2018 FORD F-53 parking brake

General
•
Store all vehicles in a dry, ventilated
place.
• Protect from sunlight, if possible.
• If vehicles are stored outside, they
require regular maintenance to protect
against rust and damage.
Body
• Wash your vehicle thoroughly to
remove dirt, grease, oil, tar or mud from
exterior surfaces, rear-wheel housing
and the underside of front fenders.
• Periodically wash your vehicle if it is
stored in exposed locations.
• Touch-up exposed or primed metal to
prevent rust.
• Cover chrome and stainless steel parts
with a thick coat of auto wax to prevent
discoloration. Re-wax as necessary
when you wash your vehicle.
• Lubricate all hood, door and luggage
compartment hinges and latches with
a light grade oil.
• Cover interior trim to prevent fading.
• Keep all rubber parts free from oil and
solvents.
Engine
• Change the engine oil and filter prior to
storage because used engine oil
contains contaminates which may
cause engine damage.
• Start the engine every 15 days for a
minimum of 15 minutes. Run at fast idle
with the climate controls set to defrost
until the engine reaches normal
operating temperature. •
With your foot on the brake, shift
through all the gears while the engine
is running.
• We recommend that you change the
engine oil before you use your vehicle
again.
Fuel system
• Fill the fuel tank with high-quality fuel
until the first automatic shutoff of the
fuel pump nozzle.
Cooling system
• Protect against freezing temperatures.
• When removing your vehicle from
storage, check coolant fluid level.
Confirm that there are no cooling
system leaks and that fluid is at the
recommended level.
Battery
• Check and recharge as necessary. Keep
connections clean.
• If storing your vehicle for more than 30
days without recharging the battery,
we recommend that you disconnect
the battery cables to maintain battery
charge for quick starting.
Note: It is necessary to reset memory
features if battery cables are disconnected.
Brakes
• Make sure the brakes and parking brake
release fully.
Tires
• Maintain recommended air pressure.
107
Motorhome (TY3) Canada/United States of America, enUSA, Edition date: 201712, Second Printing Vehicle Care

Use of one of the dissimilar spare tires
listed above at any one wheel location can
lead to impairment of the following:
•
Handling, stability and braking
performance.
• Comfort and noise.
• Ground clearance and parking at curbs.
• Winter weather driving capability.
• Wet weather driving capability.
• All-wheel driving capability.
3. Full-size dissimilar spare without
label on wheel
When driving with the full-size dissimilar
spare wheel and tire assembly, do not:
• Exceed 70 mph (113 km/h).
• Use more than one dissimilar spare
wheel and tire assembly at a time.
• Use commercial car washing
equipment.
• Use snow chains on the end of the
vehicle with the dissimilar spare wheel
and tire assembly.
The usage of a full-size dissimilar spare
wheel and tire assembly can lead to
impairment of the following:
• Handling, stability and braking
performance.
• Comfort and noise.
• Ground clearance and parking at curbs.
• Winter weather driving capability.
• Wet weather driving capability.
• All-wheel driving capability.
When driving with the full-size dissimilar
spare wheel and tire assembly additional
caution should be given to:
• Towing a trailer.
• Driving vehicles equipped with a
camper body.
• Driving vehicles with a load on the
cargo rack. Drive cautiously when using a full-size
dissimilar spare wheel and tire assembly
and seek service as soon as possible.
Tire Change Procedure
WARNINGS
When one of the front wheels is off
the ground, the transmission alone
will not prevent the vehicle from
moving or slipping off the jack, even if the
transmission is in park (P). To help prevent the vehicle from
moving when you change a tire, be
sure to place the transmission in park
(P), set the parking brake and block (in
both directions) the wheel that is
diagonally opposite (other side and end of
the vehicle) to the tire being changed. Never get underneath a vehicle that
is supported only by a jack. If the
vehicle slips off the jack, you or
someone else could be seriously injured. Do not attempt to change a tire on
the side of the vehicle close to
moving traffic. Pull far enough off the
road to avoid the danger of being hit when
operating the jack or changing the wheel. Always use the jack provided as
original equipment with your vehicle.
If using a jack other than the one
provided as original equipment with your
vehicle, make sure the jack capacity is
adequate for the vehicle weight, including
any vehicle cargo or modifications. 1.
Park on a level surface, set the parking
brake and activate the hazard flashers.
2. Place the transmission in park (P) and
turn the engine off.
126
Motorhome (TY3) Canada/United States of America, enUSA, Edition date: 201712, Second Printing Wheels and Tires

3. Block the diagonally opposite wheel.
The parking brake is on the
transmission. Therefore, the vehicle will
not be prevented from moving when a
rear wheel is lifted, even if the parking
brake is applied. Be sure to block both
directions of the wheel that is
diagonally opposite to the wheel that
is being lifted.
4. Remove the spare tire and jack from the storage location.
5. Loosen the wheel nut by pulling up on the handle of the lug nut wrench about
one-half turn (counterclockwise). Do
not remove the wheel lug nuts until you
raise the tire off the ground.
6. Position the jack to raise the front or rear wheel. Raise the vehicle with the
jack applied to the axle(s).
Note: Never use the rear differential as a
jacking point.
7. Raise the vehicle until the wheel is completely off the ground.
8. Remove the lug nuts with the lug nut wrench.
9. Replace the flat tire with the spare tire. 10. Use the lug nut wrench to screw the
lug nut snugly against the wheel.
11. Lower the vehicle.
12. Remove the jack and fully tighten the
lug nuts in the order shown. See
Technical Specifications (page
128). 8-lug nut wheel
10-lug nut wheel
13. Replace any wheel trim.
127
Motorhome (TY3) Canada/United States of America, enUSA, Edition date: 201712, Second Printing Wheels and TiresE175447 E161440 E161441
13
4
27
6
5
8 1
2
3
4
5
6
7 8
9
10
E169375

Specification
Name
WSS-M2C938-A
Automatic transmission fluid and power steering fluid
(Canada): MERCON® LV
Motorcraft® MERCON® LV Automatic Transmission Fluid
CXT-10-LV12
WSS-M14P19-A
Windshield washer fluid (U.S.):
Motorcraft® Premium Windshield Wash Concentrate
with Bitterant
ZC-32-B2
WSS-M14P19-A
Windshield washer fluid (Canada):
Motorcraft® Premium Quality Windshield Washer Fluid
CXC-37-(A, B, D, F)
WSH-M17B19-A
A/C refrigerant (U.S.):
Motorcraft® R-134a Refrigerant
YN-19
WSH-M17B19-A
A/C refrigerant (Canada):
Motorcraft® R-134a Refrigerant
CYN-16-R
WSH-M1C231-B
A/C refrigerant compressor oil:
Motorcraft® PAG Refrigerant Compressor Oil
YN-12-D
ESA-M1C75-B
Transmission, steering, parking linkages and pivots and
brake pedal shaft grease:
Premium Long-Life Grease
XG-1-E1
ESB-M1C93-B
Multi-purpose grease:
Motorcraft® Multi-Purpose Grease Spray
XL-5-A
1 Motorcraft® DOT 3 High Performance Motor Vehicle Brake Fluid is for vehicles with
Hydroboost brake booster systems. This include chassis with gross vehicle weight ratings
of 16,000 lb (7257 kg), 18,000 lb (8165 kg) and 19,500 lb (8845 kg).
2 Motorcraft® DOT 5.1 Motor Vehicle Brake Fluid is for vehicles with Hydromax brake
booster systems. This includes chassis with gross vehicle weight ratings of 19,500 lb
(8845 kg), 20,500 lb (9299 kg), 22,000 lb (9979 kg), 24,000 lb (10886 kg) and 26,000
lb (11793 kg).
135
Motorhome (TY3) Canada/United States of America, enUSA, Edition date: 201712, Second Printing Capacities and Specifications

Check every six months
Hinges, latches and outside locks for proper operation. Lubricate if necessary. Parking brake for proper operation.
Safety belts and seat latches for wear and function.
Safety warning lamps (brake, ABS, airbag and safety belt) for operation.
Washer spray and wiper operation. Clean or replace blades as necessary.
Multi-point Inspection
In order to keep your vehicle running right,
it is important to have the systems on your
vehicle checked regularly. This can help
identify potential issues and prevent major
problems. We recommend having the
following multi-point inspection performed
at every scheduled maintenance interval
to help make sure your vehicle keeps
running great. Multi-point inspection
Horn operation
Accessory drive belt(s)
Radiator, cooler, heater and A/C hoses
Battery performance
Suspension component for leaks ordamage
Engine air filter
Steering and linkage
Exhaust system
Tires (including spare) for wear and properpressure**
Exterior lamps and hazard warning system
operation
Windshield for cracks, chips or pits
Fluid levels *
; fill if necessary
Washer spray and wiper operation
For oil and fluid leaks
* Brake, coolant recovery reservoir, automatic transmission, power steering and window
washer.
** If your vehicle is equipped with a temporary mobility kit, check the tire sealant expiration
Use By date on the canister. Replace as needed.
142
Motorhome (TY3) Canada/United States of America, enUSA, Edition date: 201712, Second Printing Scheduled Maintenance

Be sure to ask your dealership service
advisor or technician about the multi-point
vehicle inspection. It is a comprehensive
way to perform a thorough inspection of
your vehicle. Your checklist gives you
immediate feedback on the overall
condition of your vehicle.
NORMAL SCHEDULED MAINTENANCE Every 7500 miles (12000 km) or six months (whichever comes first)
Change engine oil and filter.
Rotate tires *
, inspect tire wear and measure tread depth.
Inspect wheels and related components for abnormal noise, wear, looseness or drag.
Perform multi-point inspection (recommended).
* Vehicles with dual rear wheels should rotate the front wheels when specified; rear wheels
only if unusual wear is noted. Every 15000 miles (24000 km) or 12 months (whichever comes first)
Inspect automatic transmission fluid level. Consult dealer for requirements.
Inspect brake pads, shoes, rotors, drums, brake linings, hoses and parking brake.
Inspect engine cooling system strength and hoses.
Inspect exhaust system and heat shields.
Inspect steering linkage, ball joints, suspension, tie-rod ends, drive shaft and U-joints.
Lubricate if equipped with grease fittings. Other maintenance items
Replace engine air filter.
Every 30000 miles (48000
km)
Change automatic transmission fluid and filter. Consult
dealer for requirements.
Every 60000 miles (96000
km) Replace front wheel bearing grease and grease seal if non-
sealed bearings are used.
Replace spark plugs.
Every 97,500 miles (157000
km)
143
Motorhome (TY3) Canada/United States of America, enUSA, Edition date: 201712, Second Printing Scheduled Maintenance

A
About This Manual...........................................5
ABS
See: Brakes............................................................. 40
ABS driving hints See: Hints on Driving With Anti-Lock
Brakes.................................................................. 40
Accessories See: Replacement Parts
Recommendation.............................................. 8
Adjusting the Steering Wheel.....................12
Air Filter See: Changing the Engine Air Filter.............103
Appendices.....................................................158
Audible Warnings and Indicators.............20 Fail-Safe Cooling Warning Chime.................20
Headlamps On Warning Chime...................... 20
Key in Ignition Warning Chime........................ 20
Parking Brake On Warning Chime.................20
Shift to Park Warning Chime........................... 20
Automatic Transmission..............................37
Brake-Shift Interlock........................................... 39
If Your Vehicle Gets Stuck In Mud or Snow.................................................................... 39
Understanding the Positions of Your Automatic Transmission............................... 37
Automatic Transmission Fluid Check...............................................................97
Adjusting automatic transmission fluid levels.................................................................... 98
Automatic transmission fluid filter...............99
Correct fluid level................................................. 98
High fluid level....................................................... 98
Low fluid level....................................................... 98
B
Battery See: Changing the 12V Battery....................... 101
Brake Fluid Check..........................................99 Hydroboost.......................................................... 100
Hydromax............................................................... 99
Brakes................................................................40 General Information........................................... 40
Breaking-In.......................................................54 C
California Proposition 65...............................7
Capacities and Specifications
.................133
Alternative Engine Oil for Extremely Cold
Climates............................................................ 136
Specifications...................................................... 134
Car Wash See: Cleaning the Exterior............................... 105
Catalytic Converter........................................34 On-Board Diagnostics (OBD-II)..................... 35
Readiness for Inspection and Maintenance (I/M) Testing..................................................... 35
Changing a Fuse
.............................................87
Fuses........................................................................\
. 87
Changing a Road Wheel............................125 Dissimilar Spare Wheel and Tire Assembly
Information....................................................... 125
Tire Change Procedure..................................... 126
Changing the 12V Battery...........................101 Battery relearn..................................................... 102
Changing the Engine Air Filter.................103
Cleaning the Engine....................................106
Cleaning the Exterior...................................105 Cleaning the Headlamps................................. 105
Exterior Chrome Parts...................................... 105
Exterior Plastic Parts......................................... 105
Stripes or Graphics............................................ 105
Underbody............................................................ 106
Under Hood.......................................................... 106
Cleaning the Wheels
...................................106
Coolant Check See: Engine Coolant Check.............................. 93
Cruise Control
...................................................12
Principle of Operation......................................... 42
Cruise control See: Using Cruise Control.................................. 42
Customer Assistance....................................61
D
Daytime Running Lamps..............................15
Direction Indicators
........................................15
Driving Hints.....................................................54
Driving Through Water.................................55
DRL See: Daytime Running Lamps.......................... 15
161
Motorhome (TY3) Canada/United States of America, enUSA, Edition date: 201712, Second Printing Index

E
Economical Driving.......................................54
Emission Law...................................................33
Noise Emissions Warranty, Prohibited
Tampering Acts and Maintenance...........34
Tampering With a Noise Control System................................................................. 33
Engine Block Heater
......................................27
Using the Engine Block Heater........................ 27
Engine Coolant Check..................................93 Adding Coolant..................................................... 94
Coolant Change.................................................... 95
Engine Coolant Temperature Management.................................................... 96
Fail-Safe Cooling.................................................. 95
Recycled Coolant................................................. 95
Severe Climates.................................................... 95
Engine Emission Control..............................33
Engine Oil Check.............................................91 Adding Engine Oil................................................. 92
Engine Oil Dipstick..........................................91
Engine Specifications.................................129 Drivebelt Routing................................................ 129
Environment.......................................................11
Essential Towing Checks..............................51 Before Towing a Trailer....................................... 52
Hitches...................................................................... 51
Launching or Retrieving a Boat or Personal Watercraft (PWC)........................................... 53
Safety Chains.......................................................... 51
Trailer Brakes.......................................................... 52
Trailer Lamps......................................................... 52
When Towing a Trailer........................................ 52
Export Unique Options.................................10
F
Ford Credit...........................................................8 US Only....................................................................... 8
Ford Protect....................................................138 Ford Protect Extended Service Plan
(CANADA ONLY)........................................... 139
Ford Protect Extended Service Plans (U.S. Only)................................................................... 138
Fuel and Refueling
.........................................28
Fuel Consumption..........................................31
Calculating Fuel Economy................................. 31Filling the Fuel Tank..............................................
31
Fuel Filter
..........................................................101
Fuel Quality......................................................28
Choosing the Right Fuel.................................... 28
Fuses..................................................................68
Fuse Specification Chart............................68 Diode and Relay Module.................................... 79
F53 Passenger Compartment Fuse Panel..................................................................... 81
F53 Power Distribution Box............................. 68
G
Gauges................................................................16 Engine Coolant Temperature Gauge..............17
Engine Oil Pressure Gauge................................ 16
Fuel Gauge............................................................... 17
Speedometer.......................................................... 16
Transmission Fluid Temperature Gauge.................................................................... 17
Gearbox See: Transmission................................................ 37
General Maintenance Information........140 Multi-point Inspection...................................... 142
Owner Checks and Services............................ 141
Protecting Your Investment........................... 140
Why Maintain Your Vehicle?.......................... 140
Why Maintain Your Vehicle at Your Dealership?...................................................... 140
Getting Assistance Outside the U.S. and Canada...........................................................64
Getting the Services You Need..................61 Away From Home................................................. 61
H
Handbrake See: Parking Brake................................................ 41
Hazard Flashers
...............................................57
Hints on Driving With Anti-Lock Brakes.............................................................40
I
Ignition Switch
.................................................25
In California (U.S. Only)...............................62
Information Displays
......................................21
General Information............................................. 21
162
Motorhome (TY3) Canada/United States of America, enUSA, Edition date: 201712, Second Printing Index