2018 KIA RIO HATCHBACK ignition

Maintenance
64
8
Engine compartment fuse
replacement
1. Turn the ignition switch and all
other switches off.
2. Remove the fuse panel cover by pressing the tab and pulling the
cover up. When the blade type
fuse is disconnected, remove it by
using the clip designed for chang-
ing fuses located in the engine
compartment fuse box. Upon
removal, securely insert reserve
fuse of the same rating. 3. Check the removed fuse; replace it
if it is blown. To remove or insert
the fuse, use the fuse puller in the
engine compartment fuse panel.
4. Push in a new fuse of the same rating, and make sure it fits tightly
in the clips. If it fits loosely, consult
an authorized Kia dealer.
Multi fuse
If the multi fuse is blown, it must be
removed as follows:
1. Turn off the engine.
2. Disconnect the negative batterycable.
3. Remove the nuts shown in the pic- ture above.
4. Replace the fuse with a new one of the same rating.
5. Reverse these steps to reinstall the multi fuse.
CAUTION
After checking the fuse panel inthe engine compartment,securely install the fuse panelcover through the audible click-ing sound.
If not, electrical failures mayoccur from water contact.
OYB076037
OYB076029

Maintenance
72
8
Engine room compartment fuse panel
Fuse NameFuse ratingCircuit Protected
MDPS80AMDPS (Motor Driven Power Steering) Unit
ALT150AFuse - ABS1, BAS2, BLOWER, REAR HEATED
REAR HEATED40AInstrument Panel Junction Block (Rear Defogger Relay)
ABS140AESC (Electronic Stability Control) Module, Multipurpose Check Connector
ABS240AESC (Electronic Stability Control) Module
BLOWER40ABlower Relay
WIPER10AFront Wiper Motor, Multifunction Switch, Wiper Low Relay
ECU415AECM (Engine Control Module)/PCM (Power train Control Module)
SENSOR10AOil Control Valve #1/#2, Cooling Fan1/2 Relay, Oxygen Sensor (Up), Oxygen Sensor (Down), Variable
Intake Solenoid Valve, Air Conditioner Relay, Purge Control Solenoid Valve, Canister Close Valve
ECU215AECM (Engine Control Module)/PCM (Power train Control Module)
ECU320AECM (Engine Control Module)/PCM (Power train Control Module)
HEAD LAMP RH10AHead Lamp Right Handle side
HEAD LAMP LH10AHead Lamp Left Handle side
IGN COIL20AIgnition Coil #1~#4, Condenser
ECU515AECM (Engine Control Module)/PCM (Power train Control Module), Fuel Pump Relay

873
Maintenance
Fuse NameFuse ratingCircuit Protected
B/UP LAMP10ABack-Up Lamp Switch
B+140AInstrument Panel Junction Block (Fuse - DRL2, FOGLAMP FRONT, STOP LAMP, MODULE6, Power
Connector (AUDIO, ROOM LAMP))
B+250AInstrument Panel Junction Block (Fuse - IMMO, SMART KEY, BRAKE SWITCH, SAFETY P/WINDOW,
S/HEATER, SUNROOF, Power Window Relay)
IG240AIgnition Switch, IG2 Relay, Start Relay
COOLING FAN40ACooling Fan1/2 Relay
ECU130AFuse - ECU3, ECU4, Main Relay
HEAD LAMP20AHead Lamp Relay
H/LAMP HI20AWith CANADA DRL : SLM(Seat Belt & Lighting Module) or BCM(Body Control Module)
Without CANADA DRL : Head Lamp HI Relay
FUEL PUMP20AFuel Pump Relay
HORN15AHorn Relay/ Burglar Alarm Horn Relay
A/CON10AAir Conditioner Relay
AMS10ABattery Sensor
B+340AInstrument Panel Junction Block (Fuse - T/SIGNAL LAMP, DOOR LOCK, Tail Lamp Relay)
IG140AIgnition Switch, IG1 Relay, ACC Relay
POWER OUTLET40AInstrument Panel Junction Block (Power Outlet Relay)

875
Maintenance
LIGHT BULBS
Bulb replacement precaution
Please keep extra bulbs on hand
with appropriate wattage ratings in
case of emergencies.
Refer to “Bulb Wattage” in chapter 9.
When changing lamps, first turn off
the engine at a safe place, firmly
apply the parking brake and detach
the battery’s negative (-) terminal.
Use only bulbs of the specifiedwattage. net-work failure
The headlamp, taillight, and fog light
may light up when the head lamp
switch is turned ON, and not light up
when the taillight or for light switch is
turned ON. This may be cause by
network failure or vehicle electrical
control system malfunction. If there is
a problem, we recommend the sys-
tem be serviced by an authorized Kia
dealer.
trical control system stabilization
A normally functioning lamp may
flicker momentarily. This momentary
occurrence is due to stabilization
function of the vehicle's electrical on
control system. If the lamp soon
returns to normal, the vehicle does
not require service.
However, if the lamp goes out after
the momentary flickering, or the flick-
ering continues, we recommend the
system be serviced by an authorized
Kia dealer.
WARNING- Working on the lights
Prior to working on the light,
firmly apply the parking brake,
ensure that the ignition switch
is turned to the LOCK position
and turn off the lights to avoid
sudden movement of the vehi-
cle and burning your fingers or
receiving an electric shock.
CAUTION -Light replace-
ment
Be sure to replace the burned- out bulb with one of the samewattage rating. Otherwise, itmay cause damage to the fuseor electric wiring system.
CAUTION -Headlamp
Lens
To prevent damage, do notclean the headlamp lens withchemical solvents or strongdetergents.

Your vehicle is equipped with a cat-
alytic converter emission control
device.
Therefore, the following precautions
must be observed:
Use only UNLEADED FUEL forgasoline engines.
Do not operate the vehicle when there are signs of engine malfunc-
tion, such as misfire or a noticeable
loss of performance.
Do not misuse or abuse the engine. Examples of misuse are
coasting with the ignition off and
descending steep grades in gear
with the ignition off.
Do not operate the engine at high idle speed for extended periods (5
minutes or more).
Do not modify or tamper with any part of the engine or emission con-
trol system. All inspections and
adjustments must be made by an
authorized Kia dealer.
Avoid driving with an extremely low fuel level. Running out of fuel could
cause the engine to misfire, dam-
aging the catalytic converter. Failure to observe these precautions
could result in damage to the catalyt-
ic converter and to your vehicle.
Additionally, such actions could void
your warranties.
Perchlorate Material-special handling
may apply, See www.dtsc.ca.gov/haz-
ardouswaste/ perchlorate.
Notice to California Vehicle Dismantlers:
Perchlorate containing materials,
such as air bag inflators, seatbelt
pretensioners and keyless remote
entry batteries, must be disposed of
according to Title 22 California Code
of Regulations Chapter 67384.10
(a).
CALIFORNIA
PERCHLORATE NOTICE
8112
Maintenance

Index
6I
Fuel filler lid ..................................................................4-38Opening the fuel filler lid ..........................................4-38
Closing the fuel filler lid ............................................4-38
Fuel gauge......................................................................4-\
55
Fuses ........................................................................\
......8-60 Inner panel fuse replacement ......................................8-62
Memory fuse ..............................................................8-63
Engine compartment fuse replacement ......................8-64
Fuse/relay panel description ......................................8-66
Gauges ........................................................................\
..4-54
Glove box ....................................................................4-12\
8
Glove box lamp............................................................4-101
Glove box lamp bulb replacement ................................8-99
Hazard warning flasher ....................................................7-2
Hazardous driving conditions ........................................6-57
Headlamp (Low/High beam) bulb replacement (Headlamp type B) ......................................................8-82
Headlamp (Low/High beam) bulb replacement (Headlamp Type A) ....................................................8-80
Headlight escort function ..............................................4-87
Headlight position..........................................................4-89
Headlight welcome function..........................................4-87 Headrest (Front) ..............................................................3-6
Heated steering wheel....................................................4-48
High - beam operation ..................................................4-90
High mounted stop lamp bulb replacement (4 door) ....8-96
High mounted stop lamp bulb replacement (5 door) ....8-91
Highway driving ............................................................6-60
Hill-start assist control (HAC) ......................................6-33
Hood ........................................................................\
......4-36
Opening the hood ........................................................4-36
Closing the hood ........................................................4-37
Hood open warning ....................................................4-37
Horn ........................................................................\
......4-47
Ignition switch position ..................................................6-6
Indicator lights ..............................................................4-82
Inside rearview mirror ..................................................4-49
Instrument cluster ..........................................................4-52 Instrument cluster control ..........................................4-53
LCD window control ..................................................4-53
Gauges ........................................................................\
4-54
Warning lights ............................................................4-74
Indicator lights ............................................................4-82
Interior care..................................................................8-106
Interior features............................................................4-131 Cup holder ................................................................4-131
Sunvisor ....................................................................4-13\
1
G
H
I

I7
Index
Seat warmer ..............................................................4-132
Power outlet ..............................................................4-133
USB charger ..............................................................4-134
Floor mat anchor(s) ..................................................4-136
Shopping bag holder ................................................4-136
Clothes hanger ..........................................................4-135
Covering shelf ..........................................................4-137
Interior light ..................................................................4-98 Map lamp ....................................................................4-98\
room lamp ..................................................................4-99
Luggage room lamp ..................................................4-101
Vanity mirror lamp ....................................................4-102
Glove box lamp ........................................................4-101
Jump starting....................................................................7-5
Key operations ................................................................4-4
Key positions ..................................................................6-6 Ignition switch position ................................................6-6
Keys ........................................................................\
........4-4 Record your key number ..............................................4-4
Key operations ..............................................................4-4 Label
Tire sidewall labeling ..................................................8-50
Vehicle certification label ..........................................9-10
Tire specification and pressure label ..........................9-11
LCD modes (for Type B cluster) ..................................4-64
LCD windows ................................................................4-59 Over view ....................................................................4-59\
Trip information ..........................................................4-59
LCD modes (for Type B cluster) ................................4-64
Service mode ..............................................................4-65
User settings mode(for Type B cluster) ......................4-65
Warning messages ......................................................4-69
License plate lamp bulb replacement (5,4 door) ..........8-91
Light bulb position (Front) ............................................8-77
Light bulb position (Rear) (4 door) ..............................8-79
Light bulb position (Rear) (5 door) ..............................8-78
Light bulb position (Side) ..............................................8-80
Light bulbs ....................................................................8-75\
Bulb replacement precaution ......................................8-75
Light bulb position (Front) ........................................8-77
Light bulb position (Rear) (5 door) ............................8-78
Light bulb position (Rear) (4 door) ............................8-79
Light bulb position (Side) ..........................................8-80
Headlamp (Low/High beam) bulb replacement (Headlamp Type A) ..................................................8-80
J
K
L

I11
Index
Side repeater lamp (Bulb type) bulb replacement ........8-86
Side repeater lamp (LED type) bulb replacement ........8-85
Sliding the sunroof ........................................................4-42
Smart key ........................................................................\
4-6Smart key functions ......................................................4-6
Smart key precautions ..................................................4-7
Smart key functions ........................................................4-6
Smart trunk (4 door) How to use the smart trunk ........................................4-23
How to deactivate the smart trunkfunction using the smart key ..................................................................4-25
Detecting area ............................................................4-25
Smooth cornering ..........................................................6-58
Snow tires ......................................................................6-\
61
Spare tire Jack and tools ..............................................................7-18
Removing and storing the spare tire ..........................7-19
Changing tires ............................................................7-20
Special driving conditions ............................................6-57 Hazardous driving conditions ....................................6-57
Rocking the vehicle ....................................................6-57
Smooth cornering ........................................................6-58
Driving at night ..........................................................6-58
Driving in the rain ......................................................6-59
Driving in flooded areas ............................................6-59
Driving off-road ..........................................................6-60
Highway driving ........................................................6-60
Speedometer ..................................................................4-54 Sport mode integrated control system ..........................6-53
SRS care ......................................................................3-\
54
SRS components and functions ..................................3-34
Starting difficulties, see engine will not start ..................7-4
Starting the engine ........................................................6-12 Starting the engine with an ignition key ....................6-12
Starting the engine with a smart key ..........................6-13
Steering wheel ..............................................................4-46 Electric power steering ..............................................4-46
Tilt and telescopic steering ........................................4-47
Heated steering wheel ................................................4-48
Horn ........................................................................\
....4-47
Stop and tail lamp (LED type) bulb replacement (4 door) ........................................................................\
8-96
Stop and tail lamp (LED type) bulb replacement (5 door) ........................................................................\
8-89
Stop and tail lamp/Side marker (Bulb type) replacement (4 door) ........................................................................\
8-93
Stop and tail lamp bulb replacement (5 door) ..............8-86
Storage compartment ..................................................4-128 Center console storage ..............................................4-128
Glove box ..................................................................4-128
Sunglass holder ........................................................4-129
Luggage net holder ..................................................4-129
Sunglass holder ............................................................4-129
Sunroof ........................................................................\
..4-41 Sliding the sunroof ......................................................4-42
Sunroof open warning ................................................4-42