2018 FORD POLICE INTERCEPTOR climate control

Protected Components
Fuse Amp Rating
Fuse or Relay
Number
Not used (spare).
15A
28
Radio.
20A
29
Global positioning system module.
Front park lamps.
15A
30
Brake signal for police equipment.
5A
31
Master window and mirror switch.
15A
32
Lock switch illumination.
Police console inline delayed accessory
feed.
Delayed accessory feed.
Not used (spare).
10A
33
Reverse park aid module.
10A
34
Blind spot monitor module.
Rear video camera.
Motorized humidity sensor.
5A
35
Overdrive cancel switch (Low gear switch
feed).
Column shift – low gear.
Not used (spare).
10A
36
Not used (spare).
10A
37
Auto–dimming mirror.
10A
38
Rear camera display mirror.
High beam headlamp shutters.
15A
39
Rear park lamps.
10A
40
Extended power module.
7.5A
41
Police 4-button steering wheel control
module.
5A
42
Not used (spare).
10A
43
Not used (spare).
10A
44
Not used (spare).
5A
45
Climate control module.
10A
46
171
Taurus (CPH) Police, Canada/United States of America, enUSA, Edition date: 201708, Second Printing Fuses

Note:
For flexible fuel vehicles, if you are
operating on E85, you may experience poor
starts or an inability to start the engine and
driveability problems until the fuel trim and
ethanol content have been relearned.
Make sure that you dispose of old batteries
in an environmentally friendly way. Seek
advice from your local authority about
recycling old batteries.
If storing your vehicle for more than 30
days without recharging the battery, we
recommend that you disconnect the
battery cables to maintain battery charge
for quick starting.
Battery Management System (If
Equipped)
The battery management system monitors
battery conditions and takes actions to
extend battery life. If excessive battery
drain is detected, the system temporarily
disables some electrical systems to
protect the battery.
Systems included are:
• Heated rear window.
• Heated seats.
• Climate control.
• Heated steering wheel.
• Audio unit.
• Navigation system.
A message may appear in the information
displays to alert you that battery
protection actions are active. These
messages are only for notification that an
action is taking place, and not intended to
indicate an electrical problem or that the
battery requires replacement. After battery replacement, or in some
cases after charging the battery with an
external charger, the battery management
system requires eight hours of vehicle sleep
time to relearn the battery state of charge.
During this time your vehicle must remain
fully locked with the ignition switched off.
Note:
Prior to relearning the battery state
of charge, the battery management system
may temporarily disable some electrical
systems.
Electrical Accessory Installation
To make sure the battery management
system works correctly, do not connect an
electrical device ground connection
directly to the battery negative post. This
can cause inaccurate measurements of
the battery condition and potential
incorrect system operation.
Note: If you add electrical accessories or
components to the vehicle, it may adversely
affect battery performance and durability.
This may also affect the performance of
other electrical systems in the vehicle.
CHECKING THE WIPER
BLADES Run the tip of your fingers over the edge of
the blade to check for roughness.
Clean the wiper blades with washer fluid
or water applied with a soft sponge or
cloth.
191
Taurus (CPH) Police, Canada/United States of America, enUSA, Edition date: 201708, Second Printing MaintenanceE142463

•
Cover interior trim to prevent fading.
• Keep all rubber parts free from oil and
solvents.
Engine
• Change the engine oil and filter prior to
storage because used engine oil
contains contaminates which may
cause engine damage.
• Start the engine every 15 days for a
minimum of 15 minutes. Run at fast idle
with the climate controls set to defrost
until the engine reaches normal
operating temperature.
• With your foot on the brake, shift
through all the gears while the engine
is running.
• We recommend that you change the
engine oil before you use your vehicle
again.
Fuel system
• Fill the fuel tank with high-quality fuel
until the first automatic shutoff of the
fuel pump nozzle.
Cooling system
• Protect against freezing temperatures.
• When removing your vehicle from
storage, check coolant fluid level.
Confirm that there are no cooling
system leaks and that fluid is at the
recommended level.
Battery
• Check and recharge as necessary. Keep
connections clean.
• If storing your vehicle for more than 30
days without recharging the battery,
we recommend that you disconnect
the battery cables to maintain battery
charge for quick starting. Note:
It is necessary to reset memory
features if battery cables are disconnected.
Brakes
• Make sure the brakes and parking brake
release fully.
Tires
• Maintain recommended air pressure.
Miscellaneous
• Make sure all linkages, cables, levers
and pins under your vehicle are covered
with grease to prevent rust.
• Move vehicles at least 25 ft (7.5 m)
every 15 days to lubricate working parts
and prevent corrosion.
Removing Vehicle From Storage
When your vehicle is ready to come out of
storage, do the following:
• Wash your vehicle to remove any dirt
or grease film build-up on window
surfaces.
• Check windshield wipers for any
deterioration.
• Check under the hood for any foreign
material that may have collected
during storage such as mice or squirrel
nests.
• Check the exhaust for any foreign
material that may have collected
during storage.
• Check tire pressures and set tire
inflation per the Tire Label.
• Check brake pedal operation. Drive
your vehicle
15 ft (4.5 m) back and
forth to remove rust build-up.
203
Taurus (CPH) Police, Canada/United States of America, enUSA, Edition date: 201708, Second Printing Vehicle Care

the government course as a tire
graded 100. The relative
performance of tires depends
upon the actual conditions of their
use, however, and may depart
significantly from the norm due to
variations in driving habits, service
practices, and differences in road
characteristics and climate.
Traction AA A B C
WARNING
The traction grade assigned
to this tire is based on
straight-ahead braking traction
tests, and does not include
acceleration, cornering,
hydroplaning or peak traction
characteristics. The traction grades, from highest
to lowest are AA, A, B, and C. The
grades represent the tire
’s ability
to stop on wet pavement as
measured under controlled
conditions on specified
government test surfaces of
asphalt and concrete. A tire
marked C may have poor traction
performance. Temperature A B C WARNING
The temperature grade for
this tire is established for a
tire that is properly inflated and
not overloaded. Excessive speed,
underinflation, or excessive
loading, either separately or in
combination, can cause heat
buildup and possible tire failure. The temperature grades are A
(the highest), B and C,
representing the tire
’s resistance
to the generation of heat and its
ability to dissipate heat when
tested under controlled conditions
on a specified indoor laboratory
test wheel. Sustained high
temperature can cause the
material of the tire to degenerate
and reduce tire life, and excessive
temperature can lead to sudden
tire failure. The grade C
corresponds to a level of
performance which all passenger
car tires must meet under the
Federal Motor Vehicle Safety
Standard No. 139. Grades B and A
represent higher levels of
performance on the laboratory
test wheel than the minimum
required by law.
Glossary of Tire Terminology
*Tire label: A label showing the
original equipment tire sizes,
recommended inflation pressure
and the maximum weight the
vehicle can carry.
206
Taurus (CPH) Police, Canada/United States of America, enUSA, Edition date: 201708, Second Printing Wheels and Tires

A
A/C
See: Climate Control........................................... 83
About This Manual...........................................7
ABS See: Brakes............................................................ 119
ABS driving hints See: Hints on Driving With Anti-Lock
Brakes................................................................ 120
Accessories See: Replacement Parts
Recommendation............................................ 12
Adjusting the Headlamps..........................192 Horizontal Aim Adjustment............................ 193
Vertical Aim Adjustment.................................. 192
Adjusting the Pedals.....................................58
Adjusting the Steering Wheel
...................56
Airbag Disposal...............................................49
Air Conditioning See: Climate Control........................................... 83
Air Filter See: Changing the Engine Air Filter.............196
Alarm See: Anti-Theft Alarm........................................ 55
All-Wheel Drive...............................................112
Anti-Theft Alarm
............................................55
Alarm System........................................................ 55
Arming the Alarm................................................. 55
Disarming the Alarm........................................... 55
Triggering the Alarm............................................ 55
Appendices....................................................326
At a Glance........................................................16
Audible Warnings and Indicators..............73 Headlamps On Warning Chime...................... 73
Key in Ignition Warning Chime......................... 73
Parking Brake On Warning Chime.................. 73
Audio Control..................................................56 Auxiliary Steering Wheel Controls.................57
Audio Input Jack...........................................262
Audio System................................................256 General Information......................................... 256
Audio Unit.......................................................257 Menu Structure................................................... 259
Autolamps.........................................................61 Windshield Wiper Activated
Headlamps......................................................... 61Automatic Transmission
...........................109
Automatic Transmission Adaptive
Learning............................................................... 111
Brake-Shift Interlock......................................... 109
If Your Vehicle Gets Stuck In Mud or Snow..................................................................... 111
Understanding the Positions of Your Automatic Transmission............................ 109
Automatic Transmission Fluid Check - 2.0L EcoBoost™........................................185
6F35 Transmission............................................ 185
Automatic Transmission Fluid Check - 3.5L Duratec/3.5L Ecoboost™/
3.7L..................................................................185
6F50/6F55 Transmission............................... 185
Adjusting Automatic Transmission Fluid Levels.................................................................. 187
Checking the fluid level.................................... 187
Moving the Air Filter Assembly (Accessing the Dipstick).................................................... 186
Reinstalling The Air Filter Assembly...........188
Auxiliary Power Points.................................90 12 Volt DC Power Point...................................... 90
Locations................................................................ 90
AWD See: All-Wheel Drive........................................... 112
B
Battery See: Changing the 12V Battery...................... 189
Blind Spot Information System..............130 Switching the System Off and On.................131
System Errors........................................................ 131
System Limitations............................................. 131
Using the System............................................... 130
BLIS See: Blind Spot Information System..........130
Bonnet Lock See: Opening and Closing the Hood............174
Booster Seats..................................................25 Types of Booster Seats...................................... 26
Brake Fluid Check
........................................188
Brakes................................................................119 General Information........................................... 119
Breaking-In......................................................147
Bulb Specification Chart...........................194
353
Taurus (CPH) Police, Canada/United States of America, enUSA, Edition date: 201708, Second Printing Index

C
Cabin Air Filter.................................................85
California Proposition 65..............................11
Capacities and Specifications - 2.0L
EcoBoost™.................................................238
Alternative Engine Oil for Extremely Cold Climates............................................................ 241
Specifications..................................................... 238
Capacities and Specifications - 3.5L Duratec.........................................................242
Alternative Engine Oil for Extremely Cold Climates........................................................... 245
Specifications..................................................... 243
Capacities and Specifications - 3.5L Ecoboost™.................................................246
Alternative Engine Oil for Extreme Cold Climates........................................................... 250
Specifications...................................................... 247
Capacities and Specifications - 3.7L.................................................................250
Alternative Engine Oil for Extremely Cold Climates........................................................... 254
Specifications....................................................... 251
Capacities and Specifications................229
Car Wash See: Cleaning the Exterior............................... 197
Catalytic Converter......................................106 On-Board Diagnostics (OBD-II).................... 107
Readiness for Inspection and Maintenance (I/M) Testing.................................................... 107
Center Console................................................91
Console Mounting Plates................................... 91
Universal Top Tray................................................ 91
Changing a Bulb
............................................193
Front Fog Lamp................................................... 193
High-Intensity Discharge Headlamps.........193
LED Lamps............................................................ 194
License Plate Lamp........................................... 194
Changing a Fuse............................................172 Fuses........................................................................\
172
Changing a Road Wheel............................223 Dissimilar Spare Wheel and Tire Assembly
Information...................................................... 223
Tire Change Procedure.................................... 224
Changing the 12V Battery..........................189 Battery Management System......................... 191
Changing the Engine Air Filter.................196 Changing the Wiper Blades......................192
Checking the Wiper Blades.......................191
Child Restraint and Seatbelt
Maintenance.................................................34
Child Restraint Positioning
..........................27
Child Safety.......................................................18
General Information............................................. 18
Cleaning Leather Seats..............................201
Cleaning Products
........................................197
Materials................................................................. 197
Cleaning the Engine
....................................199
Cleaning the Exterior...................................197
Cleaning the Headlamps................................. 198
Exterior Chrome Parts...................................... 198
Exterior Plastic Parts......................................... 198
Stripes or Graphics............................................ 198
Underbody............................................................ 198
Under Hood.......................................................... 198
Cleaning the Instrument Panel and Instrument Cluster Lens........................200
Cleaning the Interior
..................................200
Cleaning the Wheels..................................202
Cleaning the Windows and Wiper Blades............................................................199
Climate Control
..............................................83
Coolant Check See: Engine Coolant Check............................. 181
Crash Sensors and Airbag Indicator.......44 Airbags and Police Equipment....................... 45
Cross Traffic Alert.........................................132 False Alerts........................................................... 134
Switching the System Off and On...............134
System Errors....................................................... 134
System Lights, Messages and Audible Alerts................................................................... 133
System Limitations............................................ 134
Using the System................................................ 132
Cruise Control
..................................................57
Principle of Operation....................................... 129
Cruise control See: Using Cruise Control................................ 129
Customer Assistance
..................................156
D
Data Recording
..................................................9
Event Data Recording.......................................... 10
Service Data Recording........................................ 9
354
Taurus (CPH) Police, Canada/United States of America, enUSA, Edition date: 201708, Second Printing Index

Daytime Running Lamps.............................63
Decommissioning Requirements..........325
Police Engine Idle feature............................... 325
Vehicle Sealing of Aftermarket Equipment....................................................... 325
Decommissioning the Vehicle................325
Direction Indicators.......................................63
Doors and Locks.............................................52
Driver and Passenger Airbags...................38 Children and Airbags.......................................... 39
Proper Driver and Front Passenger Seating Adjustment........................................................ 38
Driving Aids
.....................................................130
Driving Hints....................................................147
Driving Through Water...............................148
DRL See: Daytime Running Lamps......................... 63
E
Economical Driving.......................................147
Emission Law
.................................................105
Noise Emissions Warranty, Prohibited
Tampering Acts and Maintenance.........106
Tampering With a Noise Control System............................................................... 105
End User License Agreement
..................326
VEHICLE SOFTWARE END USER LICENSE
AGREEMENT (EULA) ................................. 326
Engine Block Heater
.....................................94
Using the Engine Block Heater....................... 95
Engine Coolant Check.................................181 Adding Coolant.................................................... 181
Coolant Change.................................................. 183
Engine Coolant Temperature Management................................................... 184
Fail-Safe Cooling................................................ 183
Recycled Coolant................................................ 182
Severe Climates.................................................. 183
Engine Emission Control...........................105
Engine Oil Check
...........................................179
Adding Engine Oil............................................... 180
Engine Oil Dipstick - 2.0L EcoBoost™..................................................179
Engine Oil Dipstick - 3.5L Duratec/3.5L Ecoboost™/3.7L........................................179 Engine Specifications - 2.0L
EcoBoost™.................................................229
Drivebelt Routing............................................... 229
Engine Specifications - 3.5L Duratec.........................................................229
Drivebelt Routing............................................... 230
Engine Specifications - 3.5L Ecoboost™.................................................230
Drivebelt Routing............................................... 230
Engine Specifications - 3.7L......................231 Drivebelt Routing................................................ 231
Environment
......................................................15
Essential Towing Checks...........................144 Before Towing a Trailer..................................... 145
Hitches.................................................................... 144
Launching or Retrieving a Boat or Personal Watercraft (PWC)......................................... 145
Safety Chains....................................................... 144
Trailer Brakes........................................................ 144
Trailer Lamps....................................................... 144
When Towing a Trailer...................................... 145
Event Data Recording See: Data Recording.............................................. 9
Export Unique Options.................................14
Exterior Mirrors
................................................66
Blind Spot Information System...................... 67
Fold-Away Exterior Mirrors............................... 66
Heated Exterior Mirrors ..................................... 66
Integrated Blind Spot Mirror............................ 66
Power Exterior Mirrors........................................ 66
F
Fastening the Seatbelts..............................30 Seatbelt Locking Modes..................................... 31
Using Seatbelts During Pregnancy...............30
Flat Tire See: Changing a Road Wheel........................ 223
Floor Mats
.......................................................148
Foot Pedals See: Adjusting the Pedals................................. 58
Ford Credit
..........................................................11
US Only...................................................................... 11
Ford Protect
..................................................304
Ford Protect Extended Service Plan
(CANADA ONLY).......................................... 305
Ford Protect Extended Service Plans (U.S. Only)................................................................. 304
355
Taurus (CPH) Police, Canada/United States of America, enUSA, Edition date: 201708, Second Printing Index

Front Passenger Sensing System............39
Fuel and Refueling.........................................97
Fuel Consumption.......................................103
Calculating Fuel Economy.............................. 104
Filling the Fuel Tank.......................................... 104
Fuel Filler Funnel Location.........................99
Fuel Filter
.........................................................189
Fuel Quality - E85..........................................97 Choosing the Right Fuel - Flex Fuel
Vehicles............................................................... 97
Switching Between E85 and Gasoline........98
Fuel Quality - Gasoline................................99 Choosing the Right Fuel.................................... 99
Fuel Shutoff
.....................................................151
Fuses.................................................................163
Fuse Specification Chart...........................163 Passenger Compartment Fuse Panel........168
Power Distribution Box..................................... 163
G
Gauges...............................................................69 Fuel Gauge............................................................. 69
Information Display............................................. 69
Speedometer........................................................ 69
Gearbox See: Transmission.............................................. 109
General Information on Radio Frequencies...................................................50
General Maintenance Information
.......306
Multi-Point Inspection.................................... 308
Owner Checks and Services.......................... 307
Protecting Your Investment.......................... 306
Why Maintain Your Vehicle?......................... 306
Why Maintain Your Vehicle at Your Dealership?.................................................... 306
Getting Assistance Outside the U.S. and Canada..........................................................159
Getting the Services You Need
...............156
Away From Home............................................... 156
H
Handbrake See: Parking Brake............................................. 120
Hazard Flashers
..............................................151
Headlamp Adjusting See: Adjusting the Headlamps...................... 192Headlamp Exit Delay....................................62
Headrest
See: Head Restraints.......................................... 86
Head Restraints
..............................................86
Adjusting the Head Restraint........................... 87
Tilting Head Restraints ...................................... 87
Heated Windows and Mirrors....................85 Heated Exterior Mirror........................................ 85
Heated Rear Window......................................... 85
Heating See: Climate Control........................................... 83
Hill Start Assist..............................................120 Switching the System On and Off.................121
Using Hill Start Assist......................................... 121
Hints on Controlling the Interior Climate...........................................................84
Defogging the Side Windows in Cold Weather.............................................................. 85
General Hints......................................................... 84
Quickly Cooling the Interior.............................. 84
Quickly Heating the Interior............................. 84
Recommended Settings for Cooling............84
Recommended Settings for Heating...........84
Vehicle Stationary for Extended Periods During Extreme High Ambient
Temperatures................................................... 84
Hints on Driving With Anti-Lock Brakes
............................................................120
Hood Lock See: Opening and Closing the Hood............174
I
Ignition Switch.................................................92
In California (U.S. Only)
..............................157
Information Display Control.......................57
Information Displays.....................................74 General Information............................................ 74
Information Messages
..................................77
AdvanceTrac ™....................................................... 77
Alarm........................................................................\
. 77
AWD........................................................................\
.. 78
Battery and Charging System.......................... 78
Blind Spot Information and Cross Traffic Alert System...................................................... 79
Brake System......................................................... 79
Doors and Locks................................................... 79
Fuel........................................................................\
... 80
356
Taurus (CPH) Police, Canada/United States of America, enUSA, Edition date: 201708, Second Printing Index