2018 CHEVROLET CORVETTE engine overheat

Chevrolet Corvette Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
11374030) - 2018 - CRC - 11/8/17
238 Vehicle Care
If ambient temperatures are
anticipated below−28 °C (−18 °F),
make sure a proper mixture ratio of
50% DEX-COOL coolant and 50%
clean, drinkable water is used.
Checking Coolant
The vehicle must be on a level
surface when checking the coolant
level.
Check to see if coolant is visible in
the coolant surge tank. If the coolant
inside the coolant surge tank is
boiling, do not do anything else until
it cools down. If coolant is visible
but the coolant level is not at or
above the cold fill line, add a
mixture of 40% DEX-COOL coolant
and 60% clean, drinkable water at
the coolant recovery tank, but be
sure the cooling system is cool
before this is done. See Engine
Overheating 0240.
The engine coolant surge tank is
toward the rear of the engine
compartment on the passenger side
of the vehicle. See Engine
Compartment Overview 0221. When the engine is cold, the coolant
level should be at the cold fill line on
the coolant surge tank.
When the engine is hot, the level
could be higher than the cold fill
line. If the coolant is below the cold
fill line when the engine is hot, there
could be a leak in the cooling
system.
If the coolant is low, add the coolant
or take the vehicle to your dealer for
service.
How to Add Coolant to the
Coolant Surge Tank
{Warning
Spilling coolant on hot engine
parts can burn you. Coolant
contains ethylene glycol and it will
burn if the engine parts are hot
enough.
{Warning
Steam and scalding liquids from a
hot cooling system are under
pressure. Turning the pressure
cap, even a little, can cause them
to come out at high speed and
you could be burned. Never turn
the cap when the cooling system,
including the pressure cap, is hot.
Wait for the cooling system and
pressure cap to cool.
If coolant is needed, add the proper
DEX-COOL coolant mixture directly
to the surge tank, but be sure the
cooling system is cool before this
is done.

Chevrolet Corvette Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
11374030) - 2018 - CRC - 11/8/17
240 Vehicle Care
1. Press up on the two indents atthe bottom and lift the aero
panel off the bracket.
Stingray Shown, Grand Sport and
Z06 Similar
2. Unscrew the two fasteners that secure the bracket.
3. Gently pull the bracket away from the grille.
To replace the bracket and aero
panel: 1. Position the bracket over the grille.
2. Secure the bracket by pushing the two fasteners into place. 3. Snap the aero panel into place.
Engine Overheating
The vehicle has several indicators
to warn of engine overheating.
There is an engine coolant
temperature gauge on the
instrument cluster. See
Engine
Coolant Temperature Gauge 0108.
The vehicle may also display a
message on the Driver Information
Center (DIC).
If the decision is made not to lift the
hood but to get service help right
away, see Roadside Assistance
Program 0325.
If the decision is made to lift the
hood, make sure the vehicle is
parked on a level surface.
Then check to see if the engine
cooling fan is running. If the engine
is overheating, the fan should be
running. If it is not, do not continue
to run the engine, and have the
vehicle serviced.
Caution
Do not run the engine if there is a
leak in the engine cooling system.
This can cause a loss of all
coolant and can damage the
system and vehicle. Have any
leaks fixed right away.
If Steam Is Coming from the
Engine
{Warning
Steam and scalding liquids from a
hot cooling system are under
pressure. Turning the pressure
cap, even a little, can cause them
to come out at high speed and
you could be burned. Never turn
the cap when the cooling system,
including the pressure cap, is hot.
Wait for the cooling system and
pressure cap to cool.

Chevrolet Corvette Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
11374030) - 2018 - CRC - 11/8/17
Vehicle Care 241
If No Steam Is Coming from
the Engine
If an engine overheat warning is
displayed but no steam can be seen
or heard, the problem may not be
too serious. Sometimes the engine
can get a little too hot when the
vehicle:
.Climbs a long hill on a hot day.
. Stops after high-speed driving.
. Idles for long periods in traffic.
If the overheat warning is displayed
with no sign of steam: 1. Turn the air conditioning off.
2. Turn the heater on to the highest temperature and to the
highest fan speed. Open the
windows as necessary.
3. When it is safe to do so, pull off the road, shift to P (Park) or
N (Neutral), and let the
engine idle.
If the temperature overheat gauge is
no longer in the shaded area or an
overheat warning no longer
displays, the vehicle can be driven. Continue to drive the vehicle slowly
for about 10 minutes. Keep a safe
vehicle distance from the vehicle in
front. If the warning does not come
back on, continue to drive normally
and have the cooling system
checked for proper fill and function.
If the warning continues, pull over,
stop, and park the vehicle
right away.
If there is no sign of steam, idle the
engine for three minutes while
parked. If the warning is still
displayed, turn off the engine until it
cools down.
Washer Fluid
What to Use
When the vehicle needs windshield
washer fluid, be sure to read the
manufacturer instructions before
use. If the vehicle will be operating
in an area where the temperature
may fall below freezing, use a fluid
that has sufficient protection against
freezing.
Adding Washer Fluid
Open the cap with the washer
symbol on it. Add washer fluid until
the tank is full. See
Engine
Compartment Overview 0221.
Caution
.
Do not use washer fluid that
contains any type of water
repellent coating. This can
cause the wiper blades to
chatter or skip.
. Do not use engine coolant
(antifreeze) in the
windshield washer. It can
damage the windshield
washer system and paint.
(Continued)

Chevrolet Corvette Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
11374030) - 2018 - CRC - 11/8/17
350 Index
Electrical SystemEngine Compartment Fuse
Block . . . . . . . . . . . . . . . . . . . . . . . . 252
Fuses . . . . . . . . . . . . . . . . . . . . . . . . 251
Overload . . . . . . . . . . . . . . . . . . . . . 251
Rear Compartment Fuse Block . . . . . . . . . . . . . . . . . . . . . . . . 254
Electronic Stability Control (ESC) Off Light . . . . . . . . . . . . . . . . 115
Emergency OnStar . . . . . . . . . . . . . . . . . . . . . . . 337
Engine Air Cleaner/Filter . . . . . . . . . . . . . 233
Check Light (MalfunctionIndicator) . . . . . . . . . . . . . . . . . . . . . 111
Compartment Overview . . . . . . . 221
Coolant Temperature
Gauge . . . . . . . . . . . . . . . . . . . . . . 108
Coolant Temperature Warning Light . . . . . . . . . . . . . . . .115
Cooling System . . . . . . . . . . 236, 239
Drive Belt Routing . . . . . . . . . . . . 320
Exhaust . . . . . . . . . . . . . . . . . . . . . . 184
Oil Life System . . . . . . . . . . . . . . . 231
Oil Pressure Light . . . . . . . . . . . . .116
Overheating . . . . . . . . . . . . . . . . . . 240
Power Messages . . . . . . . . . . . . . 125
Running While Parked . . . . . . . . 185 Engine (cont'd)
Starting . . . . . . . . . . . . . . . . . . . . . . . 180
Entry Lighting . . . . . . . . . . . . . . . . . . . 141
Event Data Recorders . . . . . . . . . . 333
Exit Lighting . . . . . . . . . . . . . . . . . . . . 141
Extended Parking . . . . . . . . . . . . . . . 184
Extender, Seat Belt . . . . . . . . . . . . . . 70
Exterior Lamp Controls . . . . . . . . . 137
Exterior Lamps Off Reminder . . . 137
Exterior Lighting Battery Saver . . . . . . . . . . . . . . . . . . . . . . . . . 142
F
FeaturesMemory . . . . . . . . . . . . . . . . . . . . . . . . . 13
Filter, Engine Air Cleaner . . . . . . . . . . . 233
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 138
Flashers, Hazard Warning . . . . . . 140
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . 278
Floor Mats . . . . . . . . . . . . . . . . . . . . . . 300
Fluid Automatic Transmission . . . . . . 232
Brakes . . . . . . . . . . . . . . . . . . . . . . . . 243
Washer . . . . . . . . . . . . . . . . . . . . . . . 241
Folding Mirrors . . . . . . . . . . . . . . . . . . 45
Frequency Statement Radio . . . . . . . . . . . . . . . . . . . . . . . . . 331 Front Air Dam . . . . . . . . . . . . . . . . . . 178
Front Seats
Heated and Ventilated . . . . . . . . . . 64
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 210 Additives . . . . . . . . . . . . . . . . . . . . . .211
Economy Driving . . . . . . . . . . . . . . . 25
Filling a Portable FuelContainer . . . . . . . . . . . . . . . . . . . 213
Filling the Tank . . . . . . . . . . . . . . . 212
Foreign Countries . . . . . . . . . . . . .211
Gauge . . . . . . . . . . . . . . . . . . . . . . . . 106
Low Fuel Warning Light . . . . . . . .117
Management, Active . . . . . . . . . . 184
Requirements, California . . . . . .211
Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . 251 Engine Compartment Fuse
Block . . . . . . . . . . . . . . . . . . . . . . . . 252
Rear Compartment Fuse Block . . . . . . . . . . . . . . . . . . . . . . . . 254
G
Garage Door Opener . . . . . . . . . . . 133Programming . . . . . . . . . . . . . . . . . 133
Gas Strut(s) . . . . . . . . . . . . . . . . . . . . 248
Gauges Boost . . . . . . . . . . . . . . . . . . . . . . . . . 107
Engine Coolant
Temperature . . . . . . . . . . . . . . . . 108

Chevrolet Corvette Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
11374030) - 2018 - CRC - 11/8/17
Index 353
Mirrors (cont'd)Power . . . . . . . . . . . . . . . . . . . . . . . . . . 44
Tilt in Reverse . . . . . . . . . . . . . . . . . . 45
Mirrors, Interior Rearview . . . . . . . . 45
Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . 198
Driver Control . . . . . . . . . . . . . . . . . 198
Monitor System, Tire Pressure . . . . . . . . . . . . . . . . . . . . . . 267
N
NavigationOnStar . . . . . . . . . . . . . . . . . . . . . . . 337
Net Cargo . . . . . . . . . . . . . . . . . . . . . . . . . . . 95
Net, Convenience . . . . . . . . . . . . . . . 95
New Vehicle Break-In . . . . . . . . . . . 177
O
Odometer . . . . . . . . . . . . . . . . . . . . . . . 106 Trip . . . . . . . . . . . . . . . . . . . . . . . . . . . 106
Off-Road Recovery . . . . . . . . . . . . . . . . . . . . . 158
Oil Engine . . . . . . . . . . . . . . . . . . . . . . . . 226
Engine Oil Life System . . . . . . . 231
Pressure Light . . . . . . . . . . . . . . . . .116
Older Children, Restraints . . . . . . . 83
Online Owner Center . . . . . . . . . . . 324
OnStar . . . . . . . . . . . . . . . . . . . . . . . . . 334 OnStar Additional
Information . . . . . . . . . . . . . . . . . . . . 341
OnStar Connections . . . . . . . . . . . . 338
OnStar Diagnostics . . . . . . . . . . . . . 340
OnStar Emergency . . . . . . . . . . . . . 337
OnStar Navigation . . . . . . . . . . . . . . 337
OnStar Overview . . . . . . . . . . . . . . . 335
OnStar Security . . . . . . . . . . . . . . . . 337
Ordering Service Publications . . . . . . . . . . 330
Outlets
Power . . . . . . . . . . . . . . . . . . . . . . . . . . 99
Overheating, Engine . . . . . . . . . . . . 240
P
Panel, Roof . . . . . . . . . . . . . . . . . . . . . . 48
Park Shifting Into . . . . . . . . . . . . . . . . . . . 182
Shifting Out of . . . . . . . . . . . . . . . . 183
Parking . . . . . . . . . . . . . . . . . . . . . . . . . 183 Brake and P (Park)
Mechanism Check . . . . . . . . . . 247
Extended . . . . . . . . . . . . . . . . . . . . . 184
Over Things That Burn . . . . . . . 183
Parking Assist . . . . . . . . . . . . . . . . . . 208
Parking or Backing Assistance Systems . . . . . . . . . . 208 Passenger Airbag Status
Indicator . . . . . . . . . . . . . . . . . . . . . . 110
Passenger Compartment Air Filter . . . . . . . . . . . . . . . . . . . . . . . . . . 153
Passenger Sensing System . . . . . 77
Perchlorate Materials Requirements, California . . . . . . 217
Performance Data Recorder (PDR) . . . . . . . . . . . . . . . 143
Personalization Vehicle . . . . . . . . . . . . . . . . . . . . . . . 126
Power Door Locks . . . . . . . . . . . . . . . . . . . . . 37
Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . 44
Outlets . . . . . . . . . . . . . . . . . . . . . . . . . 99
Protection, Battery . . . . . . . . . . . . 142
Retained Accessory (RAP) . . . 182
Seat Adjustment . . . . . . . . . . . . . . . . 59
Windows . . . . . . . . . . . . . . . . . . . . . . . 46
Pregnancy, Using Seat Belts . . . . 70
Privacy Vehicle Data Recording . . . . . . . 333
Program Courtesy Transportation . . . . . . 327
Proposition
65 Warning,
California . . . . . . . . . . . .216, 244, 287, Back Cover