2018 FIAT DUCATO BASE CAMPER instrument panel

Thousands of miles 30 60 90 120 150
Thousands of kilometres 48 96 144 192 240
Years 2 4 6 8 10
Replace timing belt (115 Multijet 2 versions)(7)
Replace
air cleanercartridge (8)●●●●●
Change engine oil and replace oil filter(9)
Change the brake fluid(10)
Replace the passenger compartment cleaner●●●●●
(7) Advised maximum mileage 144,000 km. Irrespective of the mileage, the timing drive belt must be changed every 4 years for heavy-duty use (cold climates, town
use, long periods of idling) or at least every 5 years.
(8) If the vehicle is equipped with an air cleaner specially for dusty areas: check and clean filter every 20,000 km, change filter every 40,000 km or change the air
cleaner whenever the obstructed air cleaner indicator appears.
(9) The effective interval for changing the oil and replacing the engine oil filter depends on the car usage conditions and is signalled by the warning light or message
(if present) on the instrument panel (see “Warning lights and messages” paragraph) and must never exceed 24 months. Change engine oil and oil filter every 12
months if the vehicle is driven mainly in towns.
(10) The brake fluid replacement has to be done every two years, irrespective of the mileage.
195

Natural Power versions
Thousands of miles 25 50 75 100 125
Thousands of kilometres 40 80 120 160 200
Years246810
Check battery charge status and possibly recharge●●●●●
Check tyreconditions/wear and adjust pressure, if necessary●●●●●
Check operation of lighting system (headlights, direction indicators, hazard
warning lights, boot, passenger compartment, glove compartment,
instrument panel warning lights, etc.)●●●●●
Check operation of the windscreen wiper/washer system and adjust jets, if
necessary●●●●●
Check the position/wear of the windscreen/rear window wiper blades●●●●●
Check cleanliness of bonnet and luggage compartment locks, cleanliness
and lubrication of linkage●●●●●
Visually inspect conditions of: exterior bodywork, underbody protection,
pipes and hoses (exhaust, fuel system, brakes), rubber elements (gaiters,
sleeves, bushes, etc.)●●●●●
Visually inspect conditions and wear of front disc brake pads and operation
of pad wear indicator●●●●●
Visually inspect condition and wear of rear disc brake pads and operation of
pad wear indicator (for versions/markets, where provided)●●●●●
Check and, if necessary, top up fluid levels (engine coolant, hydraulic clutch/
brakes, windscreen washer, battery, etc.)●●●●●
196
SERVICING AND CARE

INTERIOR
Regularly check that water is not
trapped under the mats (due to water
dripping off shoes, umbrellas, etc.),
as this could cause oxidation of the
sheet metal.
205) 206)
SEATS AND FABRIC
PARTS
Remove dust with a soft brush or a
vacuum cleaner. It is advisable to use a
moist brush on velvet upholstery.
Rub the seats with a sponge moistened
with a solution of water and neutral
detergent.
PLASTIC PARTS
It is advisable to clean interior plastic
parts with a moist cloth and a solution
of water and non-abrasive mild soap.
Use specific products for cleaning
plastic, without solvents and specifically
designed to prevent damage to the
appearance and colour of the treated
parts, to remove grease and tough
stains.
IMPORTANT Do not use alcohol,
petrols or derivatives to clean
the instrument panel glass.LEATHER STEERING
WHEEL/GEAR LEVER
KNOB/HANDBRAKE
(for versions/markets, where provided)
These components must be cleaned
with mild soap and water only. Never
use alcohol or alcohol-based products.
WARNING
205)Never use flammable products, such
as petroleum ether or modified petrol, to
clean the inside of the car. The
electrostatic charges which are generated
by rubbing during the cleaning operation
may cause a fire.
206)Do not keep aerosol cans in the
vehicle: they might explode. Aerosol cans
must not be exposed to a temperature
exceeding 50°C. When the vehicle is
exposed to sunlight, the internal
temperature can greatly exceed this value.
RUBBER HOSES
As far as the brake system and fuel
supply system rubber hoses are
concerned, follow the "Scheduled
Servicing Plan" in this chapter carefully.
Ozone, high temperatures and
prolonged lack of fluid in the system
may cause hardening and cracking of
the hoses, with possible leaks. Careful
checking is therefore necessary.
213

Fluids and lubricants...............248
Fog lights...........................32
Follow Me Home device.............29
Front airbags......................111
Front airbag driver's side.......111
Manually deactivating the front
airbag and side bag............112
Passenger side front airbag.....112
Front light clusters.................152
Front roof light
(changing a bulb)................157
Fuel consumption..................251
Fuel cut-off switch.................185
Fuel tank cap......................133
Fuses (replacement)................158
Gateway fms module..............171
Gear Shift Indicator..................56
Hazard warning lights...............32
HBA (Hydraulic Brake Assist)
system...........................87
HBA (system).......................87
Head restraints
Front ............................46
Headlight alignment corrector.......30
Headlight washers...................36
Headlights
Headlight alignment
corrector........................30
Light beam alignment............30
Heated rear window.................33Heating and ventilation..............37
Heating and ventilation controls......38
Hill Descent.........................88
Hill Descent Control System.........88
Hill Holder (system)..................86
Hill Holder system...................86
Identification data..................215
Ignition switch.......................10
Independent additional heater........40
Inflation pressure...................226
Inflation procedure.................181
Instrument panel....................52
Interior.............................213
Interior fittings.......................47
Isofix child restraint systems
(setup)
Arrangement possibilities for
child restraint system on seats
of vehicle......................107
Jump starting.....................183
Lifting the vehicle..................209
Light beam alignment................30
Light bulbs
Bulbs types....................150
Lights off............................27
Loading advice.....................140
Main beam headlights..............28
Maintenance and care - regular
checks..........................190Maintenance and care -
Scheduled Servicing.............190
Maintenance and care -
scheduled servicing plan.........192
Manually deactivating the front
airbag and side bag.............112
Moving footboard...................16
MSR (System).......................85
MSR system........................85
Multifunction display
Control buttons..................57
Setup menu.....................58
Nozzles...........................209
Number plate lights................156
On-board instruments..............52
Parking lights.......................29
Parking sensors....................128
Performance.......................237
Pollen filter.........................206
Power Socket.......................47
Power steering.....................222
Power steering fluid................203
Pre-tensioners......................98
Prolonged vehicle inactivity.........147
Radio.............................266
Rain sensor.........................35
Rear door with two wings............15
Rear fog lights.......................32
Rear footboard......................16
INDEX