CUSTOMER LOYALTY WC13
TOYOTA MOTOR SALES USA INC
PO BOX 2991
TORRANCE CA 90509-9809
SAFETY PRECAUTIONS
Your Mirai Fuel Cell has both high-voltage DC and AC systems as well as a 12-volt system.
Both DC and AC high voltage are very dangerous and can cause personal injury, severe
burns, electric shock and even fatal injury.
To avoid personal injury, please follow all caution labels attached to high-voltage parts.
Do not touch or attempt to remove or replace any high-voltage (orange-colored) wiring
and connectors. Do not touch the service plugs located on top of the high voltage traction
battery and fuel cell stack assemblies.
If an accident occurs, do not touch any high-voltage wiring, connectors or parts such as the
under hood inverter with converter assembly or the high voltage traction battery assembly.
Do not touch the potassium hydroxide electrolyte that might spill or leak from the high
voltage traction battery as the result of an accident. If potassium hydroxide electrolyte
gets on your skin or in your eyes, neutralize it immediately with a saturated boric acid
solution (ratio: 80 grams boric acid to two liters water). Seek immediate medical attention.
The hydrogen gas is flammable, and can ignite within a large range of concentrations
(4 to 74.5%). However, it diffuses easily and tends not to remain near the ground. If the
sound of hydrogen leaking (a loud hissing sound) can be heard, immediately step away
from the vehicle as there is a chance that the hydrogen gas may ignite.
Water is recommended as the extinguishing agent for vehicle fires except for hydrogen
and/or high voltage traction battery fires which should be allowed to burn out.
The Toyota Mirai Fuel Cell is being offered in limited quantities. While
non-powertrain and non-fuel cell component warranty service can be performed
by any Toyota dealership, powertrain warranty service and fuel cell component
warranty service must only be performed by an authorized Mirai Fuel Cell Toyota
dealership.
To locate your nearest authorized Mirai Fuel Cell Toyota dealership, log on to
www.toyota.com or contact the Toyota Customer Experience Center at (800)
3 3 1- 4 3 3 1.
38353a2_15-TCS-08663_WarrMaintGuide_Mirai_4_0F_lm.indd 208/17/2015 18:23
JOBNAME: 2006314-2014-mir-toy PAGE: 13 SESS: 12 OUTPUT: Wed Aug 12 11:02:11 2015
/tweddle/toyota/sched-maint/2006314-en-mir/wg16
WHAT IS COVERED AND
HOW LONG
Basic Warranty
This warranty covers repairs and
adjustments needed to correct defects in
materials or workmanship of any part
supplied by Toyota, subject to the
exceptions indicated under “What Is Not
Covered” on pages 14-15.
Coverage is for 36 months or
36,000 miles, whichever occurs first, with
the exception of wheel alignment and
wheel balancing, which are covered for
12 months or 12,000 miles, whichever
occurs first.
Fuel Cell System Warranty
This warranty covers repairs needed to
correct defects in materials or
workmanship of the components listed
here and supplied by Toyota, subject to
the exceptions indicated under “What Is
Not Covered” on pages 14-15.
•Fuel cell air compressor
• Fuel cell boost converter
• Fuel cell ECU
• Fuel cell hydrogen tanks
• Fuel cell power control unit (PCU)
• Fuel cell stack
• Hybrid battery ECU (battery voltage
sensor)
• Hybrid battery pack
• Hybrid control module (power
management control module)
• Hydrogen fueling ECU
Coverage is for 96 months or
100,000 miles, whichever occurs first.
Powertrain Warranty
This warranty covers repairs needed to
correct defects in materials or
workmanship of any component listed in
the next column and supplied by Toyota,
subject to the exceptions indicated under
“What Is Not Covered” on pages 14-15.
Coverage is for 60 months or
60,000 miles, whichever occurs first.
Transaxle and Mounts
Case and all internal parts, transaxle
mounts, seals and gaskets.
Front-Wheel-Drive System
Axle shaft, hub, bearings, seals and
gaskets.
Restraint Systems Warranty
This warranty covers repairs needed to
correct defects in materials or
workmanship of any seatbelt or air bag
system supplied by Toyota, subject to the
exceptions indicated under “What Is Not
Covered” on pages 14-15.
Coverage is for 60 months or
60,000 miles, whichever occurs first.
For vehicles sold and registered in the
state of Kansas, the warranty for seatbelts
and related components is 10 years,
regardless of mileage.
New Vehicle Limited Warranty
WARRANTY
Your Warranties in Detail13
