2018 FORD EXPLORER transmission oil

Specification
Name
-
Lock cylinders (U.S.):
Penetrating and Lock Lubricant
XL-1
-
Lock cylinders (Canada):
Penetrating Fluid
CXC-51-A
-
Lock cylinders (Mexico):
Penetrating and Lock Lubricant
MXL-1
If you use oil and fluids that do not meet
the defined specification and viscosity
grade, this may lead to:
• Component damage which is not
covered by the vehicle warranty.
• Longer engine cranking periods.
• Increased emission levels.
• Reduced engine performance.
• Reduced fuel economy.
• Degraded brake performance.
We recommend Motorcraft® motor oil for
your vehicle. If Motorcraft® oil is not
available, use motor oils of the
recommended viscosity grade that meet
API SN requirements and display the API
Certification Mark for gasoline engines. An oil that displays this symbol conforms
to current engine, emission system and
fuel economy performance standards of
ILSAC.
Do not use supplemental engine oil
additives because they are unnecessary
and could lead to engine damage that may
not be covered by your vehicle warranty.
Note:
Ford recommends using DOT 4 Low
Viscosity (LV) High Performance Brake Fluid
or equivalent meeting WSS-M6C65-A2. Use
of any fluid other than the recommended
fluid may cause degraded brake
performance and not meet the Ford
performance standards. Keep brake fluid
clean and dry. Contamination with dirt,
water, petroleum products or other
materials may result in brake system
damage and possible failure.
Note: Automatic transmissions that require
MERCON® LV transmission fluid should
only use MERCON® LV transmission fluid.
The use of any other fluid may cause
transmission damage.
Alternative Engine Oil for
Extremely Cold Climates
To improve engine cold start performance,
we recommend that you use the following
alternative engine oil in extremely cold
climates, where the ambient temperature
reaches -22.0°F (-30°C) or below.
362
Explorer (TUB) Canada/United States of America, enUSA, Edition date: 201711, Fourth-Printing Capacities and SpecificationsE142732

Multi-Point Inspection
Hazard warning system operation
Accessory drive belt(s)
Horn operation
Battery performance
Radiator, cooler, heater and air conditioninghoses
Engine air filter
Suspension components for leaks ordamage
Exhaust system
Steering and linkage
Exterior lamps operation
Tires (including spare) for wear and properpressure2
Fluid levels 1
; fill if necessary
Windshield for cracks, chips or pits
For oil and fluid leaks
Washer spray and wiper operation
Half-shaft dust boots
1 Brake, coolant recovery reservoir, automatic transmission and window washer
2 If your vehicle is equipped with a temporary mobility kit, check the tire sealant expiration
Use By date on the canister. Replace as needed.
Be sure to ask your dealership service
advisor or technician about the multi-point
vehicle inspection. It is a comprehensive
way to perform a thorough inspection of
your vehicle. Your checklist gives you
immediate feedback on the overall
condition of your vehicle.
NORMAL SCHEDULED
MAINTENANCE
Intelligent Oil-Life Monitor™
Your vehicle is equipped with an Intelligent
Oil-Life Monitor that determines when you
should change the engine oil based on how
your vehicle is used. By using several
important factors in its calculations, the
monitor helps reduce the cost of owning
your vehicle and reduces environmental
waste at the same time. This means you do not have to remember
to change the oil on a mileage-based
schedule. Your vehicle lets you know when
an oil change is due by displaying a
message in the information display.
The following table provides examples of
vehicle use and its impact on oil change
intervals. It is a guideline only. Actual oil
change intervals depend on several factors
and generally decrease with severity of
use.
502
Explorer (TUB) Canada/United States of America, enUSA, Edition date: 201711, Fourth-Printing Scheduled Maintenance

When to Expect the OIL CHANGE REQUIRED Message
Vehicle Use and Example
Interval
Normal
7,500– 10,000 mi
(12,000– 16,000 km) Normal commuting with highway driving
No, or moderate, load or towing
Flat to moderately hilly roads
No extended idling
Severe
5,000– 7,500 mi
(8,000– 12,000 km) Moderate to heavy load or towing
Mountainous or off-road conditions
Extended idling
Extended hot or cold operation
Extreme
3,000–5,000 mi
(5,000–8,000 km) Maximum load or towing
Extreme hot or cold operation
Normal Maintenance Intervals At Every Oil Change Interval as Indicated by the Information Display
1
Change engine oil and filter. 2
Rotate the tires.
Perform a multi-point inspection, recommended.
Inspect the automatic transmission fluid level. Consult your dealer for requirements.
Inspect the brake pads, rotors, hoses and parking brake.
Inspect the engine cooling system strength and hoses.
Inspect the exhaust system and heat shields.
Inspect the rear axle and U-joints (four wheel drive only).
Inspect the half-shaft boots.
Inspect the steering linkage, ball joints, suspension, tire-rod ends, driveshaft and U-
joints.
503
Explorer (TUB) Canada/United States of America, enUSA, Edition date: 201711, Fourth-Printing Scheduled Maintenance

At Every Oil Change Interval as Indicated by the Information Display
1
Inspect the tires, tire wear and measure the tread depth.
Inspect the wheels and related components for abnormal noise, wear, looseness or
drag.
1 Do not exceed one year or 10,000 mi (16,000 km) between service intervals.
2 Reset the Intelligent Oil-Life Monitor after engine oil and filter changes. See
Engine Oil
Check (page 289). Other Maintenance Items
1
Replace brake fluid.
Every 3 Years
Replace cabin air filter.2
Every
20,000 mi
(32,000 km)
Replace engine air filter.
Every
30,000 mi
(48,000 km)
Change engine coolant.3
At
100,000 mi
(160,000 km)
Replace spark plugs.
Every
100,000 mi
(160,000 km) Inspect accessory drive belt or belts. 4
Change automatic transmission fluid.
Every
150,000 mi
(240,000 km) Replace accessory drive belt or belts. 5
1 Perform these maintenance items within 3,000 mi (4,800 km) of the last engine oil and
filter change. Do not exceed the designated distance for the interval.
2 Should be performed by an authorized dealer.
3 Initial replacement at six years or
100,000 mi (160,000 km), then every three years or
50,000 mi (80,000 km).
4 After initial inspection, inspect every other oil change until replaced.
5 If not replaced within the last
100,000 mi (160,000 km).
504
Explorer (TUB) Canada/United States of America, enUSA, Edition date: 201711, Fourth-Printing Scheduled Maintenance

SPECIAL OPERATING
CONDITIONS SCHEDULED
MAINTENANCE
If you operate your vehicle primarily in any
of the following conditions, you need to
perform extra maintenance as indicated.
If you operate your vehicle
occasionally
under any of these conditions, it is not
necessary to perform the extra
maintenance. For specific
recommendations, see your dealership
service advisor or technician. Perform the services shown in the
following tables when specified or within
3,000 mi (4,800 km)
of the message
appearing in the information display
prompting you to change your oil.
• Example 1: The message comes on at
28,750 mi (46,270 km)
. Perform the
30,000 mi (48,000 km) automatic
transmission fluid replacement.
• Example 2
: The message has not
come on, but the odometer reads
30,000 mi (48,000 km) (for example,
the Intelligent Oil-Life Monitor was
reset at
25,000 mi (40,000 km).
Perform the engine air filter
replacement. Towing a Trailer or Using a Car-top Carrier
Change engine oil and filter as indicated by the information
display and perform services listed in the Normal Sched-
uled Maintenance chart.
As required
Inspect rear axle and U-joints (four wheel drive only).
Inspect frequently, service
as required
Inspect half-shaft boots.
See axle maintenance items under
Exceptions.
Change automatic transmission fluid.
Every
30,000 mi
(48,000 km)
Replace spark plugs.
Every
60,000 mi
(96,000 km)
505
Explorer (TUB) Canada/United States of America, enUSA, Edition date: 201711, Fourth-Printing Scheduled Maintenance

Extensive Idling or Low-speed Driving for Long Distances, as in Heavy Commercial Use
Change engine oil and filter as indicated by the information
display and perform services listed in the Normal Sched-
uled Maintenance chart.
As required
Replace cabin air filter.
Inspect frequently, service
as required
Replace engine air filter.
Change automatic transmission fluid.
Every 30,000 mi
(48,000 km)
Replace spark plugs.
Every
60,000 mi
(96,000 km) Operating in Dusty or Sandy Conditions (Such as Unpaved or Dusty Roads)
Replace cabin air filter.
Inspect frequently, service
as required
Replace engine air filter.
Inspect the wheels and related components for abnormal
noise, wear, looseness or drag.
Every
5,000 mi (8,000 km)
Rotate tires, inspect tires for wear and measure tread
depth.
Change engine oil and filter. 1
Every
5,000 mi (8,000 km)
or six months
Perform multi-point inspection.
Change automatic transmission fluid.
Every
30,000 mi
(48,000 km)
1 Reset your Intelligent Oil-Life Monitor after engine oil and filter changes. See Oil Change
Indicator Reset
(page 290). Exclusive use of E85 (Flex Fuel Vehicles Only)
If ran exclusively on E85, fill the fuel tank full with regular
unleaded fuel.
Every oil change
Exceptions
There are several exceptions to the Normal
Schedule: 506
Explorer (TUB) Canada/United States of America, enUSA, Edition date: 201711, Fourth-Printing Scheduled Maintenance

If Your Vehicle Gets Stuck In Mud or
Snow.................................................................. 190
SelectShift Automatic ™
Transmission................................................... 188
Understanding the Positions of Your Automatic Transmission............................. 187
Automatic Transmission Fluid Check - 2.3L EcoBoost™.......................................295
Automatic Transmission Fluid Check - 3.5L Duratec/3.5L Ecoboost™............295
Adding Transmission Fluid ............................ 296
Checking the Transmission Fluid Level.................................................................. 295
Autowipers........................................................81 Autowipers Settings............................................ 82
Auxiliary Power Points
................................165
110 Volt AC Power Point................................... 165
12 Volt DC Power Point..................................... 165
Locations............................................................... 165
B
Battery See: Changing the 12V Battery..................... 298
Blind Spot Information System
..............232
........................................................................\
........... 232
Switching the System On and Off..............234
System Errors...................................................... 234
Using the Blind Spot Information System.............................................................. 233
BLIS See: Blind Spot Information System..........232
Bonnet Lock See: Opening and Closing the Hood..........284
Booster Seats
..................................................29
Types of Booster Seats...................................... 30
Brake Fluid Check........................................297
Brakes...............................................................196 General Information.......................................... 196
Breaking-In.....................................................257
Bulb Specification Chart..........................306
C
Cabin Air Filter................................................142 Capacities and Specifications - 2.3L
EcoBoost™ .................................................
350
Alternative Engine Oil for Extremely Cold
Climates........................................................... 353
Specifications...................................................... 351
Capacities and Specifications - 3.5L Duratec.........................................................354
Alternative Engine Oil for Extremely Cold Climates........................................................... 358
Specifications..................................................... 355
Capacities and Specifications - 3.5L Ecoboost™.................................................358
Alternative Engine Oil for Extremely Cold Climates........................................................... 362
Specifications..................................................... 360
Capacities and Specifications................343
Cargo Nets.......................................................241
Car Wash See: Cleaning the Exterior.............................. 309
Catalytic Converter......................................184 On-Board Diagnostics (OBD-II)................... 185
Readiness for Inspection and Maintenance (I/M) Testing................................................... 185
Center Console..............................................167 Rear Seat Armrest.............................................. 167
Second Row Center Console.......................... 167
Changing a Bulb..........................................303 Front Direction Indicator................................. 303
Headlamp............................................................ 303
Headlamp High Beam..................................... 304
LED Lamps........................................................... 305
License Plate Lamp.......................................... 305
Rear Direction Indicator and Reversing Lamp................................................................. 304
Changing a Fuse..........................................282 Fuses...................................................................... 282
Changing a Road Wheel............................337 Dissimilar Spare Wheel and Tire Assembly
Information...................................................... 337
Tire Change Procedure.................................... 338
Changing the 12V Battery.........................298
Changing the Engine Air Filter................308
Changing the Wiper Blades....................300 Front Wiper Blades.......................................... 300
Rear Window Wiper Blade.............................. 301
Checking MyKey System Status................61 MyKey Distance..................................................... 61
Number of Admin Keys...................................... 62
558
Explorer (TUB) Canada/United States of America, enUSA, Edition date: 201711, Fourth-Printing Index

Anti-Lock Braking System..............................
100
Automatic High Beam Control....................... 101
Battery..................................................................... 101
Blind Spot Monitor.............................................. 101
Brake System........................................................ 101
Cruise Control....................................................... 101
Direction Indicator............................................... 101
Door Ajar................................................................. 101
Engine Coolant Temperature.......................... 101
Engine Oil............................................................... 101
Fasten Safety Belt.............................................. 102
Front Airbag.......................................................... 102
Front Fog Lamps................................................ 102
Heads Up Display............................................... 102
High Beam............................................................. 102
Hood Ajar............................................................... 102
Lane Keeping Aid................................................ 102
Liftgate Ajar.......................................................... 102
Low Fuel Level..................................................... 102
Low Tire Pressure Warning............................. 102
Low Washer Fluid............................................... 102
Parking Lamps..................................................... 102
Powertrain Fault................................................. 102
Service Engine Soon.......................................... 103
Stability Control.................................................. 103
Stability Control Off.......................................... 103
Transmission Tow/Haul................................... 103
Washer Fluid Check....................................298
Washers See: Cleaning the Exterior.............................. 309
Waxing...............................................................311
Wheel Nuts See: Changing a Road Wheel........................ 337
Wheels and Tires...........................................317
General Information........................................... 317
Technical Specifications.................................. 341
Windows and Mirrors.....................................91
Windshield Washers.....................................82 Front Camera Washer........................................ 82
Windshield Wipers
.........................................81
Speed Dependent Wipers................................. 81
Wiper Blades See: Checking the Wiper Blades.................300
Wipers and Washers......................................81
568
Explorer (TUB) Canada/United States of America, enUSA, Edition date: 201711, Fourth-Printing Index