2018 Seat Ibiza fuel pump

The essentials
Fluid level control Filling capacities Tank level
Petrol and die-
sel engines
40 l, 7 l reserve
Natural gas en-
gine a)
approx. 11.6 kga)
The capacity depends on the efficacy and charac-
teristics of the nat ur
al gas pumps. The capacity indi-
cated is based on a minimum loading pressure of 200
bar.
Capacity of the windscreen washer fluid con-
tainer Windscreen
washer fluid con-
t ainer appr

ox. 3 litres Fuel
Fig. 58
Fuel tank flap with tank cap attached. The tank flap is released electronically by
means of the centr
al l
ocking and is l

ocated
at the rear of the vehicle, on the right. The
tank holds approximately 40 litres.
Opening the fuel tank cap

Fuses and bulbs
No. Consumer/Amps
4 Petrol engine pump relay (MPI),
Gauge control unit (T
SI and Diesel)15
5 Pr
essure transducer, EPW Solenoid
Val v

e, TOG Sensor, PWM Electric
fan, Camshaft Control Valve, Active
Carbon Tank Valve and Oil Pressure
Regulating Valve (TSI) 10
6 Ignition coils (MPI and TSI)
20
Glow plug relay, Suction hose re-
sistance (Diesel) 7.5
7 V

acuum pump (TSI) 15
8 Injectors and EKP Relay Coil (MPI
and CNG), Fuel Metering V
al

ve (Die-
sel) 10
9 Servo sensor 7.5
10 Vref Battery: Gateway, BDM and
BCM 7.5
14 Engine Injection Module, Main En-
gine Relay, ESC 7.5
15 Aut

omatic Gearbox DQ200 and
AQ160 30
17 50 Diag 7.5
18 Starter Motor 30
20 ESC (Pump)
60
ABS (Pump) 40
21 ESC/ABS (Valves) 25 No. Consumer/Amps
24 TH4 Electric fan without A/C for
moderat
e climat

e countries 30
25 TH4 fan with A/C or T5I for moder-
ate climat
e countries 20
P

TC1 40
26 TJ1/TJ4/TJ7/T6P or TH4/T5I Electric
fan f
or w

arm climate countries 50
27 TH4 fan with A/C or T5I for moder-
ate climat
e countries 30
P

TC2 40
28 PTC3 40 Changing bulbs
Gener al not
es Read the additional information carefully

Start and driving
When starting a cold engine, it may be a little
noisy f or the first f
e
w seconds until oil pres-
sure has built up in the hydraulic valve com-
pensators. This is quite normal, and no cause
for concern.
If the engine does not start immediately,
switch the starter off after 10 seconds and try
again after half a minute. If the engine still
does not start, the fuel pump fuse should be
checked