2018.5 VAUXHALL MOVANO_B brake

212Vehicle carenot be driven. Seek the
assistance of a workshop.
21. Stow tyre repair kit under the front
seat.
Notice
The driving characteristics of the repaired tyre are severely affected,
therefore have this tyre replaced.
If unusual noise is heard or the
compressor becomes hot, turn
compressor off for at least
30 minutes.
The built-in safety valve opens at a
pressure of seven bar (102 psi).
Note the expiry date of the kit. After
this date its sealing capability is no
longer guaranteed. Pay attention to
storage information on sealant
bottle.
Replace the used sealant bottle. Dispose of the bottle as prescribed
by applicable laws.
The compressor and sealant can be
used from approx. -30 °C.Wheel changing
Some vehicles are equipped with a
tyre repair kit instead of a spare wheel 3 209.
Make the following preparations and
observe the following information:
● Park the vehicle on a level, firm and non-slippery surface. The
front wheels must be in the
straight-ahead position.
● Apply the parking brake and engage first gear or reverse gear
(manual transmission) or N
(manual transmission
automated).
● Switch off the air suspension system 3 142.
● Remove the spare wheel 3 214.
● Never change more than one wheel at a time.
● Use the jack only to change wheels in case of puncture, not
for seasonal winter or summer
tyre change.
● The jack is maintenance-free.● If the ground on which the vehicle
is standing is soft, a solid board
(max. 1 cm thick) should be
placed under the jack.
● No people or animals may be in the vehicle when it is jacked-up.
● Never crawl under a jacked-up vehicle.
● Do not start the engine when the vehicle is raised on the jack.
● Clean wheel bolts/nuts and their threads before mounting the
wheel.9 Warning
Do not grease wheel bolt, wheel
nut and wheel nut cone.
1. Remove the wheel cover using the hook supplied.
Vehicle tools 3 203.
Depending on vehicle, first
remove the bolt / nut covers by
hand then remove the wheel
cover, or press wheel cover at the points indicated by the arrows and
turn to release.

218Vehicle care● Switch off all unnecessaryelectrical consumers.
● Switch off the air suspension system 3 142.
● Do not lean over the vehicle battery during jump starting.
● Do not allow the terminals of one
lead to touch those of the other
lead.
● The vehicles must not come into contact with each other during
the jump starting process.
● Apply the parking brake and engage neutral (manual
transmission) or N (manual
transmission automated).Jump start terminal
In the event of a discharged vehicle
battery, the jump start terminal
enables the vehicle to be started
without the need to access the battery inside the vehicle.
The jump start terminal is located in
the engine compartment and
identified by a " <" sign on the red
insulating cover. Lift the red insulating
cover to access the terminal
connector.
Ensure the red insulating cover is
latched back into position when not in
use.
Jump starting procedure
Depending on model, the jump start
terminal may be located at the left-
hand or right-hand side of the engine
compartment.

220Vehicle careCaution
Do not tow the vehicle from the
rear. The front towing eye must
only be used for towing and not
recovering a vehicle.
Switch on ignition to permit operation
of brake lights, horn and windscreen
wipers, and move the steering wheel
slightly to release the steering wheel
lock.
Switch off the air suspension system 3 142.
Move the selector lever to neutral.
Release the parking brake.
Caution
Vehicles with manual
transmission automated: If neutral cannot be selected, the vehiclemust only be towed with the drive
wheels raised off the ground.
The vehicle should always be
towed with the ignition switched
off.
Manual transmission automated
3 153.Caution
Drive slowly. Do not drive jerkily.
Excessive tractive force can
damage the vehicle.
When the engine is not running,
considerably more force is needed to
brake and steer.
To prevent the entry of exhaust fumes
from the towing vehicle, switch on the air recirculation system 3 119 and
close the windows.
Seek the assistance of a workshop.
After towing, unscrew the towing eye
and refit the cover.
Towing another vehicle
Attach a tow rope – or better still a tow
rod – to the rear towing eye, never to
the rear axle and suspension units.
Caution
The rear towing eye must only be
used for towing and not recovering a vehicle.

226Service and maintenanceEngine oil viscosity grades
The SAE viscosity grade gives
information of the thickness of the oil.
Multigrade oil is indicated by two
figures, e.g. SAE 5W-30. The first
figure, followed by a W, indicates the
low temperature viscosity and the
second figure the high temperature viscosity.
Select the appropriate viscosity grade
depending on the minimum ambient
temperature 3 229.
All of the recommended viscosity
grades are suitable for high ambient
temperatures.
Coolant and antifreeze
Use only silicate-free long life coolant (LLC) antifreeze approved for the
vehicle. Consult a workshop.
The system is factory filled with
coolant designed for excellent
corrosion protection and frost
protection down to approx. -28 °C.
This concentration should be
maintained all year round. The use of additional coolant additives that
intend to give additional corrosionprotection or seal against minor leaks
can cause function problems. Liability
for consequences resulting from the
use of additional coolant additives will be rejected.
Washer fluid Use only washer fluid approved for
the vehicle to prevent damage of
wiper blades, paintwork, plastic and
rubber parts. Consult a workshop.
Brake fluid Over time, brake fluid absorbs
moisture which will reduce braking
effectiveness. The brake fluid should
therefore be replaced at the specified
interval.
AdBlue Only use AdBlue to reduce the
nitrogen oxides in the exhaust
emission 3 145.

256Customer informationThis data includes, for example:● Vehicle status information (e.g. wheel rotation rate, speed,
movement delay, lateral
acceleration, "seatbelts
fastened" display),
● Ambient conditions (e.g. temperature, rain sensor,
distance sensor).
Most of this data is volatile and is
processed only in the vehicle itself, and not beyond the operating time.
Moreover, many control units include
data storage device (amongst others the vehicle key). This is used to allow
information to be documented
temporarily or permanently on vehicle condition, component stress,
maintenance requirements and
technical events and errors.
The following information, for
example, is stored:
● System component operating states (e.g. fill level, tyre
pressure, battery status),
● State of charge of the high voltage battery, estimated range
(in the case of electric vehicles),● Faults and defects in important system components (e.g. lights,
brakes),
● System reactions in special driving situations (e.g. triggeringof an airbag, actuation of the
stability control systems),
● Information on events damaging the vehicle.
In special cases (e.g. if the vehicle
has detected a malfunction), it may be
necessary to save data that would
otherwise just be volatile.
When you use services, the operating
data saved can be read together with the vehicle identification number andused if necessary. Staff working for
the service net-work (e.g. garages, manufacturers) or third parties (e.g.
breakdown services) can read the
data from the vehicle. Services
include repair services, maintenance
processes, warranty cases and
quality assurance measures.
Data is generally read via the OBD
(On-Board Diagnostics) port
prescribed by law in the vehicle. The operating data which has been read
out documents the technical conditionof the vehicle or individual
components and assists with fault
diagnosis, compliance with warranty
obligations and quality improvement.
This data, in particular information on component stress, technical events,
operator errors and other faults, is
transmitted to the manufacturer
where appropriate, together with the vehicle identification number. The
manufacturer is also subject to
product liability. The manufacturer
potentially also needs operating data
from vehicles for product recalls.
Fault memories in the vehicle can be
reset by a service company when
carrying out servicing or repairs.
Comfort and infotainment
functions
Comfort settings and custom settings
can be stored in the vehicle and
changed at any time.

260IndexAAbsorptive Glass Mat battery .....185
Accessories and vehicle modifications .......................... 179
Active emergency braking ..103, 165
AdBlue ........................ 101, 145, 225
AdBlue gauge ............................... 93
AdBlue tank ................................ 247
Adjustable air vents ...................131
Airbag and belt tensioners ...........98
Airbag deactivation ................63, 98
Airbag label................................... 59 Airbag system .............................. 59
Air conditioning regular operation ................................ 132
Air conditioning system .............. 119
Air intake .................................... 132
Air suspension ........................... 142
Air suspension system................ 219
Air vents...................................... 131
Antifreeze ................................... 183
Antilock brake system ................ 156
Antilock brake system (ABS) .....100
Anti-theft alarm system ................36
Anti-theft bolts............................. 212
Anti-theft locking system .............. 35
Anti-theft security lock ..................23
Appearance care ........................221
Armrest ........................................ 51
Ashtrays ....................................... 91Automatic light control ...............110
Automatic locking ...................24, 29
Autostop ....................... 17, 137, 138
Auxiliary heater ........................... 125
B Battery ........................................ 185
Battery discharge protection ......117
Battery, jump starting.................. 217
Belts.............................................. 55
BlueInjection ............................... 145
Bonnet ....................................... 180
Bottle holders................................ 75
Brake assist ............................... 158
Brake fluid .......................... 185, 225
Brakes ............................... 156, 185
Brake system ............................. 100
Breakdown.................................. 219
Bulb replacement ....................... 189
Bus Rear seats ................................. 52
C
Cabin bulkhead grille ....................81
Capacities .................................. 247
Cargo management system ........78
Car Pass ...................................... 21
Catalytic converter .....................144
Central locking system ................24
Centre high-mounted brake light 195
Changing tyre and wheel size ...208

262F
Fault ........................................... 156
Fire extinguisher ........................... 82
First aid ......................................... 82
First aid kit ................................... 82
Fixed air vents ........................... 132
Fog light ..................................... 103
Fog lights ............................ 114, 192
Folding mirrors ............................. 39
Folding seat .................................. 75
Front airbag system .....................62
Front courtesy light .....................115
Front fog lights ....................110, 114
Front reading light....................... 116
Front seats.................................... 46
Front storage ................................ 75
Front turn lights .......................... 192
Fuel economy rating (ecoScoring) ............................ 107
Fuel for diesel engines ..............173
Fuel gauge ................................... 93
Fuel tank ..................................... 247
Fuse box ..................... 199, 200, 201
Fuses ......................................... 198
G
Gauges ......................................... 91
General information ...................175
Glass panel .................................. 44
Glovebox ..................................... 75Glovebox cooler ......................... 132
Grab handles ................................ 77
Ground clearance .......................142
H Hand brake - see Parking brake. 157
Hazard warning flashers ............113
Headlight flash ........................... 112
Headlight range adjustment ......112
Headlights .................. 110, 111, 189
Headlights when driving abroad 113
Head restraint adjustment .............8
Head restraints ............................ 45
Heated exterior mirrors .................16
Heated mirrors ............................. 40
Heated rear window ...............16, 43
Heating ........................................ 52
Heating and ventilation system . 118
High beam ......................... 103, 111
High beam assist ................103, 111
Hill start assist ........................... 158
Horn ....................................... 15, 86
Hub cap hook ............................. 203
I
Identification plate .....................228
Idle speed control .......................138
Ignition switch positions .............136
Immobiliser .................................. 38
Indicators ...................................... 91
Info Display ................................. 105Information displays.................... 104
Infotainment system ...................105
Initial drive information.................... 6
Instrument cluster ........................91
Instrument panel fuse box .........200
Instrument panel illumination .....198
Instrument panel overview ........... 11
Instrument panel storage ..............74
Interior care ............................... 223
Interior lighting ............................ 115
Interior lights ...................... 115, 197
Interior mirrors .............................. 40
Interruption of power supply ......156
Introduction .................................... 3
ISOFIX .......................................... 65
J Jack ............................................ 203
Journey record............................ 107
Jump starting ............................. 217
K Keys ............................................. 20Keys, locks ................................... 20
L
Lane departure warning .....101, 171
Lashing eyes ............................... 77
Lashing straps .............................. 77
Laying up the vehicle ..................185
Light covers, misted.................... 114

263Lighting....................................... 110
Lighting features .........................117
Light switch ................................ 110
Limited-slip rear axle ..................161
Load compartment .................24, 77
Load compartment fuse box ......201
Load compartment grille ...............81
Load compartment lighting .........115
Loading information .....................83
Low beam ................................... 103
Low fuel ..................................... 102
Luggage floor net .........................77
M
Malfunction indicator light ............99
Manual adjustment ......................39
Manual anti-dazzle ......................40
Manual door locks ........................24
Manual mode ............................. 154
Manual transmission............. 17, 152 Manual transmission automated ......................... 17, 153
Manual windows ..........................41
Messages ................................... 105
Mirror adjustment ........................... 9
Mirrors .................................... 39, 40
Misted light covers .....................114
N New vehicle running-in ..............136
Number plate light .....................196O
Object detection systems ...........167
Odometer ..................................... 92
Oil ............................................... 181
Oil, engine .......................... 225, 229
Oil level ......................................... 94
Oil pressure ................................ 102
Outside temperature ....................88
Overcab storage ..........................77
Overhead console .......................76
Overrun cut-off ........................... 138
P Parking ................................ 19, 141
Parking assist ............................ 167
Parking brake ............................ 157
Parking distance control .............167
Parking ticket holder .....................44
Particulate filter ........................... 144
Pedals......................................... 135
Performing work ........................180
Power door locks ..........................28
Power outlets ............................... 89
Power side step ............................ 30
Power sliding door ........................30
Power steering fluid ....................183
Power take-off ............................ 176
Power windows ............................ 41
Preheating ......................... 101, 137
Puncture ............................. 209, 212R
Radio Frequency Identification (RFID) ..................................... 258
Radio remote control ...................21
Rain sensor .................................. 87
REACH ....................................... 255
Reading lights ............................ 116
Rear air conditioning system .....124
Rear bench seat storage ..............76
Rear courtesy light...................... 115
Rear doors ................................... 34
Rear fog light ............................. 103
Rear fog lights ....................110, 114
Rear heating system .................. 122
Rear reading light .......................116
Rear reversing lens ......................42
Rear seats ................................... 52
Bus ............................................ 52
Installing .................................... 52
Rear seat access ......................52
Removing .................................. 52
Rear storage ................................. 77
Rear view camera ...................... 169
Rear windows .............................. 42
Recommended fluids and lubricants ........................ 225, 229
Refuelling ................................... 173
Registered trademarks ...............255
Remote control ............................. 21
Retractable parking brake ..........157