2018 FORD F-650/750 door lock

Engine compartment (with engine off)
Inspect for glazing, fraying or cracking. There should be no
more than 5-7 cracks per rib, per 1 in (2.5 cm)
Belts (fan, alternator,
water pump and air
conditioning
compressor)
Inspect for signs of fluid puddles or dripping fluid on the
ground under the engine, or the underside of the engine.
Fluid leaks
Inspect for debris that may have collected on the HVAC air
inlet grille or inside the exterior module as this may reduce
system performance.
HVAC air inlet Engine starting (with parking brake applied)
Before entering the cab, verify that the vehicle is equipped
with spare electrical fuses (if used), three red reflective
triangles, a properly charged and rated fire extinguisher and
wheel chocks.
Safety and emergency
equipment
Walk around the vehicle and verify all steps and grab handles,
inside and out (as well as behind), are tight and clean. Use
extreme caution and a three-point stance at all times.
Inspect door latches for proper closing, latching and locking.
Set the parking brake. Make sure the gearshift lever is in
neutral (N) or park (P) (if equipped with a park position).
Starting the engine
Diesel engine:
Turn the key to the on position. Turn the key
to start when the wait to start indicator light in the instrument
cluster turns off.
Gasoline engine:
Turn the key to start, and then release it
as soon as the engine starts.
Verify pressure builds to normal operating range.
Engine oil pressure
A tone indicating low air pressure should sound immediately
after the engine starts but before the compressor has built-
up pressure. The tone should stop when the air pressure
reaches
70 psi (483 kPa). Let the air pressure build to
governed cutout pressure, which should occur between
115– 130 psi (793–896 kPa)
.
Low air pressure warning
tone (if equipped with an
air compressor)
Press the accelerator and verify that it operates smoothly,
without any binding or irregular feel. Release the pedal and
verify the engine returns to idle speed immediately.
Accelerator
177
F650750 (TBC) , enUSA, Edition date: 201708, First Printing Vehicle Inspection Guide

When washing and waxing, park your
vehicle in a shaded area out of direct
sunlight. Always wash your vehicle before
applying wax.
•
Use a quality wax that does not contain
abrasives.
• Follow the manufacturer ’s instructions
to apply and remove the wax.
• Apply a small amount of wax in a
back-and-forth motion, not in circles.
• Do not allow wax to come in contact
with any non-body (low-gloss black)
colored trim. The wax will discolor or
stain the parts over time.
•Roof racks.
• Bumpers.
• Grained door handles.
• Side moldings.
• Mirror housings.
• Windshield cowl area.
• Do not apply wax to glass areas.
• After waxing, your car's paint should
feel smooth, and be free of streaks and
smudges.
CLEANING THE ENGINE
Engines are more efficient when they are
clean because grease and dirt buildup keep
the engine warmer than normal.
When washing:
• Take care when using a power washer
to clean the engine. The high-pressure
fluid could penetrate the sealed parts
and cause damage.
• Do not spray a hot engine with cold
water to avoid cracking the engine
block or other engine components. •
Spray Motorcraft Engine Shampoo and
Degreaser on all parts that require
cleaning and pressure rinse clean. In
Canada, use Motorcraft Engine
Shampoo.
• Never wash or rinse the engine while it
is hot or running; water in the running
engine may cause internal damage.
• Never wash or rinse any ignition coil,
spark plug wire or spark plug well, or
the area in and around these locations.
• Cover the battery, power distribution
box, and air filter assembly to prevent
water damage when cleaning the
engine.
CLEANING THE WINDOWS AND
WIPER BLADES
Car wash chemicals and environmental
fallout can result in windshield and wiper
blade contamination. Dirty windshield and
wipers will result in poor windshield wiper
operation. Keep the windshield and wiper
blades clean to maintain windshield wiper
performance.
To clean the windshield and wiper blades:
• Clean the windshield with a
non-abrasive glass cleaner. When
cleaning the interior of the windshield,
avoid getting any glass cleaner on the
instrument panel or door panels. Wipe
any glass cleaner off these surfaces
immediately.
• For windshields contaminated with
tree sap, chemicals, wax or bugs, clean
the entire windshield using steel wool
(no greater than 0000 grade) in a
circular motion and rinse with water.
• Clean the wiper blades with isopropyl
rubbing alcohol or windshield washer
concentrate.
231
F650750 (TBC) , enUSA, Edition date: 201708, First Printing Vehicle Care

USING SNOW CHAINS
WARNING
Snow tires must be the same size,
load index, and speed rating as those
originally provided by Ford. Use of
any tire or wheel not recommended by
Ford can affect the safety and
performance of your vehicle, which could
result in an increased risk of loss of vehicle
control, vehicle rollover, personal injury,
and death. Additionally, the use of
non-recommended tires and wheels could
cause steering, suspension, axle, transfer
case, or power transfer unit failure. It is also
strongly advised to follow the Ford
recommended tire inflation pressure found
on the Safety Compliance Certification
Label (affixed to either the door hinge
pillar, door-latch post, or the door edge
that meets the door-latch post, next to the
driver ’s seating position), or Tire Label
which is located on the B-Pillar or the edge
of the driver door. Failure to follow the tire
pressure recommendations can cause
uneven treadwear patterns and adversely
affect the way your vehicle handles. The tires on your vehicle have all-weather
treads to provide traction in rain and snow.
However, in some climates, you may need
to use snow tires and cables. If you need
to use cables, it is recommended that steel
wheels (of the same size and
specifications) be used, as cables may chip
aluminum wheels.
Note:
The suspension insulation and
bumpers help prevent vehicle damage. Do
not remove these components from your
vehicle when using snow tires and chains.
Follow these guidelines when using snow
tires and chains:
• If possible, avoid fully loading your
vehicle.
• Use only SAE Class S chains. •
Install chains securely, verifying that
the chains do not touch any wiring,
brake lines or fuel lines.
• Drive cautiously. If you hear the chains
rub or bang against your vehicle, stop
and retighten the chains. If this does
not work, remove the chains to prevent
damage to your vehicle.
• Remove the tire chains when they are
no longer needed. Do not use tire
chains on dry roads.
If you have any questions regarding snow
chains or cables, please contact your
authorized dealer.
CHANGING A ROAD WHEEL
If you get a flat tire while driving, do not
apply the brake heavily. Instead, gradually
decrease your speed. Hold the steering
wheel firmly and slowly move to a safe
place on the side of the road.
Tire Change Procedure WARNINGS
When one of the front wheels is off
the ground, the transmission alone
will not prevent the vehicle from
moving or slipping off the jack, even if the
transmission is in park (P). To help prevent the vehicle from
moving when you change a tire, be
sure to place the transmission in park
(P), set the parking brake and block (in
both directions) the wheel that is
diagonally opposite (other side and end of
the vehicle) to the tire being changed. Never get underneath a vehicle that
is supported only by a jack. If the
vehicle slips off the jack, you or
someone else could be seriously injured.
251
F650750 (TBC) , enUSA, Edition date: 201708, First Printing Wheels and Tires

Check Every Month
Air filter restriction gauge. 1
Engine oil level.
Fuel and water separator. Drain if necessary, or if indicated by the information display. 1
Function of all interior and exterior lights.
Holes and slots in the tail pipe to make sure they are functional and clear of debris. 1
Tires (including spare) for wear and proper pressure. Windshield washer fluid level.
1 Diesel engine only. Check Every Six Months
Battery connections. Clean if necessary.
Body and door drain holes for obstructions. Clean if necessary.
Cooling system fluid level and coolant concentration (freeze-point protection). Door weatherstrips for wear. Lubricate if necessary.
Hinges, latches and outside locks for proper operation. Lubricate if necessary. Parking brake for proper operation.
Safety belts and seat latches for wear and function.
Safety warning lamps (brake, ABS, airbag and safety belt) for operation.
Washer spray and wiper operation. Clean or replace blades as necessary.
323
F650750 (TBC) , enUSA, Edition date: 201708, First Printing Scheduled Maintenance

2
2-Speed Rear Axle.......................................120
Axle Shifting......................................................... 120
A
A/C See: Climate Control........................................... 72
About This Manual
...........................................7
Diesel Engine Information................................... 8
Minor Troubleshooting Guide............................ 9
Warnings.................................................................... 8
ABS See: Brakes............................................................. 121
ABS driving hints See: Hints on Driving With Anti-Lock
Brakes................................................................. 122
Accessories.....................................................316
Accessories See: Replacement Parts
Recommendation............................................ 13
Adjusting the Headlamps
.........................210
Horizontal Aim Adjustment............................. 211
Vertical Aim Adjustment................................. 210
Adjusting the Steering Wheel...................46
Air Brakes.........................................................125 Air Chamber Stroke Indication...................... 125
Cam Brakes - Automatic Slack Adjusters........................................................... 125
Emergency Air Brake......................................... 126
Air Conditioning See: Climate Control........................................... 72
Air Filter See: Changing the Engine Air Filter - 6.7L
Diesel.................................................................. 213
See: Changing the Engine Air Filter - 6.8L...................................................................... 217
Air Induction System Inspection.............221 Chassis-mounted Charge Air Cooler..........222
Air Suspension
................................................141
Air Suspension Dump Button......................... 141
Connecting and Disconnecting a Trailer with Air Suspension and Air Suspension
Dump Button.................................................... 141
Suspension Conversions................................... 141
System Indicator Light....................................... 141
Appendices....................................................350 At a Glance
.........................................................17
Audible Warnings and Indicators.............63 Beltminder Warning............................................ 63
Door Ajar.................................................................. 63
Headlamps On Warning Chime...................... 63
Key in Ignition Warning Chime........................ 63
Parking Brake On Warning Chime.................. 63
Audio Control..................................................46 Media........................................................................\
. 47
Seek, Next or Previous........................................ 47
Audio Input Jack...........................................283
Audio System................................................276 General Information.......................................... 276
Audio Unit - Vehicles With: AM/FM/CD/ SYNC
..............................................................277
Audio Unit - Vehicles With: AM/ FM
...................................................................279
Automatic Transmission.............................114
Brake-Shift Interlock........................................... 117
If Your Vehicle Gets Stuck In Mud or Snow................................................................... 118
Understanding the Shift Positions of a 6– Speed Automatic Transmission..........114
Understanding your SelectShift™ Automatic transmission............................... 115
Automatic Transmission Fluid Check............................................................203
Transmission Fluid Level................................ 204
Auxiliary Power Points.................................83 110 Volt AC Power Point..................................... 83
12 Volt DC Power Point....................................... 83
Locations................................................................. 83
Auxiliary Switches
........................................316
Axle Inspection.............................................226
Front Axle.............................................................. 226
B
Battery See: Changing the 12V Battery...................... 207
Bonnet Lock See: Opening and Closing the Hood...........186
Booster Seats
...................................................27
Types of Booster Seats....................................... 27
Brake Fluid Check........................................205
Brakes.................................................................121 General Information............................................ 121
375
F650750 (TBC) , enUSA, Edition date: 201708, First Printing Index

D
Data Recording.................................................12
Service Data Recording....................................... 12
Daytime Running Lamps............................50
Diesel Particulate Filter..............................109
Oxidation Catalytic Converter and Diesel
Particulate Filter System............................. 110
Direction Indicators
........................................51
Doors and Locks.............................................42
Draining the Fuel Filter Water Trap - 6.7L Diesel............................................................206
Draining the Diesel Fuel Conditioner Module (DFCM)............................................................ 206
Driving Aids.....................................................139
Driving Hints
...................................................148
Driving Through Water................................152
Operation in Standing Water.......................... 152
DRL See: Daytime Running Lamps......................... 50
E
Economical Driving
......................................149
Electrical System Inspection....................221 Accessory Feed Connections......................... 221
Electromagnetic Compatibility
..............350
Electronic Locking Differential.................119 Activating the Locking Differential..............120
Driver-Controlled Locking Differential.........119
Servicing a Vehicle with a Locking
Differential....................................................... 120
Emission Law
.................................................102
Noise Emissions Warranty, Prohibited
Tampering Acts and Maintenance..........103
Tampering With a Noise Control System............................................................... 102
End User License Agreement..................352 SYNC End User License Agreement
(EULA).............................................................. 352
Engine Block Heater
.....................................90
Rapid Heat Supplemental Heating
System................................................................. 91
Using the Engine Block Heater......................... 91
Engine Coolant Check - 6.7L Diesel.............................................................194
Adding Coolant................................................... 194Checking Coolant Corrosion Inhibitor
Additive Strength .......................................... 197
Coolant Change.................................................. 198
Engine and Secondary Cooling System Refill Procedure.............................................. 196
Engine-driven Cooling Fan (Fan Clutch)............................................................... 198
Recycled Coolant................................................ 197
Severe Climates................................................... 197
Engine Coolant Check - 6.8L...................198 Adding Coolant................................................... 199
Coolant Change.................................................. 201
Engine Coolant Temperature Management.................................................. 202
Engine-driven Cooling Fan (Fan Clutch)............................................................... 201
Fail-Safe Cooling................................................ 201
Recycled Coolant.............................................. 200
Severe Climates.................................................. 201
Engine Emission Control
............................102
Engine Idle Shutdown..................................90
Engine Immobilizer See: Passive Anti-Theft System..................... 44
Engine Oil Check - 6.7L Diesel.................190 Adding Engine Oil............................................... 190
Engine lubrication for severe service operation ........................................................... 191
Engine Oil Check - 6.8L...............................191 Adding Engine Oil................................................ 191
Engine Oil Dipstick - 6.7L Diesel.............190
Engine Oil Dipstick - 6.8L
..........................190
Engine Specifications - 6.7L Diesel.......255 Drivebelt Routing............................................... 255
Engine Specifications - 6.8L
...................256
Drivebelt Routing................................................ 257
Entering, Exiting or Climbing on This Vehicle..............................................................15
Environment.....................................................16
Essential Towing Checks...........................145 Before Towing a Trailer..................................... 145
Hitches.................................................................... 145
Safety Chains....................................................... 145
Trailer Brakes........................................................ 145
Trailer Lamps........................................................ 145
When Towing a Trailer...................................... 145
Event Data Recording See: Data Recording............................................. 12
377
F650750 (TBC) , enUSA, Edition date: 201708, First Printing Index

Getting the Services You Need................159
Away From Home............................................... 159
H
Handbrake See: Parking Brake.............................................. 122
Hazard Flashers............................................154
Headlamp Adjusting See: Adjusting the Headlamps...................... 210
Headlamp Removal See: Removing a Headlamp............................ 211
Headrest See: Head Restraints........................................... 75
Head Restraints...............................................75 Adjusting the Head Restraint........................... 76
Heated Exterior Mirrors.................................74
Heating See: Climate Control........................................... 72
Hints on Controlling the Interior Climate
............................................................73
Defogging the Side Windows in Cold
Weather............................................................... 74
General Hints.......................................................... 73
Quickly Cooling the Interior............................... 73
Quickly Heating the Interior.............................. 73
Recommended Settings for Cooling.............73
Recommended Settings for Heating............73
Vehicle Stationary for Extended Periods During Extreme High Ambient
Temperatures.................................................... 73
Hints on Driving With Anti-Lock Brakes.............................................................122
Hood Lock See: Opening and Closing the Hood...........186
I
Ignition Switch
................................................86
In California (U.S. Only).............................160
Information Display Control.......................47
Information Displays
....................................64
General Information........................................... 64
Information Messages
.................................66
Diesel Messages................................................... 67
Engine....................................................................... 70
Fuel........................................................................\
.... 70
Key........................................................................\
..... 70Maintenance..........................................................
70
Park Brake................................................................. 71
Installing Child Restraints...........................20 Child Seats.............................................................. 20
Tether Strap Attachment.................................. 26
Using Cinch Tongue Lap and Shoulder Belts (All Front Center, Super Cab and Crew
Cab Rear Center Positions)......................... 23
Using Lap and Shoulder Belts.......................... 21
Using Lower Anchors and Tethers for CHildren (LATCH)............................................ 25
Using Tether Straps............................................. 25
Instrument Cluster
........................................56
Instrument Lighting Dimmer.....................50
Instrument Panel Overview.........................17
Interior Lamps
..................................................51
Interior Mirror...................................................55
Introduction.........................................................7
J
Jump Starting the Vehicle.........................155 Connecting the Jumper Cables..................... 155
Jump Starting....................................................... 156
Preparing Your Vehicle...................................... 155
Removing the Jumper Cables........................ 156
K
Keys and Remote Controls........................40
L
Lighting Control..............................................49 Headlamp Flasher............................................... 50
High Beams............................................................ 49
Lighting..............................................................49 General Information............................................ 49
Limited Slip Differential
..............................119
Load Carrying.................................................140
Load Limit.......................................................140
Unloaded or Lightly Loaded Vehicles.........140
Locking and Unlocking
.................................42
Autolock and Autounlock.................................. 42
Battery Saver......................................................... 43
Illuminated Entry.................................................. 43
Power Door Locks................................................ 42
Remote Control..................................................... 42
379
F650750 (TBC) , enUSA, Edition date: 201708, First Printing Index

Smart Unlocks.......................................................
42
Lug Nuts See: Changing a Road Wheel......................... 251
M
Maintenance..................................................185 General Information.......................................... 185
Manual Climate Control...............................72
Manual Seats....................................................77 Manual Lumbar .................................................... 78
Moving the Seat Backward and Forward................................................................ 77
Recline Adjustment.............................................. 77
Tilting the Seatback Forward (Two-Passenger Bench Seat).................... 78
Message Center See: Information Displays................................. 64
Mirrors See: Windows and Mirrors................................ 52
Mobile Communications Equipment......14
Motorcraft Parts - 6.7L Diesel..................257
Motorcraft Parts - 6.8L..............................258
N
Noise Pollution Control.................................16 Air Intake System.................................................. 16
Body........................................................................\
... 16
Cooling System...................................................... 16
Engine........................................................................\
16
Exhaust System..................................................... 16
Transmission Enclosure...................................... 16
Normal Scheduled Maintenance
...........325
Intelligent Oil-Life Monitor™ (Diesel Engine
Only).................................................................. 325
Normal Maintenance Intervals..................... 326
O
Oil Change Indicator Reset.......................194
Oil Check See: Engine Oil Check - 6.7L Diesel.............190
See: Engine Oil Check - 6.8L........................... 191
Opening and Closing the Hood..............186 Closing the Hood................................................ 187
Opening the Hood............................................. 186Ordering Additional Owner's
Literature......................................................163
Obtaining a French Owner ’s Manual..........163
Overhead Console
.........................................85
P
Parking Brake
..................................................122
Air Brakes............................................................... 123
Hydraulic Brakes.................................................. 122
Passive Anti-Theft System........................44 SecuriLock®........................................................... 44
PATS See: Passive Anti-Theft System..................... 44
Perchlorate........................................................13
Power Door Locks See: Locking and Unlocking............................. 42
Power Seats
.....................................................78
Air-Ride Seat.......................................................... 79
Power Steering Fluid Check....................205
Power Take-Off..............................................118
Power Windows
..............................................52
Bounce-Back......................................................... 52
One-Touch Up or Down..................................... 52
Window Lock......................................................... 52
Protecting the Environment........................16
R
Rear Axle Fluid Check
.................................227
Changing the Fluid............................................ 228
Checking the Fluid Level................................. 228
Rear Axle...........................................................119 General Information........................................... 119
Rear Seat Armrest
.........................................82
Rear Seats........................................................80 Folding the Rear Seat Back (Crew Cab)
........................................................................\
....... 80
Folding up the Rear Seat Cushion.................80
Returning the Seat to the Seating Position............................................................... 80
Recommended Towing Weights............144
Refueling - Diesel
...........................................97
Fuel Filler Cap....................................................... 98
Fuel Fill Rate.......................................................... 98
Refueling - Gasoline.....................................98 Fuel Filler Cap....................................................... 99
380
F650750 (TBC) , enUSA, Edition date: 201708, First Printing Index