2018 CHEVROLET CITY EXPRESS maintenance

Chevrolet City Express Owner Manual (GMNA-Localizing-U.S./Canada-
11683523) - 2018 - CRC - 7/10/17
Service and Maintenance 247
Engine air filter :Replace at
specified intervals. When driving for
prolonged periods in dusty
conditions, check/replace the filter
more frequently.
Engine coolant* : Replace coolant
at the specified interval. When
adding or replacing coolant, be sure
to use only prediluted ACDelco CE
Long Life Antifreeze Coolant (blue)
or equivalent. See Recommended
Fluids and Lubricants 0257.
Mixing any other type of coolant or
using non-distilled water may
reduce the recommended service
interval of the coolant.
Engine oil and oil filter : Replace
engine oil and oil filter at the
specified intervals. For
recommended oil grade and
viscosity, see Recommended Fluids
and Lubricants 0257.
Engine valve clearance* : Inspect
only if valve noise increases. Adjust
valve clearance if necessary. Evaporative emissions control
vapor lines :
Check vapor lines for
leaks or looseness. Tighten
connections or replace parts as
necessary.
Fuel lines* : Check the fuel hoses,
piping, and connections for leaks,
looseness, or deterioration. Tighten
connections or replace parts as
necessary.
Spark plugs : Replace at specified
intervals. Install new plugs of the
same type as originally equipped.
Chassis and Body Maintenance
Brake lines and cables : Visually
inspect for proper installation.
Check for chafing, cracks,
deterioration, and signs of leaking.
Replace any deteriorated or
damaged parts immediately.
Brake pads, rotors, drums, and
linings : Check for wear,
deterioration, and fluid leaks.
Replace any deteriorated or
damaged parts immediately. Exhaust system :
Visually inspect
the exhaust pipes, muffler, and
hangers for leaks, cracks,
deterioration, and damage. Tighten
connections or replace parts as
necessary.
Steering gear and linkage, axle
and suspension parts, drive shaft
boots : Check for damage,
looseness, and leakage of oil or
grease. Under severe driving
conditions, inspect more frequently.
Tire rotation : Tires should be
rotated every 8 000 km (5,000 mi).
When rotating tires, check for
damage and uneven wear. Replace
if necessary.
Transmission fluid/oil : Visually
inspect for signs of leakage at
specified intervals.
If towing a trailer, using a camper or
car-top carrier, or driving on rough
or muddy roads, replace the CVT
fluid every 96 000 km (60,000 mi) or
request the dealer to inspect the
fluid.

Chevrolet City Express Owner Manual (GMNA-Localizing-U.S./Canada-
11683523) - 2018 - CRC - 7/10/17
248 Service and Maintenance
Maintenance Schedules
To help ensure smooth, safe, and
economical driving, two
maintenance schedules are
provided, depending upon the
conditions in which you usually
drive. These schedules contain both
distance and time intervals, up to
160 000 km (100,000 mi)/
120 months. For most people, the
odometer reading will indicate when
service is needed. However, if you
drive very little, your vehicle should
be serviced at the regular time
intervals shown in the schedule.
After 160 000 km (100,000 mi)/
120 months, continue maintenance
at the same mileage/time intervals.
Additional Maintenance Items for
Severe Operating Conditions
Additional maintenance items for
severe operating conditions should
be performed on vehicles that are
driven under especially demanding
conditions. Additional maintenanceitems should be performed if you
primarily operate your vehicle under
the following conditions:
.
Repeated short trips of less than
8 km (5 mi).
. Repeated short trips of less than
16 km (10 mi) with outside
temperatures remaining below
freezing.
. Operating in hot weather in
stop-and-go “rush hour”traffic.
. Extensive idling and/or low
speed driving for long distances,
such as police, taxi,
or door-to-door delivery use.
. Driving in dusty conditions.
. Driving on rough, muddy, or salt
spread roads.
. Using a car-top carrier.
For vehicles operated in Canada,
both standard and severe
maintenance items should be
performed at every interval.
Standard Maintenance
The following tables show the
standard maintenance schedule.
Depending upon weather and
atmospheric conditions, varying
road surfaces, individual driving
habits, and vehicle usage, additional
or more frequent maintenance may
be required. After 160 000 km
(100,000 mi)/120 months, continue
maintenance at the same mileage/
time interval.

Chevrolet City Express Owner Manual (GMNA-Localizing-U.S./Canada-
11683523) - 2018 - CRC - 7/10/17
Service and Maintenance 249
Emission Control System Maintenance
Abbreviations :I = Inspect and correct or replace as necessary
R = Replace
Maintenance OperationPerform at number of
kilometers (km), miles (mi),
or months (mo), whichever
comes first. Maintenance Interval
8 000 km/5,000 mi/6 mo
16 000 km/10,000 mi/12 mo
24 000 km/15,000 mi/18 mo
32 000 km/20,000 mi/24 mo
40 000 km/25,000 mi/30 mo
48 000 km/30,000 mi/36 mo
56 000 km/35,000 mi/42 mo
64 000 km/40,000 mi/48 mo
72 000 km/45,000 mi/54 mo
80 000 km/50,000 mi/60 mo
88 000 km/55,000 mi/66 mo
96 000 km/60,000 mi/72 mo
104 000 km/65,000 mi/78 mo 112 000 km/70,000 mi/84 mo
120 000 km/75,000 mi/90 mo
128 000 km/80,000 mi/102 mo 136 000 km/85,000 mi/6 mo
144 000 km/90,000 mi/108 mo 152 000 km/95,000 mi/114 mo
160 000 km/100,000 mi/120 mo
Drive belts. (1) I* I* I* I* I* I* I*
Air cleaner filter. (2) R R R
EVAP vapor lines. I* I* I* I* I*
Fuel lines. (3) I* I* I* I* I*
Fuel filter.
Engine coolant.* (4) (5)
Engine oil. R R R R R R R R R R R R R R R R R R R R
Engine oil filter. R R R R R R R R R R R R R R R R R R R R
Spark plugs. (6) Replace every 168 000 km (105,000 mi)
Intake and exhaust valve clearances.* (7)

Chevrolet City Express Owner Manual (GMNA-Localizing-U.S./Canada-
11683523) - 2018 - CRC - 7/10/17
250 Service and Maintenance
Footnotes—Emission Control
System Maintenance
(1) After 64 000 km (40,000 mi) or
48 months, inspect every 16 000 km
(10,000 mi) or 12 months. Replace
the drive belts if found damaged.
(2) If operating mainly in dusty
conditions, more frequent
maintenance may be required.
(3) Periodic maintenance is not
required.
(4) First replacement interval is
168 000 km (105,000 mi) or
84 months. After first replacement,
replace every 120 000 km
(75,000 mi) or 60 months. (5)
Use only prediluted ACDelco CE
Long Life Antifreeze Coolant (blue)
or equivalent. Mixing any other type
of coolant or using non-distilled
water may reduce the life
expectancy of the factory fill coolant.
See Recommended Fluids and
Lubricants 0257.
(6) Replace spark plug when the
plug gap exceeds 1.4 mm (0.055 in)
even if within specified periodic
replacement mileage.
(7) Periodic maintenance is not
required. However, if valve noise
increased, inspect valve clearance. * Maintenance items and intervals
with * are recommended for reliable
vehicle operation. The owner need
not perform such maintenance in
order to maintain the emission
warranty or manufacturer recall
liability. Other maintenance items
and intervals are required.

Chevrolet City Express Owner Manual (GMNA-Localizing-U.S./Canada-
11683523) - 2018 - CRC - 7/10/17
Service and Maintenance 251
Chassis and Body Maintenance
Abbreviations :I = Inspect and correct or replace as necessary
R = Replace
Maintenance OperationPerform at number of
kilometers (km), miles (mi),
or months (mo), whichever
comes first. Maintenance Interval
8 000 km/5,000 mi/6 mo
16 000 km/10,000 mi/12 mo
24 000 km/15,000 mi/18 mo
32 000 km/20,000 mi/24 mo
40 000 km/25,000 mi/30 mo
48 000 km/30,000 mi/36 mo
56 000 km/35,000 mi/42 mo
64 000 km/40,000 mi/48 mo
72 000 km/45,000 mi/54 mo
80 000 km/50,000 mi/60 mo
88 000 km/55,000 mi/66 mo
96 000 km/60,000 mi/72 mo
104 000 km/65,000 mi/78 mo 112 000 km/70,000 mi/84 mo
120 000 km/75,000 mi/90 mo
128 000 km/80,000 mi/102 mo 136 000 km/85,000 mi/6 mo
144 000 km/90,000 mi/108 mo 152 000 km/95,000 mi/114 mo
160 000 km/100,000 mi/120 mo
Brake lines and cables. IIIIIIIIII
Disc brake pads and rotors.∞ IIIIIIIIII
Drum brake drums and linings.∞ IIIIIIIIII
Brake fluid.∞ RRRRR
CVT fluid. (1) IIIIIIIIII
Steering gear and linkage, axle and suspension
parts.∞ I
IIII
Tire rotation. (2)
Front drive shaft boots.∞ IIIIIIIIII
Exhaust system.∞ IIIII

Chevrolet City Express Owner Manual (GMNA-Localizing-U.S./Canada-
11683523) - 2018 - CRC - 7/10/17
252 Service and Maintenance
Footnotes—Chassis and Body
Maintenance
Maintenance items with ∞should be
performed more frequently
according to “Maintenance Under
Severe Operating Conditions”.
(1) If towing a trailer, using a
camper or a car-top carrier,
or driving on rough or muddy roads,
inspect CVT fluid deterioration at
your dealer every 96 000 km
(60,000 mi), then change CVT fluid
if necessary. And if the inspection is
not performed, change (not just
inspect) CVT fluid every 96 000 km
(60,000 mi).
(2) Refer to “Tire Rotation” under
“Explanation of Scheduled
Maintenance Items” earlier in this
section.Maintenance Under Severe
Operating Conditions
The maintenance intervals shown
on the preceding pages are for
normal operating conditions. If the
vehicle is mainly operated under
severe driving conditions as shown
below, more frequent maintenance
must be performed on the following
items as shown in the table.
Severe Driving Conditions
. Repeated short trips of less than
8 km (5 mi).
. Repeated short trips of less than
16 km (10 mi) with outside
temperatures remaining below
freezing. .
Operating in hot weather in
stop-and-go “rush hour”traffic.
. Extensive idling and/or low
speed driving for long distances,
such as police, taxi,
or door-to-door delivery use.
. Driving in dusty conditions.
. Driving on rough, muddy, or salt
spread roads.
. Using a car-top carrier.

Chevrolet City Express Owner Manual (GMNA-Localizing-U.S./Canada-
11683523) - 2018 - CRC - 7/10/17
Service and Maintenance 253
Maintenance operation: Inspect = Inspect and correct or replace as necessary.Maintenance item Maintenance operation Maintenance interval
Brake fluid. ReplaceEvery 16 000 km (10,000 mi)
or 12 mo
Disc brake pads and rotors. InspectEvery 8 000 km (5,000 mi) or 6 mo
Drum brake drums and linings. InspectEvery 8 000 km (5,000 mi) or 6 mo
Steering gear and linkage, axle, and
suspension parts. Inspect
Every 8 000 km (5,000 mi) or 6 mo
Front drive shaft boots. InspectEvery 8 000 km (5,000 mi) or 6 mo
Exhaust system. InspectEvery 8 000 km (5,000 mi) or 6 mo

Chevrolet City Express Owner Manual (GMNA-Localizing-U.S./Canada-
11683523) - 2018 - CRC - 7/10/17
254 Service and Maintenance
Special Application
Services
.Severe Commercial Use
Vehicles Only: Lubricate chassis
components every oil change.
. Have underbody flushing service
performed. See “Underbody
Maintenance” inExterior Care
0 233.
Additional
Maintenance and Care
Your vehicle is an important
investment and caring for it properly
may help to avoid future costly
repairs. To maintain vehicle
performance, additional
maintenance services may be
required.
It is recommended that your dealer
perform these services —their
trained dealer technicians know
your vehicle best. Your dealer can
also perform a thorough
assessment with a multi-point
inspection to recommend when your
vehicle may need attention.
The following list is intended to
explain the services and conditions
to look for that may indicate
services are required. Battery
The 12-volt battery supplies power
to start the engine and operate any
additional electrical accessories.
.
To avoid break-down or failure to
start the vehicle, maintain a
battery with full cranking power.
. Trained dealer technicians have
the diagnostic equipment to test
the battery and ensure that the
connections and cables are
corrosion-free.
Belts
. Belts may need replacing if they
squeak or show signs of
cracking or splitting.
. Trained dealer technicians have
access to tools and equipment
to inspect the belts and
recommend adjustment or
replacement when necessary.