which case a tire of the same brand, size, load, speed and tread type will
be used. In some circumstances, Ford may authorize another brand
and/or model to substitute for the original brand and model, even if still
available.
Normal tire wear or damage is not reimbursable. See page 14 for details
of what is not covered.
Extended warranty coverage periods are available for certain
vehicle parts and conditions. Specifically,
(1) Your vehicle’s Powertrain components are covered for five years or
60,000 miles, whichever occurs first. The extended coverage applies to
theEngine: all internal lubricated parts, cylinder block, cylinder heads,
electrical fuel pump, powertrain control module, engine mounts,
flywheel, injection pump, manifold (exhaust and intake), manifold bolts,
oil pan, oil pump, seals and gaskets, engine thermostat, engine
thermostat housing, timing chain cover, timing chain (gears or belt),
turbocharger/supercharger unit, valve covers, water pump;
Transmission: all internal parts, clutch cover, seals and gaskets, torque
converter, transfer case (including all internal parts), transmission case,
transmission mounts; single-speed gearbox (for The Focus Electric);
Front-Wheel Drive: axle shafts, front bearings seals and gaskets,
universal and constant velocity joints; Rear-Wheel Drive:axle shafts,
bearings (front and rear), center support bearing, drive axle housing
(including all internal parts), drive shaft, retainers, supports, seals and
gaskets, universal and constant velocity joints. Four-wheel/All-Wheel
Drive: axle shafts, bearings (front and rear), center support bearing,
drive shafts, final drive housing (including all internal parts),
hubs-automatic front locking (four-wheel drive), locking rings
(four-wheel drive), seals and gaskets, universal and constant velocity
joints.
(2) Your vehicle’s safety belts and air bag Supplemental Restraint System
(SRS) are covered for an extended Safety Restraint Coverage Period,
which lasts for five years or 60,000 miles, whichever occurs first.
10
•You are subject to a penalty or sanction under local, state, or federal
law because your vehicle has failed to conform to the emissions
standards. (A penalty or sanction can include being denied the right
to use your vehicle.)
• Your vehicle has not been tampered with, misused, or abused.
The warranty coverage period for:
Passenger cars and light duty trucks (applies to vehicles up to
8,500 pounds GVWR) as follows: -
8 years or 80,000 miles (whichever occurs first) for catalytic converters,electronic emissions control unit, and onboard emissions diagnostic
devices, including the Battery Energy Control Module (BECM).
- 2 years or 24,000 miles (whichever occurs first) for all other covered parts.
See WHAT IS COVERED below for list of covered parts.
Note that the warranty period begins on the Warranty Start Dateas
specified on page 2 of this booklet.
WHAT IS COVERED?
For your vehicle, if these parts contain an emissions-related defect, they
are covered by both the Emissions Defects Warranty and the Emissions
Performance Warranty.
• Air Flow Sensor
• Air/Fuel Feedback Control System and Sensors
• Air Induction System
• Battery Energy Control Module (BECM)
•
Brake Hydraulic/Electric Control Assembly (Plug-in Hybrid vehicles only)
• Brake Vacuum Pump (Plug-in Hybrid vehicles only)
• Catalytic Converter
• Electronic Engine Control Sensors and Switches
• Evaporative Emission Control System
• Exhaust Gas Recirculation (EGR) System
• Exhaust Manifold
• Exhaust Pipe (Manifold to Catalyst)
19
COVERAGE FOR 2018 MODEL VEHICLES (GVWR OF 14,000 LBS. OR LESS)UNDER LONG TERM DEFECTS WARRANTY
(Coverage for up to 7 years/70,000 miles, whichever first cccurs)
Part Name2.0L Fusion Hybrid
2.0L C-max Hybrid
Power Steering Wiring Assembly X
Catalytic Converter X X
Cam Timing Assembly X X
Variable Camshaft Timing Assembly X X
Transmission Range Sensor / Detent Assembly X
Exhaust Gasket X
Hybrid Powertrain Control Module X X
Inverter System Controller X X
Coolant Pump Motor X
Fuel Tank X X
Battery Energy Control Module X X
On-board Battery Charger (1) X
High Voltage Traction Battery X X
Instrument Cluster (3) X X
Powertrain Control Wiring Harness X
Powertrain Control Module (PCM)/Electronic Engine Control Unit (ECU) X X
Main Body Wiring Harness (4) X X
Battery Cable (4) X
Main Wiring Assembly (4) X X
Fuel Sender Wiring Assembly (4) X
Main Jumper Wiring Assembly (4) X X
Electric Coolant Heater Assembly (4) X X
(1) for Plug-in Hybrid vehicles only
(2) for Full Hybrids Only
(3)
for Service Engine Soon/Malfunction Indicator Lamp (MIL) functionality concerns only
(4) for MIL illumination only
29
