2018 Ram ProMaster fuel pressure

CavityMaxi Fuse Mini Fuse Description
F09 –15 Amp Blue Rear Power Outlet
F10 –15 Amp Blue Horn
F11 –15 Amp Blue Fuel Pressure Regulator (MPROP)-DRV
(3.0 Diesel Engine) — If Equipped
F14 –20 Amp Yellow Power Outlet
F15 –7.5 Amp Brown USB Charger
F16 –7.5 Amp Brown KL15 Shifter Transmission Module (STM)
(3.6), KL15 Starter Relay Coil (3.6 Gasoline
Engine)
F16 –7.5 Amp Brown KL15 Manual Transmission Automated
(MTA), KL15 Gear Selector Unit, KL15 En-
gine Control Module (ECM), KL15 Starter
Relay Coil (3.0 Diesel Engine)
F17 –20 Amp Yellow Engine Control Module (ECM), Injectors
(3.6 Gasoline Engine)
F17 –20 Amp Yellow Secondary Loads, Engine Control Module
(ECM) (3.0 Diesel Engine)
F18 –7.5 Amp Brown KL30 Engine Control Module (ECM), KL30
Main Relay Coil (3.6 Gasoline Engine)
188 IN CASE OF EMERGENCY

Checking Oil Level — Gas Engine
To assure proper lubrication of your vehicle’s engine, the
engine oil must be maintained at the correct level. Check
the oil level at regular intervals, such as every fuel stop.
The best time to check the engine oil level is about five
minutes after a fully warmed up engine is shut off.
Checking the oil while the vehicle is on level ground will
improve the accuracy of the oil level readings. Always
maintain the oil level within the SAFE zone on the dipstick.
Adding one quart of oil when the reading is at the bottom
of the SAFE zone will result in a reading at the top of the
safe zone on these engines.
CAUTION!
Overfilling or underfilling will cause oil aeration or
loss of oil pressure. This could damage your engine.
Adding Washer Fluid
The fluid reservoir is located in the engine compartment
and should be checked at regular intervals. Fill the reser-
voir with windshield washer solvent (not radiator anti-
freeze) and operate the system for a few seconds to flush
out any residual water.The washer fluid reservoir will hold a full gallon of fluid
when the Low Washer Fluid Light illuminates.
WARNING!
Commercially available windshield washer solvents
are flammable. They could ignite and burn you. Care
must be exercised when filling or working around the
washer solution.
After the engine has warmed, operate the defroster for a
few minutes to reduce the possibility of smearing or
freezing the fluid on the cold windshield. Mopar All
Weather Windshield Washer Solution or equivalent, used
with water as directed on the container, aids cleaning
action, reduces the freezing point to avoid line clogging,
and is not harmful to paint or trim.
Maintenance-Free Battery
Your vehicle is equipped with a maintenance-free battery.
You will never have to add water, nor is periodic mainte-
nance required.
8
SERVICING AND MAINTENANCE 233

Fuel Economy
Underinflated tires will increase tire rolling resistance
resulting in higher fuel consumption.
Tread Wear
Improper cold tire inflation pressures can cause abnormal
wear patterns and reduced tread life, resulting in the need
for earlier tire replacement.
Ride Comfort And Vehicle Stability
Proper tire inflation contributes to a comfortable ride.
Over-inflation produces a jarring and uncomfortable ride.
Tire Inflation Pressures
The proper cold tire inflation pressure is listed on the
driver’s side B-Pillar or rear edge of the driver’s side door.
At least once a month:
•Check and adjust tire pressure with a good quality
pocket-type pressure gauge. Do not make a visual
judgement when determining proper inflation. Tires
may look properly inflated even when they are under-
inflated.
• Inspect tires for signs of tire wear or visible damage.
CAUTION!
After inspecting or adjusting the tire pressure, always
reinstall the valve stem cap. This will prevent moisture
and dirt from entering the valve stem, which could
damage the valve stem.
Inflation pressures specified on the placard are always
“cold tire inflation pressure”. Cold tire inflation pressure is
defined as the tire pressure after the vehicle has not been
driven for at least three hours, or driven less than 1 mile
(1.6 km) after sitting for a minimum of three hours. The
cold tire inflation pressure must not exceed the maximum
inflation pressure molded into the tire sidewall.
Check tire pressures more often if subject to a wide range
of outdoor temperatures, as tire pressures vary with tem-
perature changes.
Tire pressures change by approximately 1 psi (7 kPa) per
12°F (7°C) of air temperature change. Keep this in mind
when checking tire pressure inside a garage, especially in
the Winter.
Example: If garage temperature = 68°F (20°C) and the
outside temperature = 32°F (0°C) then the cold tire inflation
8
SERVICING AND MAINTENANCE 259

Adding Engine Coolant (Antifreeze).............243
Adding Washer Fluid ....................... .233
Additives, Fuel ........................... .282
AirBag..................................112 Air Bag Operation ........................114
Air Bag Warning Light .....................111
Enhanced Accident Response ................222
Event Data Recorder (EDR) .................223
If A Deployment Occurs ....................119
Maintaining Your Air Bag System .............122
Side Air Bags ...........................115
Transporting Pets ....................... .130
Air Bag Light ....................... .74, 111, 131
Air Bag Maintenance ....................... .122
Air Cleaner, Engine (Engine Air Cleaner Filter) ......236
Air Conditioner Maintenance ..................237
Air Conditioning Filter ....................52, 238
Air Conditioning, Operating Tips .............51, 53
Air Conditioning Refrigerant ...............237, 238
Air Conditioning System .....................237
Air Filter ............................... .236
Air Pressure, Tires ......................... .259
Alarm (Security Alarm) .......................21
Alarm System (Security Alarm) .................21
Alterations/Modifications, Vehicle ................6Antifreeze (Engine Coolant)
................242, 286
Disposal .............................. .244
Anti-Lock Brake System (ABS) ..................88
Anti-Lock Warning Light ......................80
Assist, Hill Start ............................94
Audio Systems (Radio) ...................... .290
Auto Down Power Windows ...................54
Automatic Door Locks ........................23
Automatic Transaxle .........................18
Automatic Transmission ..................140, 248
Adding Fluid .......................... .248
Fluid And Filter Changes ...................248
Fluid Change .......................... .248
Fluid Level Check .................... .247, 248
Fluid

Type ......................... .247, 288
Special Additives ........................ .247
Battery .............................. .75, 233
Charging System Light .....................75
Keyless Key Fob Replacement ................17
Belts, Seat ............................... .131
Body Builders Guide ..........................6
Body Mechanism Lubrication ..................239
B-Pillar Location .......................... .254
Brake Assist System .........................90
322 INDEX

Brake Control System, Electronic................89
Brake Fluid .......................... .246, 288
Brake, Parking ............................ .139
Brake System ......................... .246, 280
Anti-Lock (ABS) ..........................88
Fluid Check ........................... .246
Master Cylinder ........................ .246
Parking .............................. .139
Warning Light ...........................76
Brake/Transmission Interlock ..................142
Bulb Replacement ......................... .179
Bulbs, Light .......................... .133, 179
Camera, Rear ............................ .157
Capacities, Fluid .......................... .286
Caps, Filler Fuel ................................. .159
Oil (Engine) ........................... .232
Power Steering ......................... .150
Radiator (Coolant Pressure) .................244
Carbon Monoxide Warning ................131, 285
Cargo Area Features .........................57
Cargo Compartment .........................57
Cargo Light ...............................42
Car Washes .............................. .273Cellular Phone
........................... .306
Certification Label ......................... .161
Changing A Flat Tire .....................195, 248
Chart, Tire Sizing .......................... .250
Check Engine Light (Malfunction Indicator Light) ....84
Checking Your Vehicle For Safety ...............130
Checks, Safety ............................ .130
Child Restraint ........................... .123
Child Restraints Booster Seats ........................... .126
Child Restraints ........................ .123
Child Seat Installation .....................129
Infants And Child Restraints ................125
Older Children And Child Restraints ...........126
Clean

Air Gasoline ........................ .282
Cleaning Wheels ............................... .267
Climate Control ............................45
Cold Weather Operation ..................... .137
Compact Disc (CD) Maintenance ................314
Compact Spare Tire ........................ .265
Contract, Service .......................... .318
Coolant Pressure Cap (Radiator Cap) .............244
Cooling System ........................... .241
Adding Coolant (Antifreeze) .................243
12
INDEX 323

Service............................... .179
Tire Pressure Monitoring (TPMS) ............77, 95
Traction Control ..........................92
Turn Signal ....................... .38, 82, 133
Warning (Instrument Cluster Description) .....76, 82
Loading Vehicle ....................... .161, 163
Capacities ............................. .163
Tires................................. .254
Locks Automatic Door ..........................23
Door ..................................22
Low Tire Pressure System .....................95
Lubrication, Body ......................... .239
Lug Nuts ............................... .280
Maintenance Free Battery .....................233
Maintenance Schedule ...................... .227
Malfunction Indicator Light (Check Engine) ......80, 84
Manual, Service ........................... .320
Memory Feature (Memory Seat) .................23
Memory Seat ..............................23
Memory Seats And Radio .....................23
Methanol ............................... .283
Mirrors ..................................34
Electric Remote ...........................35 Exterior Folding
..........................35
Heated .................................38
Outside ................................35
Rearview ...............................34
Modifications/Alterations, Vehicle ................6
Monitor, Tire Pressure System ..................95
Mopar Parts ............................. .319
Multi-Function Control Lever ...................38
New Vehicle Break-In Period ..................138
Occupant Restraints .........................99
Octane Rating, Gasoline (Fuel) .................282
Oil, Engine ........................... .235, 286
Capacity .............................. .286
Change Interval ........................ .235
Dipstick .............................. .233
Disposal .............................. .236
Filter ............................. .236,
286
Filter Disposal .......................... .236
Identification Logo ...................... .235
Materials Added To ...................... .236
Pressure Warning Light .....................77
Recommendation .....................235, 286
Synthetic ............................. .236
328 INDEX