2017 CHEVROLET VOLT engine overheat

Chevrolet VOLT Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9807421) - 2017 - CRC - 11/18/15
Vehicle Care 253
Caution
If the pressure cap is not tightly
installed, coolant loss and
possible engine damage may
occur. Be sure the cap is properly
and tightly secured.
Engine Overheating
The vehicle has an indicator to warn
of engine overheating.
If the decision is made not to lift the
hood when this warning appears,
get service help right away. See
Roadside Assistance
Program0345.
If the decision is made to lift the
hood, make sure the vehicle is
parked on a level surface.
Then check to see if the engine
cooling fan is running. If the engine
is overheating, the fan should be
running. If it is not, do not continue
to run the vehicle, and have the
vehicle serviced.
Caution
Running the engine without
coolant may cause damage or a
fire. Vehicle damage would not be
covered by the vehicle warranty.
Washer Fluid
What to Use
When adding windshield washer
fluid to the vehicle, be sure to read
the manufacturer's instructions
before use. If operating the vehicle
in an area where the temperature
may fall below freezing, use a fluid
that has sufficient protection against
freezing.
Adding Washer Fluid
Open the cap with the washer
symbol on it. Add washer fluid until
the tank is full. See Engine
Compartment Overview 0242 for
reservoir location.
Caution
. Do not use washer fluid that
contains any type of water
repellent coating. This can
cause the wiper blades to
chatter or skip.
. Do not use engine coolant
(antifreeze) in the
windshield washer. It can
damage the windshield
washer system and paint.
. Do not mix water with
ready-to-use washer fluid.
Water can cause the
solution to freeze and
damage the washer fluid
tank and other parts of the
washer system.
(Continued)

Chevrolet VOLT Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9807421) - 2017 - CRC - 11/18/15
Vehicle Care 263
When the current electrical load is
too heavy, the circuit breaker opens
and closes, protecting the circuit
until the current load returns to
normal or the problem is fixed. This
greatly reduces the chance of circuit
overload and fire caused by
electrical problems.
Fuses and circuit breakers protect
the following in the vehicle:
.Headlamp Wiring
. Windshield Wiper Motor
. Power Windows and other
Power Accessories
Replace a bad fuse with a new one
of the identical size and rating.
If there is a problem on the road and
a fuse needs to be replaced, the
same amperage fuse can be
borrowed. Choose some feature of
the vehicle that is not needed to use
and replace it as soon as possible.
Headlamp Wiring
An electrical overload may cause
the lamps to go on and off, or in
some cases to remain off. Have the headlamp wiring checked right away
if the lamps go on and off or
remain off.
Windshield Wipers
If the wiper motor overheats due to
heavy snow or ice, the windshield
wipers will stop until the motor cools
and the wiper control is turned off.
After removal of the blockage, the
wiper motor will restart when the
control is then moved to the desired
operating position.
Although the circuit is protected
from electrical overload, overload
due to heavy snow or ice, may
cause wiper damage. Always clear
ice and heavy snow from the
windshield before using the
windshield wipers.
If the overload is caused by an
electrical problem and not snow or
ice, be sure to get it fixed.
Engine Compartment
Fuse Block
To open the fuse block cover, press
the clips at the side and back and
pull the cover up.
Caution
Spilling liquid on any electrical
component on the vehicle may
damage it. Always keep the
covers on any electrical
component.

Chevrolet VOLT Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9807421) - 2017 - CRC - 11/18/15
Vehicle Care 271
A fuse puller is in the engine
compartment fuse block.
The vehicle may not have all of the
fuses, relays, and features shown.Fuses Usage
F1 –
F2 –
F3 –
F4 –
F5 Pedestrian protection
F6 On-board charger module
F7 Front heated seat
F8 Front heated seat
F9 Driver door/Mirror switches
F10 –
F11 Amplifier
F12 Steering wheel switch backlighting
F13 –
F14 – Fuses Usage
F15 –
F16 –
F17 –
F18 –
F19 Obstacle detection
F20 Fuel
F21 Rear heated seat
F22 Right power windows
Relays Usage K1 –
K2 –
K3 –
K4 –
K5 –Wheels and Tires
Tires
Every new GM vehicle has
high-quality tires made by a
leading tire manufacturer. See
the warranty manual for
information regarding the tire
warranty and where to get
service. For additional
information refer to the tire
manufacturer.
{Warning
.Poorly maintained and
improperly used tires are
dangerous.
.Overloading the tires can
cause overheating as a
result of too much
flexing. There could be a
blowout and a serious
crash. See Vehicle Load
Limits 0171.
(Continued)

Chevrolet VOLT Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9807421) - 2017 - CRC - 11/18/15
368 Index
Electric Parking Brake . . . . . . . . . . 188
Electric Parking Brake Light . . . . 111
Electrical Equipment,Add-On . . . . . . . . . . . . . . . . . . . . . . . 234
Electrical Requirements for Battery Charging . . . . . . . . . . . . . . 229
Electrical System
Engine Compartment FuseBlock . . . . . . . . . . . . . . . . . . . . . . . . 263
Instrument Panel Fuse Block . . . . . . . . . . . . . . . . . . . . . . . . 266
Overload . . . . . . . . . . . . . . . . . . . . . 262
Rear Compartment Fuse Block . . . . . . . . . . . . . . . . . . . . . . . . 269
Emergency OnStar
®. . . . . . . . . . . . . . . . . . . . . . 356
Energy Efficiency Driving . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Energy Information . . . . . . . . . . . . . 128
Engine Air Cleaner/Filter . . . . . . . . . . . . . 246
Check and Service Engine
Soon Light . . . . . . . . . . . . . . . . . . 109
Compartment Overview . . . . . . . 242
Coolant . . . . . . . . . . . . . . . . . . . . . . . 250
Coolant Temperature Warning Light . . . . . . . . . . . . . . . .114
Cooling System . . . . . . . . . . 248, 249 Engine (cont'd)
Cooling System Messages . . . 134
Drive Belt Routing . . . . . . . . . . . . 340
Exhaust . . . . . . . . . . . . . . . . . . . . . . 185
Oil Life System . . . . . . . . . . . . . . . 245
Oil Messages . . . . . . . . . . . . . . . . . 134
Oil Pressure Light . . . . . . . . . . . . .115
Overheating . . . . . . . . . . . . . . . . . . 253
Running While Parked . . . . . . . . 186
Engine Unavailable Out of Fuel . . . . . . . . . . . . . . . . . . . 183
Entry Lighting . . . . . . . . . . . . . . . . . . . 155
Event Data Recorders . . . . . . . . . . 353
Exit Lighting . . . . . . . . . . . . . . . . . . . . 155
Extended Range Mode . . . . . . . . . 180
Extender, Safety Belt . . . . . . . . . . . . 62
Exterior Lamp Controls . . . . . . . . . 149
F
Filter, Engine Air Cleaner . . . . . . . . . . . 246
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 151
Flashers, Hazard Warning . . . . . . 152
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . 291 Changing . . . . . . . . . . . . . . . . . . . . . 299
Floor Mats . . . . . . . . . . . . . . . . . . . . . . 322
Fluid Brakes . . . . . . . . . . . . . . . . . . . . . . . . 254
Washer . . . . . . . . . . . . . . . . . . . . . . . 253 Folding Mirrors . . . . . . . . . . . . . . . . . . 46
Forward Automatic Braking . . . . . 210
Forward Collision Alert
(FCA) System . . . . . . . . . . . . . . . . . 208
Frequency Statement Radio . . . . . . . . . . . . . . . . . . . . . . . . . 351
Front Seats
Adjustment . . . . . . . . . . . . . . . . . . . . . 52
Heated . . . . . . . . . . . . . . . . . . . . . . . . . 54
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 230 Additives . . . . . . . . . . . . . . . . . . . . . 231
Filling a Portable Fuel
Container . . . . . . . . . . . . . . . . . . . 233
Filling the Tank . . . . . . . . . . . . . . . 231
Foreign Countries . . . . . . . . . . . . 231
Gauge . . . . . . . . . . . . . . . . . . . . . . . . 105
Low Fuel Warning Light . . . . . . . .116
Requirements, California . . . . . 230
System Messages . . . . . . . . . . . . 135
Function Check Electric Drive Unit Shift
Lock Control . . . . . . . . . . . . . . . . 258
Fuses Engine Compartment FuseBlock . . . . . . . . . . . . . . . . . . . . . . . . 263
Instrument Panel Fuse Block . . . . . . . . . . . . . . . . . . . . . . . . 266

Chevrolet VOLT Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9807421) - 2017 - CRC - 11/18/15
Index 371
Messages (cont'd)Compass . . . . . . . . . . . . . . . . . . . . . 133
Door Ajar . . . . . . . . . . . . . . . . . . . . . 133
Electric Drive Unit . . . . . . . . . . . . 134
Engine Cooling System . . . . . . . 134
Engine Oil . . . . . . . . . . . . . . . . . . . . 134
Fuel System . . . . . . . . . . . . . . . . . . 135
Key and Lock . . . . . . . . . . . . . . . . . 135
Lamp . . . . . . . . . . . . . . . . . . . . . . . . . 136
Object Detection System . . . . . 136
Propulsion Power . . . . . . . . . . . . . 138
Ride Control System . . . . . . . . . . 138
Security . . . . . . . . . . . . . . . . . . . . . . 139
Service Vehicle . . . . . . . . . . . . . . . 139
Starting the Vehicle . . . . . . . . . . . 140
Tire . . . . . . . . . . . . . . . . . . . . . . . . . . . 140
Vehicle . . . . . . . . . . . . . . . . . . . . . . . 132
Vehicle Reminder . . . . . . . . . . . . . 140
Vehicle Speed . . . . . . . . . . . . . . . . 140
Mirrors Automatic DimmingRearview . . . . . . . . . . . . . . . . . . . . . . 46
Convex . . . . . . . . . . . . . . . . . . . . . . . . . 45
Folding . . . . . . . . . . . . . . . . . . . . . . . . . 46
Heated . . . . . . . . . . . . . . . . . . . . . . . . . 46
Manual Rearview . . . . . . . . . . . . . . . 46
Power . . . . . . . . . . . . . . . . . . . . . . . . . . 46
Mirrors, Interior Rearview . . . . . . . . 46 Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . 193
Driver Control . . . . . . . . . . . . . . . . . 193
Electric . . . . . . . . . . . . . . . . . . . . . . . 180
Extended Range . . . . . . . . . . . . . . 180
Hold Light . . . . . . . . . . . . . . . . . . . . .113
Modes Driver Selected . . . . . . . . . . . . . . . 181
Maintenance . . . . . . . . . . . . . . . . . . 183
Monitor System, Tire Pressure . . . . . . . . . . . . . . . . . . . . . . 280
Mountain Mode Light . . . . . . . . . . . 113
N
Navigation
OnStar®. . . . . . . . . . . . . . . . . . . . . . 357
New Vehicle Break-In . . . . . . . . . . . 175
O
Object Detection System Messages . . . . . . . . . . . . . . . . . . . . . 136
Odometer . . . . . . . . . . . . . . . . . . . . . . . 105 Trip . . . . . . . . . . . . . . . . . . . . . . . . . . . 105
Off-Road Recovery . . . . . . . . . . . . . . . . . . . . . 167
Oil Engine . . . . . . . . . . . . . . . . . . . . . . . . 243
Engine Oil Life System . . . . . . . 245
Messages . . . . . . . . . . . . . . . . . . . . 134
Pressure Light . . . . . . . . . . . . . . . . .115 Older Children, Restraints . . . . . . . 75
Online Owner Center . . . . . . . . . . . 344
OnStar . . . . . . . . . . . . . . . . . . . . . . . . . 354
OnStar
®Additional
Information . . . . . . . . . . . . . . . . . . . . 360
OnStar
®Connections . . . . . . . . . . . 357
OnStar®Diagnostics . . . . . . . . . . . . 359
OnStar®Emergency . . . . . . . . . . . . 356
OnStar®Navigation . . . . . . . . . . . . . 357
OnStar®Overview . . . . . . . . . . . . . . 355
OnStar®Security . . . . . . . . . . . . . . . 356
Ordering Service Publications . . . . . . . . . . 350
Out of Fuel/Engine Unavailable . . . . . . . . . . . . . . . . . . . 183
Outlets
Power . . . . . . . . . . . . . . . . . . . . . . . . . . 99
Overheating, Engine . . . . . . . . . . . . 253
P
Park Shifting Into . . . . . . . . . . . . . . . . . . . 177
Shifting Out of . . . . . . . . . . . . . . . . 178
Parking Brake and P (Park)Mechanism Check . . . . . . . . . . 258
Over Things That Burn . . . . . . . 179
Parking Assist . . . . . . . . . . . . . . . . . . 204