2016 Peugeot 508 Hybrid engine

42
In the event of a breakdown
508HY-comp _en_Chap08_en-cas-de-pannes_ed01-2016
R e f i t t i n g
To refit the battery, carry out the removal operations in reverse order and connect the positive (+) terminal last.
After refitting
 Check that the battery terminals are secure.  Switch on the ignition, without starting the engine.  Check that there are no error messages or warning lamps on. If there is any problem, contact a PEUGEOT dealer or a qualified
workshop to have the system reset.  Check the correct operation of all openings: doors, boot and windows.  After refitting, wait for about 2 minutes.  Start the engine.
 Check the correct operation of the anti-pinch systems: electric windows and panoramic sunroof.  Check the correct operation of the electric parking brake by releasing and applying it again.  Switch off the ignition.  Get out of the vehicle and check the operation of the remote control.  Set: the time, the radio preset stations and the audio settings.
After reconnecting the battery, certain functions may be temporarily
unavailable: air conditioning, navigation.
In all cases, if there is a problem, contact a PEUGEOT dealer or a
qualified workshop.

44
Technical data
508HY-comp _en_Chap09_caracteristiques-techniques_ed01-2016
* The maximum power corresponds to the value type approved on an engine test bed, under conditions defined by European legislation (directive 1999/99/EC).

Diesel engine and gearbox
Diesel engine2.0 litre HDi 163 hp
Gearbox E T G 6 e l e c t r o n i c ( 6 - s p e e d )
Cubic capacity (cc) 1 9 9 7
Bore x stroke (mm) 85 x 88
Max power: EU standard (kW) * 120
Max power engine speed (rpm) 3 850
Max torque: EU standard (Nm) 300
Max torque engine speed (rpm) 1 750
Fuel Diesel
Catalytic converter Ye s
Particle filter Ye s
Engine oil capacity in litres (with filter replacement) 5.0

45
9
Technical data
508HY-comp _en_Chap09_caracteristiques-techniques_ed01-2016
* The kerb weight is equal to the unladen weight + driver (75 kg). ** The weight of the braked trailer can be increased, within the GTW limit, if the GV W of the towing vehicle is reduced by an equal amount; warning, towing using a lightly loaded towing vehicle may have an adverse effect on its road holding.
The GTW and towed load values indicated are valid up to a maximum altitude of 1000 metres; the towed load mentioned must be reduced by 10 % for each additional 1000 metres of altitude. The maximum authorised speed is reduced when towing (comply with the legislation in force in your country). High ambient temperatures may result in a reduction in the per formance of the vehicle to protect the engine; if the ambient temperature is above 37 °C, limit the towed load.
Weights and towed loads (in kg)
VersionDiesel HYbrid4
GearboxETG6 electronic ( 6 - s p e e d )
Model code: 8U...RHCM/P
- Unladen weight 1 770
- Kerb weight * 1 845
- Gross vehicle weight (GV W) 2 325
- Gross train weight (GTW) on a 12% gradient 3 125
- Braked trailer (within GTW limit) on a 10% or 12% gradient 800
- Braked trailer ** (with load transfer with the GTW limit) 1 100
- Unbraked trailer 750
- Recommended nose weight 75

48
Frequently asked questions
508HY-comp_en_Chap13_questions_ed01-2016
Frequently asked questions
100% electric mode (zero emissions)
QuestionAnswer
Why is it not always possible for me to select ZEV (Zero Emissions Vehicle) mode even though the battery seems well charged?
This situation is temporary. Certain conditions will occasionally prevent the change to ZEV mode, even if the battery has sufficient charge, such as, for example, very cold conditions, altitude, demisting, high demand for
heating or air conditioning, regeneration of the particle filter (FAP).
Why do I sometimes see an alert message " Electric mode not available: FAP regeneration in progress" ?
This is a message which indicates that regeneration of the particle filter (FAP) is in progress. This is a completely normal process that takes place every 240 or 300 miles (400 or 500 km) (or more frequently in prolonged urban use), as on a conventional HDi Diesel vehicle. In the case of a conventional HDi Diesel vehicle, this process is not generally noticed by the driver. On the other hand, in the case of HYbrid4 this phenomenon may be noticeable (in urban use) as temporarily the HDi engine will not stop and this message will be displayed at intervals while regeneration is in progress.
Why is it not possible for me to put the vehicle into ZEV mode, even though I had just been running electrically in AUTO mo de?
The management of ZEV is different from AUTO mode. Changing to ZEV mode is only possible with a battery charge of at least 4 bars, in order to assure sufficient range. In AUTO mode, the system alone manages the conditions for changing temporarily to electric mode, for shorter periods and with a lower state of charge of the battery.
Why is the range in ZEV mode lower when going uphill? The vehicle needs more energy when going uphill than when running on the level. So it is better to stay in AUTO mode, which will favour operation of the HDi Diesel engine.
Why is it that the system makes me come out of ZEV mode; it does not return to ZEV mode automatically when the conditions allow?
It is not intended to give preference to ZEV running at any cost, as it is not always the most economical mode. So the system returns automatically to AUTO mode.

50
Frequently asked questions
508HY-comp_en_Chap13_questions_ed01-2016
Air conditioning / Heating
QuestionAnswer
It seems to me that the vehicle runs less on electric when the heating or air conditioning is operating, is that right?
The demand for heating or air conditioning may require the starting of the HDi Diesel engine until the desired level of comfort is attained. Normal operation of the HYbrid4 system is simply put back. The period can be longer under very low or very high ambient temperatures.
It seems to me that when it is very hot and the air conditioning is working, the vehicle runs on electric for shorter periods. Is that right?
When it is hot, the periods when the HDi Diesel engine is put on standby and the vehicle runs on electric are necessarily restricted in order to limit the difference between the temperature in the vehicle and the level of comfort selected. In very hot weather, it is possible to press the " ECO OFF " button (which brings the vehicle out of ZEV mode and prevents electric running or the stopping of the engine) to give preference to temperature control (keeps the air conditioning running).
M i s c e l l a n e o u s
QuestionAnswer
Is towing possible with my HYbrid4 vehicle? For information on the towing ability of your HYbrid4 vehicle, refer to " Weights and towed loads" in the "Technical data" section. This allows a jet ski or two-wheeler on a trailer to be towed, for example. This limit is related to maintaining adequate cooling capacity for the HDi Diesel engine as well as the components of the HYbrid4 system that are also cooled by the engine's cooling system.
Why does engine braking seem so strong? If the high voltage battery is not fully charged, the engine braking results mainly from the energy recovery by the electric motor. The power of this engine braking is higher than that of an internal combustion engine.

51
.
Alphabetical index
508HY-comp_en_Chap14_index-alpha_ed01-2016
Accessory position .........................................16Advice on driving ............................................22Air conditioning .........................................21, 24
Battery, 12 V ................................................5, 39Battery, high voltage .......................5, 26 -28, 43
Cable, high voltage .........................................27Car wash .........................................................35Cooling, high voltage battery ..........................28
Demisting/defrosting .......................................24Dimensions .....................................................46Display screen, instrument panel ...........7, 9, 12Driving economically.......................................23
Filter, particle ..............................................5, 25Fittings, boot ...................................................30Flat bed (recovery) ..........................................38Four-wheel drive (4WD) ......................18, 22, 36Fuel consumption ..................................8, 11, 23
AE
B
C
D
F
Gearbox, electronic ...................5, 14, 22-24, 31Gear lever, electronic gearbox .......................31Ground clearance ...........................................46
Head-up display ..............................................15Heating ......................................................21, 24High voltage ..............................................26, 27Histogramme, fuel consumption .....................11
G
H
Ignition on........................................................16Ignition switch .................................................14Instrument panel ...............................................7
I
Key, electronic ...........................................14, 18Keyless Entry and Starting .................14, 16, 18Key not recognised .........................................18Key with remote control ..................................14Kit, temporary puncture repair ........................Kit, temporary puncture repair ........................Kit, temporary puncture repair37
K
Eco-driving .....................................................23ECO OFF (switch) ...........................................21Electric running (ZEV) ............10, 18, 21, 23, 24Emergency switching off .................................Emergency switching off .................................Emergency switching off17Energy flows ...............................................9, 10Energy recovery ....................................8, 10, 23Engine compartment ......................................29Engine, Diesel .....................5, 18, 21, 24, 35, 44Environment ....................................................23

52
Alphabetical index
508HY-comp_en_Chap14_index-alpha_ed01-2016
Opening the bonnet ........................................29
READY lamp .....................................7, 8, 27, 29Recovery of the vehicle ..................................38Regeneration of the particle filter ...............Regeneration of the particle filter ...............Regeneration of the particle filter5, 25Removing the battery......................................39Reset histogram ..............................................11Reset trip ...................................................12, 13
Screen, colour .................................................Screen, colour .................................................Screen, colour47Selector, gear ............................................Selector, gear ............................................Selector, gear31, 3 5Snow chains ....................................................36Socket, 12 volt accessory ...............................30Speedometer ....................................................Speedometer ....................................................Speedometer7Starting the HYbrid4 system...........................14State of charge, battery ....................5, 9, 24, 26Storage wells ..................................................30Stowing rings ..................................................30Switching off the HYbrid4 system ............14, 18
Parking brake, electric ........................15, 22, 35Power indicator .............................................Power indicator .............................................Power indicator7, 8Puncture ..........................................................37
O
R
S
P
V
W
T
Washing (advice).............................................35Weights ...........................................................45
Table of weights ..............................................45Table of engine and motor data ................43-45Technical data ...........................................43, 46To o l s ..........................................................3 7, 3 8Touch screen...................................9, 11, 13, 47Touch screen (Menus) ....................................47Towed loads ....................................................45Towing eye ......................................................38Trip computer .............................................Trip computer .............................................Trip computer11 -13Ty r e s ................................................................37
Menus (Touch screen) ....................................47Mode selector .......................................Mode selector .......................................Mode selector6, 18, 23Motor, electric .............................................5, 43
M
Ventilation, high voltage battery .....................28