
JOBNAME: 2372852-en-2017_TACO PAGE: 13 SESS: 3 OUTPUT: Wed Jul 13 07:48:07 2016
/InfoShareAuthorCODA/InfoShareAuthorCODA/TS_Warr_Maint/2372852-en-2017_T\
ACOMA.00505-17WMG-TAC_/TS_Warr_Maint_v1
WHAT IS COVERED AND
HOW LONG
Basic Warranty
This warranty covers repairs and
adjustments needed to correct defects in
materials or workmanship of any part
supplied by Toyota, subject to the
exceptions indicated under “What Is Not
Covered” on pages 14-15.
Coverage is for 36 months or
36,000 miles, whichever occurs first, with
the exception of wheel alignment and
wheel balancing, which are covered for
12 months or 12,000 miles, whichever
occurs first.
Powertrain Warranty
This warranty covers repairs needed to
correct defects in materials or
workmanship of any component listed
below and in the next column and
supplied by Toyota, subject to the
exceptions indicated under “What Is Not
Covered” on pages 14-15.
Coverage is for 60 months or
60,000 miles, whichever occurs first.
Engine
Cylinder block and head and all internal
parts, timing gears and gaskets, timing
chain/belt and cover, flywheel, valve
covers, oil pan, oil pump, engine mounts,
turbocharger housing and all internal
parts, supercharger housing and all
internal parts, engine control computer,
water pump, fuel pump, seals and gaskets.Transmission and Transaxle
Case and all internal parts, torque
converter, clutch cover, transmission
mounts, transfer case and all internal
parts, engine control computer, seals and
gaskets.
Front-Wheel-Drive System
Final drive housing and all internal parts,
axle shafts, drive shafts, constant velocity
joints, front hub and bearings, seals and
gaskets.
Rear-Wheel-Drive System
Axle housing and all internal parts,
propeller shafts, U-joints, axle shafts, drive
shafts, bearings, supports, seals and
gaskets.
Restraint Systems Warranty
This warranty covers repairs needed to
correct defects in materials or
workmanship of any seatbelt or air bag
system supplied by Toyota, subject to the
exceptions indicated under “What Is Not
Covered” on pages 14-15.
Coverage is for 60 months or
60,000 miles, whichever occurs first.
For vehicles sold and registered in the
state of Kansas, the warranty for seatbelts
and related components is 10 years,
regardless of mileage.
New Vehicle Limited Warranty
WARRANTY
Your Warranties in Detail13 

JOBNAME: 2372852-en-2017_TACO PAGE: 25 SESS: 3 OUTPUT: Wed Jul 13 07:48:07 2016
/InfoShareAuthorCODA/InfoShareAuthorCODA/TS_Warr_Maint/2372852-en-2017_T\
ACOMA.00505-17WMG-TAC_/TS_Warr_Maint_v1
WHAT IS NOT COVERED
These warranty obligations do not apply to
failures or noncompliance caused by:
•The use of replacement parts not
certified in accordance with aftermarket
parts certification regulations.
•The use of replacement parts not
equivalent in quality or design to
original equipment parts.
Provisions under the “What Is Not
Covered” section of the New Vehicle
Limited Warranty also apply to this
warranty.
PARTS LIST: LONG-TERM
EMISSION DEFECT
WARRANTY
The parts listed here are covered for seven
years or 70,000 miles from the vehicle’s
in-service date, whichever occurs first.
Air/Fuel Metering System
•Air fuel ratio sensor on models
equipped with 2GR-FKS
•Air pump
•Engine control computer (engine
control module)
•Fuel delivery pipe on models equipped
with 2GR-FKS
•Fuel pressure sensor on models
equipped with 2GR-FKS
•Fuel pump (high pressure and low
pressure) on models equipped with
2GR-FKS
•Throttle body
Air Induction System
•Intake manifold
•Intake air surge tank on models
equipped with 2GR-FKS
Catalyst System
•Exhaust front pipe (including catalytic
converter)
•Exhaust front pipe no. 2 (including
catalytic converter) on models equipped
with 2GR-FKS
•Exhaust manifold (including manifold
converter) on models equipped with
2GR-FKS
Evaporative Control System
•Charcoal canister
•Fuel tank
California Emission Control Warranty
WARRANTY
Your Warranties in Detail25 

JOBNAME:2372852-en-2017_TACO PAGE:53SESS: 3OUTPUT: WedJul1307:48:07 2016
/InfoShareAuthorCODA/InfoShareAuthorCODA/TS_Warr_Maint/2372852-en-2017_T\
ACOMA.00505-17WMG-TAC_/TS_Warr_Maint_v1
120,000 milesor144 months
Check installation ofdriver’s floormatInspect andadjust allfluid levelsInspect wiperbladesLubricate propellershaft(4WD)Re-torque propellershaftboltReplace cabinairfilter
Replace engineairfilterReplace engineoiland oilfilter1
Replace sparkplugs4
Rotate tires
Inspect thefollowing:_Ball joints anddust covers
_ Brake linesandhoses
_ Brake linings/drums andbrake
pads/discs
5
_ Drive belts
_ Drive shaftboots (4WD)
_ Engine coolant
6
_Exhaust pipesandmountings
_ Front differential oil(4WD) _
Fuel lines andconnections, fueltank
band andfueltank vapor ventsystem
hoses
_ Fuel tank capgasket
_ Radiator andcondenser
_ Rear differential oil
_ Steering gear
_ Steering linkageandboots
_ Transfer caseoil(4WD)
_ Transmission forsigns ofleakage
_ Vacuum pumpforbrake booster (except
for off-road package models)
7
Additional Maintenance ItemsforSpecial Operating Conditions2
Drivingondirt roads ordusty roads:Replace transfercaseoil(4WD)Tighten nutsandbolts onchassis andbody
Driving whiletowing, usingacar-top carrier, orheavy vehicle loading8:Replace frontdifferential oil(4WD)Replace reardifferential oilReplacetransfercaseoil(4WD)Replace transmission fluidoroilTighten nutsandbolts onchassis andbody
Extensive idlingand/or lowspeed driving foralong distance suchaspolice, taxior
door-to-door deliveryuse:
Replaceautomatic transmission fluid
DEALERSERVICEVERIFICATION:
D
AT E:
M
ILEAGE:1Reset theoilreplacement reminderlight(“MAINT REQD”)orthe message “OILMAINTENANCE REQUIRED”onthe
multi-information displayaftermaintenance atevery 5,000 miles.
2Perform theseservice itemsonlyifyou drive primarily undertheconditions indicated.3Includesoperating onroads which roadsalthasbeen applied.4Maintenance servicesofspark plugs arerequired undertheterms ofthe Emissions ControlWarranty.5Inspectthickness measurement anddisc runout.6Refer to“Engine Coolant” inthe “Explanation ofMaintenance Items”section inthe back ofthis guide formore
information.
7If blade/vane requiresreplacement, useanew blade/vane. Neverreusetheblade/vane.8Not allvehicles aredesigned fortowing. RefertoyourVehicle Owner’ sManual fordetails.
Maintenance Log
MAINTENANCE
MaintenanceLog53
JOBNAME:2372852-en-2017_TACO PAGE:53SESS: 3OUTPUT: WedJul1307:48:07 2016
/InfoShareAuthorCODA/InfoShareAuthorCODA/TS_Warr_Maint/2372852-en-2017_T\
ACOMA.00505-17WMG-TAC_/TS_Warr_Maint_v1
120,000 milesor144 months
Check installation ofdriver’s floormat
Inspect andadjust allfluid levels
Inspect wiperblades
Lubricate propellershaft(4WD)
Re-torque propellershaftbolt
Replace cabinairfilter Replace
engineairfilter
Replace engineoiland oilfilter1
Replace sparkplugs4
Rotate tires
Inspect thefollowing:_Ball joints anddust covers
_ Brake linesandhoses
_ Brake linings/drums andbrake
pads/discs
5
_ Drive belts
_ Drive shaftboots (4WD)
_ Engine coolant
6
_Exhaust pipesandmountings
_ Front differential oil(4WD) _
Fuel lines andconnections, fueltank
band andfueltank vapor ventsystem
hoses
_ Fuel tank capgasket
_ Radiator andcondenser
_ Rear differential oil
_Steering gear
_ Steering linkageandboots
_ Transfer caseoil(4WD)
_ T
ransmissionforsigns ofleakage
_ Vacuum pumpforbrake booster (except
for off-road package models)
7
Additional Maintenance ItemsforSpecial Operating Conditions2
Drivingondirt roads ordusty roads:Replace transfercaseoil(4WD)
Tighten nutsandbolts onchassis andbody
Driving whiletowing, usingacar-top carrier, orheavy vehicle loading8:Replace frontdifferential oil(4WD)
Replace reardifferential oil
Replace transfercaseoil(4WD)
Replace transmission fluidoroil
Tighten nutsandbolts onchassis andbody
Extensive idlingand/or lowspeed driving foralong distance suchaspolice, taxior
door-to-door deliveryuse:
Replaceautomatic transmission fluid
DEALERSERVICEVERIFICATION:
D
AT E:
M
ILEAGE:
Maintenance Log
MAINTENANCE
MaintenanceLog53
JOBNAME:2372852-en-2017_TACO PAGE:53SESS: 3OUTPUT: WedJul1307:48:07 2016
/InfoShareAuthorCODA/InfoShareAuthorCODA/TS_Warr_Maint/2372852-en-2017_T\
ACOMA.00505-17WMG-TAC_/TS_Warr_Maint_v1
120,000 milesor144 months
Check installation ofdriver’s floormat
Inspect andadjust allfluid levels
Inspect wiperblades
Lubricate propellershaft(4WD)
Re-torque propellershaftbolt
Replace cabinairfilter Replace
engineairfilter
Replace engineoiland oilfilter1
Replace sparkplugs4
Rotate tires
Inspect thefollowing:_Ball joints anddust covers
_ Brake linesandhoses
_ Brake linings/drums andbrake
pads/discs
5
_ Drive belts
_ Drive shaftboots (4WD)
_ Engine coolant
6
_Exhaust pipesandmountings
_ Front differential oil(4WD) _
Fuel lines andconnections, fueltank
band andfueltank vapor ventsystem
hoses
_ Fuel tank capgasket
_ Radiator andcondenser
_ Rear differential oil
_Steering gear
_ Steering linkageandboots
_ Transfer caseoil(4WD)
_ T
ransmissionforsigns ofleakage
_ Vacuum pumpforbrake booster (except
for off-road package models)
7
Additional Maintenance ItemsforSpecial Operating Conditions2
Drivingondirt roads ordusty roads:Replace transfercaseoil(4WD)
Tighten nutsandbolts onchassis andbody
Driving whiletowing, usingacar-top carrier, orheavy vehicle loading8:Replace frontdifferential oil(4WD)
Replace reardifferential oil
Replace transfercaseoil(4WD)
Replace transmission fluidoroil
Tighten nutsandbolts onchassis andbody
Extensive idlingand/or lowspeed driving foralong distance suchaspolice, taxior
door-to-door deliveryuse:
Replaceautomatic transmission fluid
DEALERSERVICEVERIFICATION:
D
AT E:
M
ILEAGE:1Reset theoilreplacement reminderlight(“MAINT REQD”)orthe message “OILMAINTENANCE REQUIRED”onthe
multi-information displayaftermaintenance atevery 5,000 miles.
2Perform theseservice itemsonlyifyou drive primarily undertheconditions indicated.3Includesoperating onroads which roadsalthasbeen applied.4Maintenance servicesofspark plugs arerequired undertheterms ofthe Emissions ControlWarranty.5Inspectthickness measurement anddisc runout.6Refer to“Engine Coolant” inthe “Explanation ofMaintenance Items”section inthe back ofthis guide formore
information.
7If blade/vane requiresreplacement, useanew blade/vane. Neverreusetheblade/vane.8Not allvehicles aredesigned fortowing. Refertoyour Vehicle Owner’s Manualfordetails.
Maintenance Log
MAINTENANCE
MaintenanceLog53
137077_WMG_Tacoma_x-tions.indd   537/19/16   3:23 PM