2018 YAMAHA WOLVERINE warning

1-20
1
Head to Toe
Safety Checklist
YAMAHA 1XD-F1558-00HeadHelmet and eye protection.BodySeatbelt and protectiv
e clothing.HandsInside v
ehicle and holding the
handhold or steering wheel.FeetOn floor or footrests,
ready to brace, and door closed.
1XD-F8446-00
Be Prepared
Adju
st, lock and ne ver remo ve handhold.
Alw ays u se handhold, N ever hold cage.
Alw ays w ear seatb elt and helmet.YAMAHA 2MB-F1568-00
WARNING
DRIVER DRIVER
UNDER
UNDER16
16DRIVERUNDER16
Improper Use of Off-High way Vehicle Can Cau se Severe Inju ry or Death
Read Ow ner’s Man ual
Read Tips Gu ide for the Recreational Off-Highw ay Vehicle Driv er
Follo w All Instr uction and Warnings
Be Prepared
Driv
e Responsib ly If you
think or feel the v ehicle may tip or roll,
redu ce you r risk to inju ry:
Pay Attention and Plan Ahead
Do not allo w careless or reckless driv ing.
Do you
r part to pre vent inju ries:
Requ
ire Proper Use of Yo ur Vehicle
Rollo vers ha ve caused
se vere injuries and death,
e ven on flat, open areas.
Stay completely inside the
vehicle.
Passenger m
ust b e ab le to reach the handhold while
keeping feet flat on floor and sitting upright with
b ac
k against seat.
Dr

iv
er m ust b e ab le to comfortab ly reach all controls
w hile sitting u pright with back against seat.
W
ear an appro ved helmet, eye protection and protecti ve gear.
Fasten seat b
elts.

Do not allo w anyone to ride in the cargo b ed.
A
void side hilling (riding across slopes).
Plan for hills, rou
gh terrain, ruts, and other changes
in traction and terrain. A void pa ved su rfaces.
A
void hard acceleration w hen turning, e ven from a stop.
Slo
w do wn b efore entering a tu rn.
A
void ab ru pt maneuv ers, sideways sliding, skidding,
or fishtailing, and ne ver do don uts.
A
void loss of control and rollo vers: Do not p
ut an y part of you
r
body ou tside of
the v ehicle for any reason.
Keep a firm grip on the steering w
heel
or handhold and b race yourself.

Do not exceed seating capacity: 1 passenger.
Do not allo
w operation on pub lic roads
( u nless designated for off-highw ay vehicle access)
— collisions w ith cars and trucks can occu r.
Do not let people dri
ve or ride
after u sing alcohol or dr ugs.
Make su
re operators are 16 or older
w ith v alid driv er’s license.


10
11
12
UB3D7AE0.book Page 20 Tuesday, November 7, 2017 9:38 AM

4-2
4
EBU31268Indicator lights and warning lights
EBU31270Low-range indicator light “L”
This indicator light comes on when the drive
select lever is in the “L” position.EBU31280High-range indicator light “H”
This indicator light comes on when the drive
select lever is in the “H” position.
1. Differential gear lock indicator light “DIFF. LOCK”
2. Low-range indicator light “L”
3. High-range indicator light “H”
4. Neutral indicator light “N”
5. Reverse indicator light “R”
6. Parking brake indicator light “ ”
7. Drivetrain icon “ / ”
8. Engine trouble warning light “ ”
9. Coolant temperature warning light “ ”
10.Electric Power Steering warning light “EPS”356421
7
8109
1. Helmet indicator light “ ”
2. Seat belt indicator light “ ”
21
UB3D7AE0.book Page 2 Tuesday, November 7, 2017 9:38 AM

4-4
4
When the On–Command drive knob is set
to “DIFF LOCK” or “4WD”, the drivetrain
icon will flash until the differential has
locked or unlocked. Turn the steering wheel
back and forth or drive slowly to help the
differential gear lock to engage or disen-
gage. EBU31333Coolant temperature warning light “ ”
This light comes on to warn that the coolant
temperature is too hot. If the light comes on
during operation, stop the vehicle as soon as
it is safe to do so and allow the engine to cool
down for about 10 minutes. (See page 8-60.)TIPIf you continue to drive the vehicle while the
engine is overheating, a buzzer will sound. NOTICEECB03460Continuous use while this warning light is
on will damage the engine.
The electrical circuit of the warning light can
be checked by turning the key to “ ” (on). If
the warning light does not come on initially
when the key is turned to “ ” (on), or if the
warning light remains on, have a Yamaha
dealer check the electrical circuit.EBU31341Engine trouble warning light “ ”
This warning light comes on or flashes if a
problem is detected in the electrical circuit
monitoring the engine. When this occurs, the
display will indicate an error code (see page
4-10). Have a Yamaha dealer check the self-
diagnosis system.
The electrical circuit of the warning light can
be checked by turning the key to “ ” (on). If
the warning light does not come on initially
when the key is turned to “ ” (on), or if the
warning light remains on, have a Yamaha
dealer check the vehicle.
UB3D7AE0.book Page 4 Tuesday, November 7, 2017 9:38 AM

4-5
4
EBU33041Electric Power Steering warning light
“EPS”
This warning light comes on when the key is
turned to “ ” (on), and then goes off once
the engine is started. If the warning light re-
mains on or comes on after the engine is
started, the EPS system may not be working
correctly. When this occurs, have a Yamaha
dealer check the EPS system.
The electrical circuit of the warning light can
be checked by turning the key to “ ” (on). If
the warning light does not come on, have a
Yamaha dealer check the electrical circuit.TIPIf the steering load is too heavy (e.g., exces-
sive steering use at slow speed or when op-
erating in deep mud, sand, or snow), the
power assist is reduced to protect the EPS
motor from overheating.
EBU31360Helmet indicator light “ ”
The indicator light comes on and stays on
while the key is turned to “ ” (on) to remind
the occupants to always wear a helmet. If the
indicator light does not come on when the key
is turned to “ ” (on), have a Yamaha dealer
check the electrical circuit.EBU31370Seat belt indicator light “ ”
The indicator light comes on when the key is
turned to “ ” (on) to remind the occupants
to fasten their seat belt. The indicator light
stays on until the driver seat belt is properly
latched. If the indicator light does not come
on when the key is turned to “ ” (on), or if
the indicator light remains on after the driver
seat belt is properly latched, have a Yamaha
dealer check the electrical circuit.
UB3D7AE0.book Page 5 Tuesday, November 7, 2017 9:38 AM

4-10
4
(empty) as the fuel level decreases. When the
“E” segment disappears and the “ ” icon
flashes, refuel as soon as possible.TIPIf the electrical circuit for the fuel gauge is not
working correctly, all display segments
and “ ” will flash repeatedly. Have a Yamaha
dealer check the vehicle. Error code display This model is equipped with a self-diagnosis
device for various electrical circuits.
If a problem is detected in any of those cir-
cuits, the engine trouble warning light will
come on or flash, and the display will indicate
an error code.
If the display indicates an error code, note the
code number and have a Yamaha dealer
check the vehicle.
NOTICEECB00812If the multi-function display indicates an
error code, the vehicle should be checked
as soon as possible in order to avoid en-
gine damage.
1. Error code display
2. Engine trouble warning light “ ”
2
1
UB3D7AE0.book Page 10 Tuesday, November 7, 2017 9:38 AM

4-15
4
EBU33461SeatsTo remove a seat cushion, lift the front of the
cushion, and then pull the cushion off. To install a seat cush
ion, insert the projec-
tions on the rear of the seat cushion under the
seat frame, and then insert the projection on
the front of the cushion into the grommet
while pushing the cushion downward. Make
sure the seats are properly secured before
starting off. WARNING! A loose seat could
cause the operator to lose control, or cau-
se the operator or passenger to fall.
[EWB03510]
1. Door
2. Latch
2
1
1. Seat cushion
1
UB3D7AE0.book Page 15 Tuesday, November 7, 2017 9:38 AM

4-20
4
EBU31520Cup holdersBe sure to tightly close the cap of any plastic
bottle before placing it in a cup holder.
Some plastic bottles may not fit into the cup
holders depending on their size and shape.
WARNING
EWB03240Never ride with any open or glass con-
tainers in the cup holders; otherwise, the
contents may spill and the glass contain-
ers may be thrown about and break, and
possibly injure people in the vehicle dur-
ing sudden braking or an accident.
 Do not place any other items than seal-
able plastic containers in the cup hold-
ers; otherwise, they may be thrown about and possibly injure people in the
vehicle during sudden braking or an ac-
cident.
EBU33630Cargo bed
WARNING
EWB03250
Never carry passengers in the cargo
bed.
Maximum load limit:
Storage compartment between the driver
seat and the passenger seat:6.4 kg (13.5 lb)
1. Cup holder
1
UB3D7AE0.book Page 20 Tuesday, November 7, 2017 9:38 AM

4-23
4
WARNING
EWB02492Suspension components become hot
during operation. Never touch the com-
pression damping force adjusting bolt
and screw, the rebound damping force
adjusting screw or the oil reservoir with
your bare hand or skin until suspension
components have cooled.
 Always adjust the shock absorber as-
semblies on the left and right side to the
same setting. Uneven adjustment can
cause poor handling and loss of stability,
which could lead to an accident. NOTICEECB00091Never turn an adjusting mechanism be-
yond the minimum and maximum settings. TIPAlthough the total number of clicks or turns of
a damping force adjusting mechanism may
not exactly match the following specifications due to small differences in production, the ac-
tual number of clicks or turns always repre-
sents the entire adjusting range. To obtain a
precise adjustment, it would be advisable to
check the number of clicks or turns of each
damping force adjusting mechanism and to
modify the specifications as necessary.
Spring preload
1. Loosen the locknut.
2. Turn the spring preload adjusting nut in direction (a) to increase the spring pre-
load and thereby harden the suspension,
and in direction (b) to decrease the spring
preload and thereby soften the suspen-
sion.
UB3D7AE0.book Page 23 Tuesday, November 7, 2017 9:38 AM