2018 FORD POLICE INTERCEPTOR spare wheel

WARNINGS
Do not attempt to change a tire on
the side of the vehicle close to
moving traffic. Pull far enough off the
road to avoid the danger of being hit when
operating the jack or changing the wheel. Always use the jack provided as
original equipment with your vehicle.
If using a jack other than the one
provided, make sure the jack capacity is
adequate for the vehicle weight, including
any vehicle cargo or modifications. If you
are unsure if the jack capacity is adequate,
contact the authorized dealer. To reduce the risk of possible serious
injury or death, do not remove the full
size spare tire from the factory
secured location. This location is necessary
to achieve police-rated 75 mph (120 km/h)
rear impact crash-test performance.
Removal increases the risk of fuel leak in
high-speed rear impacts. Note:
Passengers should not remain in your
vehicle when the vehicle is being jacked.
Note: Jack at the specified locations to
avoid damage to the vehicle.
1. Park on a level surface, set the parking
brake and activate the hazard flashers.
2. Place the transmission in park (P) and
turn the engine off. 3. Block the diagonally opposite wheel.
4.
Lift truck cargo cover, then remove the
wingnut that secures the spare tire by
turning counterclockwise.
5. Remove the spare tire from the spare tire well.
6. Remove the wing nut bolt that secures
the jack kit by turning it
counterclockwise.
7. Remove the jack and the wrench from the bag. Fold down the wrench socket
to use to loosen the lug nuts and to
operate the jack.
8. Loosen each wheel lug nut one-half turn counterclockwise, but do not
remove them until the wheel is raised
off the ground. 9. The vehicle jacking points are shown
here, and are depicted on the warning
label on the jack. Small arrow-shaped
marks on the sills show the location of
the jacking points. 225
Taurus (CPH) Police, Canada/United States of America, enUSA, Edition date: 201708, Second Printing Wheels and TiresE142551 E145908 E201156

10. Raise the wheel by turning the jack
handle clockwise.
11. Remove the lug nuts with the lug wrench.
12. Replace the flat tire with the spare tire, marking sure the valve stem is
facing outward. Reinstall the lug nuts
until the wheel is snug against the
hub. Do not fully tighten the lug nuts
until the wheel has been lowered.
13. Lower the wheel by turning the jack handle counterclockwise.14.
Remove the jack and fully tighten the
lug nuts in the order shown. See
Technical Specifications (page
227). Stowing the jack and flat tire
1. Insert the straight end of the jack
retention bracket through the eyelet of
the angled bracket and swing the
retention bracket over the jack. With
the jack in place, place the end of the
retention bracket over the threaded
stud in the trunk floor and secure it with
the plastic wing nut.
2. Screw the extension bolt onto the threaded stud of the jack retention
bracket.
226
Taurus (CPH) Police, Canada/United States of America, enUSA, Edition date: 201708, Second Printing Wheels and Tires12
3
4
5
E75442 E211101

3. Place the flat tire in the spare tire well
with the wheel facing up.
4. Safely secure the wheel by screwing the large wing nut onto the extension
bolt.
TECHNICAL SPECIFICATIONS
Wheel Lug Nut Torque Specifications WARNING
When you install a wheel, always remove any corrosion, dirt or foreign materials
present on the mounting surfaces of the wheel or the surface of the wheel hub,
brake drum or brake disc that contacts the wheel. Make sure to secure any fasteners
that attach the rotor to the hub so they do not interfere with the mounting surfaces of
the wheel. Installing wheels without correct metal-to-metal contact at the wheel mounting
surfaces can cause the wheel nuts to loosen and the wheel to come off while your vehicle
is in motion, resulting in loss of vehicle control, personal injury or death. lb.ft (Nm)
1
Bolt size
110 lb.ft (150 Nm)
1/2-20 x 1.5
1 Torque specifications are for nut and bolt threads free of dirt and rust. Use only Ford
recommended replacement fasteners.
Retighten the lug nuts to the specified torque within 100 miles (160 kilometers) after any
wheel disturbance, such as tire rotation, changing a flat tire or wheel removal.
227
Taurus (CPH) Police, Canada/United States of America, enUSA, Edition date: 201708, Second Printing Wheels and TiresE239129

C
Cabin Air Filter.................................................85
California Proposition 65..............................11
Capacities and Specifications - 2.0L
EcoBoost™.................................................238
Alternative Engine Oil for Extremely Cold Climates............................................................ 241
Specifications..................................................... 238
Capacities and Specifications - 3.5L Duratec.........................................................242
Alternative Engine Oil for Extremely Cold Climates........................................................... 245
Specifications..................................................... 243
Capacities and Specifications - 3.5L Ecoboost™.................................................246
Alternative Engine Oil for Extreme Cold Climates........................................................... 250
Specifications...................................................... 247
Capacities and Specifications - 3.7L.................................................................250
Alternative Engine Oil for Extremely Cold Climates........................................................... 254
Specifications....................................................... 251
Capacities and Specifications................229
Car Wash See: Cleaning the Exterior............................... 197
Catalytic Converter......................................106 On-Board Diagnostics (OBD-II).................... 107
Readiness for Inspection and Maintenance (I/M) Testing.................................................... 107
Center Console................................................91
Console Mounting Plates................................... 91
Universal Top Tray................................................ 91
Changing a Bulb
............................................193
Front Fog Lamp................................................... 193
High-Intensity Discharge Headlamps.........193
LED Lamps............................................................ 194
License Plate Lamp........................................... 194
Changing a Fuse............................................172 Fuses........................................................................\
172
Changing a Road Wheel............................223 Dissimilar Spare Wheel and Tire Assembly
Information...................................................... 223
Tire Change Procedure.................................... 224
Changing the 12V Battery..........................189 Battery Management System......................... 191
Changing the Engine Air Filter.................196 Changing the Wiper Blades......................192
Checking the Wiper Blades.......................191
Child Restraint and Seatbelt
Maintenance.................................................34
Child Restraint Positioning
..........................27
Child Safety.......................................................18
General Information............................................. 18
Cleaning Leather Seats..............................201
Cleaning Products
........................................197
Materials................................................................. 197
Cleaning the Engine
....................................199
Cleaning the Exterior...................................197
Cleaning the Headlamps................................. 198
Exterior Chrome Parts...................................... 198
Exterior Plastic Parts......................................... 198
Stripes or Graphics............................................ 198
Underbody............................................................ 198
Under Hood.......................................................... 198
Cleaning the Instrument Panel and Instrument Cluster Lens........................200
Cleaning the Interior
..................................200
Cleaning the Wheels..................................202
Cleaning the Windows and Wiper Blades............................................................199
Climate Control
..............................................83
Coolant Check See: Engine Coolant Check............................. 181
Crash Sensors and Airbag Indicator.......44 Airbags and Police Equipment....................... 45
Cross Traffic Alert.........................................132 False Alerts........................................................... 134
Switching the System Off and On...............134
System Errors....................................................... 134
System Lights, Messages and Audible Alerts................................................................... 133
System Limitations............................................ 134
Using the System................................................ 132
Cruise Control
..................................................57
Principle of Operation....................................... 129
Cruise control See: Using Cruise Control................................ 129
Customer Assistance
..................................156
D
Data Recording
..................................................9
Event Data Recording.......................................... 10
Service Data Recording........................................ 9
354
Taurus (CPH) Police, Canada/United States of America, enUSA, Edition date: 201708, Second Printing Index

Filling a Portable Fuel Container..................
100
S
Safety Canopy ™............................................43
Safety Precautions........................................97
Scheduled Maintenance Record............314
Scheduled Maintenance..........................306
Seatbelt Extension
........................................35
Seatbelt Height Adjustment......................32
Seatbelt Reminder
.........................................33
Belt-Minder™........................................................ 33
Seatbelts...........................................................29 Principle of Operation........................................ 29
Seatbelt Warning Lamp and Indicator Chime...............................................................32
Conditions of operation..................................... 32
Seats...................................................................86
Security..............................................................55
Side Airbags.....................................................42
Sitting in the Correct Position...................86
Snow Chains See: Using Snow Chains.................................. 219
Spare Wheel See: Changing a Road Wheel........................ 223
Special Notices................................................12 My Fleet Management........................................ 13
New Vehicle Limited Warranty......................... 12
On-board Diagnostics (OBD-II)....................... 13
Special Instructions.............................................. 12
Special Operating Conditions Scheduled Maintenance................................................312
Engine Idle Hour Meter..................................... 313
Exceptions............................................................. 314
Speed Control See: Cruise Control............................................ 129
Stability Control
............................................123
Principle of Operation....................................... 123
Starter Switch See: Ignition Switch............................................. 92
Starting a Gasoline Engine.........................92 Cold Weather Starting - Flex Fuel
Vehicles............................................................... 93
Failure to Start....................................................... 93
Guarding Against Exhaust Fumes.................94
Important Ventilating Information................94
Stopping the Engine When Your Vehicle is Moving................................................................. 94Stopping the Engine When Your Vehicle is
Stationary.......................................................... 94
Starting and Stopping the Engine...........92 General Information............................................ 92
Steering............................................................135 Electric Power Steering.................................... 135
Steering Wheel
...............................................56
Storage Compartments...............................91
Sun Visors.........................................................68 Slide-on-rod.......................................................... 68
Supplementary Restraints System..........37 Principle of Operation......................................... 37
Symbols Glossary
.............................................7
SYNC™ Applications and Services........................................................282
911 Assist............................................................... 282
SYNC™ AppLink ™
.....................................284
SYNC Mobile Apps............................................ 284
SYNC™...........................................................264 General Information......................................... 264
SYNC™ Troubleshooting.........................295
T
Technical Specifications See: Capacities and Specifications............229
The Better Business Bureau (BBB) Auto Line Program (U.S. Only).......................158
Tire Care..........................................................205 Glossary of Tire Terminology........................ 206
Information About Uniform Tire Quality Grading............................................................. 205
Information Contained on the Tire Sidewall............................................................ 207
Police Wheels and Tires................................... 218
Temperature A B C............................................ 206
Traction AA A B C.............................................. 206
Treadwear............................................................ 205
Tire Pressure Monitoring System...........220 Changing Tires With a Tire Pressure
Monitoring System........................................ 221
Understanding Your Tire Pressure Monitoring System ....................................... 221
Tires See: Wheels and Tires..................................... 205
Towing a Trailer
.............................................142
Load Placement.................................................. 142
359
Taurus (CPH) Police, Canada/United States of America, enUSA, Edition date: 201708, Second Printing Index

Towing the Vehicle on Four
Wheels..........................................................146
Emergency Towing............................................. 146
Recreational Towing.......................................... 146
Towing...............................................................142
Traction Control.............................................122 Principle of Operation....................................... 122
Transmission Code Designation.............237
Transmission..................................................109
Transporting the Vehicle............................154
U
Under Hood Overview - 2.0L EcoBoost™..................................................175
Under Hood Overview - 3.5L Duratec/ 3.7L..................................................................176
Engine Shield........................................................ 177
Under Hood Overview - 3.5L Ecoboost™..................................................178
USB Port
.........................................................263
Using All-Wheel Drive..................................112 Driving In Special Conditions With
All-Wheel Drive (AWD)................................ 114
Operating AWD Vehicles With Mismatched Tires..................................................................... 114
Operating AWD Vehicles With Spare Tires...................................................................... 113
Using Cruise Control....................................129 Switching Cruise Control Off.......................... 129
Switching Cruise Control On.......................... 129
Using Snow Chains......................................219
Using Stability Control................................124
Using SYNC™ With Your Media Player............................................................285
Accessing Your Play Menu............................. 290
Connecting Your Digital Media Player to the USB Port.......................................................... 285
Media Menu Features...................................... 288
Media Voice Commands................................. 287
System Settings................................................. 292
What's Playing?................................................. 287
Using SYNC™ With Your Phone............269 Accessing Features Through the Phone
Menu.................................................................. 273
Accessing Your Phone Settings.................... 278
Making a Call........................................................ 272
Pairing Subsequent Cell Phones.................270 Pairing Your Cell Phone for the First Time
........................................................................\
..... 269
Phone Options during an Active Call..........272
Phone Voice Commands................................ 270
Receiving Calls.................................................... 272
System Settings................................................. 279
Text Messaging................................................... 276
Using Traction Control................................122 Switching the System Off................................ 122
System Indicator Lights and Messages.......................................................... 122
Using a Switch...................................................... 122
Using the Information Display Controls............................................................. 122
Using Voice Recognition...........................266 Initiating a Voice Session................................ 266
System Interaction and Feedback..............267
Utilizing the Mediation/Arbitration Program (Canada Only).........................159
V
Vehicle Care
....................................................197
General Information........................................... 197
Vehicle Certification Label........................237
Vehicle Identification Number................236
Vehicle Storage............................................202 Battery................................................................... 203
Body........................................................................\
202
Brakes.................................................................... 203
Cooling system................................................... 203
Engine.................................................................... 203
Fuel system.......................................................... 203
General.................................................................. 202
Miscellaneous..................................................... 203
Removing Vehicle From Storage.................203
Tires........................................................................\
203
Ventilation See: Climate Control........................................... 83
VIN See: Vehicle Identification Number............236
Voice Control....................................................57
W
Warning Lamps and Indicators.................70 Airbag readiness................................................... 70
Anti-Lock Braking System................................ 70
360
Taurus (CPH) Police, Canada/United States of America, enUSA, Edition date: 201708, Second Printing Index