2016 Ram 2500 oil pressure

only when the level on the dipstick is below the “ADD”
mark. The total capacity from the ADD mark to the Full
mark is 2 qts (1.9L).
CAUTION!
Overfilling or underfilling the crankcase will cause
oil aeration or loss of oil pressure. This could damage
your engine.
Never operate the engine with oil level below the “ADD”
mark or above the upper “SAFE” mark.
Change Engine Oil
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
Engine Oil Selection
For best performance and maximum protection under all
types of operating conditions, the manufacturer only recommends engine oils that are API CJ-4 certified and
meet the requirements of FCA LLC. Use MOPAR or an
equivalent oil meeting FCA Material Standard MS-10902.
Products meeting Cummins CES 20081 may also be used.
The identification of these engine oils are typically lo-
cated on the back of the oil container.
American Petroleum Institute (API) Engine Oil
Identification Symbol
This symbol means that the oil has
been certified by the American Petro-
leum Institute (API). The manufac-
turer only recommends API Certified
engine oils.
7
MAINTAINING YOUR VEHICLE 337

5. Remove lid using a socket or strap wrench. Rotatecounterclockwise for removal. Remove used o-ring
and discard it.
6. Remove the used filter cartridge from the housing and dispose of according to your local regulations.
7. Wipe clean the sealing surfaces of the lid and housing.
8. Install new o-ring back into ring groove on the filter housing and lubricate with clean engine oil.
NOTE: WIF sensor is re-usable. Service kit comes with
new o-ring for filter canister and WIF sensor.Priming If The Engine Has Run Out Of Fuel
WARNING!
Do not open the high pressure fuel system with the
engine running. Engine operation causes high fuel
pressure. High pressure fuel spray can cause serious
injury or death.
1. Add a substantial amount of fuel to the tank, approxi- mately 2 to 5 gal (8L to 19L).
2. Turn ignition switch to the start position to engage starter for one second, return ignition switch to run
position. This will activate in tank fuel pump for
approximately 15 seconds. Repeat this process twice.
3. Start the engine using the “Normal Starting” proce- dure. Refer to “Starting Procedures” in “Starting and
Operating” for further information.
350 MAINTAINING YOUR VEHICLE

Adding Engine Coolant (Antifreeze)............140
Adding Fuel .............................114
Air Bag Light .............................25
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . .128
Alarm (Security Alarm) ......................28
Antifreeze (Engine Coolant) ..................139
Capacities ........................... .146
Disposal ............................. .142
Automatic Transmission Fluid Type ........................... .150
Axle Fluid ............................. .150
Battery .................................30
Charging System Light ....................30
Brake Fluid ............................ .150
Brake System ........................... .144
Fluid Check .......................... .144
Master Cylinder ....................... .144Warning Light
..........................26
Capacities, Antifreeze (Engine Coolant) ..........146
Capacities, Fluid ......................... .146
Caps, Filler Oil (Engine) .......................... .127
Radiator (Coolant Pressure) ................142
Charge Air Cooler ........................ .144
Coolant Pressure Cap (Radiator Cap) ...........142
Cooling System .......................... .138
Adding Coolant (Antifreeze) ...............140
Coolant Capacity ...................... .146
Coolant Level ......................... .138
Disposal Of Used Coolant .................142
Drain, Flush, And Refill ...................139
Points To Remember .....................143
Pressure Cap ......................... .142
Radiator Cap ......................... .142
Selection Of Coolant (Antifreeze) ........139 , 147
8
INDEX - RAM 1500 391

New Vehicle Break-In Period..................13
Oil Pressure Light ..........................31
Oil, Engine ............................. .126
Capacity ............................ .146
Change Interval ....................... .127
Dipstick ............................. .126
Disposal ............................. .128
Filter ........................... .128 , 147
Filter Disposal ........................ .128
Materials Added To ..................... .128
Pressure Warning Light .................31,34
Recommendation ...................... .126
Viscosity ............................ .127
Radiator Cap (Coolant Pressure Cap) ...........139
Remote Starting System ......................12 Schedule, Maintenance
.....................152
Seat Belts Reminder ..............................24
Security Alarm ............................28
Selection Of Coolant (Antifreeze) ..............147
Signals, Turn .............................57
Starting .................................97
Automatic Transmission ...................98
Engine Block Heater .................100 , 107
Remote ...............................12
Starting Procedures .........................97
Starting Procedures (Diesel Engines) .............97
Tip Start ................................98
Ti re s Pressure Warning Light ....................40
Transfer Case Fluid ............................... .150
394 INDEX - RAM 1500

Adding Engine Coolant (Antifreeze)............356
Adding Fuel ............................ .312
Air Bag Light ........................... .191
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . .340
Air Filter .............................. .340
Alarm (Security Alarm) .....................194
Antifreeze (Engine Coolant) ..................355
Capacities ........................... .373
Disposal ............................. .358
Automatic Transmission Adding Fluid ......................... .365
Fluid Level Check ...................... .364
Fluid Type ........................... .377
Shifting ............................. .286
Axle Fluid ............................. .377
Battery ................................ .196
Blanket .......................... .274 , 354Charging System Light
...................196
Emergency Starting ..................... .326
Brake System ........................... .360
Fluid Check .......................... .360
Master Cylinder ....................... .360
Warning Light ........................ .192
Brake/Transmission Interlock .................286
Capacities, Antifreeze (Engine Coolant) ..........373
Capacities, Fluid ......................... .373
Caps, Filler Oil (Engine) .......................... .338
Radiator (Coolant Pressure) ................358
Charge Air Cooler ........................ .360
Coolant Pressure Cap (Radiator Cap) ...........358
Cooling System .......................... .354
Adding Coolant (Antifreeze) ...............356
Coolant Capacity ...................... .373
Coolant Level ......................... .354
396 INDEX - RAM 2500 / 3500 / 4500 / 5500

Disposal Of Used Coolant.................358
Drain, Flush, And Refill ...................355
Points To Remember .....................359
Pressure Cap ......................... .358
Radiator Cap ......................... .358
Selection Of Coolant (Antifreeze) ........355 , 374
Cruise Light ............................ .223
Diesel Exhaust Brake ...................... .281
Diesel Fuel ............................. .307
Diesel Fuel Requirements ....................307
Bulk Storage Of ....................... .316
Diesel Fuel System, Re-Priming ...............350
Disposal Antifreeze (Engine Coolant) ................358
Door Ajar .............................. .201
Door Ajar Light ......................... .201
Draining Fuel/Water Separator Filter ...........344Electronic Range Select (ERS)
.................294
Electronic Speed Control (Cruise Control) ........176
Electronic Throttle Control Warning Light ........198
Electronic Vehicle Information Center (EVIC) ......228
Emergency, In Case Of Jump Starting ......................... .326
Engine ................................ .333
Air Cleaner .......................... .340
Block Heater ...................... .265 , 280
Break-In Recommendations ................173
Compartment ..................... .333 , 334
Coolant (Antifreeze) .....................374
Identification ..................... .333 , 334
Idling .............................. .275
Jump Starting ......................... .326
Oil............................. .336 , 374
Oil Filler Cap ......................... .338
Oil Synthetic ......................... .339
Runaway ............................ .306
8
INDEX - RAM 2500 / 3500 / 4500 / 5500 397

LightsAirBag ............................. .191
Brake Warning ........................ .192
Cruise .......................... .223 , 225
Engine Temperature Warning ...............195
Fog .................................211
Low Fuel ............................ .209
Malfunction Indicator (Check Engine) .........202
Park ............................ .221 , 223
Seat Belt Reminder ..................... .190
Security Alarm ........................ .194
Tire Pressure Monitoring (TPMS) ............206
Turn Signal .......................... .222
Warning (Instrument Cluster Description) . .195 , 222
Maintenance Procedures ....................335
Maintenance Schedule ..................... .380
Malfunction Indicator Light (Check Engine) .......202
Manual Transmission ..................... .298Fluid Level Check
...................... .362
Shift Speeds .......................... .300
New Vehicle Break-In Period .................173
Noise Control Maintenance .......................... .367
Tampering Prohibited ....................368
Noise Emission Warranty ....................366
Oil Change Indicator ...................... .381
Oil Pressure Light ........................ .197
Oil, Engine ............................. .336
Capacity ............................ .373
Change Interval ....................... .337
Dipstick ............................. .336
Disposal ............................. .340
Filter ........................... .340 , 374
Filter Disposal ........................ .340
Identification Logo ..................... .337
8
INDEX - RAM 2500 / 3500 / 4500 / 5500 399

Starting Procedures (Diesel Engines)............260
Synthetic Engine Oil ...................... .339
Tip Start ............................... .261
Ti re s Pressure Warning Light ...................206
Torque Converter Clutch ....................297
Traction Control ......................... .362
Transfer Case Fluid ............................... .377
Transmission Automatic ........................... .286
Fluid ............................... .377
Manual ......................... .261 , 298
Shifting ............................. .284
Turn Signals ............................ .222Viscosity, Engine Oil
...................... .338
Voltmeter .............................. .272
Water Separator, Diesel Fuel ..................344
8
INDEX - RAM 2500 / 3500 / 4500 / 5500 401