2016 Peugeot Expert VU adblue

35
AdBlue® fluid range
indicators
once the AdBlue® tank is on reserve or after
detection of a fault with the SCR emissions
control system, when the ignition is switched
on, an indicator displays an estimate of the
distance that can be covered, the range, before
engine starting is prevented.
In the event of simultaneous system fault and
low AdBlue
® level, the shortest range figure is
the one displayed.
In the event of the risk of non-starting related to a lack of AdBlue®
the engine start prevention system
required by regulations is activated
automatically once the AdBlue
® tank is
e m pt y.
Remaining range greater than 1 500 miles (2 400 km )
Pressing this button will display the remaining
range.
F
t
hen
select "Diagnostic ".
Above 3 000 miles (5 000 km), the value is not
specified. When switching on the ignition, there is no
automatic display of range in the instrument
panel.
the

range is then displayed temporarily.
You can access this information in the touch
screen, if your vehicle has one.
F

Sel
ect the "Driving" menu.
Remaining range between 350 and 1500 miles (600 and 2 400 km)
When switching on the ignition, this warning
lamp comes on, accompanied by an audible
signal and the display of a message (e.g.
"
to

p-up emissions additive: Starting prevented
in 900 miles") indicating the remaining range
expressed in miles or kilometres.
F

Sel

ect " OPTIONS ".
For more information on AdBlue
® and
the SCR system , and in particular on
topping-up the AdBlue
®, refer to the
corresponding section.
If your vehicle has an LCD instrument panel,
"N
o

S
tA

R
t

IN" is displayed.
When driving, the message is displayed every
200 miles (300 km) until the fluid has been
topped-up.
go t

o a P
e

ugeot
dealer or a qualified
workshop to have the AdBlue
® topped-up.
You can also top-up the tank yourself.
1
Instruments

36
Remaining range between 0 and 350 miles (0 and 600 km)
When switching on the ignition, this warning
lamp flashes, accompanied by an audible
signal and the display of a message (e.g.
"
to
p-up emissions additive: Starting prevented
in 350 miles") indicating the remaining range
expressed in miles or kilometres. Breakdown related to a lack of AdBlue
®
When switching on the ignition, this
warning lamp flashes, accompanied
by an audible signal and the display
of the message "
to

p-up emissions
additive: Starting prevented".
to b

e able to start the engine,
we recommend that you call on a
P
e

ugeot dealer or a qualified
workshop for the top-up required.
If you carry out the top-up yourself, it
is essential to add at least 3.8 litres of
AdBlue
® to the tank.
For more information on AdBlue
® and
the SCR system , and in particular on
topping-up the AdBlue
®, refer to the
corresponding section.
If your vehicle has an LCD instrument panel,
"N
o

S
tA

R
t

IN" is displayed.
If your vehicle has an LCD instrument panel,
"N
o
S
tA
R
t
IN" is displayed.
When driving, the message is displayed every
30 seconds until the fluid has been topped-up.
go t

o a P
e

ugeot
dealer or a qualified
workshop to have the AdBlue
® topped-up.
You can also top-up the tank yourself.
ot

her wise you will not be able to restart your
engine.
th
e AdBlue
® tank is empty: the system required
by regulations prevents engine starting.
Instruments

283
AdBlue® and SCR system
for BlueHDi Diesel engines
to assure respect for the environment and
conformity with the new
eu ro 6 emissions
standard, without adversely affecting the
per formance or fuel consumption of Diesel
engines, P
e

ugeot has taken the decision to
equip its vehicles with an effective system that
associates SCR (Selective Catalytic Reduction)
with a particle filter (FAP) for the treatment of
exhaust gases.
Presentation of the SCR system
using a fluid called AdBlue® containing urea, a
catalytic converter turns up to 85% of nitrogen
oxides (N
ox

) into nitrogen and water, which are
harmless to health and the environment.
th
e AdBlue
® is held in a special tank with
a capacity of about 22 litres: this provides
a driving range of about 12 500 miles
(20

000

km), after which an alert is triggered
warning you when the reserve remaining is
enough for just 1 500 miles (2 400 km).
During each scheduled service of your vehicle
by a P
e

ugeot dealer or a qualified workshop,
the AdBlue
® tank is refilled in order to allow
normal operation of the SCR system.
on
ce the AdBlue
® tank is empty, a
s
ystem required by regulations prevents
starting of the engine.
If the SCR

is faulty, the level of
emissions from your vehicle will no
longer meet the
e
u
ro 6 standard: your
vehicle becomes polluting.
In the event of a confirmed fault
with the SCR system, you must go
to a P
e

ugeot
dealer or a qualified
workshop as soon as possible: after
a running distance of 650 miles
(1

100 km), a system will be triggered
automatically to prevent engine starting.
When filling the tank, the filling rate
must not exceed 40 litres per minute.
If the estimated mileage between two services
is greater than 12 500 miles (20 000 km), we
recommend that you go to a P
e

ugeot
dealer
or a qualified workshop to have the necessary
top-up carried out.
7
Practical information

284
Topping-up the AdBlue®
Filling the AdBlue® tank is an operation
included in every routine service on your
vehicle by a P
e

ugeot dealer or a qualified
workshop.
Nevertheless, given the capacity of the tank, it
may be necessary to top-up the fluid between
services, more particularly if an alert (warning
lamps and a message) signals the requirement.
You can go to a P
e

ugeot dealer or a qualified
workshop.
If you envisage topping-up yourself, please
read the following warnings carefully.
Precautions in use
Keep AdBlue® out of the reach of
children, in its original bottle.
Never transfer AdBlue
® to another
container: it would lose its purity.
us
e only AdBlue
® fluid that meets the
IS
o
22241 standard.
Never dilute AdBlue
® with water.
Never pour AdBlue® into the Diesel fuel
tank.
th

e supply in a non-drip bottle simplifies
topping-up. You can obtain 1.89 litre (half a
u
S
g

allon) bottles from a P
e

ugeot dealer or a
qualified workshop.
Never top-up from an AdBlue
®
dispenser reserved for heavy goods
vehicles.
AdBlue
® is a urea-based solution. th
is liquid is
non-flammable, colourless and odourless (kept
in a cool area).
In the event of contact with the skin, wash
the affected area with soap and water. In the
event of contact with the eyes, wash (irrigate)
the eyes with large amounts of water or with
an eye wash solution for at least 15 minutes.
If a burning sensation or irritation persists, get
medical attention.
If swallowed, immediately wash out the mouth
with clean water and then drink plenty of water.
In certain conditions (high ambient
temperature, for example), the risk of release of
ammonia cannot be excluded: do not inhale the
fluid. Ammonia vapour has an irritant effect on
mucous membranes (eyes, nose and throat).
Important
If your vehicle's AdBlue
® tank is
c
ompletely empty (which is confirmed
by the alert messages and the
impossibility of starting the engine)
you must add at least 3.8 litres (so
two

1.89

litre bottles).
Practical information

285
Recommendations on storage
Never store bottles of AdBlue® in your
vehicle.
AdBlue
® freezes at about -11°C and
deteriorates above 25°C. It is recommended
that bottles be stored in a cool area and
protected from direct sunlight.
un

der these conditions, the fluid can be kept
for at least a year.
If the additive has frozen, it can be used once it
has completely thawed out.
Procedure
Before starting the top-up procedure, ensure
that the vehicle is parked on a flat and level
sur face.
F

S
witch off the ignition and remove the
key, or if your vehicle has one, press the
S
tA

R
t/
S
t
o
P b
utton to switch off the
engine.
F

F
or access to the AdBlue
® tank, open the
left-hand front door.
F

F

rom below, pull the black cover. F
t
u
rn the blue cap a 6
th of a turn anti-
clockwise.
F

L

ift off the cap.
Do not dispose of AdBlue
® bottles in
the household waste. Place them in a
container provided for this purpose or
take them to your dealer.
In wintry conditions, ensure that
the temperature of the vehicle is
above

-11°C.
o
t

her wise the AdBlue
®
may be frozen and so cannot be poured
into its tank. Park your vehicle in a
warmer area for a few hours to allow the
top-up to be carried out.
7
Practical information

286
F After emptying the bottle, wipe away any spillage around the tank filler using a damp
cloth. If any additive is split or splashed, wash
immediately with cold water or wipe with
a damp cloth.
If the additive has crystallised, clean it
off using a sponge and hot water.
F
R
efit the blue cap to the tank and turn it
a 6
th of a turn clockwise, to its stop.Important: when topping-up after
running out of additive
, signalled
by the message "
to
p up emissions
additive: Starting prevented", you
must wait for about 5 minutes before
switching the ignition on again, without
opening the driver's door, unlocking
the vehicle, introducing the remote
control key into the ignition switch,
or placing the electronic key of the
"Keyless Entr y and Star ting" system
inside the vehicle .
Switch on the ignition, then wait for
10


seconds before starting the engine.
F
o
b

tain a bottle of AdBlue
®. After first
checking the use-by date, read carefully
the instructions on use on the label before
pouring the contents of the bottle into your
vehicle's AdBlue
® tank.
Freezing of the AdBlue
®
AdBlue® freezes at temperatures below
around -11°C.
th

e SCR system includes a heater
for the AdBlue
® tank, allowing you to
continue driving in very cold conditions. F
R efit the black cover, starting at the top.
F

C
lose the door.
Practical information

506
180° rear vision .............................................25 9
ABS
........
....................................................... 161
Accessories


.................................. 203, 271, 272
Access to the spare wheel
............................297
Active Safety Brake......................... 23, 243-247
AdBlue
® additive .................. 26, 35 -37, 283 -285
Additive, Diesel ..................................... 280, 281
Adjusting headlamp beam height
................. 15

5
Adjusting head restraints


......................103, 104
Adjusting the seat


................................... 99, 102
Adjusting the air distribution


.........................128
Adjusting the air flow


..................................... 128
Adjusting the date


........................... 46, 420, 476
Adjusting the height and reach of the steering wheel


.................................... 99
Adjusting the lumbar support


........................................................ 10 0
Adjusting the seat belt height
...............

........................................... 166
Adjusting the temperature
............................ 12

8
Adjusting the time


........................... 46, 421, 477
Advice on driving


.................................. 19 6 -198
Airbags


............................................ 24, 170, 17 7
Airbags, curtain
............................................. 17

3
Airbags, front ......................................... 171, 173
Airbags, lateral


...................................... 172 , 173
Air conditioning


............... 12, 127, 129, 130, 137
Air conditioning, automatic


...........................13 5Air conditioning, digital


.........................
132, 13 6
Air conditioning, dual-zone automatic

..........
128
Air conditioning, manual

.......
126, 132, 13 5, 13 6
Air intake

...............................
125, 126, 128, 131
Alarm

...............................................................
95
Alarm, volumetric

............................................
95
Anti-lock braking system (ABS)
..............................................
16
1
Anti-slip regulation (ASR)

.............................
161
Anti-theft

...........................................
52, 67, 205
Area, loading
...............................
........
47, 55, 73
Armrest, front ................................................
103
Assistance call

......................................
160, 338
Audio streaming (Bluetooth)
........ 3
98, 454, 495
Audio system (radio) ...............
89, 150 -152, 15 8,
226, 245, 247, 250, 256, 264, 483
Auxiliary ...............................................
398, 454
A
B
C
Battery .................................... 270, 281, 321-325
Battery capacity ............................... .............325
Battery, charging


........................................... 323
Battery, remote control
............... 5

4, 70, 71, 139
Bench seat, one-piece, fixed


............................................................ 11 0
Blind spot monitoring system
................................................. 252, 254
Blinds, side


.................................................... 123
BlueHDi


..................................... 31, 35, 208, 283Bluetooth
(hands-free)
............... 4
06, 407, 462, 463, 497
Bluetooth (telephone)

............
406-408, 462-464
Bonnet

...........................................................
276
Brake discs
.................................................... 28
2
Brake lamps
........................... 3
10, 311, 313 - 315
Brakes

...............................................
18, 22, 282
Bulbs (changing)
................... 3
03, 304, 310, 313
Cable, audio

.........................................
398, 454
Cable, jack

...........................................
398, 454
Capacity, fuel tank
..............................
..........
265
Cap, fuel filler ................................................
265
CarPlay connection ..............................386, 442
CD, MP3
....................................... 3
98, 454, 494
Central locking ..........................................
59, 64
Changing a bulb .....3 03, 3 0 4, 310, 311, 313 - 315
Changing a bulb (boot lid)
.............................313
Changing a bulb (side-hinged doors)
.................................... 3

10
Changing a fuse


............................316, 317, 320
Changing a wheel


.........................................296
Changing a wiper blade


........................15 9 , 2 74
Changing the remote control battery
..................................................... 5

4, 70
Checking the engine oil level


..........................34
Alphabetical index

508
I
Identification, vehicle ....................................3 37
Ignition ................ ...................201, 203, 410, 466
Immobiliser, electronic


................52, 67, 71, 205
Indicator, AdBlue
® range ................................. 35
Indicator, coolant temperature ........................ 3
1
Indicator, engine oil level
................................ 34
Indicator lamps, operation


.............................. 17
Indicators, direction


...................................... 148
Inflating tyres


.................................................. 12
Inflating tyres and accessories (using the kit)
..............................

................290
Instrument panel
...............................

.........14 -16
Instrument panel, LCD
........................ 14, 3 5 - 37
Instrument panel, LCD text
............................. 15
Instrument panel, matrix
................................. 16
Intelligent
t
ra

ction Control
............................ 16

2
IS
oFI

X


.................................................. 187, 190
g.

P. S .


............................................................
366
gr

ip control

...................................................
16 4gu
ide-me-home
............................................
150
Jack
........

.............................. 122, 296, 398, 454
Hazard warning lamps


.......................... 160, 287
Headlamp adjustment


................................... 155
Headlamp beam height


................................. 155
Headlamp dipping, automatic


....................... 15 4
Headlamps, automatic dipping


............... 29, 153
Headlamps, automatic illumination


.................................. 146, 149, 15 0
Headlamps, dipped beam


................ 29, 146, 304, 306, 308
Headlamps, halogen


............................ 304, 306
Headlamps, main beam
................... 2

9, 146, 304, 307, 308
Headlamps, Xenon


.............................. 304, 308
Headlamp wash


............................................ 15 8
Head restraints, front

............................ 103, 104
Head-up display


........................... 222, 223, 244
Heated bench seat
........................................ 10

5
Heating


............................. 12, 125, 126, 13 5 -13 8
Heating, additional
...............................

... 95, 138
Heating, programmable


.......................... 95, 138
Hill start assist

............................................... 20

6
Horn ............................................................... 161
J
H
Fitting the mat ............................................... 11 9
Flap, fuel filler ............................... .................265
Flap, removable


............................................ 10 6
Flashing indicators


........................................ 148
Foglamp, rear
......................... 1

47, 310, 313, 315
Foglamps


...................................................... 304
Foglamps, front


.....................147, 152, 304, 309
Frequency (radio)


.................................. 3 9 5 , 4 51
Fuel .......................................................... 12, 267
Fuel consumption
...................................... 12

, 42
Fuel tank .......................................................... 20
Fusebox, engine compartment


.....................320
Fuses


............................................. 316, 317, 320
ga

uge, fuel .................................................... 265
ge

arbox, automatic

..............12, 14-16, 21, 199,
204, 206, 209, 218, 219, 233, 237, 282, 321
ge

arbox, electronic

....................12, 14-16, 202,
206, 214, 218, 219, 282
ge

arbox, manual

..................12, 14-16, 21, 206,
207, 218, 219, 233, 237, 282
gea

r lever
..............................
.........................12
gea

r lever, automatic gearbox
..................... 20

9
ge

ar lever, electronic gearbox

.....................282
ge

ar lever, manual gearbox

.........................207
ge

ar shift indicator

....................................... 208
gl

ove box ...................................................... 120
G
Alphabetical index