2017 FIAT QUBO fuel filter

PROTECTING THE ENVIRONMENT
The devices for reducing petrol engine emissions are
the following:
three-way catalytic converter
Lambda sensors
anti-evaporation system.
In addition, do not let the engine run, even for a test,
with one or more spark plugs disconnected.
The following devices are used for reducing diesel
fuel engine emissions:
oxidising catalytic converter
exhaust gas recirculation system (EGR)
diesel particulate filter (DPF) (for versions/
markets, where provided).
DIESEL PARTICULATE FILTER (DPF)
(for versions/markets, where provided)
The Diesel Particulate Filter is a mechanical filter,
integral to the exhaust system, that physically traps
carbon particulates present in the exhaust gases
of diesel engines.
It is needed to eliminate almost all particulates in
compliance with current/future legislation. During
normal use of the vehicle, the engine control unit
records a set of data (e.g.: travel time, type of route,
temperatures, etc.) and it will then calculate how
much particulate has been trapped by the filter.Since this filter physically traps particulate, it should
be regenerated (cleaned) at regular intervals by
burning the carbon particles. The regeneration
procedure is controlled automatically by the engine
management control unit according to the filter
conditions and vehicle use conditions.
During regeneration, the following may occur: a
limited increase in the engine speed, activation of the
fan, a limited increase in fumes and high
temperatures at the exhaust.
These are not faults; they do not impair vehicle
performance or damage the environment. If
the dedicated message is displayed, refer to the
“Warning lights and messages” section.
96
KNOWING YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
CARE
TECHNICAL DATA
INDEX

GLOW PLUG PREHEATING/GLOW
PLUG FAULT (Multijet versions -
amber)
Glow plugs preheating
This warning light comes on when the key is turned
to MAR. It will go out as soon as the glow plugs have
reached a preset temperature.
Start the engine as soon as the warning light goes
out.
IMPORTANT When it is particularly warm outside,
the warning light stays on for an extremely short
time.
Glow plug preheating fault
The warning light flashes if there is a fault in the
preheating system. Go to a Fiat Dealership as soon
as possible.
A specific message is displayed on certain versions.
WATER IN DIESEL FUEL FILTER
(Multijet versions - amber)
When the ignition key is turned to MAR, the warning
light turns on but should go off after a few seconds.
The warning light
turns on when there is water in
the diesel fuel filter.
A specific message is displayed on certain versions.
The presence of water in the fuel supply
circuit may cause severe damage to the
injection system and irregular engine
operation. If warning light
lights up (on some
versions with the message on the display), go to a
Fiat Dealership as soon as possible to have the
system bled.Water may have entered the tank if
this appears immediately after refuelling: if this
happens, switch the engine off immediately
and contact a Fiat Dealership.
The presence of water in the fuel supply
circuit may cause severe damage to the
injection system and irregular engine
operation. If warning light
lights up (on some
versions, warning light
with the message on the
display), go to a Fiat Dealership as soon as
possible to have the system bled.Water may have
entered the tank if this appears immediately
after refuelling: if this happens, switch the engine
off immediately and contact a Fiat Dealership.
ESC SYSTEM (amber)
ESC system activation
Flashing of the warning light while driving indicates
the intervention of the ESC system.
140
KNOWING YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
CARE
TECHNICAL DATA
INDEX

Thousands of kilometres 35 70 105 140 175
Years 2 4 6 8 10
Check cleanliness of sliding side door lower guides (or every 6 months)●●●●●
Check handbrake lever travel and adjust, if necessary●●●●●
Check condition and wear of front disc brake pads and operation of pad
wear indicator●●●●●
Check rear drum brake lining condition and wear●●
Visually inspect condition of the accessory drive belt(s)●●
Check mechanical gearbox fluid●
Change engine oil and replace oil filter (versions with DPF)
(2)
Replace accessory drive belt/s(3)
Replace fuel filter cartridge(4)●●
Replace air cleaner cartridge●●●●●
Change the brake fluid
(5)
Replace the passenger compartment cleaner●●●●●
(2) The actual interval for changing the engine oil and replacing the engine oil filter depends on the vehicle usage conditions and is
signalled by the warning light or message (if present) in the instrument panel (see chapter "Warning lights and messages"). In any
case, it must never exceed 24 months. Change engine oil and filter every 12 months if the vehicle is driven mainly in towns.
(3) Areas that are not dusty: recommended maximum mileage 120,000 km. The belt must be replaced every 6 years, regardless of
distance travelled. Dusty areas and/or demanding use of the car (cold climates, town use, long periods of idling): advised maximum
mileage 60,000 km. The belt must be replaced every 4 years, regardless of distance travelled.
(4) If the vehicle runs on fuel with quality below the relevant European specification, this filter must be replaced every 35,000 km
(5) The brake fluid replacement has to be done every two years, irrespective of the mileage.
188
KNOWING YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
CARE
TECHNICAL DATA
INDEX

REGULAR CHECKS
Every 1,000 km or before long journeys, check and, if
necessary, top up the following:
engine coolant level;
brake fluid level;
windscreen washer fluid level;
tyre inflation pressure and condition;
operation of lighting system (headlamps, direction
indicators, hazard warning lights, etc.);
operation of screen wash/wipe system and
positioning/wear of windscreen/rear window
wiper blades.
Check and top up, if required, the engine oil level
every 3,000 km.
HEAVY USAGE OF THE VEHICLE
If the vehicle is used mainly under one of the
following conditions:
towing a trailer or caravan;
dusty roads;
short, repeated journeys (less than 7-8 km) at
sub-zero outside temperatures;
engine often idling or driving long distances at low
speeds or long periods of inactivity;
the following checks must be carried out more often
than indicated in the Scheduled Servicing Plan:
check front disc brake pad condition and wear;
check cleanliness of bonnet and boot locks,
cleanliness and lubrication of linkage;
visually inspect the conditions of: engine, gearbox,
transmission, pipes and hoses (exhaust/fuel
supply/brakes), rubber parts (boots/sleeves/
bushes, etc.);
check battery charge and battery fluid level
(electrolyte);
visually inspect condition of the auxiliary drive
belts;
check and, if necessary, change engine oil and
replace oil filter;
check and, if necessary, replace pollen filter;
check and, if necessary, replace air filter.
189
KNOWING YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
CARE
TECHNICAL DATA
INDEX

REFUELLING
1.4 Euro 6
Recommended fuels
and original lubricants
litres kg
Fuel tank: 45 -Unleaded petrol with
R.O.N. no lower than 95
(EN228 specifications) including a reserve of: 6/7 -
Engine cooling system: 6.64 -Mixture of distilled water
and PARAFLU UP liquid at
50%
(*)
Engine sump: - 2.1
SELENIA K P.E.
Engine sump and filter: - 2.25
Gearbox casing/differential: - 1.5TUTELA TRANSMISSION
TECHNYX
(***)
(*)When the vehicle is used in particularly harsh weather conditions, we recommend using a 60-40 mixture of PARAFLUUPand
demineralised water.
(***) 1.4 Euro 6 versions
226
KNOWING YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
CARE
TECHNICAL DATA
INDEX

1.3 16V Multijet 80 HP Euro 6 - 1.3 16V Multijet
95 HP Euro 6Recommended fuels
and original lubricants
litres kg
Fuel tank: 45 -
Diesel for motor vehicles
(EN590 Specification)
including a reserve of: 6/7 -
Engine cooling system: 7.6 -Mixture of distilled water
and PARAFLU UP liquid
at 50%
(*)
Engine sump: 3.7 3.13
SELENIA WR
FORWARD.
Engine sump and filter: 3.9 3.30
Gearbox casing/differential: 1.84 1.6TUTELA
TRANSMISSION
TECHNYX
Hydraulic power steering 0.38 0.35TUTELA
TRANSMISSION GI/E
Hydraulic brake circuit: - 0.5 TUTELA TOP 4
Windscreen and rear window
washer fluid reservoir:3.0 -Water and fluid mixture
TUTELA
PROFESSIONAL SC
35
(*)When the vehicle is used in particularly harsh weather conditions, we recommend using a 60-40 mixture of PARAFLUUPand
demineralised water.
228
KNOWING YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
CARE
TECHNICAL DATA
INDEX

Front ceiling light with map
reading lights (changing a
bulb) ............................................ 166
Front light clusters .................... 160
Front light clusters
(changing a bulb) ...................... 160
Front power socket ................... 53
Fuel (reserve warning light) ..... 139
Fuel cap ......................................... 94
Fuel consumption ...................... 233
Fuel cut-off system ..................... 95
Fuel filter (water in fuel
warning light) ............................ 140
Fuel level gauge ........................... 14
Fuel reserve warning light........ 139
Fuses (replacement) .................. 169
Gear lever.................................... 127
Gear Shift Indication ................. 145
Generic failure indication
(warning light)........................... 142
Generic failure indication
warning light.............................. 142
Glove compartment................... 52
Glow plug preheating fault
warning light.............................. 140
Glow plugs (preheating/fault
warning light) ........................... 140Glow plugs preheating
warning light.............................. 140
Handbrake (warning light) ....... 133
Handbrake lever ......................... 125
Hazard lights ................................ 51
Headlight alignment
corrector .................................... 70
Headlights
– Headlight alignment
corrector................................. 70
– Light beam direction ............ 70
Headrest
– Front ........................................ 30
– Rear .......................................... 31
Heating and ventilation ............. 36
Heating and ventilation
system; ........................................ 35
Heavy use of the vehicle .......... 189
Hill Holder (system) .................. 74
How to warm up the engine
after it has just started ........... 124
Identification data ...................... 208
Ignition switch
– Ignition .................................... 12
– Steering lock ......................... 12
In an emergency ......................... 146
Inflation pressure ....................... 221Inflation procedure .................... 154
Injection system/EOBD
engine control system
(warning light)........................... 138
Injection system/EOBD
engine control system fault
warning light.............................. 138
Installing
electrical/electronic devices ... 92
Instrument panel ......................... 4
Interior fittings ............................ 52
Interiors ....................................... 206
Isofix child restraint systems
(setup) ........................................ 109
– Arrangement possibilities
for child restraint system
on seats of vehicle ............... 111
Isofix child seat assembly
setup ........................................... 109
iTPMS ............................................ 78
Jack ................................................ 148
Jump starting ............................... 146
Keys
– Key with remote control..... 7
– Key without remote
control .................................... 7
– Ordering additional
remote controls .................... 9
KNOWING YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
CARE
TECHNICAL DATA
INDEX

Left direction indicator
warning light.............................. 145
Lifting the vehicle....................... 180
Light beam direction .................. 70
Low battery charge warning
light ............................................. 135
Low engine oil level ................... 138
Low engine oil pressure
warning light.............................. 137
Luggage Compartment.............. 59
Main beam headlights................. 42
Main beam warning light .......... 145
Maintenance and care -
regular checks........................... 189
Maintenance and care -
Scheduled Servicing ................. 183
Maintenance and care -
scheduled servicing plan......... 184
Manual climate control
system ......................................... 39
Manually deactivating the
front airbag and side bag ........ 115
MSR system.................................. 76
Multifunction display
– Control buttons .................... 16
– Setup menu............................. 17
– Standard screen ..................... 15
Number plate lights................... 165Number plate lights (bulb
replacement) ............................. 165
On-board instruments............... 13
Ordering additional remote
controls ....................................... 9
Parking .......................................... 125
Parking lights ................................ 42
Parking sensor fault warning
light ............................................. 143
Parking sensors ........................... 84
Parking sensors (warning
light) ............................................ 143
Particulate filter (DPF) .............. 96
Partition ........................................ 30
Passenger compartment
fuse box ..................................... 175
Passenger compartment
fuse box table ........................... 177
Performance................................ 223
Pollen filter .................................. 197
Power steering fluid .................. 196
Power supply............................... 212
Pre-tensioners ............................ 100
pressure restoring...................... 156
Prolonged vehicle inactivity ..... 132
Protecting the environment ..... 96
Radio.............................................. 91Radio transmitters and
mobile phones ........................... 92
Rear ceiling light ......................... 167
Rear fog lights .............................. 51
– Warning light ......................... 144
Rear fog lights (changing a
bulb) ............................................ 163
Rear fog lights warning light .... 144
Rear light clusters ...................... 163
Rear light clusters (changing
a bulb)......................................... 163
Rear side windows ..................... 54
Rear window washer ................. 45
Rear window wiper .................... 45
Rear-view mirrors
– Interior rear-view mirror..... 33
– Wing mirrors ......................... 33
Refuelling...................................... 226
Refuelling the vehicle ................. 93
Removable ceiling light ............. 168
Replacing the battery ................ 198
Replacing the rear window
wiper blade................................ 202
Replacing the windscreen
wiper blades .............................. 202
Rev counter.................................. 13
KNOWING YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
CARE
TECHNICAL DATA
INDEX