Operation . . . . . . 230
Diesel Engines . . . . . . . . . . . . . . . 227
Economy Driving . . . . . . . . . . . . . . . 24
Filling the Tank . . . . . . . . . . . . . . . 235
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . 270
Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . 71
Running out of Fuel . . . . . . . . . . . 233
Water in Fuel . . . . . . . . . . . . . . . . . 231
Fuel for Diesel Engines . . . . . . . . . 227
G
Gauges
Diesel Exhaust Fluid (DEF) . . . . . 72
Engine Coolant Temperature . . . 72
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71
Odometer . . . . . . . . . . . . . . . . . . . . . . . 70
Speedometer . . . . . . . . . . . . . . . . . . . 70
Tachometer . . . . . . . . . . . . . . . . . . . . . 71
Trip Odometer . . . . . . . . . . . . . . . . . . 70
Warning Lights andIndicators . . . . . . . . . . . . . . . . . . . . . 68
General Information Vehicle Care . . . . . . . . . . . . . . . . . . 240
Getting In and Out of the
Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 29 Glove Box . . . . . . . . . . . . . . . . . . . . . . . 55
GM Mobility Reimbursement
Program . . . . . . . . . . . . . . . . . . . . . . . 366
H
Hazard Warning Flashers . . . . . . . . 94
HeadlampsAiming . . . . . . . . . . . . . . . . . . . . . . . . 277
Bulb Replacement . . . . . . . 277, 280
Daytime Running Lamps(DRL) Indicator Light . . . . . . . . . . 81
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 93
High-Beam On Light . . . . . . . . . . . . 81
High/Low Beam Changer . . . . . . . 93
Heated Mirrors . . . . . . . . . . . . . . . . . . . 34
Heater Engine . . . . . . . . . . . . . . . . . . . . . . . . 172
Heating . . . . . . . . . . . . . . . . . . . . . . . . . 131
High Idle System . . . . . . . . . . . . . . . 174
High-Beam On Light . . . . . . . . . . . . . 81
Hill and Mountain Roads . . . . . . . . 150
Hooks Shopping Bag . . . . . . . . . . . . . . . . . . 57
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
HVAC . . . . . . . . . . . . . . . . . . . . . . . . . . . 131
I
Idle Shutdown . . . . . . . . . . . . . . . . . . 174
Idle Shutdown Light . . . . . . . . . . . . . 80
Ignition Positions . . . . . . . . . . . . . . . 166
Information Publication Ordering . . . . . . . . . . 370
Information on Loading the Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 58
Instrument Cluster . . . . . . . . . . . . . . . 69
Instrument Panel Storage Area . . . . . . . . . . . . . . . . . . . 55
Introduction . . . . . . . . . . . . . . . . . . . . . . . 2
J
Jump Starting - North America . . . . . . . . . . . . . . . . . . . . . . . 311
K
Keyless EntryRemote (RKE) System . . . . . . . . . 26
Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
L
Lamps
Cargo . . . . . . . . . . . . . . . . . . . . . . . . . . . 96
Cornering . . . . . . . . . . . . . . . . . . . . . . . 95
Dome . . . . . . . . . . . . . . . . . . . . . . . . . . . 96
Exterior Controls . . . . . . . . . . . . . . . . 92
Interior . . . . . . . . . . . . . . . . . . . . . . . . 287