2016 Ram ProMaster automatic transmission

ONBOARD DIAGNOSTIC SYSTEM — OBD II
Your vehicle is equipped with a sophisticated Onboard
Diagnostic system called OBD II. This system monitors
the performance of the emissions, engine, and automatic
transmission control systems. When these systems are
operating properly, your vehicle will provide excellent
performance and fuel economy, as well as engine emis-
sions well within current government regulations.
If any of these systems require service, the OBD II system
will turn on the “Malfunction Indicator Light (MIL).” It
will also store diagnostic codes and other information to
assist your service technician in making repairs. Al-
though your vehicle will usually be drivable and not
need towing, see your authorized dealer for service as
soon as possible.
CAUTION!
•Prolonged driving with the MIL on could cause
further damage to the emission control system. It
could also affect fuel economy and driveability.
The vehicle must be serviced before any emissions
tests can be performed.
• If the MIL is flashing while the engine is running,
severe catalytic converter damage and power loss
will soon occur. Immediate service is required.
354 MAINTAINING YOUR VEHICLE

WARNING!(Continued)
the brake fluid to catch fire. Brake fluid can also
damage painted and vinyl surfaces, care should be
taken to avoid its contact with these surfaces.
• Do not allow petroleum based fluid to contaminate
the brake fluid. Brake seal components could be
damaged, causing partial or complete brake failure.
This could result in a collision.
Automatic Transmission (3.6L Gasoline Engine
Only)
Selection Of Lubricant
It is important to use the proper transmission fluid to
ensure optimum transmission performance and life. Use
only the manufacturer’s specified transmission fluid.
Refer to “Fluids, Lubricants, And Genuine Parts” in this
section for fluid specifications. It is important to maintain
the transmission fluid at the correct level using the recommended fluid. No chemical flushes should be used
in any transmission; only the approved lubricant should
be used.
CAUTION!
Using a transmission fluid other than the manufac-
turer’s recommended fluid may cause deterioration
in transmission shift quality and/or torque converter
shudder, and will require more frequent fluid and
filter changes. Refer to “Fluids, Lubricants, And
Genuine Parts” in this section for fluid specifica-
tions.
Special Additives
The manufacturer strongly recommends against using
any special additives in the transmission.
378 MAINTAINING YOUR VEHICLE

Automatic Transmission Fluid (ATF) is an engineered
product and its performance may be impaired by supple-
mental additives. Therefore, do not add any fluid addi-
tives to the transmission. The only exception to this
policy is the use of special dyes for diagnosing fluid
leaks. Avoid using transmission sealers as they may
adversely affect seals.
CAUTION!
Do not use chemical flushes in your transmission as
the chemicals can damage your transmission compo-
nents. Such damage is not covered by the New
Vehicle Limited Warranty.
Fluid Level Check
The fluid level is preset at the factory and does not
require adjustment under normal operating conditions.
Routine fluid level checks are not required, therefore thetransmission filler tube is capped and no dipstick is
provided. Your authorized dealer can check your trans-
mission fluid level using a special service dipstick. If you
notice fluid leakage or transmission malfunction, visit
your authorized dealer immediately to have the trans-
mission fluid level checked. Operating the vehicle with
an improper fluid level can cause severe transmission
damage.
CAUTION!
If a transmission fluid leak occurs, visit your autho-
rized dealer immediately. Severe transmission dam-
age may occur. Your authorized dealer has the proper
tools to adjust the fluid level accurately.
Fluid And Filter Changes
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
7
MAINTAINING YOUR VEHICLE 379

Chassis
ComponentFluid, Lubricant, or Genuine Part
Automatic Transmission – 3.6L Gasoline Engine Only Use Only ATF+4 Automatic Transmission Fluid. Failure to use ATF+4 fluid may affect the function or perfor-
mance of your transmission. We recommend MOPAR
ATF+4 Fluid.
Brake Master Cylinder We recommend you use MOPAR DOT 4.
Power Steering Reservoir Use Pentosin CHF 11S power steering fluid meeting
FCA Material Standard MS-11655.
408 MAINTAINING YOUR VEHICLE

Mileage or time passed
(whichever comes first)
20,000
30,000
40,000
50,000
60,000
70,000
80,000
90,000
100,000
110,000
120,000
130,000
140,000
150,000
Or Years: 2 3 4 5 6 7 8 9 10 11 12 13 14 15
Or Kilometers:
32,000
48,000
64,000
80,000
96,000
112,000
128,000
144,000
160,000
176,000
192,000
208,000
224,000
240,000
Change automatic transmission
fluid and filter. XX
Inspect and replace PCV valve if
necessary. X
** The spark plug change interval is mileage based only,
yearly intervals do not apply.
414 MAINTENANCE SCHEDULES

Automatic Transaxle........................12
Automatic Transmission .................222, 379
Adding Fluid ......................... .379
Fluid And Filter Changes ..................379
Fluid Change ......................... .379
Fluid Level Check ...................... .379
Fluid Type ........................ .378, 408
Gear Ranges .......................... .225
Special Additives ...................... .378
Battery ............................ .135, 364
Charging System Light ...................135
Keyless Transmitter Replacement (RKE) ........19
Belts, Seat ...............................66
Body Builders Guide ........................6
Body Mechanism Lubrication .................368
B-Pillar Location ......................... .257
Brake Assist System ...................... .244
Brake Control System, Electronic ..............241Brake Fluid
............................ .408
Brake, Parking .......................... .239
Brake System ........................ .241, 376
Anti-Lock (ABS) ....................... .241
Fluid Check .......................... .376
Parking ............................. .239
Warning Light ........................ .142
Brake/Transmission Interlock .................224
Bulb Replacement ..................... .399, 401
Bulbs, Light .......................... .68, 399
Camera, Rear ............................112
Capacities, Fluid ......................... .405
Caps, Filler Fuel ................................ .287
Power Steering ........................ .238
Radiator (Coolant Pressure) ................374
Carbon Monoxide Warning ................65, 286
Cargo Light ..............................98
10
INDEX 431

Customer Assistance...................... .419
Customer Programmable Features .............190
Data Recorder, Event .......................53
Dealer Service ........................... .357
Defroster, Windshield ....................66, 207
Diagnostic System, Onboard .................354
Dimmer Control ...........................93
Dimmer Switch, Headlight ...................95
Dipsticks Automatic Transmission ..................379
Oil (Engine) .......................... .358
Power Steering ........................ .238
Disabled Vehicle Towing ....................347
Disposal Antifreeze (Engine Coolant) ................374
Door Ajar .............................. .136
Door Ajar Light ......................... .136
Door Locks ..............................20 Door Locks, Automatic
......................22
Driving Through Flowing, Rising, Or Shallow Standing
Water ............................... .235
Electric Remote Mirrors ......................73
Electronic Brake Control System ...............241
Brake Assist System .....................244
Electronic Speed Control (Cruise Control) ........102
Electronic Stability Control (ESC) ..............244
Electronic Throttle Control Warning Light ........137
Electronic Vehicle Information Center (EVIC) Exit Trip ............................. .166
NewTrip ............................ .166
Start Of Trip Procedure ...................166
Trip Computer ........................ .166
Trip Functions ........................ .167
Emergency, In Case Of Freeing Vehicle When Stuck ................344
10
INDEX 433

FlashersHazard Warning ....................... .309
Turn Signal ........................ .68, 157
Flooded Engine Starting ....................221
Fluid Capacities ......................... .405
Fluid Leaks ..............................68
Fluid Level Checks Automatic Transmission ..................379
Brake ............................... .376
Cooling System ........................ .371
Power Steering ........................ .238
Fluids, Lubricants And Genuine Parts ...........406
Fog Lights ...............................94
Four-Way Hazard Flasher ...................309
Freeing A Stuck Vehicle .....................344
Fuel .................................. .282
Adding ............................. .287
Additives ............................ .284
Clean Air ............................ .283Ethanol
............................. .283
Filler Cap (Gas Cap) .....................287
Gasoline ............................. .282
Materials Added ....................... .284
Methanol ............................ .283
Octane Rating ..................... .282, 406
Requirements ...................... .282, 405
Tank Capacity ......................... .405
Fueling ............................... .287
Fuses ................................. .387
Gas Cap (Fuel Filler Cap) .............287, 288, 355
Gasoline, Clean Air ....................... .283
Gasoline (Fuel) .......................... .282
Gasoline, Reformulated .....................283
Gear Ranges ............................ .225
Gear Select Lever Override ..................346
General Information ................... .204, 281
Glass

Cleaning .......................... .385
10
INDEX 435