2017 TOYOTA COROLLA iM fuel pump

JOBNAME: 2372394-en-2017_SCIO PAGE: 13 SESS: 4 OUTPUT: Wed Jul 20 11:35:24 2016
/InfoShareAuthorCODA/InfoShareAuthorCODA/TS_Warr_Maint/2372394-en-2017_S\
CION-iM.00505-17WMG-IM_/TS_Warr_Maint_v1
WHAT IS COVERED AND
HOW LONG
Basic Warranty
This warranty covers repairs and
adjustments needed to correct defects in
materials or workmanship of any part
supplied by Toyota, subject to the
exceptions indicated under “What Is Not
Covered” on pages 14-15.
Coverage is for 36 months or
36,000 miles, whichever occurs first, with
the exception of wheel alignment and
wheel balancing, which are covered for
12 months or 12,000 miles, whichever
occurs first.
Powertrain Warranty
This warranty covers repairs needed to
correct defects in materials or
workmanship of any component listed
below and in the next column and
supplied by Toyota, subject to the
exceptions indicated under “What Is Not
Covered” on pages 14-15.
Coverage is for 60 months or
60,000 miles, whichever occurs first.
Engine
Cylinder block and head and all internal
parts, timing gears and gaskets, timing
chain/belt and cover, flywheel, valve
covers, oil pan, oil pump, engine mounts,
turbocharger housing and all internal
parts, supercharger housing and all
internal parts, engine control computer,
water pump, fuel pump, seals and gaskets.Transmission and Transaxle
Case and all internal parts, torque
converter, clutch cover, transmission
mounts, transfer case and all internal
parts, engine control computer, seals and
gaskets.
Front-Wheel-Drive System
Final drive housing and all internal parts,
axle shafts, drive shafts, constant velocity
joints, front hub and bearings, seals and
gaskets.
Rear-Wheel-Drive System
Axle housing and all internal parts,
propeller shafts, U-joints, axle shafts, drive
shafts, bearings, supports, seals and
gaskets.
Restraint Systems Warranty
This warranty covers repairs needed to
correct defects in materials or
workmanship of any seatbelt or air bag
system supplied by Toyota, subject to the
exceptions indicated under “What Is Not
Covered” on pages 14-15.
Coverage is for 60 months or
60,000 miles, whichever occurs first.
For vehicles sold and registered in the
state of Kansas, the warranty for seatbelts
and related components is 10 years,
regardless of mileage.
New Vehicle Limited Warranty
WARRANTY
Your Warranties in Detail13

JOBNAME:2372394-en-2017_SCIO PAGE:53SESS: 4OUTPUT: WedJul2011:35:24 2016
/InfoShareAuthorCODA/InfoShareAuthorCODA/TS_Warr_Maint/2372394-en-2017_S\
CION-iM.00505-17WMG-IM_/TS_Warr_Maint_v1
120,000 milesor144 months
Check installation ofdriver’s floormat
Inspect andadjust allfluid levels
Inspect wiperblades
Replace cabinairfilter
Replace engineairfilter
Replace engineoiland oilfilter
1
Replace sparkplugs3
Rotate tires
Inspect thefollowing:_Ball joints anddust covers
_ Brake linesandhoses
_ Brake linings/drums and
brake pads/discs
4
_ Drive shaftboots_Engine coolant5
_Exhaust pipesandmountings
_ Fuel lines andconnections, fueltank
band andfueltank vapor ventsystem
hoses
_ Fuel tank capgasket
_ Radiator andcondenser
_ Steering gear
_ Steering linkageandboots
_ Transmission forsigns ofleakage
_Vacuum pumpforbrake booster
Additional Maintenance ItemsforSpecial Operating Conditions
2
Drivingondirt roads ordusty roads:Tighten nutsandbolts onchassis andbody
Driving whiletowing, usingacar-top carrier, orheavy vehicle loading6:Replace transmission fluidoroilTighten nutsandbolts onchassis andbody
Extensive idlingand/or lowspeed driving foralong distance suchaspolice, taxior
door-to-door deliveryuse:
Replacecontinuously variabletransmission (CVT)fluid
DEALERSERVICEVERIFICATION:
D
AT E:
M
ILEAGE:
1Reset theoilreplacement reminderlight(“MAINT REQD”)orthe message “OILMAINTENANCE REQUIRED”onthe
multi-information displayaftermaintenance atevery 5,000 miles.
2Perform theseservice itemsonlyifyou drive primarily undertheconditions indicated.3Maintenance servicesofspark plugs arerequired undertheterms ofthe Emissions ControlWarranty.4Inspectthickness measurement anddisc runout.5Refer to“Engine Coolant” inthe “Explanation ofMaintenance Items”section inthe back ofthis guide formore
information.
6Not allvehicles aredesigned fortowing. Refertoyour Vehicle Owner’s Manualfordetails.
MAINTENANCE LOG
MAINTENANCE
MaintenanceLog53
JOBNAME:2372394-en-2017_SCIO PAGE:53SESS: 4OUTPUT: WedJul2011:35:24 2016
/InfoShareAuthorCODA/InfoShareAuthorCODA/TS_Warr_Maint/2372394-en-2017_S\
CION-iM.00505-17WMG-IM_/TS_Warr_Maint_v1
120,000 milesor144 months
Check installation ofdriver’s floormat
Inspect andadjust allfluid levels
Inspect wiperblades
Replace cabinairfilter
Replace engineairfilter
Replace engineoiland oilfilter
1
Replace sparkplugs3
Rotate tires
Inspect thefollowing:_Ball joints anddust covers
_ Brake linesandhoses
_ Brake linings/drums and
brake pads/discs
4
_ Drive shaftboots
_ Engine coolant5
_Exhaust pipesandmountings
_ Fuel lines andconnections, fueltank
band andfueltank vapor ventsystem
hoses _
Fuel tank capgasket
_ Radiator andcondenser
_ Steering gear
_ Steering linkageandboots
_ Transmission forsigns ofleakage
_ Vacuum pumpforbrake booster
Additional Maintenance ItemsforSpecial Operating Conditions
2
Drivingondirt roads ordusty roads:Tighten nutsandbolts onchassis andbody
Driving whiletowing, usingacar-top carrier, orheavy vehicle loading6:Replace transmission fluidoroilTighten nutsandbolts onchassis andbody
Extensive idlingand/or lowspeed driving foralong distance suchaspolice, taxior
door-to-door deliveryuse:
Replacecontinuously variabletransmission (CVT)fluid
DEALERSERVICEVERIFICATION:
D
AT E:
M
ILEAGE:
1Reset theoilreplacement reminderlight(“MAINT REQD”)orthe message “OILMAINTENANCE REQUIRED”onthe
multi-information displayaftermaintenance atevery 5,000 miles.
2Perform theseservice itemsonlyifyou drive primarily undertheconditions indicated.3Maintenance servicesofspark plugs arerequired undertheterms ofthe Emissions ControlWarranty.4Inspectthickness measurement anddisc runout.5Refer to“Engine Coolant” inthe “Explanation ofMaintenance Items”section inthe back ofthis guide formore
information.
6Not allvehicles aredesigned fortowing. Refertoyour Vehicle Owner’s Manualfordetails.
MAINTENANCE LOG
MAINTENANCE
MaintenanceLog53
JOBNAME:2372394-en-2017_SCIO PAGE:53SESS: 4OUTPUT: WedJul2011:35:24 2016
/InfoShareAuthorCODA/InfoShareAuthorCODA/TS_Warr_Maint/2372394-en-2017_S\
CION-iM.00505-17WMG-IM_/TS_Warr_Maint_v1
120,000 milesor144 months
Check installation ofdriver’s floormatInspect andadjust allfluid levelsInspect wiperbladesReplace cabinairfilterReplace engineairfilterReplace engineoiland oilfilter1
Replace sparkplugs3
Rotate tires
Inspect thefollowing:_Ball joints anddust covers
_ Brake linesandhoses
_ Brake linings/drums and
brake pads/discs4
_Drive shaftboots
_ Engine coolant5
_Exhaust pipesandmountings
_ Fuel lines andconnections, fueltank
band andfueltank vapor ventsystem
hoses
_ Fuel tank capgasket
_ Radiator andcondenser
_ Steering gear
_ Steering linkageandboots
_Transmission forsigns ofleakage
_ Vacuum pumpforbrake booster
Additional Maintenance ItemsforSpecial Operating Conditions
2
Drivingondirt roads ordusty roads:Tighten nutsandbolts onchassis andbody
Driving whiletowing, usingacar-top carrier, orheavy vehicle loading6:Replace transmission fluidoroil
Tighten nutsandbolts onchassis andbody
Extensive idlingand/or lowspeed driving foralong distance suchaspolice, taxior
door-to-door deliveryuse:
Replacecontinuously variabletransmission (CVT)fluid
DEALERSERVICEVERIFICATION:
D
AT E:
M
ILEAGE:
1Reset theoilreplacement reminderlight(“MAINT REQD”)orthe message “OILMAINTENANCE REQUIRED”onthe
multi-information displayaftermaintenance atevery 5,000 miles.
2Perform theseservice itemsonlyifyou drive primarily undertheconditions indicated.3Maintenance servicesofspark plugs arerequired undertheterms ofthe Emissions ControlWarranty.4Inspectthickness measurement anddisc runout.5Refer to“Engine Coolant” inthe “Explanation ofMaintenance Items”section inthe back ofthis guide formore
information.
6Not allvehicles aredesigned fortowing. Refertoyour Vehicle Owner’s Manualfordetails.
MAINTENANCE LOG
MAINTENANCE
MaintenanceLog53
belts
137042_WMG_Corolla_p53.indd 537/25/16 5:27 PM

JOBNAME: 2372394-en-2017_SCIO PAGE: 56 SESS: 4 OUTPUT: Wed Jul 20 11:35:24 2016
/InfoShareAuthorCODA/InfoShareAuthorCODA/TS_Warr_Maint/2372394-en-2017_S\
CION-iM.00505-17WMG-IM_/TS_Warr_Maint_v1
Fuel Lines and Connections,
Fuel Tank Band and Fuel Tank
Vapor Vent System Hoses
Visually inspect for corrosion, damage,
cracks, and loose or leaking connections.
Tighten connections or replace parts as
necessary.
Fuel Tank Cap Gasket
Visually inspect for cracks, deterioration
and damage and replace if necessary.
Nuts and Bolts on Chassis and
Body
Re-tighten the seat-mounting bolts and
front/rear suspension member retaining
bolts to specified torque.
Radiator and Condenser
Inspect for debris, corrosion and signs of
damage. Have any problem repaired
immediately by a qualified technician.
Spark Plugs
Replace at specified intervals. Install new
plugs of the same type as originally
equipped. A qualified technician should
perform this operation.
Steering Gear
Inspect for signs of leakage. If you
discover any leakage, have it repaired
immediately by a qualified technician.
Steering Linkage and Boots
With the vehicle stopped, check for
excessive freeplay in the steering wheel.
Inspect the linkage for bending and
damage and the dust boots for
deterioration, cracks and damage. Replace
any damaged parts. A qualified technician
should perform these operations.
Tire Rotation
Tires should be rotated according to the
instructions in the Owner’s Manual. When
rotating tires, check for damage and
uneven wear. Replace if necessary.
Transmission Fluid or Oil
Inspect or replace at specified intervals.
When performing inspections, check each
component for signs of leakage. If you
discover any leakage, have it repaired by a
qualified technician immediately.
Vacuum Pump for Brake
Booster
Inspect at specified intervals. A qualified
technician should perform this operation.
Wiper Blades
The wiper blades should not show any
signs of cracking, splitting, wear,
contamination or deformation. The wiper
blades should clear the windshield without
streaking or skipping.
EXPLANATION OF MAINTENANCE ITEMS
Maintenance Log56
MAINTENANCE