2016 Peugeot Expert VU bonnet

276
Expert_en_Chap07_info-pratiques_ed01-2016
BonnetOpeningClosing
F take the stay out of its support slot.
F C lip the stay back into its housing.
F

L
ower the bonnet and release it at the end
of its travel.
F

P
ull on the bonnet to check that it has
latched correctly.
F
u
n
clip the stay from its housing and place
it in the support slot to hold the bonnet
open.
Do not open the bonnet under very
windy conditions.
When the engine is hot, handle the
exterior safety catch and the stay with
care (risk of burns).
to

avoid damaging electrical units,
it is strictly forbidden to use a high
pressure jet wash under the bonnet. The cooling fan may star t after
switching off the engine: take care
with articles and clothing that might
be caught by the fan blades.
F

L

ift the safety catch, then raise the bonnet.
F
o
p

en the door.
F

P

ull the release lever, located at the bottom
of the door aperture, towards you.
Before doing anything under the
bonnet, deactivate the Stop & Start
system to avoid any risk of injury
resulting from an automatic change to
S
t

A R
t m

o d e .
Practical information

278
Expert_en_Chap07_info-pratiques_ed01-2016
Checking levels
take care when working under the bonnet, as certain areas of the engine may be extremely hot (risk of burns) and the cooling fan could start at
any time (even with the ignition off).
Engine oil level
the check is carried out either when
the ignition is switched on using the
oil level indicator in the instrument
panel for vehicles so equipped, or
using the dipstick.Checking using the dipstick
the location of the dipstick is shown in the
corresponding underbonnet layout view.
F t
a
ke the dipstick by its coloured grip and
remove it completely.
F

W
ipe the end of the dipstick using a clean
non-fluffy cloth.
F

R
efit the dipstick and push fully down, then
pull it out again to make the visual check:
the correct level is between the marks A
and B .
Check all of these levels regularly, in line with the manufacturer's service schedule.
t
o
p them up if necessary, unless other wise indicated.
If a level drops significantly, have the corresponding system checked by a PE
u
g
Eo
t dealer or a qualified workshop.
A = MA X
to e

nsure that the reading is correct, your
vehicle must be parked on a level sur face
with the engine having been off for more than
30


minutes.
It is normal to top-up the oil level between
two services (or oil changes). PE
u

g
Eo

t

recommends that you check the level, and top-
up if necessary, every 3 000 miles (5 000 kms). B = MIN
If you find that the level is above the A mark or
below the B mark, do not star t the engine .
-

I
f the level is above the MAX mark (risk
of damage to the engine), contact a
PE
u

g
Eo
t dealer or a qualified workshop.
-

I
f the level is below the MIN mark, you
must top-up the engine oil.
Practical information

279
Expert_en_Chap07_info-pratiques_ed01-2016
Oil grade
Before topping-up the oil or changing the oil,
check that the oil is the correct grade for your
engine and conforms to the manufacturer's
recommendations.
Topping-up the engine oil level
the location of the oil filler cap is shown in the
corresponding underbonnet layout view.
F u
n
screw the oil filler cap to reveal the filler
aperture.
F

A
dd oil in small quantities, avoiding any
spills on engine components (risk of fire).
F

W
ait a few minutes before checking the
level again using the dipstick.
F

A
dd more oil if necessary.
F

A
fter checking the level, carefully refit the
oil filler cap and the dipstick in its tube.
After topping-up the oil, the check when
switching on the ignition with the oil
level indicator in the instrument panel
is not valid during the 30 minutes after
topping-up.
Engine oil change
Refer to the manufacturer's service schedule
for details of the interval for this operation.
In order to maintain the reliability of the engine
and emission control system, never use
additives in the engine oil.
th

e brake fluid level should be close
to the "MA X" mark. If it is not, check
the brake pad wear.
Brake fluid level
Changing the fluid
Refer to the manufacturer's service schedule
for details of the interval for this operation.
Fluid specification
the brake fluid must conform to the
manufacturer's recommendations.
Coolant level
the coolant level should be close
to the "MA X" mark but should never
exceed it.
In addition, as the cooling system is pressurised,
wait at least one hour after switching off the
engine before carrying out any work.
to a

void any risk of scalding, unscrew the cap
by two turns to allow the pressure to drop. When
the pressure has dropped, remove the cap and
top up the level. The cooling fan may star t after switching
off the engine: take care with ar ticles and
clothing that might be caught by the fan
blades. When the engine is warm, the temperature of
the coolant is regulated by the fan.
Check the coolant level regularly, according
to the use made of your vehicle (every
3 000

miles or 5 000 kms / 3 months); if
necessary, top-up using coolant recommended
by the manufacturer.
to

pping-up the coolant between services is
normal.
Power steering fluid level
the power steering fluid level should
be close to the "MA X" mark. With
the engine cold, unscrew the cap to
check the level.
7
Practical information

321
Expert_en_Chap08_En-cas-de-panne_ed01-2016
12 V batterythe battery is located under the bonnet.
F op en the bonnet using the interior release
lever, then the exterior safety catch.
F

S
ecure the bonnet stay.
Access to the battery
Procedure for starting the engine using another
battery or charging a discharged battery.
General points
Lead-acid starter batteries
Protect your eyes and face before
handling the battery.
All operations on the battery must be
carried out in a well ventilated area and
away from naked flames and sources
of sparks, so as to avoid the risk of
explosion or fire.
Wash your hands afterwards.
Versions equipped with Stop & Start are
fitted with a 12 V lead-acid battery of
specific technology and specification.
Its replacement should be carried
out only by a PE
u

g
Eo

t
dealer or a
qualified workshop. If your vehicle has an automatic
gearbox, do not try to start the engine
by pushing the vehicle.
Batteries contain harmful substances
such as sulphuric acid and lead.
th

ey must be disposed of in
accordance with regulations and must
not, in any circumstances, be discarded
with household waste.
ta

ke used remote control batteries and
vehicle batteries to a special collection
point.
For more information on the Bonnet
and Engine , refer to the corresponding
section(s).
F

I
f fitted to your vehicle, remove the plastic
cover to access the (+) terminal.
th

e battery (-) terminal is not accessible.
A remote earth point is provided at the front of
the vehicle.
8
In the event of a breakdown

327
Expert_en_Chap08_En-cas-de-panne_ed01-2016
on vehicles fitted with Diesel engines, the fuel
system must be primed if you run out of fuel.
For all versions other than BlueHDi, refer to the
corresponding engine compartment view.
Running out of fuel (Diesel)
For more information on Diesel misfuel
prevention, refer to the corresponding
section. F
A dd at least five litres of Diesel fuel to the
tank.
F
o
p
en the bonnet.
F

I
f necessary, unclip the styling cover for
access to the priming pump.
F

S
queeze and release the priming pump
repeatedly until resistance is felt (there
may be resistance at the first press).
F
o
p
erate the starter to start the engine
(if the engine does not start at the first
attempt, wait around 15 seconds before
trying again).
F

I
f the engine does not start after a few
attempts, operate the priming pump again
then start the engine.
F

R
efit the styling cover and clip it in place.
F

C
lose the bonnet.
1.6 HDi engine
(except BlueHDi)
If the engine does not start first time,
don't keep trying but start the procedure
again from the beginning.
BlueHDi engine
F Fill the fuel tank with at least five litres of Diesel.
F

S
witch on the ignition (without starting the
engine).
F

W
ait around 6 seconds and switch off the
ignition.
F

R
epeat the operation 10 times.
F
o
p
erate the starter to run the engine.
Other engines
F Add at least five litres of Diesel fuel to the tank.
F
o
p
en the bonnet.
F

I
f necessary, unclip the styling cover for
access to the priming pump.
F

S
queeze and release the priming pump
repeatedly until resistance is felt (there
may be resistance at the first press).
F
o
p
erate the starter to start the engine
(if the engine does not start at the first
attempt, wait around 15 seconds before
trying again).
F

I
f the engine does not start after a few
attempts, operate the priming pump again
then start the engine.
F

R
efit the styling cover and clip it in place.
F

C
lose the bonnet.
8
In the event of a breakdown

337
Expert_en_Chap09_caracteristiques-techniques_ed01-2016
Identification markingsVarious visible markings for the identification of your vehicle.
A.
V
ehicle Identification Number (VIN)
under the bonnet.


t
h
is number is engraved on the chassis
near the right hand front wheel arch.
th

e tyre pressures must be checked
when the tyres are cold, at least once
a month.
If the tyre pressures are too low, this
increases fuel consumption.
B.
V

ehicle Identification Number (VIN) on
the windscreen lower cross member.


t
h
is number is indicated on a self-
adhesive label which is visible through the
windscreen. C.
M

anufacturer's label.


t
h
is self-destroying label on the middle
door pillar, right or left hand side, contains
the following information:
-
t

he manufacturer's name,
-

t
he European whole vehicle type
approval number,
-

t
he vehicle identification number (VIN),
-

t
he maximum authorised weight (gross
vehicle weight),
-

t
he maximum authorised weight with
trailer (gross train weight),
-

t
he maximum front axle weight,
-

t
he maximum rear axle weight.D.
T

yre/paint label.


t
h
is label on the middle door pillar, driver's
side, contains the following information:
-

t
he tyre inflation pressures, laden and
unladen,
-

t
he tyre sizes (including the tyre load
index and speed rating),
-

t
he inflation pressure for the spare
wheel,
-

t
he paint colour code.
9
technical data

506
Expert_en_Chap11_index-alpha_ed01-2016
ABS ...............................................................161
Access, AdBlue tank ..................................... 285
Accessories


.................................. 203, 271, 272
Access to the spare wheel
............................297
Active Safety Brake........................ 23, 243, 246
AdBlue
® ................................ 2 6, 35 -37, 283 -285
Additive, AdBlue ...................................... 26, 285
Additive, Diesel


....................................... 26, 285
Adjusting headlamp beam height
................. 15

5
Adjusting headlamps


.................................... 155
Adjusting head restraints


......................103, 104
Adjusting seat


......................................... 99, 102
Adjusting the air distribution


.........................128
Adjusting the air flow


..................................... 128
Adjusting the date


........................... 46, 420, 476
Adjusting the height and reach of the steering wheel


.................................... 99
Adjusting the lumbar support


........................10 0
Adjusting the seat belt height


.......................166
Adjusting the temperature
............................ 12

8
Adjusting the time


........................... 46, 421, 477
Advice on driving


.................................. 19 6 -198
Airbags


............................................ 24, 170, 17 7
Airbags, curtain
............................................. 17

3
Airbags, front ......................................... 171, 173
Airbags, lateral


...................................... 172 , 173Air conditioning


...............
12, 127, 129, 130, 137
Air conditioning, automatic

...........................
13 5
Air conditioning, digital

.........................
132, 13 6
Air conditioning, dual-zone automatic

..........
128
Air conditioning, manual

.......
126, 132, 13 5, 13 6
Air intake

...............................
125, 126, 128, 131
Alarm

...............................................................
95
Alarm, volumetric

............................................
95
Anti-lock braking system (ABS) ....................
161
Anti-theft

...........................................
52, 67, 205
Area, loading
...............................
........
47, 55, 73
Armrest, front ................................................
103
ASR

...............................................................
161
Assistance call

......................................
160, 338
Assistance, emergency braking
........... 1
61, 247
Audio streaming (Bluetooth)
..............................
...
398, 454, 495
Audio system (radio) ......
89, 150 -152, 158, 226,
245, 247, 250, 256, 264, 483
Auxiliary


...............................................398, 454
A
B
C
Blinds, side .................................................... 123
BlueHDi ..................................... 31, 35, 208, 283
Bluetooth (hands-free)
............... 4

06, 407, 462, 463, 497
Bluetooth (telephone)


............406-408, 462-464
Bonnet


........................................................... 276
Boot


................................................................. 94
Boot lid


................................ 64, 65, 94, 313, 314
Brake discs
.................................................... 28

2
Brake lamps


........................... 310, 311, 313 - 315
Brakes


............................................... 18, 22, 282
Braking, automatic emergency


............................ 23, 243, 245 -247
Bulbs (changing)
................... 3

03, 304, 310, 313
Bulbs (changing, type)
.................................. 3

03
Battery


.................................... 270, 281, 321-325
Battery capacity
...............................

............. 325
Battery, charging


........................................... 323
Battery, remote control
............... 5

4, 70, 71, 139
Bench seat, one-piece, fixed


........................ 11 0
Blind spot monitoring system

......... 29, 252, 254 Cable, audio


......................................... 398, 454
Cable, jack


........................................... 398, 454
Capacity, fuel tank
..............................

..........265
Cap, fuel filler
................................................ 265
CarPlay connection ..............................386, 442
CD


................................................ 398, 454, 494
CD, MP3
....................................... 3

98, 454, 494
Central locking


.......................................... 59, 64
Changing a bulb


.....3 03, 3 0 4, 310, 311, 313 - 315
Changing a bulb (boot lid)


.............................313
Changing a bulb (side-hinged doors)
........... 3

10
180° rear vision

............................................. 259
Alphabetical index

510
Expert_en_Chap11_index-alpha_ed01-2016
Pads, brake ................................................... 282
Paint colour code .......................................... 337
Parking brake


.................................. 18, 205, 282
Parking sensors, audible and visual


.............256
Parking sensors, front


...................................256
Parking sensors, rear ............................255, 256
PE
u

g
Eo
t Connect Assistance ...................338
PE
u

g
Eo
t Connect Nav
...............................3

41
P
Eu

g
Eot C

onnect Packs

...........................338
PE
u

g
Eo
t Connect Radio ...........................429
P
Eu

g
Eot C

onnect S
oS ............................. 33

8
Plates, identification ...................................... 337
Platform cab
.......................................... 3

15, 332
Player, Apple
® .............................. 3 99, 455, 495
Player, MP3 CD ............................................. 494
Player,
u
S

B

.................................. 398, 454, 492
Port,
u
S

B

............................. 1

22, 398, 454, 492
Pressures, tyres


................... 290, 295, 302, 337 Pre-tensioning seat belts


..............................
169
Priming pump

................................................
327
Priming the fuel system ................................
327
Profiles

..................................................
418 , 474
Protecting children

.................
171, 174 -176 , 18 2 ,
187, 188, 190, 193
Puncture

........................................................
290
Radio

...................
394, 398, 450, 454, 488, 489
Radio, digital (Digital Audio Broadcasting - DAB)

..........
396, 397, 452, 453
Radio Media

........
388, 390, 392, 444, 446, 448
Range

..............................................................
42
Range, AdBlue

................................................
35
RDS

.......................................................
3 9 5 , 4 51
Rear screen, demisting

.........................
13 3, 13 4
Recharging the battery
................................. 32
3
Recirculation, air

...................
125, 126, 128, 131
Reduction of electrical load

..........................
270
Regeneration of the particle filter
.................
2
81
Reinitialisation of the under-inflation detection system .........................................
263
Reinitialising the remote control
............... 5
4, 70
Reminder, key in ignition ...............................
201
Reminder, lighting on ....................................
148
Remote control
...... 4

7-50, 52, 55 -59, 67, 68, 71, 74, 75
Removing a wheel
........................................299
Removing the mat


.........................................11 9Safety, children
......................
17
1, 174 -176 , 18 2 ,

187, 188, 190, 193
Saturation of the particle filter (Diesel)
.........
2
81
Screen, instrument panel ..........................
4 0 , 41
Screen menu map .......
352, 354, 356, 360, 362,
370, 372, 374, 378, 384, 386, 388, 390, 392, 400, 402, 404, 412, 414, 416, 434, 440, 442,
444, 446, 448, 456, 458, 460, 468, 470, 472
Screen, multifunction (with audio system)


....487
P
R
S
Replacing bulbs .....3 03, 3 0 4, 310, 311, 313 - 315
Replacing fuses .............................. ......316, 317
Replacing the air filter


...................................281
Replacing the oil filter
................................... 2

81
Replacing the passenger compartment filter


...................................... 281
Reservoir, headlamp wash


...........................280
Reservoir, screenwash
................................. 28

0
Reset journey


.................................................. 41
Resetting the service indicator


.......................33
Resetting the trip recorder


..............................38
Rev counter


................................................ 14 -16
Reversing camera


......................................... 259
Reversing camera (on interior mirror)
..........258
Reversing lamp
............................. 31

0, 313, 315
Roof bars
............................................... 2

72, 273
Roof rack
............................................... 2

72, 273
Running out of fuel (Diesel)

..........................3

27oi
l change
..................................................... 278oi
l consumption
............................................ 278
oi

l, engine
...............................

...................... 278
on

-board tools


...................................... 287, 289
op

ening the bonnet
...................................... 2

76
op

ening the boot
..............................

.. 47, 59, 94
op

ening the doors
....... 4

7, 59, 74, 78 - 81, 83, 93
op

ening to 90/180/235°

.................................. 92
op

ening to 180°

.............................................. 91
O
Alphabetical index