2017 AUDI A4 check engine

This message appears when there is only enough
Ad Blue left to drive the distance indicated in the i nstr ument cluster . Fill the Ad Blue. Otherwise
the eng ine will not start aga in if you stop it once
the distance indicated has been dr iven .
• Refill with at least x qt (l) AdBlue. Engine
start not po ssible . S ee owner 's m anual
This message appears when the AdBlue ta nk is
empty. Fill the AdB lue . Otherwise you will not be
ab le to start the engine agai n once yo u stop it.
The AdBl ue m ust be refilled when the amoun t in
the tank has reached the minimum level
c::> page 301, Preparation .
Incorrect filling/system malfunction
A message appears if the Ad Blue tank was filled
with a f luid other than Ad Bl ue and the system
h as detec ted that the t ank was fi lled incor rect ly,
or if there is a system malfunc tion .
II Ad Blue: malfunct ion! No engine start in
x mi (km ). See owner's manual
This message appears when it is only poss ible to
drive the d istance indicated in the instrumen t
cluster . Drive to the nearest authorized A udi
deale r or autho riz ed Aud i Serv ice Facility to have
the m alfunction co rrected. Otherwise the engine
w ill no t start aga in if you stop it once the d is­
tance indicated has been driven .
• Ad Blue : malfun ction! No engin e start poss i­
ble. See owner' s manual
This message appea rs if the system has detected
that the tank was filled inco rrectly or that there
is a malfunction . D rive immediately to the near­
est a utho riz ed Aud i dea ler o r authorized Audi
Service Fa cili ty to have the malfunction correct­
ed . Otherwise you will not be able to start the en­
gine again once you stop it.
Checking and Filling
Preparation
Applies to: vehicles with selective cata lytic reduction
Fig. 243 Right rear s ide o f th e ve hicle: removing t he Ad Bl­
u e cap
The Ad Blue tank ope ning is located near the d ie­
se l tank opening. Add at least 1.5 gallons (5. 7
L)
of Ad Blue. This is the minim um amount required
to ensure the system detects the refilling and to
start the engine. You can add a maximum of 6.3 gallons (24 L).
Requireme nt: the request to add Ad Blue must
appea r in the instrument cluster disp lay.
.,. Switch the ignit ion off.
.,. Open the tank filler doo r
c::> page 298.
.,. Tu rn the tank filler neck cap to the left to re­
move
c::>fig. 243.
.,. Refill Ad Blue using a bottle c::> page 302, a can­
ister
c::> page 302 or a pump nozzle
c::> page 303 .
A WARNING , ~ -Ad B lue can irritate the sk in, eyes and respira­
tory sys tem.
If th ere is contact with the flu id,
flus h immed iate ly w ith plenty of wa ter. Con­
su lt a phys ician if necessary.
(D Note
- Only use Ad Blue that conforms to the
standard ISO 22241-1. Do not m ix any addi­
tives with the Ad Blue and do not dilu te it
w ith wate r.
- Do not add AdBl ue to the diesel tank or add
diese l fuel to t he A d Bl ue tank. Do not s tart
t he engine un de r any c ircumst ances if th e
wrong fuel is filled in the tan k. There is a
r is k of damaging the fue l tank system and
301

Checking and Filling
the engine. See an authorized Audi dealer or
authorized Audi Service Facility for assis­
tance.
- Ad Blue attacks surfaces such as painted ve­
hicle components, plastic and carpet. Re­
move the fluid as quickly as possible with a
damp cloth and plenty of cold water. If the
Ad Blue has already crystallized, use warm
water and a sponge . Ad Blue residue that is
not removed will crystallize and can damage
the affected surface.
- Do not store refill bottles or canisters per­
manently in the vehicle. If the container
leaks, the escaping AdBlue could damage
the vehicle interior.
- Do not allow Ad Blue to come into contact
with clothing.
If there is contact with the
fluid , flush immediately with plenty of wa­
ter.
(D Tips
Follow the Ad Blue manufacturer 's instruc­
tions for use and storage.
Refilling AdBlue using the bottle
Applies to: veh icles with selective catalyt ic reduction
.. Remove the cap from the refill bottle¢ A in
Preparation on page 301,
~ CD in Preparation
on page 301.
.. Position the bottle on the filler tube and turn
the bottle clockwise until it stops turning.
.. Press lightly against the bottom of the bottle
to empty it. Continue pressing the bottom of
the bottle until it is empty or until fluid stops
flowing into the tank.
.,. Remove the bottle and seal the filler neck
¢ page 303, Completing AdBlue refill.
(D Note
Only use refill bottles that are approved for
your vehicle. Using other systems can cause
Ad Blue to leak.
(j) Tips
- You can obtain refill bottles from an author­
ized Audi dealer or authorized Audi Service
Facility.
302
- A permitted refill bottle contains approxi­
mately 0.5 gallon (1.9 liters) of AdBlue.
Refilling AdBlue using a canister
Applies to: vehicles with selective catalyt ic reduct ion
@
+®
Fig. 244 Canis te r w ith attachable hose
.,. Remove the cover from the refill canister ¢ A
in Preparation on page 301, ¢(Din Prepara­
tion on page 301 .
.. Secure the end of the hose (Don the opening in
the canister @by turning the hose to the right .
.. Remove the cap @from the other end of the
hose @ .
.. Position the end of the hose@on the filler
neck in the vehicle and turn the hose to the
right to tighten it .
.,. Lift the canister up and then tip it. Continue
holding the canister in a tipped position until it
is empty or until no more fluid flows into the
tank .
.. Remove the canister and close the filler tube
¢ page 303, Completing AdBlue refill .
([) Note
Only use refill canisters that are approved for
your vehicle. Using other systems can cause
AdBlue to leak.
(D Tips
- An authorized Audi dealer or authorized
Audi repair facility can tell you which refill
canisters are approved for your vehicle .
- A permitted refill canister contains approxi­
mately 1.3 gallons (5 liters) of Ad Blue.

Check ing and F illing
Engine compartment
Working in the engine compartment
Special care is required if you are working in the
engine compartment
Fo r wo rk in th e engine compa rtmen t, s uch as
c h ec kin g and filli ng flu id s, th ere is a risk of in­
j u ry, sc aldin g, ac cide nts, a nd b urn s. For this
rea son, foll ow all the warning s and gener al
s a fe ty p recaution s pr ov ided in the f ollow ing in·
f o rm ation . Th e en gine c omp artmen t is a dan ­
ger ous are a.
¢ ,&.
_& WARNING
- T urn the engine off.
- Switch the ign ition off .
- Set the parking brake .
- Select the P selector lever pos ition .
- let the engine cool down.
- Never open the hood if you can see steam or coolant escaping from the engine compart­
ment, because th is increases the r isk of
burns . Wait until no steam or coolant is es­
caping .
- Keep ch ildren away from the engine com­
partment .
- Never spill flu ids on a hot engine. These flu­
ids (such as the anti -freezing agent con ­
ta ined in the coolant) can ignite .
- Avoid short circu its in the electrical system,
especially to the battery .
- When working in the engine compartment,
remember that the rad iator fan can sw itch
on even if the ign ition is switched off, which
increases the risk of injury .
- Never open the cap on the coolant expan­ sion tank when the eng ine is warm. The
cooling system is under pressu re .
- To protect your face, hands, and arms from
hot steam or coolant, cover the cap with a
large cloth when opening.
- Do not remove the engine cover under any
circumstances. This increases the risk of
burns.
- If tests need to be performed w ith the en­
gine running, there is additional danger d ue
304
to moving components (such as the ribbed
be lt, alternator and rad iator fan) and from
the high-voltage ignition system.
- Do not under any circumstances activate the
throttle inadvertently (for example, by hand
from the engine compartment) if the vehi­
cle is stat ionary but the eng ine is running
and a gear is engaged . Otherwise, the veh i­
cle will start to move immediately and this
could result in an acc ident.
- Pay attent ion to the following warnings list­
ed when wor k on the fue l system o r on the
electrical equipment is req uired.
- Always disconnect the vehicle battery
from the vehicle electrical system.
- Do not smoke .
- Never work near open flames.
- Always have a working fire extinguisher
nearby
- To reduce the r isk of e lectr ic shock and in­
jury, never touch the follow ing components
when the engine is running or is being start ­
ed:
- Ign ition cable
- Other components in the electronic high-
voltage ign ition system
- If you must check or perform work on the engine whi le it is running:
- Set the parking brake and place the selec­
tor lever in the P (park) pos ition first.
- Always proceed w ith extreme cau tion so
that clothing, jewelry or long hair do not become ca ught in the rad iator fan, fan
belt or other moving components or do
not come into contact with hot compo­
nents. Tie back long hair before beginning
work and do not wear clothing that can hang down into the engine .
- Limit your exposure to exhaust and chemi­
cals to as short a time as possible¢.&. .
_& WARNING
California Proposition 65 Warning :
- Engine exhaust, some of its constituents,
and certa in vehicle components conta in or
emit chemicals known to the State of Cali-
fornia to cause cancer and birth defects and ..,

reproductive harm. In addition, certain flu­
ids contained in vehicles and certain prod­
ucts of component wear contain or emit
chemicals known to the State of California
to cause cancer and birth defects or other
reproduct ive harm.
- Battery posts, terminals and related acces­
sories contain lead and lead compounds,
chem icals known to the State of California
to cause cance r and rep roductive harms.
Wash hands after handling.
(D Note
When filling flu ids, be sure not to mix the flu­
ids up . Otherwise severe ma lfunctions and en­
gine damage w ill occur.
@ For the sake of the environment
You should regularly check the grou nd under
your veh icle in order to detect Leaks qu ickly . If
there are v isible spots from oil or other fluids,
bring your vehicle to an authorized Aud i dea l­
er or authorized Audi Service Facility to be
checked.
Opening the hood
The hood is released from the interior.
F ig. 2 45 Dri ver fo otw ell : rele ase leve r
Checki ng an d Fill in g
Fig. 246 Unlocke d hood: lever
Make sure the wiper arms are not raised up from
the windshield. Otherwise the paint could be
damaged .
.,. With the driver's door open, pull the lever be­
low the instrument pane l in the direction of the
arrow
c;> fig. 245 .
.,. Raise the hood slightly c;> ,&. .
.,. Press the lever c;> fig. 246 in the direct ion of the
arrow. This releases the hooks .
.. Open the hood .
A WARNING
-
Never open the hood if you can see steam or
coolant escaping from the engine compart­ ment, because this increases the risk of
burns. Wait until no steam or coolant is es­
cap ing .
Closing the hood
.,. Push the hood down until you override the
force of the str uts .
.,. Let the hood fall lightly into the latch .
Do not
press it in.
c;> &_ .
A WARNING
-===
If the hood is not latched complete ly, it could
fly up wh ile you are driving and obstruct your
vis ion.
- For safety reasons, the hood must always be
closed securely while driv ing. Because of
this, always check the hood after closing it
to make sure it is latched correctly . The
hood is latched if the front corners cannot
be lifted.
~
305

Checking and Filling
-If you notice that the hood is not latched
wh ile you are dr iv ing, stop immediately and
Engine compartment overview
The most important check points .
close it, because driving when the hood is
not latched increases the r isk of an accident.
F ig. 247 Ty pical lo ca tion of th e reservoir a nd the engine o il filler op ening
@ Washer fluid reservoir (0) . . . . . . 316
@ Jump start po int( +) under a cover,
(-) with hex head screw . ...... .. 314,356
@ Eng ine oil filling opening
( @ Coolant expansion tank (-L) . . . . . 310
® Brake fluid reservoir (0)) . . . . . . . 31 1
The location of the engine oil filling hole and the coo lant expansion tank~
fig. 247 (items @and
@) may differ depending on the engine version .
A WARNING
Read and follow all WARNINGS before check­
ing anything in the eng ine compartment
~ page 304.
306
Engine oil
Engine oil specifications
The engine oil used must conform to exact speci­
fications .
The serv ice interval d isplay in the instrument
cluster of your vehicle will inform you when it is
time for an o il change. We recommend that you
have you r oil changed by an author ized Audi Se rv­
i ce Adv isor.
If you have to top off the oil between oil changes, u se the Audi oil quality standard specif ied in the
tab~.
~

<( a, .... N ,....
N .... 0 0
3 a,
Audi oil quality standard
Gas oline
VW 502 00 or
engi ne vw 504 00
Diesel vw 507 00
eng ine
A udi recomm ends
~ Castrot /jglQ,Y j;-11Jt ?rtwF«J.o,.11-J.
Audi recomm ends Longlife high perf orma nce
engine oil from Aud i Genuine Parts
Using the proper engine oil is important for the
functionality and service life of the eng ine. Your
engine was factory-filled with a high-quality oil
which can usually be used throughout the entire
year.
(D Note
Your Limited New Vehicle Warranty does not
cover damage or malfunctions due to failure
to follow recommended maintenance and use
requirements as set forth in the Aud i Owner's
Manual and Warranty
& Maintenance booklet .
- Use only a high quality eng ine oil that ex-
pressly complies with the Aud i oil quality
standard specified for your vehicle's engine .
U si ng a ny other oil can cause serious engine
damage.
- Do not mix any lubr icants or othe r additives
i nto the engine oil. Doing so can cause en­
gine damage.
If you need to add oil and there is none availa­
ble that meets the Audi o il quality standard
your eng ine requ ires, you may add a tota l of
no more than 0 .5 qua rt/liter of a h igh-quality
"synthetic"oil that meets the following speci­
fications.
- Vehicles with gasoline engine: AC EA A3 or
API SM with a viscosity grade of SAE OW-30,
SAE SW-30 or SAE 5W-40.
- Vehicles with diesel engine: ACEA C3 or API CF with a viscosity grade of SAE OW-30
or SAE 5W-30.
- For more information about engine oil that
has been approved for your vehicle, please
contact either your authorized Audi dea ler
Ch eck ing and Filling
or Audi Customer Relations at
1 (800) 822-2834 or visit our web site at
www.aud iusa .com or www .a udicanada .ca.
Engine oil consumption
The engine in your vehicle depends on on ade­
quate amount of oil to lubricate and cool all of
its moving ports.
In order to provide effective lubrication and cool ­
ing of internal engine components, all internal
combust ion eng ines consume a certa in amount
of oil. Oil consumption varies from eng ine to en­
gine and may change s ignificantly over the life of
the engine. Typ ically, engines w ith a specified
break-in period (see
c::> page 73) consume more
o il during the break-in per iod than they consume
after oil consumpt ion has stabil ized.
Under normal cond itions, the rate of oil con­
sumption depends on the quality and viscos ity of
the oil, the RPM (revolutions per minute) at
which the engine is operated, the amb ient tem­
peratu re and road co ndit ions. Furt her fac to rs a re
the amo unt of oil di lution from wate r condensa­
tion or fuel residue and the oxidation level of the oi l. As any engine is subject to wear as mileage
builds up, the oil consumption may increase over
time unt il replacement of worn components may
become necessary.
With a ll these variab les coming into play, no
standard rate of oil consumption can be estab­
lished or spec ified . There is no alternative to reg­
ular and frequent checking of the oi l level, see
Not e.
If the yellow engine oil level warning symbo l El
in the instrument cluster lights up, you should
check the oil level as soon as possible
c::> page 308 . Top off the o il at your earliest con­
venience
c::> page 308 .
A WARNING
Before you check anyt hing in the engine com­
partment, always read and heed all WARN­
IN GS
c::> .&. in Working in the engine compart-
ment on page 304. ..,_
307

Check ing and F illing
CJ) Note
Driving with an insufficient oil level is likely to
cause severe damage to the engine .
@ Tips
-The oil pre ssure warn ing display. is not
an ind icato r of the oil l evel. Do not rel y on
it. In stead , che ck th e oil le vel in your e n­
gi ne a t regul ar int ervals, prefe rably e ach
t ime you re fuel , and al ways befo re go ing
on a long trip .
-If you have the impression your engine con­
sumes excessive amounts of oil, we recom­
mend that you consult an authorized Aud i
dealer to have the cause of your concern
properly d iagnosed . Keep in mind that the
accurate measurement of oil consumpt ion
r equi res great ca re and may take some
time. An authorized Audi dealer has instruc­
tions about how to measure oil consump­
tion accurately.
Checking the engine oil level
The engine oil level can be checked in the Info­
tainment system
.. Park you r vehicle on a level surface.
.. Shut the engine off when it is warm.
.. Switch only the ignition back on.
.. Wait approximately two minut es .
.. Se lect in the Infotainment system: the
I MENU I
button > Ve hicle > left cont rol button > S er vice
& c h ecks > Oil lev el.
.. Check the oil level in the Infotainment system
display . Add engine oil if the bar in the oil level
indicato r is near "min "¢
page 308 .
The engine oil consumpt ion may be up to
0 .5 quart pe r 600 miles (0.5 l iter/1,000 km), de­
pending on driving style and operating condi­
tions. Consumption may be highe r d uring the
fi rst 3 ,000 mi les (5,000 km). Because of this, the
engine o il level must be checked regu larly. I t
wou ld be best to check each time you refuel your
vehicle and before long drives .
308
(D Tips
The oil level indicator in the disp lay is only an
i nformat ional disp lay .
If the oil leve l is too
l ow, a min imum oil warning appears in the in­
strument cluster. Add oil and close the hood.
The current oil level is displayed in the instru ­
ment cluster the next t ime the ignition is
switched on.
Adding engine oil F ig. 248 E n gin e compartment : engine oil f ille r open ing
cover
.. Read a nd follo w all WARNIN GS before check­
ing anything in the engine compartment ¢
A
in Working in the engine compartment on
page 304 .
.. Turn the engine off .
.. Unscrew the cap
ce--: for the engine oil filling
opening <=>
fig. 248, <=> page 306 .
.. Carefully add 0 .5 quart (0.5 l iter) of the correct
oil ¢
page 306.
.. Check the oil level aga in after two minutes
¢ page 308, Checking the engine oil level .
.. Add more o il if necessary.
.. Close the engine oi l filler opening cap .
A WARNING
-When adding oil, do not let oil drip onto hot
engine components. This increases the risk
of a fire.
- You must secure the cap on the oil f iller
open ing correctly so that oil does not leak
out onto the hot engine and exhaust system
when the engine is runn ing, because this is
a fire hazard .
- Always clean sk in thoroughly if it comes into
contact with eng ine oil.

<( a, .... N ,....
N .... 0 0
3 a,
CD Note
-Check the oil level in the Infotainment sys­
tem. If the message
II Please reduce oil
level
appears, contact an authorized Audi
dealer or authorized Audi Service Fac ility to
have excess oil extracted if necessary.
- Do not mix any additional lubricants into
the engine o il. Damage caused by such addi­
tives is not covered by the warranty .
@ For the sake of the environment
-Oil should never enter the sewer system or
come into contact with the ground.
- Pay attention to legal requirements when
dispos ing of empty oil containers.
Changing the engine oil
We recommend that have your oil changed by an
authorized Audi dealer or a qualified service sta­
tion.
Before you check anything in the engine compart­
ment,
always read and heed all WARNINGS c> A
in Working in the engine compartment on
page 304 .
The engine oil must be changed according to the
intervals specified in your Warranty
& Mainte­
nance booklet. This is very important because the
lubricating properties of oil diminish gradually
during normal vehicle use.
Under some circumstances the engine oil should
be changed more frequently . Change oil more of­
ten if you drive mostly short distances, operate
the vehicle in dusty areas or under predominantly
stop-and-go traffic cond it ions, or have your vehi­
cle whe re temperatures remain below freezing
for extended pe riods.
Detergent additives in the oil will make fresh oil
look dark after the engine has been running for a
short time. This is no rmal and is not a reason to
change the oil more often than recommended.
Because of the problem of proper disposal, along
with the special tools and necessary expertise re­
qu ired, we strong ly recommend that you have
Checking and Filling
your oi l changed by an authorized Audi dealer or
a qualified service station .
If you choose to change your oil yourself, please
note the following important info rmation:
A WARNING ~
To reduce the risk of persona l injury if you
must change the engine oil in your vehicle
yourself:
- Wear eye protection.
-
-To reduce the risk of burns from hot engine
oil, let the engine cool down to the touch.
- When remov ing the oil drain plug with your
fingers, stay as far away as possible. Always
keep your forearm parallel to the ground to
help prevent hot oil from running down your
arm.
- Drain the oil into a container designed for
this purpose, one large enough to hold at
least the tota l amount of oil in your engine.
- Engine oil is poisonous. Keep it well out of
the reach of children.
- Continuous contact with used engine oil is
harmful to your skin. Always protect your
skin by washing oil off thoroughly with soap
and water.
CD Note
Never mix oil additives with your engine oil.
These additives can damage your engine and
adverse ly affect your Audi Limited New Vehi­
cle Warranty.
@ For the sake of the environment
-Before changing your oi l, first make sure
you know where you can properly dispose of
the used oil.
- Always dispose of used engine o il properly.
Do not dump it on garden soil, wooded
areas, into open streams or down sewage
drains.
- Recycle used engine o il by tak ing it to a used
eng ine oil collection fac ility in your area, or
contact a service station .
309