2018 FORD C-MAY HYBRID engine

It is your responsibility to make sure that all of the scheduled
maintenance is performed and that the materials used meet Ford
engineering specifications. Failure to perform scheduled maintenance as
specified in the Owner’s Manual will invalidate warranty coverage on
parts affected by the lack of maintenance. Make sure that receipts for
completed maintenance work are retained with the vehicle and
confirmation of maintenance work is always entered in yourOwner’s
Manual.
Your Ford or Lincoln dealership, or Ford or Lincoln Quality Care Service
Center, has factory-trained technicians who can perform the required
maintenance using genuine Ford parts. The dealership looks forward to
meeting your every service need to maximize your satisfaction with your
vehicle.
WHO PAYS FOR WARRANTY REPAIRS?
You will not be charged for repairs covered by any applicable warranty
during the stated coverage periods, unless specifically stated elsewhere
in this guide.
Some states have mandated alternate time coverage periods for parts of
your vehicle (e.g. seatbelts).
Some states and/or local governments may require a tax on a portion of
warranty repairs. Where applicable law allows, the tax must be paid by
you, the owner of the vehicle.
During the Bumper to Bumper Warranty period, dealers may receive
instructions to provide no-cost, service-type improvements - not
originally included in your Owner’s Manual - intended to increase your
overall satisfaction with your vehicle.
Sometimes Ford may offer a special adjustment program to pay all or
part of the cost of certain repairs beyond the terms of the applicable
warranty. Check with your dealer or call 1-800-392-3673 to learn whether
any adjustment program is applicable to your vehicle. Please have your
vehicle identification number available.
3

which case a tire of the same brand, size, load, speed and tread type will
be used. In some circumstances, Ford may authorize another brand
and/or model to substitute for the original brand and model, even if still
available.
Normal tire wear or damage is not reimbursable. See page 14 for details
of what is not covered.
Extended warranty coverage periods are available for certain
vehicle parts and conditions. Specifically,
(1) Your vehicle’s Powertrain components are covered for five years or
60,000 miles, whichever occurs first. The extended coverage applies to
theEngine: all internal lubricated parts, cylinder block, cylinder heads,
electrical fuel pump, powertrain control module, engine mounts,
flywheel, injection pump, manifold (exhaust and intake), manifold bolts,
oil pan, oil pump, seals and gaskets, engine thermostat, engine
thermostat housing, timing chain cover, timing chain (gears or belt),
turbocharger/supercharger unit, valve covers, water pump;
Transmission: all internal parts, clutch cover, seals and gaskets, torque
converter, transfer case (including all internal parts), transmission case,
transmission mounts; single-speed gearbox (for The Focus Electric);
Front-Wheel Drive: axle shafts, front bearings seals and gaskets,
universal and constant velocity joints; Rear-Wheel Drive:axle shafts,
bearings (front and rear), center support bearing, drive axle housing
(including all internal parts), drive shaft, retainers, supports, seals and
gaskets, universal and constant velocity joints. Four-wheel/All-Wheel
Drive: axle shafts, bearings (front and rear), center support bearing,
drive shafts, final drive housing (including all internal parts),
hubs-automatic front locking (four-wheel drive), locking rings
(four-wheel drive), seals and gaskets, universal and constant velocity
joints.
(2) Your vehicle’s safety belts and air bag Supplemental Restraint System
(SRS) are covered for an extended Safety Restraint Coverage Period,
which lasts for five years or 60,000 miles, whichever occurs first.
10

WHAT IS NOT COVERED UNDER THE NEW VEHICLE LIMITED
WARRANTY?
Damage Caused By:
•accidents, collision or objects striking the vehicle (including driving
through a car wash)
• theft, vandalism, or riot
• fire or explosion
• using contaminated or improper fuel/fluids
• customer-applied chemicals or accidental spills
• driving through water deep enough to cause water to be ingested into
the engine
• misuse of the vehicle, such a driving over curbs, overloading, racing or
using the vehicle as a stationary power source
Damage Caused by Alteration or Modification
The New Vehicle Limited Warranty does not cover any damage caused by:
•alterations or modifications of the vehicle, including the body, chassis,
electronics or their components, after the vehicle leaves the control of
Ford Motor Company
• tampering with the vehicle, tampering with the emissions systems or
with the other parts that affect these systems (for example, but not
limited to exhaust and intake systems)
• the installation or use of a non-Ford Motor Company part or software
(other than a certified emissions part or software) or any part or
software (Ford or non-Ford) designed for off-road use only installed
after the vehicle leaves the control of Ford Motor Company, if the
installed part fails or causes a Ford part to fail. Examples include, but
are not limited to lift kits, oversized tires, roll bars, cellular phones,
alarm systems, automatic starting systems and performance-enhancing
powertrain components or software and performance “chips”.
Your vehicle may allow, enable or facilitate the use of certain non-Ford
Motor Company software. Ford is not responsible for the functionality
of such software. Ford may disallow, discontinue or modify your ability
to use such software at any time without prior notification or incurring
any warranty or other obligation. Non-Ford Motor Company software
may be governed by End User License Agreement or warranty
provided by the software provider. For Ford Motor Company software
see End User License Agreement found in the Owner Manual.
12

EMISSIONS DEFECTS WARRANTY COVERAGE
During the warranty coverage period, Ford Motor Company warrants that:
•your vehicle or engine is designed, built, and equipped to meet - at
the time it is sold - the emissions regulations of the U.S.
Environmental Protection Agency (EPA).
• your vehicle or engine is free from emissions-related defects in
factory-supplied materials or workmanship, which are defects that
could prevent the vehicle or engine from conforming with applicable
EPA regulations.
•
you will not be charged for diagnosis, repair, replacement, or adjustment
of parts containing an emissions-related defect. A list of emission-related
parts can be found in What is Covered?
on pages 19-21.
The emissions defects warranty coverage period for passenger cars and
light duty trucks (applies to vehicles up to 8,500 pounds GVWR is as
follows:
• 8 years or 80,000 miles (whichever occurs first) for catalytic
converters, electronic emissions control unit, and onboard emissions
diagnostic devices, including the Battery Energy Control Module
(BECM).
• 2 years or 24,000 miles (whichever occurs first) for all other covered
parts. (NOTE: Ford’s 3-year, 36,000-mile bumper-to-bumper coverage,
as described above, surpasses this mandatory federal coverage.)
EMISSIONS PERFORMANCE WARRANTY COVERAGE
Under Emissions Performance Warranty Coverage, Ford Motor Company
will repair, replace, or adjust - with no charge for labor, diagnosis, or
parts - any emissions control device or system, if you meet all of the
following conditions:
• You have maintained and operated your vehicle according to the
instructions on proper care in the Owner’s Manual, and this booklet.
• Your vehicle fails to conform, during the warranty coverage period, to
the applicable national EPA standards as determined by an EPA
approved inspection and maintenance program.
18

•You are subject to a penalty or sanction under local, state, or federal
law because your vehicle has failed to conform to the emissions
standards. (A penalty or sanction can include being denied the right
to use your vehicle.)
• Your vehicle has not been tampered with, misused, or abused.
The warranty coverage period for:
Passenger cars and light duty trucks (applies to vehicles up to
8,500 pounds GVWR) as follows: -
8 years or 80,000 miles (whichever occurs first) for catalytic converters,electronic emissions control unit, and onboard emissions diagnostic
devices, including the Battery Energy Control Module (BECM).
- 2 years or 24,000 miles (whichever occurs first) for all other covered parts.
See WHAT IS COVERED below for list of covered parts.
Note that the warranty period begins on the Warranty Start Dateas
specified on page 2 of this booklet.
WHAT IS COVERED?
For your vehicle, if these parts contain an emissions-related defect, they
are covered by both the Emissions Defects Warranty and the Emissions
Performance Warranty.
• Air Flow Sensor
• Air/Fuel Feedback Control System and Sensors
• Air Induction System
• Battery Energy Control Module (BECM)
•
Brake Hydraulic/Electric Control Assembly (Plug-in Hybrid vehicles only)
• Brake Vacuum Pump (Plug-in Hybrid vehicles only)
• Catalytic Converter
• Electronic Engine Control Sensors and Switches
• Evaporative Emission Control System
• Exhaust Gas Recirculation (EGR) System
• Exhaust Manifold
• Exhaust Pipe (Manifold to Catalyst)
19

•Fuel Filler Door Sensor (Plug-in Hybrid vehicles only)
• Fuel Filler Tube and Seal
• Fuel Injection System
• Fuel Injector Supply Manifold
• Fuel Tank
• High Voltage Battery
• HVAC Controller (Plug-in Hybrid vehicles only)
• Ignition Coil and/or Control Module
• Intake Manifold
• Inverter System Controller (Plug-in Hybrid vehicles only)
• Malfunction Indicator Lamp (MIL)/On-Board Diagnostic (OBD) System
• Motor Electronics Coolant Pump (Plug-in Hybrid vehicles only)
• PCV System and Oil Filler Cap
• PHEV Onboard Charger
• Powertrain Control Module (PCM)/Engine Control Module (ECM)*
• Spark Control Components
• Spark Plugs and Ignition Wires
• Thermostat
• Throttle Body Assembly (MFI)
• Transmission Assembly (Plug-in Hybrid vehicles only)
• Transmission Auxiliary Oil Pump (Plug-in Hybrid vehicles only)
• Transmission Fluid Temperature Sensor (Plug-in Hybrid vehicles only)
• Vacuum Distribution System
* Includes hardware and emission related software changes only
20

For full details about coverage under California requirements for
emissions control, see:
➡Defects Warranties (pages 24-30)
➡ Performance Warranty (pages 24-25)
➡ What Is Covered? (pages 27-30)
➡ What Is Not Covered? (page 30)
EXPLANATION OF CALIFORNIA EMISSIONS WARRANTIES
Your Warranty Rights and Obligations
The California Air Resources Board and Ford Motor Company are
pleased to explain the emission control system warranty on your
2018-model vehicle. In California, new motor vehicles must be designed,
built, and equipped to meet the State’s stringent anti-smog standards.
Ford must warrant the emission control system on your vehicle for the
periods of time listed on pages 24-30, provided there has been no abuse,
neglect, or improper maintenance of your vehicle.
Your emission control system may include parts such as the carburetor
or fuel injection system, the ignition system, catalytic converter, and the
engine computer. Also included may be hoses, belts, connectors, and
other emissions-related assemblies.
Where a warrantable condition exists, Ford Motor Company will repair
your vehicle at no cost to you including diagnosis, parts, and labor.
MANUFACTURER’S WARRANTY COVERAGE
For Vehicles Eligible for Standard California Emission Warranty Coverage
If Gross Vehicle Weight Rating is 14,000 lbs. or less:
For 3 years or 50,000 miles (whichever first occurs):
1. If your vehicle fails a Smog Check inspection, all necessary repairs and
adjustments will be made by Ford to ensure that your vehicle passes the
inspection. This is your emission control system PERFORMANCE
WARRANTY.
2. If any emissions-related part on your vehicle is defective, the part will
be repaired or replaced by Ford. This is your short-term emission control
system DEFECTS WARRANTY.
24

WHAT IS COVERED?
The parts on the following list are covered by the Standard California
Defects Warranties and TZEV Defects Warranties.
•Air Flow Sensor
• Air/Fuel Feedback Control System and Sensors
• Air Induction System
• Battery Energy Control Module (BECM)
•
Brake Hydraulic/Electric Control Assembly (Plug-in Hybrid vehicles only)
• Brake Vacuum Pump (Plug-in Hybrid vehicles only)
• Catalytic Converter
• Electronic Engine Control Sensors and Switches
• Evaporative Emission Control System
• Exhaust Gas Recirculation (EGR) System
• Exhaust Manifold
• Exhaust Pipe (Manifold to Catalyst)
• Fuel Filler Door Sensor (Plug-in Hybrid vehicles only)
• Fuel Filler Tube and Seal
• Fuel Injection System
• Fuel Injector Supply Manifold
• Fuel Tank
• High Voltage Battery
• HVAC Controller (Plug-in Hybrid vehicles only)
• Ignition Coil and/or Control Module
• Intake Manifold
• Inverter System Controller (Plug-in Hybrid vehicles only)
• Malfunction Indicator Lamp (MIL)/On-Board Diagnostic (OBD) System
• Motor Electronics Coolant Pump (Plug-in Hybrid vehicles only)
• PCV System and Oil Filler Cap
• PHEV Onboard Charger
• Powertrain Control Module (PCM)/Engine Control Module (ECM)*
27