2017 DODGE VIPER battery

Cavity RelayCartridge FuseMini-Fuse Description
50 HC Micro — —Rad Fan
51 HC Micro — —Rad Fan Relay SER/PAR
52 HC Micro — —Starter Relay
53 HC Micro — —Rear Window Defroster Relay
54 HC Relay — —Rad Fan Relay High
55 HC Micro — —Wiper ON/OFF
56 HC Micro — —Wiper LO/HI
57 G8VA — —Horn Relay
58 G8VA — —A/C Clutch Relay
59 HC Micro — —HVAC Blower
60 HC Micro — —Fuel Pump
61 G8VA — —Run Relay #1
62 G8VA — —Run Relay #2
63 HC Micro — —ASD #1
64 HC Micro — —ASD #2
65 G8VA — —Run Accy #1, Pop Up, Driver Door Window Switch
66 — ——Not Used
NOTE: A 15 Amp fuse for the radio system is located
in-line at the battery positive terminal.
7
MAINTAINING YOUR VEHICLE 293

CAUTION!
•When installing the power distribution center cover,
it is important to ensure the cover is properly posi-
tioned and fully latched. Failure to do so may allow
water to get into the power distribution center and
possibly result in an electrical system failure.
• When replacing a blown fuse, it is important to use
only a fuse having the correct amperage rating. The
use of a fuse with a rating other than indicated may
result in a dangerous electrical system overload. If a
properly rated fuse continues to blow, it indicates a
problem in the circuit that must be corrected.
VEHICLE STORAGE
We recommend that you follow these guidelines for storing
your vehicle for extended periods.
• Fill the fuel tank. This will prevent water condensation
inside the tank. If you plan to store your vehicle more
than two months, add an anti-oxidant fuel stabilizer to
the fuel tank.
• Change the oil to remove any corrosive combustion
related acids in the crankcase. •
Check that the radiator coolant level of protection is to at
least -20°F (-29°C).
• Make sure that all tires are inflated to the optimum
pressure.
• Wash and wax the vehicle to protect the finish.
• Store the vehicle in a dry, well-ventilated location.
• Move the wiper blades away from the windshield.
• Block the wheels. Do not apply the parking brake.
• Cut blocks of plywood about the same size of the tires.
Cover each block with indoor/outdoor carpeting and
place them between the tires and concrete. This will
prevent tire flat spotting.
• For long-term storage, remove the tires and put the
vehicle up on blocks. Stack the tires on plywood and
cover with a tarp to prevent flat spotting.
• If the vehicle will be subjected to freezing temperatures,
either remove the battery and store it in a dry, well
ventilated area or connect a trickle charger (1.5 Amp)
with automatic shutdown / overcharge protection to the
battery. However, do not leave the trickle charger
hooked up to the battery without being plugged in to a
110 Volt AC outlet, as this will result in further drain on
294 MAINTAINING YOUR VEHICLE

the vehicle’s battery. If the vehicle is not going to be
driven in the next three weeks, perform the battery
recharge procedure in the Service Manual. Then, either
disconnect the battery at the negative terminal or use
“Hibernation Mode” to conserve battery power. Refer to
“Maintenance Procedures/Hibernation Mode” in
“Maintaining Your Vehicle” for further information.
• Cover the vehicle whenever possible to prevent acciden-
tal damage to the finish.
NOTE: Disconnecting the battery causes the engine control
system to lose memory of some “learned” functions. After
reconnecting the battery, the engine may run rough until
the control module “relearns” these functions. Using the
Battery Save Feature will prevent the engine controller
from loosing its memory.
CAUTION!
Use care when disconnecting the remote positive cable.
It is connected to the battery and can short out to any
metal on the vehicle. Always tape or wrap the exposed
cable end to prevent electrical shorts.
Check the battery every four to six weeks to ensure that the
voltage is above 12.10 Volts. The voltage will drop more rapidly in hot temperatures. If battery voltage drops below
12.10 Volts, follow the battery recharge procedure in the
Service Manual.
NOTE:
To help prevent the battery from discharging dur-
ing shorter periods of inactivity, perform the following:
1. Make sure that the liftgate, hood, doors, windows are completely closed.
2. Make sure that the key fob is operating and that the battery is good.
3. Make sure that the HOOD, LIFTGATE, and DOOR switches are in adjustment. Perform the quick system
check, which follows:
Use the key fob to set the alarm. If the alarm SET light
comes on and flashes, the system is operating properly. If
not, there is a problem with a switch or the system. See
your authorized dealer for service.
If you plan to store the vehicle longer than 30 days, we
recommend using Hibernation Mode to conserve battery
power. Refer to “Hibernation Mode” in Maintenance
Procedures for further information.
7
MAINTAINING YOUR VEHICLE 295

MAINTENANCE SCHEDULES
The Scheduled Maintenance services listed in this manual
must be done at the times or mileages specified to protect
your vehicle warranty and ensure the best vehicle perfor-
mance and reliability. More frequent maintenance may be
needed for vehicles in severe operating conditions, such as
dusty areas and very short trip driving. Inspection and
service should also be done anytime a malfunction is
suspected.
NOTE: Under no circumstances should oil change inter-
vals exceed 6,000 miles (10 000 km) or six months,
whichever comes first.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.At Each Stop For Fuel
•
Check the engine oil level about five minutes after a
fully warmed engine is shut off. Checking the oil level
while the vehicle is on level ground will improve the
accuracy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
• Check the windshield washer solvent, and add if re-
quired.
Once A Month
• Check tire pressure and look for unusual wear or
damage. Rotate tires at the first sign of irregular wear,
even if it occurs before your next scheduled service.
• Inspect the battery, and clean and tighten the terminals
as required.
• Check the fluid levels of the coolant reservoir, brake
master cylinder, power steering, and transmission, and
add as needed.
• Check all lights and all other electrical items for correct
operation.
302 MAINTENANCE SCHEDULES

Battery.............................. .120, 269
Charging System Light ....................120
Emergency Starting ...................... .256
Jump Starting .......................... .256
Key Fob Battery Replacement .................18
Keyless Key Fob Replacement ................18
Location .............................. .269
Remote Battery Replacement .................18
Saving Feature (Protection) ..................271
Storing Vehicle ......................... .271
Belts, Seat .................................67
Body Mechanism Lubrication ..................272
B-Pillar Location .......................... .215
Brake Control System, Electronic ................205
Brake, Parking ............................ .202
Brake System ......................... .203, 279
Anti-Lock (ABS) ..................... .203, 205
Fluid Check ........................ .280, 300
Master Cylinder ........................ .280
Warning Light ...........................117
Break-In Recommendations, New Vehicle ..........204
Brightness, Interior Lights .....................86
Bulb Replacement ......................... .297
Bulbs, Light ........................... .69, 296Camera, Rear
..............................95
Capacities, Antifreeze (Engine Coolant) ...........298
Capacities, Fluid .......................... .298
Caps, Filler Oil (Engine) ........................... .268
Power Steering ......................... .202
Radiator (Coolant Pressure) .................278
Carbon Monoxide Warning .................66, 238
Car Washes .............................. .282
Chains, Tire ............................. .228
Chart, Tire Sizing ...........................211
Check Engine Light (Malfunction Indicator Light). . . .265
Checking Your Vehicle For Safety ................66
Checks, Safety .............................66
Child Restraint .............................
55
Child Restraints Booster Seats ............................58
Child Restraints ..........................55
Child Seat Installation ......................61
Infants And Child Restraints .................57
Older Children And Child Restraints ...........57
Using The Top Tether Anchorage ..............62
Clean Air Gasoline ........................ .235
Cleaning Wheels ............................... .283
10
INDEX 315

Inside Rearview Mirror.......................73
Instrument Cluster .............114,115,119, 122, 129
Instrument Cluster Display Instrument Cluster Display ..................131
Instrument Panel And Controls .................113
Instrument Panel Lens Cleaning ................286
Interior Appearance Care .....................284
Interior Lights ..............................86
Intermittent Wipers (Delay Wipers) ...............88
Introduction ................................4
Jump Starting ............................ .256
KeyFob...................................9 Programming Additional Key Fobs .............13
Remote Battery Replacement .................18
Key Fob Battery Service (Remote Keyless Entry) .....18
Key Fob Programming (Remote Keyless Entry) ......18
Key Fob, Remote Keyless Entry .................16
Key-In Reminder ............................11
Keyless Entry System .......................9,16
Keyless Go .................................9
Key, Replacement ...........................13
Key, Sentry (Immobilizer) ......................12 Lane Change And Turn Signals
.................85
Lap/Shoulder Belts ..........................28
Latches ..................................69
Hood ..................................81
Lead Free Gasoline ........................ .235
Leaks, Fluid ...............................69
Life Of Tires ............................. .227
Liftgate ..................................24
Light Bulbs ................................69
Lights ................................ .69, 83
AirBag...........................36, 67, 117
Anti-Lock ............................. .206
Automatic Headlights ......................84
Brake Warning ..........................117
Bulb Replacement .....................296, 297
Cruise ............................... .130
Daytime Running .........................85
Dimmer Switch, Headlight ................85, 86
Engine Temperature Warning ................119
Exterior ................................69
Hazard Warning Flasher ...................246
Headlights ..............................83
Headlights On Reminder ....................85
Headlights On With Wipers ...............84,
89
Headlight Switch .........................83
10
INDEX 319

High Beam..............................86
High Beam/Low Beam Select .................86
Illuminated Entry .........................16
Instrument Cluster ........................83
Intensity Control ..........................86
Interior ................................86
Lights On Reminder .......................85
Low Fuel ............................. .128
Malfunction Indicator (Check Engine) ..........123
Parade Mode (Daytime Brightness) .............87
Park ................................. .129
Passing ................................86
Seat Belt Reminder .......................116
Security Alarm ..........................119
Service ............................ .296, 297
Tire Pressure Monitoring (TPMS) ..........126, 231
Turn Signal ....................... .69, 85, 129
Vanity Mirror ............................76
Warning (Instrument Cluster Description) ....119,129
Loading Vehicle Tires................................. .215
Locks ....................................20
Automatic Door ..........................21
Auto Unlock .............................21
Door ..................................20 Power Door
.............................20
Low Tire Indicator ......................... .231
Low Tire Pressure System .....................231
Lubrication, Body ......................... .272
Lug Nuts ............................... .247
Maintenance Free Battery .....................269
Maintenance Procedures ..................... .267
Maintenance Schedule ................301, 302, 303
Malfunction Indicator Light (Check Engine) . . . .123, 265
Manual, Service ............................311
Manual Transmission ....................192, 282
Fluid Level Check .....................281, 300
Lubricant Selection ...................... .300
Shift Speeds ........................... .195
Methanol ............................... .235
Mirrors ..................................73
Electric Remote ...........................76
Outside ............................. .75,
76
Rearview ...............................73
Vanity .................................76
Modifications/Alterations, Vehicle ................6
Monitor, Tire Pressure System ..................231
MOPAR Parts ......................... .266, 310
MTBE/ETBE ............................. .235
320 INDEX

Radial Ply Tires........................... .222
Radiator Cap (Coolant Pressure Cap) .............278
Radio Antenna ........................... .160
Radio Frequency General Information ..................12, 13, 19
Radio Operation .......................... .160
Radio (Sound Systems) ..................... .158
Rear Camera ...............................95
Rear Liftgate ...............................24
Rear Window Defroster ......................110
Rear Window Features .......................110
Reclining Front Seats .........................78
Recreational Towing ........................ .242
Reformulated Gasoline ...................... .235
Refrigerant .............................. .272
Reminder, Lights On .........................85
Reminder, Seat Belt ..........................27
Remote Keyless Entry ........................16
Key Fob Battery Replacement .................18
Programming Additional Key Fobs .............13
Remote Battery Replacement .................18
Remote Sound System (Radio) Controls ...........159
Replacement Keys ...........................13
Replacement Parts ......................... .266
Replacement Tires ......................... .227Reporting Safety Defects
......................311
Restraint, Head .............................81
Restraints, Child ............................55
Rocking Vehicle When Stuck ...................259
Rotation, Tires ............................ .229
Safety Checks Inside Vehicle ...................67
Safety Checks Outside Vehicle ..................69
Safety Defects, Reporting .....................311
Safety, Exhaust Gas ..........................66
Safety Information, Tire ..................... .210
Safety Tips ................................66
Schedule, Maintenance ...................301, 302
Seat Belt Automatic Locking Retractor (ALR) ............34
Energy Management Feature .................33
Lap/Shoulder Belt Operation .................30
Lap/Shoulder Belts ........................28
Lap/Shoulder Belt Untwisting ................32
Pregnant Women .........................33
Seat

Belt Extender .........................32
Seat Belt Pretensioner ......................33
Seat Belt Reminder ........................27
Seat Belt Maintenance ...................... .286
Seat Belt Reminder ..........................27
322 INDEX