2017 CHEVROLET CITY EXPRESS seats

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9967827) - 2017 - crc - 9/26/16
Instruments and Controls 91
2. Find the vehicle's currentlocation and variance zone
number on the map.
Zones 1 through 15 are
available.
3. Press
Vto scroll through and
select the appropriate
variance zone.
4. Press
3until the vehicle
heading, for example, N for
North, is displayed in the DIC.
5. If calibration is necessary, calibrate the compass. See
“Compass Calibration
Procedure” following.
Compass Calibration
The compass can be manually
calibrated. Only calibrate the
compass in a magnetically clean
and safe location, such as an open
parking lot, where driving the
vehicle in circles is not a danger.
It is suggested to calibrate away
from tall buildings, utility wires,
manhole covers, or other industrial
structures, if possible. If CAL should ever appear in the
DIC display, the compass should be
calibrated.
If the DIC display does not show a
heading, for example, N for North,
or the heading does not change
after making turns, there may be a
strong magnetic field interfering with
the compass. Such interference
may be caused by a magnetic CB or
cell phone antenna mount, a
magnetic emergency light, magnetic
note pad holder, or any other
magnetic item. Turn off the vehicle,
move the magnetic item, then turn
on the vehicle and calibrate the
compass.
To calibrate the compass, use the
following procedure:
Compass Calibration Procedure
1. Before calibrating the compass, make sure the compass zone
is set to the variance zone in
which the vehicle is located.
See “Compass Variance (Zone)
Procedure” earlier in this
section. Do not operate any switches
such as window, climate
controls, seats, etc. during the
calibration procedure.
2. Press
Tuntil PRESSVTO
CALIBRATE COMPASS
displays.
3. Press
Vto start the compass
calibration.
4. The DIC will display CALIBRATING: DRIVE IN
CIRCLES. Drive the vehicle in
tight circles at less than 8 km/h
(5 mph) to complete the
calibration. The DIC will display
CALIBRATION COMPLETE for
a few seconds when the
calibration is complete. The
DIC display will then return to
PRESS
VTO CALIBRATE
COMPASS.

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9967827) - 2017 - crc - 9/26/16
130 Lighting
Reading Lamps
If equipped with reading lamps,
press the button next to each lamp
to turn it on or off.
The vehicle may also have reading
lamps in other locations. The lamps
cannot be adjusted.
Lighting Features
Entry/Exit Lighting
The vehicle has an illuminated
entry/exit feature.
The dome lamps come on if the
E
DOME OFF button is in the
extended position, when a door is
opened, or the key is removed from
the ignition.
Battery Load
Management
The vehicle may have Electric
Power Management (EPM) that
estimates the battery's temperature
and state of charge. It then adjusts
the voltage for best performance
and extended life of the battery.
When the battery's state of charge
is low, the voltage is raised slightly
to quickly bring the charge back up.
When the state of charge is high,
the voltage is lowered slightly to
prevent overcharging. If the vehicle
has a voltmeter gauge or a voltage
display on the Driver InformationCenter (DIC), you may see the
voltage move up or down. This is
normal. If there is a problem, an
alert will be displayed.
The battery can be discharged at
idle if the electrical loads are very
high. This is true for all vehicles.
This is because the generator
(alternator) may not be spinning fast
enough at idle to produce all the
power that is needed for very high
electrical loads.
A high electrical load occurs when
several of the following are on, such
as: headlamps, high beams, fog
lamps, rear window defogger,
climate control fan at high speed,
heated seats, engine cooling fans,
trailer loads, and loads plugged into
accessory power outlets.
EPM works to prevent excessive
discharge of the battery. It does this
by balancing the generator's output
and the vehicle's electrical needs.
It can increase engine idle speed to
generate more power, whenever
needed. It can temporarily reduce
the power demands of some
accessories.

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9967827) - 2017 - crc - 9/26/16
Climate Controls 163
Be sure to keep the area under the
front seats clear of any objects so
that the air inside of the vehicle can
circulate effectively.
For information on how to use the
main climate control system, see
Climate Control Systems0158. For
information on ventilation, see Air
Vents 0163.Air Vents
Use the outlets located near the
center and on the sides of the
instrument panel to change the
direction of airflow.
Operation Tips
.
Clear away any ice, snow or
leaves from the air inlets at the
base of the windshield that may
block the flow of air into the
vehicle.
. Use of non-GM approved hood
deflectors may adversely affect
the performance of the system.
. Keep the path under the front
seats clear of objects to help
circulate the air inside of the
vehicle more effectively.
Maintenance
Service
All vehicles have a label underhood
that identifies the refrigerant used in
the vehicle. The refrigerant system
should only be serviced by trained
and certified technicians. The air
conditioning evaporator should
never be repaired or replaced by
one from a salvage vehicle.
It should only be replaced by a new
evaporator to ensure proper and
safe operation.
During service, all refrigerants
should be reclaimed with proper
equipment. Venting refrigerants
directly to the atmosphere is harmful
to the environment and may also
create unsafe conditions based on
inhalation, combustion, frostbite,
or other health-based concerns.

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9967827) - 2017 - crc - 9/26/16
174 Driving and Operating
weight of the driver, passengers,
and cargo should never exceed
the vehicle capacity weight.
Certification/Tire Label
A vehicle specific Certification/
Tire label is attached to the rear
edge of the driver door. The
label may show the size of the
vehicle's original tires and the
inflation pressures needed to
obtain the gross weight capacity
of the vehicle. This is called
Gross Vehicle Weight Rating(GVWR). The GVWR includes
the weight of the vehicle, all
occupants, fuel, and cargo.
The Certification/Tire label also
may show the maximum weights
for the front and rear axles,
called Gross Axle Weight Rating
(GAWR). To find out the actual
loads on the front and rear
axles, you need to go to a weigh
station and weigh the vehicle.
Your dealer can help you with
this. Be sure to spread out the
load equally on both sides of the
centerline.{Warning
Things you put inside the
vehicle can strike and injure
people in a sudden stop or
turn, or in a crash.
.Put things in the cargo
area of the vehicle. Try to
spread the weight evenly.
(Continued)
Warning (Continued)
.Never stack heavier
things, like suitcases,
inside the vehicle so that
some of them are above
the tops of the seats.
.Do not leave an
unsecured child restraint
in the vehicle.
.When you carry
something inside the
vehicle, secure it
whenever you can.
.Do not leave a seat
folded down unless you
need to.
Add-On Equipment
When carrying removable items,
a limit on how many people
carried inside the vehicle may
be necessary. Be sure to weigh
the vehicle before buying and
installing the new equipment.

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9967827) - 2017 - crc - 9/26/16
Vehicle Care 251
Mini-Fuse UsageF12 –
F13 HVAC 2
F14 HVAC 1
F15 –
F16 Upfitter 1 (if equipped)
F17 Exterior rearview heated mirrors
F18 Rear window defogger
F19 Compass
F20 Radio/Chime/ SiriusXM satellite
radio (if equipped)
F21 Remote function actuator/Tire
pressure monitor
F22 Ignition switch/ Discrete logic
ignition
sensor (PK3)
F23 Instrument cluster
F24 – Mini-Fuse Usage
F25 HVAC
F26 Auxiliary/Trailer reverse lamps
F27 Reverse lamps
F28 Upfitter 2/Reading lamps (if equipped)
F29 Rear blower
F30 Upfitter/Courtesy lamps
F31 Front door lock
F32 Rear door lock
F33 Cargo door unlock
F34 Passenger door unlock
F35 Rear passenger door unlock
F36 Driver door lock
F37 –
F38 – Relays Usage
K1 Run
K2 –
K3 Parking lamps
K4 Upfitter 2
K5 Rear defogger
K6 Retained accessory power
CB1 Power seats
CB2 Power windows

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9967827) - 2017 - crc - 9/26/16
Vehicle Care 257
Light Truck (LT-Metric) Tire
(1) Light Truck (LT-Metric)
Tire
:The United States version
of a metric tire sizing system.
The letters LT as the first two
characters in the tire size mean
a light truck tire engineered to
standards set by the U.S. Tire
and Rim Association.
(2) Tire Width
:The three-digit
number indicates the tire section
width in millimeters from
sidewall to sidewall.
(3) Aspect Ratio
:A two-digit
number that indicates the tire
height-to-width measurements.
For example, if the tire size
aspect ratio is 75, as shown in
item 3 of the light truck
(LT-Metric) tire illustration, it would mean that the tire's
sidewall is 75 percent as high as
it is wide.
(4) Construction Code
:A letter
code is used to indicate the type
of ply construction in the tire.
The letter R means radial ply
construction; the letter D means
diagonal or bias ply
construction; and the letter B
means belted-bias ply
construction.
(5) Rim Diameter
:Diameter of
the wheel in inches.
(6) Load Range
:Load Range.
(7) Service Description
:The
service description indicates the
load index and speed rating of a
tire. If two numbers are given as
in the example, 120/116, then
this represents the load index for
single versus dual wheel usage
(single/dual). The speed rating is
the maximum speed a tire is
certified to carry a load. This
does not apply to Goodyear LT225/75R16 G949 RSA and
Goodyear LT225/75R16 G933
RSD commercial truck tires; see
the dual tire and single tire
maximum load and load range
letter designations on the tire
sidewall.
Tire Terminology and
Definitions
Air Pressure:The amount of
air inside the tire pressing
outward on each square inch of
the tire. Air pressure is
expressed in kPa (kilopascal)
or psi (pounds per square inch).
Accessory Weight
:The
combined weight of optional
accessories. Some examples of
optional accessories are
automatic transmission, power
windows, power seats, and air
conditioning.
Aspect Ratio
:The relationship
of a tire's height to its width.

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9967827) - 2017 - crc - 9/26/16
340 Index
E
E85 or FlexFuel . . . . . . . . . . . . . . . . 199
Electrical Equipment,Add-On . . . . . . . . . . . . . . . . . . . . . . . 212
Electrical System
Engine Compartment FuseBlock . . . . . . . . . . . . . . . . . . . . . . . . 246
Floor Console Fuse Block . . . . 250
Fuses and Circuit Breakers . . . 246
Overload . . . . . . . . . . . . . . . . . . . . . 245
Emergency OnStar
®. . . . . . . . . . . . . . . . . . . . . . 328
Engine Air Cleaner/Filter . . . . . . . . . . . . . 225
Check and Service Engine
Soon Light . . . . . . . . . . . . . . . . . . 102
Compartment Overview . . . . . . . 218
Coolant . . . . . . . . . . . . . . . . . . . . . . . 227
Coolant Heater . . . . . . . . . . . . . . . 179
Coolant Temperature Gauge . . . . 98
Cooling System . . . . . . . . . . . . . . . 226
Cooling System Messages . . . .113
Drive Belt Routing . . . . . . . . . . . . 312
Exhaust . . . . . . . . . . . . . . . . . . . . . . 182
Fan . . . . . . . . . . . . . . . . . . . . . . . . . . . 232
Oil Life System . . . . . . . . . . . . . . . 221
Oil Messages . . . . . . . . . . . . . . . . . .114
Oil Pressure Gauge . . . . . . . . . . . . 97 Engine (cont'd)
Oil Pressure Light . . . . . . . . . . . . 106
Overheating . . . . . . . . . . . . . . . . . . 230
Power Messages . . . . . . . . . . . . . .114
Running While Parked . . . . . . . . 183
Starting . . . . . . . . . . . . . . . . . . . . . . . 177
Enhanced Technology Glass . . . . 38
Entry/Exit Lighting . . . . . . . . . . . . . . 130
Equipment, Towing . . . . . . . . . . . . . 210
Event Data Recorders . . . . . . . . . . 325
Extender, Safety Belt . . . . . . . . . . . . 53
Exterior Lamp Controls . . . . . . . . . 125
Exterior Lamps Off Reminder . . . 126
F
Fan Engine . . . . . . . . . . . . . . . . . . . . . . . . 232
Fast Idle System . . . . . . . . . . . . . . . . 178
Filter, Engine Air Cleaner . . . . . . . . . . . 225
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 126
Flashers, Hazard Warning . . . . . . 128
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . 273 Changing . . . . . . . . . . . . . . . . . . . . . 274
FlexFuel E85 . . . . . . . . . . . . . . . . . . . . . . . . . . . 199
Floor Mats . . . . . . . . . . . . . . . . . . . . . . 296
Fluid Automatic Transmission . . . . . . 222 Fluid (cont'd)
Brakes . . . . . . . . . . . . . . . . . . . . . . . . 234
Power Steering . . . . . . . . . . . . . . . 232
Washer . . . . . . . . . . . . . . . . . . . . . . . 233
Frequency Statement Radio . . . . . . . . . . . . . . . . . . . . . . . . . 323
Front Seats Adjustment . . . . . . . . . . . . . . . . . . . . . 41
Front Storage . . . . . . . . . . . . . . . . . . . . 85
Front Turn Signal
Bulb Replacement . . . . . . . . . . . . 242
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 198 Additives . . . . . . . . . . . . . . . . . . . . . 199
Economy Driving . . . . . . . . . . . . . . . 22
Filling a Portable FuelContainer . . . . . . . . . . . . . . . . . . . 202
Filling the Tank . . . . . . . . . . . . . . . 200
Foreign Countries . . . . . . . . . . . . 199
Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . 96
Low Fuel Warning Light . . . . . . . 107
Requirements, California . . . . . 199
System Messages . . . . . . . . . . . . .115
Full-Size Spare Tire . . . . . . . . . . . . 282
Fuses
Engine Compartment FuseBlock . . . . . . . . . . . . . . . . . . . . . . . . 246
Floor Console Fuse Block . . . . 250
Fuses and Circuit Breakers . . . 246

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9967827) - 2017 - crc - 9/26/16
344 Index
R
Radio Frequency Statement . . . . 323
Radio Reception . . . . . . . . . . . . . . . . 140
RadiosAM-FM Radio . . . . . . . . . . . . . . . . . 138
Satellite . . . . . . . . . . . . . . . . . . . . . . . 139
Reading Lamps . . . . . . . . . . . . . . . . . 130
Rear Axle . . . . . . . . . . . . . . . . . . . . . . . 236 Locking . . . . . . . . . . . . . . . . . . . . . . . 191
Rear Climate Control System . . . 160
Rear Doors . . . . . . . . . . . . . . . . . . . . . . 32
Rear Heating System . . . . . . . . . . . 160
Rear Seats . . . . . . . . . . . . . . . . . . . . . . 43
Rear Vision Camera (RVC) . . . . . 194
Rearview Mirrors . . . . . . . . . . . . . . . . 36
Reclining Seatbacks . . . . . . . . . . . . . 42
Recommended Fluids and
Lubricants . . . . . . . . . . . . . . . . . . . . . 306
Records
Maintenance . . . . . . . . . . . . . . . . . . 308
Recreational Vehicle Towing . . . . 286
Reimbursement Program, GM Mobility . . . . . . . . . . . . . . . . . . . 317
Remote Keyless Entry (RKE)
System . . . . . . . . . . . . . . . . . . . . . . . . . 25
Remote Vehicle Start . . . . . . . . . . . . 27
Replacement Bulbs . . . . . . . . . . . . . 245 Replacement Parts
Airbags . . . . . . . . . . . . . . . . . . . . . . . . . 66
Maintenance . . . . . . . . . . . . . . . . . . 307
Replacing Airbag System . . . . . . . . 66
Replacing LATCH System Parts after a Crash . . . . . . . . . . . . . 79
Replacing Safety Belt System
Parts after a Crash . . . . . . . . . . . . . 54
Reporting Safety Defects Canadian Government . . . . . . . . 324
General Motors . . . . . . . . . . . . . . . 324
U.S. Government . . . . . . . . . . . . . 323
Restraints Where to Put . . . . . . . . . . . . . . . . . . . 72
Retained Accessory Power (RAP) . . . . . . . . . . . . . . . . . . 179
Ride Control Systems Messages . . . . . . . . . . . . . . . . . . . . .116
Roads Driving, Wet . . . . . . . . . . . . . . . . . . 168
Roadside Assistance
Program . . . . . . . . . . . . . . . . . . . . . . . 317
Rotation, Tires . . . . . . . . . . . . . . . . . . 265
Routing, Engine Drive Belt . . . . . . 312
Running the Vehicle While Parked . . . . . . . . . . . . . . . . . . . . . . . . 183
S
Safety Belts . . . . . . . . . . . . . . . . . . . . . 46Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54
Extender . . . . . . . . . . . . . . . . . . . . . . . . 53
How to Wear Safety BeltsProperly . . . . . . . . . . . . . . . . . . . . . . . 47
Lap-Shoulder Belt . . . . . . . . . . . . . . 48
Reminders . . . . . . . . . . . . . . . . . . . . . . 99
Replacing after a Crash . . . . . . . . 54
Use During Pregnancy . . . . . . . . . . 53
Safety Defects Reporting Canadian Government . . . . . . . . 324
General Motors . . . . . . . . . . . . . . . 324
U.S. Government . . . . . . . . . . . . . 323
Safety Locks . . . . . . . . . . . . . . . . . . . . . 30
Safety System Check . . . . . . . . . . . . 54
Satellite Radio . . . . . . . . . . . . . . . . . . 139
Scheduling Appointments . . . . . . . 319
Seats Adjustment, Front . . . . . . . . . . . . . . . 41
Head Restraints . . . . . . . . . . . . . . . . 41
Power Adjustment, Front . . . . . . . 41
Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
Reclining Seatbacks . . . . . . . . . . . . 42
Securing Child Restraints . . . . 80, 82
Security Light . . . . . . . . . . . . . . . . . . . . . . . . . . 107
Messages . . . . . . . . . . . . . . . . . . . . .117