2017 FORD F750 suspension

The tires on your vehicle have all-weather
treads to provide traction in rain and snow.
However, in some climates, you may need
to use snow tires and cables. If you need
to use cables, it is recommended that steel
wheels (of the same size and
specifications) be used, as cables may chip
aluminum wheels.
Note:
The suspension insulation and
bumpers help prevent vehicle damage. Do
not remove these components from your
vehicle when using snow tires and chains.
Follow these guidelines when using snow
tires and chains:
• If possible, avoid fully loading your
vehicle.
• Use only SAE Class S chains.
• Install chains securely, verifying that
the chains do not touch any wiring,
brake lines or fuel lines.
• Drive cautiously. If you hear the chains
rub or bang against your vehicle, stop
and retighten the chains. If this does
not work, remove the chains to prevent
damage to your vehicle.
• Remove the tire chains when they are
no longer needed. Do not use tire
chains on dry roads.
If you have any questions regarding snow
chains or cables, please contact your
authorized dealer.
CHANGING A ROAD WHEEL
If you get a flat tire while driving, do not
apply the brake heavily. Instead, gradually
decrease your speed. Hold the steering
wheel firmly and slowly move to a safe
place on the side of the road. Tire Change Procedure WARNINGS
When one of the front wheels is off
the ground, the transmission alone
will not prevent the vehicle from
moving or slipping off the jack, even if the
transmission is in park (P). To help prevent the vehicle from
moving when you change a tire, be
sure to place the transmission in park
(P), set the parking brake and block (in
both directions) the wheel that is
diagonally opposite (other side and end of
the vehicle) to the tire being changed. Never get underneath a vehicle that
is supported only by a jack. If the
vehicle slips off the jack, you or
someone else could be seriously injured. Do not attempt to change a tire on
the side of the vehicle close to
moving traffic. Pull far enough off the
road to avoid the danger of being hit when
operating the jack or changing the wheel. Note:
Passengers should not remain in the
vehicle when the vehicle is being jacked.
Park on a level surface, set the parking
brake and activate the hazard flashers. 1.
Turn the engine off and block the wheel
that is diagonally opposite of the flat
tire using a wheel chock.
248
F-650/750 (TBC) , enUSA, First Printing Wheels and TiresE142551

Tightening lug nuts
Tighten the lug nuts to the specified torque *
at 500 miles
(800 km) after any wheel disturbance (such as tire rota-
tion, changing a flat tire or wheel removal).
Single rear wheels
Tighten the wheel lug nuts to the specified torque *
at 100
miles (160 km), and again at 500 miles (800 km) of new vehicle operation and after any wheel disturbance (such as tire rotation, changing a flat tire or wheel removal).
Dual rear wheels
* See Technical Specifications (page 250).
Multi-point Inspection
In order to keep your vehicle running right,
it is important to have the systems on your
vehicle checked regularly. This can help
identify potential issues and prevent major
problems. We recommend having the
following multi-point inspection performed
at every scheduled maintenance interval
to help make sure your vehicle keeps
running great. Multi-point inspection
Horn operation
Accessory drive belt(s)
Radiator, cooler, heater and A/C hoses
Battery performance
Suspension component for leaks ordamage
Engine air filter
Steering and linkage
Exhaust system
Tires (including spare) for wear and properpressure**
Exterior lamps operation
Windshield for cracks, chips or pits
Fluid levels *
; fill if necessary
322
F-650/750 (TBC) , enUSA, First Printing Scheduled Maintenance

Every 15000 miles (24000 km) or 12 months (whichever comes first)
Inspect the automatic transmission fluid level. Consult an authorized dealer for
requirements.
Inspect the brake pads, shoes, rotors, drums, brake linings, hoses and parking brake.
Inspect the engine cooling system concentration (freeze-point protection), level and
hoses.
Inspect the exhaust system and heat shields.
Inspect the steering linkage, ball joints, suspension, tie-rod ends, driveshaft and U-joints.
Lubricate components equipped with grease fittings. Other maintenance items
Replace the engine air filter.
Every 30000 miles (48000
km)
Replace the front wheel bearing grease and grease seal
if equipped with non-sealed bearings.
Every 60000 miles (96000
km)
Replace the spark plugs.
Every 97500 miles (156000
km)
Change the engine coolant.*
Every 105000 miles
(168000 km) Change the rear axle fluid. See Special Operating
Conditions Scheduled Maintenance (page 328).
Inspect the accessory drive belt(s). **
Change the automatic transmission fluid and filter. Consult
an authorized dealer for requirements.
Every 150000 miles
(240000 km) Replace the accessory drive belt(s) if not replaced within
the last 100000 miles (160000 km).
Replace the front wheel bearings and seals if equipped
with non-sealed bearings.
* Initial replacement at six years or 105000 miles (168000 kilometers), then every three
years or 45000 miles (72000 kilometers).
** If not replaced, inspect the belt(s) every 15000 miles (24000 kilometers).
325
F-650/750 (TBC) , enUSA, First Printing Scheduled Maintenance

Diesel Engine
At every oil change interval as indicated by the information display
1
Change the engine oil and filter. 2
Drain the fuel filter water trap.
Refill the diesel exhaust fluid tank.
Rotate the tires 3
, inspect the tires for wear and measure tread depth.
Perform a multi-point inspection (recommended).
Inspect the air filter restriction gauge. Replace the filter if necessary.
Inspect the automatic transmission fluid level. Consult an authorized dealer for
requirements.
Inspect the brake pads, shoes, rotors, drums, brake linings, hoses and parking brake.
Inspect the engine and secondary coolant concentration (freeze-point protection), level
and hoses.
Inspect the exhaust system and heat shields.
Inspect the steering linkage, ball joints, suspension, tie-rod ends, driveshaft and U-joints.
Lubricate components equipped with grease fittings.
Inspect front oil hubs for leaks and check fluid level through hub cap sight glass.
1 Do not exceed one year or 10000 miles (16000 kilometers) between service intervals.
2 Reset the Intelligent Oil-Life Monitor after engine oil and filter changes.
3 Vehicles with dual rear wheels should rotate the front wheels when specified; rear wheels
only if unusual wear is noted.
326
F-650/750 (TBC) , enUSA, First Printing Scheduled Maintenance

Operating in dusty or sandy conditions (such as unpaved or dusty roads)
Rotate the tires*
, inspect the tires for wear and measure
tread depth.
Every 7500 miles (12000
km)
Inspect the brake system pads and rotors.
Inspect the air filter restriction gauge. Replace the filter if
necessary.
Inspect the steering and suspension ball joints and tie rods.
Lubricate any grease fittings.
Change the engine oil and filter. **
Every 7500 miles (12000
km), six months or 300
engine hours Inspect and lubricate the U-joints.
Replace the engine-mounted and frame-mounted fuel
filters.
Every 15000 miles (24000
km), six months, 600 engine
hours, or as indicated by the
information display
Replace the air inlet foam filter.
Every 30000 miles (48000
km)
* Vehicles with dual rear wheels should rotate the front wheels when specified; rear wheels
only if unusual wear is noted.
** Reset the Intelligent Oil-Life Monitor after engine oil and filter changes. Off-road operation
Inspect functional holes in each leg of the twin exhaust
tips and the holes under the shield just inboard of the right
rear tire to make sure they are clean and clear of debris or
foreign materials. Refer to the Vehicle Care chapter of your
owner ’s manual for more information.
As required
Inspect the steering and suspension ball joints and tie rods.
Lubricate any grease fittings.
Rotate the tires*
, inspect the tires for wear and measure
tread depth.
Every 7500 miles (12000
km), six months or 300
engine hours
Inspect the brake system pads and rotors.
Inspect the air filter restriction gauge. Replace the filter if
necessary.
335
F-650/750 (TBC) , enUSA, First Printing Scheduled Maintenance

2
2-Speed Rear Axle........................................118
Axle Shifting.......................................................... 118
A
A/C See: Climate Control........................................... 70
About This Manual...........................................7
Diesel Engine Information................................... 8
Minor Troubleshooting Guide............................ 9
Warnings.................................................................... 8
ABS See: Brakes............................................................ 119
ABS driving hints See: Hints on Driving With Anti-Lock
Brakes................................................................ 120
Accessories.....................................................312
Accessories See: Replacement Parts
Recommendation............................................ 13
Adjusting the Headlamps........................205 Horizontal Aim Adjustment.......................... 206
Vertical Aim Adjustment................................ 205
Adjusting the Steering Wheel
...................44
Air Brakes.........................................................123 Air Chamber Stroke Indication...................... 124
Cam Brakes - Automatic Slack Adjusters........................................................... 124
Emergency Air Brake.......................................... 124
Air Conditioning See: Climate Control........................................... 70
Air Filter See: Changing the Engine Air Filter - 6.7L
Diesel.................................................................. 210
See: Changing the Engine Air Filter - 6.8L.................................................................... 209
Air Induction System Inspection.............217 Chassis-mounted Charge Air Cooler...........218
Air Suspension
...............................................136
Air Suspension Dump Button........................ 136
Connecting and Disconnecting a Trailer with Air Suspension and Air Suspension
Dump Button................................................... 136
Suspension Conversions................................. 136
System Indicator Light...................................... 136
Appendices....................................................348 Audible Warnings and Indicators..............61
Beltminder Warning............................................. 61
Door Ajar................................................................... 61
Headlamps On Warning Chime....................... 61
Key in Ignition Warning Chime......................... 61
Parking Brake On Warning Chime................... 61
Audio Control
..................................................44
Media........................................................................\
45
Seek, Next or Previous........................................ 45
Audio Input Jack...........................................279
Audio System
.................................................272
General Information.......................................... 272
Audio Unit - Vehicles With: AM/FM/CD/ SYNC..............................................................274
Audio Unit - Vehicles With: AM/FM
......273
Automatic Transmission.............................112
Brake-Shift Interlock.......................................... 115
If Your Vehicle Gets Stuck In Mud or Snow................................................................... 116
Understanding the Shift Positions of a 6– Speed Automatic Transmission..........112
Understanding your SelectShift™ Automatic transmission............................... 113
Automatic Transmission Fluid Check.............................................................198
Transmission Fluid Level................................. 199
Auxiliary Power Points..................................81 110 Volt AC Power Points.................................... 81
12 Volt DC Power Point........................................ 81
Locations.................................................................. 81
Auxiliary Switches
........................................312
Axle Inspection.............................................222
Front Axle.............................................................. 222
B
Battery See: Changing the 12V Battery..................... 203
Bonnet Lock See: Opening and Closing the Hood............181
Booster Seats..................................................25 Types of Booster Seats...................................... 25
Brake Fluid Check.......................................200
Brakes................................................................119 General Information........................................... 119
Brake System Inspection...........................219 Air Brakes............................................................... 219
Driveline Parking Brake..................................... 221
371
F-650/750 (TBC) , enUSA, First Printing Index

Storage Compartments..............................83
Sun Visors.........................................................53
Slide-on-rod........................................................... 53
Suspension System Inspection
..............223
Switching Off the Engine............................88
Symbols Glossary
...........................................10
SYNC™.............................................................281 General Information.......................................... 281
SYNC™ Troubleshooting.........................306
T
Technical Specifications See: Capacities and Specifications............252
The Better Business Bureau (BBB) Auto Line Program (U.S. Only)........................157
Tire Care..........................................................233 Glossary of Tire Terminology......................... 233
Information Contained on the Tire Sidewall............................................................ 233
Tires See: Wheels and Tires...................................... 233
Towing a Trailer.............................................138 Load Placement.................................................. 138
Towing..............................................................138
Traction Control
............................................130
Principle of Operation....................................... 130
Trailer Brakes
..................................................126
Trailer Air Supply and Parking Brake
Modular Controls............................................ 127
Trailer Brake Hand Control.............................. 126
Transmission Code Designation.............257
Transmission...................................................112
Transmission See: Transmission................................................ 112
Transporting the Vehicle
............................153
U
Under Hood Overview - 6.7L Diesel.............................................................184
Under Hood Overview - 6.8L...................183
USB Port
..........................................................279
Using Cruise Control....................................132 Switching Cruise Control Off.......................... 133
Switching Cruise Control On........................... 132
Using Snow Chains......................................247 Using SYNC™ With Your Media
Player.............................................................297
Accessing Your Play Menu............................. 302
Connecting Your Digital Media Player to the USB Port........................................................... 297
Media Menu Features...................................... 300
Media Voice Commands................................ 299
System Settings................................................ 304
What's Playing?................................................. 298
Using SYNC™ With Your Phone............285 Accessing Features Through the Phone
Menu................................................................. 290
Accessing Your Phone Settings.................... 293
Making a Call...................................................... 288
Pairing a Cell Phone for the First Time................................................................... 285
Pairing Subsequent Cell Phones.................286
Phone Options during an Active Call.........288
Phone Voice Commands................................ 287
Receiving Calls................................................... 288
System Settings................................................. 294
Text Messaging.................................................... 291
Using Traction Control - Vehicles With: Air Brakes
......................................................130
System Indicator Light..................................... 130
Using Traction Control - Vehicles With: Hydraulic Brakes........................................130
System Indicator Light....................................... 131
Using Voice Recognition...........................283 Initiating a Voice Session................................ 283
System Interaction and Feedback..............284
Utilizing the Mediation/Arbitration Program (Canada Only)..........................157
V
Vehicle Care...................................................225 General Information.......................................... 225
Vehicle Certification Label........................257
Vehicle Identification Number
................256
Vehicle Inspection Guide.............................171
Vehicle Inspection Information.................171 Trailer....................................................................... 178
Transmission........................................................ 178
Vehicle Storage
............................................230
Battery..................................................................... 231
Body........................................................................\
230
Brakes...................................................................... 231
378
F-650/750 (TBC) , enUSA, First Printing Index

Cooling system....................................................
231
Engine...................................................................... 231
Fuel system........................................................... 231
General.................................................................. 230
Miscellaneous...................................................... 231
Removing Vehicle From Storage................... 231
Tires........................................................................\
.. 231
Ventilation See: Climate Control........................................... 70
VIN See: Vehicle Identification Number............256
Voice Control...................................................45
W
Warning Lamps and Indicators................58 Anti-Lock Braking System................................ 58
Automatic Regeneration Control................... 58
Battery...................................................................... 58
Brake System......................................................... 58
Check Fuel Cap..................................................... 58
Check Suspension............................................... 58
Cruise Control........................................................ 58
Diesel Exhaust Fluid (Diesel Engine Only).................................................................... 58
Diesel Particulate Filter (Diesel Engine Only).................................................................... 59
Direction Indicator............................................... 59
Door Ajar.................................................................. 59
Electronic Locking Differential........................ 59
Engine Oil Pressure............................................. 59
Exhaust Brake On................................................ 59
Fasten Seatbelt.................................................... 59
High Beam.............................................................. 59
Hydromax............................................................... 59
Low Fuel Level (Gasoline Engine Only).................................................................... 59
Parking Brake Warning....................................... 59
Powertrain Malfunction/Reduced Power/Electronic Throttle Control
(Gasoline Engine Only)................................ 60
Service Engine Soon........................................... 60
Traction Control (Diesel Engine Only).........60
Trailer Anti-Lock Brake System (ABS).................................................................. 60
Transmission Tow/Haul.................................... 60
Two Speed Axle................................................... 60
Wait to Start (Diesel Engine Only)................60 Water in Fuel...........................................................
61
Washer Fluid Check
.....................................201
Washers See: Cleaning the Exterior.............................. 226
See: Wipers and Washers................................. 46
Waxing..............................................................227
Wheel Nuts See: Changing a Road Wheel....................... 248
Wheels and Tires
.........................................233
Technical Specifications................................. 250
Windows and Mirrors...................................50
Windshield Washers
.....................................46
Windshield Wipers........................................46
Wiper Blades See: Checking the Wiper Blades.................205
Wipers and Washers.....................................46
379
F-650/750 (TBC) , enUSA, First Printing Index