2016 Peugeot Expert VU engine coolant

19
Warning / indicator lampStateCause Action / Observations
Seat belt(s)
not fastened /
unfastened fixed
or flashing
accompanied by an
audible signal. A seat belt has not been fastened or
has been unfastened.
Pull the strap then insert the tongue in the buckle.
* Depending on the country of sale. Battery charge
*fixed.
th

e battery charging circuit has a
fault (dirty or loose terminals, slack or
cut alternator belt, ...).
th

e warning lamp should go off when the engine is
started.
If it does not go off, contact a P
e

ugeot dealer or a
qualified workshop.
Engine oil
pressure fixed.
th

ere is a fault with the engine
lubrication system. You must stop as soon it is safe to do so.
Park, switch off the ignition and contact a P
e

ugeot
dealer or a qualified workshop.
or Maximum
coolant
temperature
fixed with the needle
in the red zone.
th

e temperature of the cooling
system is too high. Stop as soon as it is safe to do so.
Wait until the engine has cooled down before topping-
up the level, if necessary.
If the problem persists, contact a P
e

ugeot dealer or
a qualified workshop.
fixed (only with the
LCD instrument
panel).
1
Instruments

31
With the engine running, when the needle or
the bar graph (depending on version) is:
-
i
n zone A , the temperature of the engine
coolant is correct,
-

i
n zone B, the temperature of the engine
coolant is too high; the maximum
temperature and the central STOP warning
lamps come on, accompanied by an
audible signal and a warning message in
the touch screen.
You MUST stop as soon as it is safe to do so.
Wait a few minutes before switching off the
engine.
Contact a P
e

ugeot dealer or a qualified
workshop. After driving for a few minutes, the temperature
and pressure in the cooling system increase.
to t

op-up the level:
F
w
ait at least one hour for the engine to
cool,
F
u
nscrew the cap two turns to allow the
pressure to drop,
F
w
hen the pressure has dropped, remove
the cap,
F
t
op-up the level to the "MA X" mark.
Be aware of the risk of burns when
topping up the cooling system. Do not
fill above the maximum level (indicated
on the header tank).
Engine coolant temperature Service indicator
System which informs the driver when the
next service is due, in accordance with the
manufacturer's servicing schedule.
th

e point at which the next service is due is
calculated from the last indicator zero reset,
depending on the distance travelled and the
time elapsed since the last service.
For BlueHDi Diesel versions, the degree of
deterioration of the engine oil is also taken into
account (depending on the country of sale).Checking the level
1
Instruments

198
When towing
Distribution of loads
F Distribute the load in the trailer so that the
heaviest items are as close as possible to
the axle and the nose weight approaches
the maximum permitted without exceeding it.
Air density decreases with altitude, thus
reducing engine performance. Above
1 000 metres, the maximum towed load must
be reduced by 10
% for every 1 000 metres of
altitude.
Side wind
F take into account the increased sensitivity to side wind.
Cooling
towing a trailer on a slope increases the
temperature of the coolant.
As the fan is electrically controlled, its cooling
capacity is not dependent on the engine speed.
F
t
o l
ower the engine speed, reduce your
speed.
th

e maximum towed load on a long incline
depends on the gradient and the ambient
temperature.
In all cases, keep a check on the coolant
temperature.
F

I
f the warning lamp and the
STOP warning lamp come on,
stop the vehicle and switch off
the engine as soon as possible.
Braking
towing a trailer increases the braking distance.to a void overheating of the brakes, the use of
engine braking is recommended.
Ty r e s
F Check the tyre pressures of the towing vehicle and of the trailer, observing the
recommended pressures.
Lighting
F Check the electrical lighting and signalling on the trailer and the headlamp beam
height of your vehicle.
For more information on Weights
, refer
to the corresponding section.
th

e rear parking sensors will be
deactivated automatically to avoid the
audible signal if a genuine P
e

ugeot
towbar is used.
If the ambient temperature is high, it
is recommended that the engine be
allowed to idle for 1 to 2 minutes after
the vehicle comes to a stop, to facilitate
its cooling. For more information on Adjusting the
headlamp beam height
, refer to the
corresponding section.
Driving

277
* According to engine.
Diesel engine
1. Screenwash and headlamp wash reservoir.
2. Coolant header tank.
3.


e
n
gine oil filler cap.
4.


e
n
gine oil dipstick.
5.
P

riming pump*.
6.
B

rake fluid filler cap.
7.


Battery.
8.
R

emote earth point ("-" terminal).
9.


Fusebox.
10.
P

ower steering fluid reservoir.
11.
A

i r f i l t e r.
th

is engine is shown as an example. t
h
e locations of the engine oil dipstick and filler cap may vary.
th

e Diesel fuel system operates under
high pressure:
-

N
ever carry out any work on this
system yourself.
-

H
Di engines make use of advanced
technology.
All maintenance and repairs require
specially trained staff, which only a
P
e

ugeot
d
ealer can provide.
7
Practical information

279
Oil grade
Before topping-up the oil or changing the oil,
check that the oil is the correct grade for your
engine and conforms to the manufacturer's
recommendations.
Topping-up the engine oil level
the location of the oil filler cap is shown in the
corresponding underbonnet layout view.
F u
n
screw the oil filler cap to reveal the filler
aperture.
F

A
dd oil in small quantities, avoiding any
spills on engine components (risk of fire).
F

W
ait a few minutes before checking the
level again using the dipstick.
F

A
dd more oil if necessary.
F

A
fter checking the level, carefully refit the
oil filler cap and the dipstick in its tube.
After topping-up the oil, the check when
switching on the ignition with the oil
level indicator in the instrument panel
is not valid during the 30 minutes after
topping-up.
Engine oil change
Refer to the manufacturer's service schedule
for details of the interval for this operation.
In order to maintain the reliability of the engine
and emission control system, never use
additives in the engine oil.
th

e brake fluid level should be close
to the "MA X" mark. If it is not, check
the brake pad wear.
Brake fluid level
Changing the fluid
Refer to the manufacturer's service schedule
for details of the interval for this operation.
Fluid specification
the brake fluid must conform to the
manufacturer's recommendations.
Coolant level
the coolant level should be close
to the "MA X" mark but should never
exceed it.
In addition, as the cooling system is pressurised,
wait at least one hour after switching off the
engine before carrying out any work.
to a

void any risk of scalding, unscrew the cap
by two turns to allow the pressure to drop. When
the pressure has dropped, remove the cap and
top up the level. The cooling fan may star t after switching
off the engine: take care with ar ticles and
clothing that might be caught by the fan
blades. When the engine is warm, the temperature of
the coolant is regulated by the fan.
Check the coolant level regularly, according
to the use made of your vehicle (every
3 000

miles or 5 000 kms / 3 months); if
necessary, top-up using coolant recommended
by the manufacturer.
to

pping-up the coolant between services is
normal.
Power steering fluid level
the power steering fluid level should
be close to the "MA X" mark. With
the engine cold, unscrew the cap to
check the level.
7
Practical information

280
Changing the coolant
the coolant does not have to be replaced at
routine services.
Fluid specification
the coolant must conform to the
manufacturer's recommendations.
th
e check and top-up must be done
with the engine cold.
A low coolant level presents the risk of
serious damage to your engine.
If the ambient temperature is high, it
is recommended that the engine be
allowed to idle for 1 to 2 minutes after
the vehicle comes to a stop, to facilitate
its cooling.
Avoid prolonged contact of used oil or
fluids with the skin.
Most of these fluids are harmful to
health or indeed very corrosive.
Do not discard used oil or fluids into
sewers or onto the ground.
ta

ke used oil to a P
e
ugeot dealer or
a qualified workshop (France) or to an
authorised waste disposal site.
Used products
To p p i n g - u p
this additive must be topped-up by a
Pe ugeot dealer or a qualified workshop
without delay.
Diesel additive level (Diesel
engine with particle filter)
A low additive level is indicated by
illumination of this warning lamp,
accompanied by an audible warning
and a message in the instrument
panel screen.
Fluid specification
For optimum cleaning and to avoid freezing,
this fluid must not be topped-up with or
replaced with plain water.
Screenwash and headlamp
wash fluid
In the case of vehicles fitted with
headlamp washers, the low fluid level
is indicated by an audible signal and
a message in the instrument panel
screen.
to

p-up the reservoir when you next
stop the vehicle.
In wintry conditions, the use of an ethyl alcohol
or methanol base fluid is recommended.
Practical information

508
I
Identification, vehicle ....................................3 37
Ignition ................ ...................201, 203, 410, 466
Immobiliser, electronic


................52, 67, 71, 205
Indicator, AdBlue
® range ................................. 35
Indicator, coolant temperature ........................ 3
1
Indicator, engine oil level
................................ 34
Indicator lamps, operation


.............................. 17
Indicators, direction


...................................... 148
Inflating tyres


.................................................. 12
Inflating tyres and accessories (using the kit)
..............................

................290
Instrument panel
...............................

.........14 -16
Instrument panel, LCD
........................ 14, 3 5 - 37
Instrument panel, LCD text
............................. 15
Instrument panel, matrix
................................. 16
Intelligent
t
ra

ction Control
............................ 16

2
IS
oFI

X


.................................................. 187, 190
g.

P. S .


............................................................
366
gr

ip control

...................................................
16 4gu
ide-me-home
............................................
150
Jack
........

.............................. 122, 296, 398, 454
Hazard warning lamps


.......................... 160, 287
Headlamp adjustment


................................... 155
Headlamp beam height


................................. 155
Headlamp dipping, automatic


....................... 15 4
Headlamps, automatic dipping


............... 29, 153
Headlamps, automatic illumination


.................................. 146, 149, 15 0
Headlamps, dipped beam


................ 29, 146, 304, 306, 308
Headlamps, halogen


............................ 304, 306
Headlamps, main beam
................... 2

9, 146, 304, 307, 308
Headlamps, Xenon


.............................. 304, 308
Headlamp wash


............................................ 15 8
Head restraints, front

............................ 103, 104
Head-up display


........................... 222, 223, 244
Heated bench seat
........................................ 10

5
Heating


............................. 12, 125, 126, 13 5 -13 8
Heating, additional
...............................

... 95, 138
Heating, programmable


.......................... 95, 138
Hill start assist

............................................... 20

6
Horn ............................................................... 161
J
H
Fitting the mat ............................................... 11 9
Flap, fuel filler ............................... .................265
Flap, removable


............................................ 10 6
Flashing indicators


........................................ 148
Foglamp, rear
......................... 1

47, 310, 313, 315
Foglamps


...................................................... 304
Foglamps, front


.....................147, 152, 304, 309
Frequency (radio)


.................................. 3 9 5 , 4 51
Fuel .......................................................... 12, 267
Fuel consumption
...................................... 12

, 42
Fuel tank .......................................................... 20
Fusebox, engine compartment


.....................320
Fuses


............................................. 316, 317, 320
ga

uge, fuel .................................................... 265
ge

arbox, automatic

..............12, 14-16, 21, 199,
204, 206, 209, 218, 219, 233, 237, 282, 321
ge

arbox, electronic

....................12, 14-16, 202,
206, 214, 218, 219, 282
ge

arbox, manual

..................12, 14-16, 21, 206,
207, 218, 219, 233, 237, 282
gea

r lever
..............................
.........................12
gea

r lever, automatic gearbox
..................... 20

9
ge

ar lever, electronic gearbox

.....................282
ge

ar lever, manual gearbox

.........................207
ge

ar shift indicator

....................................... 208
gl

ove box ...................................................... 120
G
Alphabetical index

509
Key, electronic ..........47-50, 71, 74, 75, 199, 204
Keyless en try and Starting ................55, 59, 60,
63 - 65, 68, 70, 71, 74, 75, 202, 205
Key with remote control
...........50, 64, 199, 205
Kit, hands-free


.............406, 407, 462, 463, 497
Kit, temporary puncture repair


.............289, 290
Labels


...................................................... 11, 11 6
Labels, identification
..................................... 3

37
Ladder


........................................................... 272
Lane Departure Warning System (LDWS)


......................................... 29, 248, 249
Level, brake fluid

........................................... 2

79
Level, Diesel additive


............................280, 281
Level, engine coolant


..............................31, 279
Level, engine oil

...............................
.......34, 278
Level, headlamp wash


..........................15 8, 28 0
Level, power steering fluid

............................2

79
Levels and checks
................................ 27 7-2 8 0
Level, screenwash fluid
........................15 8, 28 0
Lighting
................

.................................... 3 0, 146
Lighting, cornering


........................................ 152
Lighting dimmer
..............................

................39
Lighting, guide-me home


..............................150
Lighting, welcome


......................................... 151
Loading


................................................... 12, 273Loading area fittings .....................................
12
2
Load reduction mode
....................................270
Load restraint


................................................12 2
Locating your vehicle
................................ 52

, 67
Locking


....................................50, 55, 57, 64, 71
Locking from the inside

.............................7

2, 73
Low fuel level
..........................................20, 265
Lumbar


..........................................................10 0
K
L
Maintenance, routine ...................................... 12
Markings, identification .................................337
Mat


........................................................ 11 9 , 2 0 2
Memorising a speed


..................................... 224
Menu


................... 352, 354, 356, 358, 360, 362,
370, 372, 374, 378, 384, 386, 388, 390, 392, 400, 402, 404, 412, 414, 416, 434, 440, 442,
444, 446, 448, 456, 458, 460, 468, 470, 472
Menu, main


................................................... 487
Menus (audio)


...................................... 345, 433
Messages
...............................

...............410 , 4 6 6
Messages, quick


................................... 411, 4 6 7
Mirror, rear view
............................................ 145
Mirrors, door ..................133, 134, 143, 144, 252
Mirror, vanity
..............................

...................11 9
Misfuel prevention
...............................

..........266
Moduwork ...................................................... 10 6
Mountings, Isofix


................................... 18 6, 19 0
MP3 CD
......................................................... 494
M
Navigation ............352, 354, 356, 358, 360, 362
Navigation, connected ..................370, 372, 374
Net, cargo...................................................... 10 6
Net, high load retaining


.................................123
Number plate lamps
.............................. 31

1, 314
oi

l change

..................................................... 278
oi

l consumption

............................................ 278
oi

l, engine
...............................
......................278
on

-board tools

...................................... 287, 289
op

ening the bonnet
...................................... 2

76
op

ening the boot
..............................
..47, 59, 94
op

ening
the doors
.................... 4

7, 59, 74, 78 - 81, 83, 93
op

ening to 90/180/235° ..................................92
N
O
.
Alphabetical index