2019 Alfa Romeo 4C Spider transmission

Mileage or time passed
(whichever comes first)
12,000
24,000
36,000
48,000
60,000
72,000
84,000
96,000
108,000
120,000
132,000
144,000
156,000
Or Months: 12 24 36 48 60 72 84 96 108 120 132 144 156
Or Kilometers:
20,000
40,000
60,000
80,000
100,000
120,000
140,000
160,000
180,000
200,000
220,000
240,000
260,000
Check condition and wear of front brake
pads and discs, and operation of pad wear
indicator XXXXXXXXXXXXX
Check condition and wear of rear brake
pads and discs, and operation of pad wear
indicator XXXXXXXXXXXXX
Check and top off, if required, fluid levels
(engine coolant, brake/hydraulic clutch
fluid, windscreen washer fluid, battery
fluid, etc) XXXXXXXXXXXXX
Visually inspect the condition of accessory
drive belt(s) XX X X
Check condition of timing belt X X X
Check handbrake lever travel and adjust, if
necessary (or every 12 months) XXXXXXXXXXXXX
Check engine control system operation
(via diagnostic tool) XXXXXXXXXXXXX
Check and, if necessary, top off oil level of
twin clutch transmission XX
8
SERVICING AND MAINTENANCE 201

DEALER SERVICE
The pages that follow contain therequiredmaintenance
services determined by the engineers who designed
your vehicle.
Besides those maintenance items specified in the fixed
maintenance schedule, there are other components
which may require servicing or replacement in the
future.
CAUTION!
• Failure to properly maintain your vehicle or per-
form repairs and service when necessary could
result in more costly repairs, damage to other
components or negatively impact vehicle perfor-
mance. Immediately have potential malfunctions
examined by an authorized dealer or qualified
repair center.
• Your vehicle has been built with improved fluids
that protect the performance and durability of
your vehicle and also allow extended mainte-
nance intervals. Do not use chemical flushes in
these components as the chemicals can damage
(Continued)
CAUTION! (Continued)
your engine, transmission, or air conditioning.
Such damage is not covered by the New Vehicle
Limited Warranty. If a flush is needed because of
component malfunction, use only the specified
fluid for the flushing procedure.
Engine Oil
Change Engine Oil
The oil change indicator system will remind you that it
is time to take your vehicle in for scheduled mainte-
nance. Refer to the “Maintenance Plan” for further
information.
NOTE:The actual interval for changing the oil and
replacing the engine oil filter depends on the vehicle
usage conditions and is signalled by the warning light
or message (if present) on the instrument panel or every
12 months.
Engine Oil Selection
For best performance and maximum protection for
turbocharged engines under all types of operating
conditions, the manufacturer recommends synthetic
8
SERVICING AND MAINTENANCE 209

CAUTION!(Continued)
condition. In the event of engine malfunction,
particularly involving engine misfire or other
apparent loss of performance, have your vehicle
serviced promptly. Continued operation of your
vehicle with a severe malfunction could cause the
converter to overheat, resulting in possible dam-
age to the converter and vehicle.
Under normal operating conditions, the catalytic con-
verter will not require maintenance. However, it is
important to keep the engine properly tuned to assure
proper catalyst operation and prevent possible catalyst
damage.
NOTE: Intentional tampering with emissions control
systems can result in civil penalties being assessed
against you.
In unusual situations involving grossly malfunctioning
engine operation, a scorching odor may suggest severe
and abnormal catalyst overheating. If this occurs, stop
the vehicle, turn off the engine and allow it to cool.
Service, including a tune-up to manufacturer’s specifi-
cations, should be obtained immediately.
To minimize the possibility of catalytic converter damage:
• Do not shut off the engine or interrupt the ignition,
when the transmission is in gear and the vehicle is in
motion.
• Do not try to start the engine by pushing or towing
the vehicle.
• Do not idle the engine with any spark plug wires
disconnected or removed, such as when diagnostic
testing, or for prolonged periods during very rough
idle or malfunctioning operating conditions.
Cooling System
WARNING!
• Turn vehicle off and disconnect the fan motor
lead before working near the radiator cooling fan.
•
You or others can be badly burned by hot engine
coolant (antifreeze) or steam from your radiator. If
you see or hear steam coming from under the hood,
do not open the hood until the radiator has had
time to cool. Never open a cooling system pressure
cap when the radiator or coolant bottle is hot.
(Continued)
216 SERVICING AND MAINTENANCE

Adding Brake Fluid
If the fluid level in the reservoir is not sufficient,
proceed as follows:
1. Take the black funnel for topping up the brake fluidand its extension pipe from the service kit in the
luggage compartment.
2. Loosen the reservoir plug and introduce the funnel with the extension pipe in the reservoir inlet.
3. After topping up, remove the funnel with the exten- sion pipe. 4. Tighten the reservoir plug.
5. Reposition the brake fluid protection panel and
tighten the two screws.
NOTE: Be very careful while removing the plug from
the opening to prevent the plug from falling inside the
vehicle body.
Alfa Twin Clutch Transmission
Selection Of Lubricant
It is important to use the proper transmission fluid to
ensure optimum transmission performance and life.
Use only the manufacturer ’s specified transmission
fluid. Refer to “Fluids And Lubricants” in “Technical
Specifications” for fluid specifications. It is important to
maintain the transmission fluid at the correct level
using the recommended fluid. No chemical flushes
should be used in any transmission; only the approved
lubricant should be used.
CAUTION!
Using a transmission fluid other than the manufac-
turer ’s recommended fluid may cause deterioration
(Continued)
Brake Fluid Funnel
224 SERVICING AND MAINTENANCE

CAUTION!(Continued)
in transmission shift quality. Refer to “Fluids And
Lubricants” in “Technical Specifications” for fluid
specifications.
Special Additives
The manufacturer strongly recommends against using
any special additives in the transmission.
Transmission fluid is an engineered product and its
performance may be impaired by supplemental addi-
tives. Therefore, do not add any fluid additives to the
transmission. The only exception to this policy is the
use of special dyes for diagnosing fluid leaks.
CAUTION!
Do not use chemical flushes in your transmission as
the chemicals can damage your transmission com-
ponents. Such damage is not covered by the New
Vehicle Limited Warranty.
Fluid Level Check
The fluid level is preset at the factory and does not
require adjustment under normal operating conditions. Frequent fluid level checks are not required, but have
your authorized dealer check the fluid level as specified
in the Maintenance Schedule to ensure proper transmis-
sion function and longevity. The transmission has no
dipstick, but your authorized dealer can check your
transmission fluid level using special service tools. If
you notice fluid leakage or transmission malfunction,
visit your authorized dealer immediately to have the
transmission fluid level checked. Operating the vehicle
with an improper fluid level can cause severe transmis-
sion damage.
Fluid Changes
Under normal operating conditions, the fluid installed
at the factory will provide satisfactory lubrication for
the life of the vehicle. However, change the fluid if it
becomes contaminated (with water, etc.), or if the
transmission is disassembled for any reason.
RAISING THE VEHICLE
In the case where it is necessary to raise the vehicle, go
to an authorized dealer or service station.
8
SERVICING AND MAINTENANCE 225

NOTE:* The following are essential to ensure correct
operation and prevent serious damage to the engine:
only use spark plugs of the same make and type, which
are specially certified for such engines that strictly
comply with the spark plug replacement interval given
in the maintenance schedule. For spark plug replace-
ment, it is advisable to contact the dedicated Alfa
Romeo Dealership. Refer to “Scheduled Servicing” in
“Servicing And Maintenance” for the required spark
plug intervals.
Chassis
Component Fluid, Lubricant, or Genuine Part
Alfa Twin Clutch Transmission
• Gearbox: Full synthetic 75W-85 manual transmission fluid meeting
MS.90021 or FPW9.55550–MZ3 or the API GL4 specification.
• Control System: Use only Mopar C Series DDCT SAE 75W Hydraulic
Fluid or equivalent.
Failure to use the correct fluid may affect the function or performance of
your transmission.
Brake Master Cylinder We recommend you use Mopar DOT 4 meeting MS.90039. If DOT 4 brake
fluid is not available, then DOT 3 is acceptable.
DOT 4 brake fluid must be changed every two years regardless of mileage.
9
TECHNICAL SPECIFICATIONS 263

Adding Engine Coolant (Antifreeze)...........218
Adding Fuel ........................... .158
Adding Washing Fluid ....................205
Additives, Fuel ......................... .258
AirBag ...............................110 Air Bag Operation ......................112
Air Bag Warning Light ..................109
Driver Knee Air Bag ....................113
Enhanced Accident Response ...........117,194
Event Data Recorder (EDR) ...............194
If Deployment Occurs ...................116
Knee Impact Bolsters ....................112
Maintaining Your Air Bag System ...........119
Maintenance ..........................119
Transporting Pets ..................... .129
Air Bag Light .....................77, 109, 131
Air Cleaner, Engine (Engine Air Cleaner Filter) . . .210
Air Conditioner Maintenance ................211
Air Conditioner Refrigerant ..............211,212
Air Conditioner System ....................211
Air Filter ............................. .210
Air Pressure Tires .............................. .236
Alarm System Security Alarm .........................20 Alfa DNA System (Dynamic Car Control System) .146
Alfa Twin Clutch Transmission............83, 141
Fluid Type ....................... .225, 263
Alterations/Modifications Vehicle ...............................5
Antifreeze (Engine Coolant) ..............217, 261
Disposal ............................ .220
Anti-Lock Brake System (ABS) ................88
Anti-Lock Warning Light ....................79
Automatic Transaxle .......................18
Automatic Transmission ...................141
Fluid Type .......................... .263
Battery ............................ .77, 208
Charging System Light ...................77
Keyless Key Fob Replacement ..............16
Belts, Seat ............................. .130
Body Mechanism Lubrication ................212
B-Pillar Location ........................ .231
Brake Fluid ........................... .263
Brake, Parking ......................... .139
Brake
System ....................... .221, 256
Anti-Lock (ABS) ........................88
Master Cylinder ...................... .221
Parking ............................ .139
276 INDEX

Enhanced Accident Response Feature.......117,194
Ethanol .............................. .259
Euro Twin Clutch Transmission Fluid Type .......................... .225
Exhaust Gas Cautions ..................130, 261
Exhaust System ..................... .130, 215
Exterior Lights ....................... .30, 133
Filters Air Cleaner ......................... .210
Engine Fuel ......................... .262
Engine Oil .......................... .210
Engine Oil Disposal ....................210
Flashers Hazard Warning ...................... .166
Turn Signals ...................... .82, 133
Flooded Engine Starting ...................138
Fluid, Brake ........................... .263
Fluid Capacities ........................ .261
Fluid Leaks ........................... .133
Fluids And Lubricants .....................262
Fold-Flat Seats ...........................25
Four-Way Hazard Flasher ..................166
Fuel ................................. .258
Adding ............................ .158Additives
........................... .258
Capacity ........................... .261
Clean Air ........................... .258
Ethanol ............................ .259
Gasoline ........................... .258
Materials Added ...................... .258
Methanol ........................... .259
Octane Rating ........................ .258
Requirements ........................ .258
Tank Capacity ....................... .261
Fueling .............................. .158
Fuses ................................ .177
Gasoline, Clean Air ...................... .258
Gasoline,

(Fuel) ..................... .258, 261
Gasoline, Reformulated ....................258
General Information ....................98, 268
General Maintenance ..................... .209
Glass Cleaning ......................... .254
Hazard Driving Through Flowing, Rising, Or Shallow
Standing Water ....................... .161
Hazard Warning Flashers ...................166
Headlights ..............................31
12
INDEX 279