2016 Peugeot 301 oil filter

9
Limit the causes of excess consumption
Spread loads throughout the vehicle; place the heaviest items in the
bottom of the boot, as close as possible to the rear seats.
Limit the loads carried in the vehicle and reduce wind resistance (roof
bars, roof rack, bicycle carrier, trailer...). Use a roof box in preference.
Remove roof bars and roof racks after use.
At the end of winter, remove snow tyres and refit your summer tyres.
Observe the recommendations on maintenance
Check the tyre pressures regularly, when cold, referring to the label in
the door aperture, driver's side.
Carry out this check in particular:
-
b
efore a long journey,
-

a
t each change of season,
-

a
fter a long period out of use.
Don't forget the spare wheel and the tyres on any trailer or caravan.
Have your vehicle serviced regularly (engine oil, oil filter, air filter...) and
observe the schedule of operations recommended by the manufacturer.
When refuelling, do not continue after the 3
rd cut-off of the nozzle to
avoid any over flow.
At the wheel of your new vehicle, it is only after the first 1 800 miles
(3

000 kilometres) that you will see the fuel consumption settle down to
a consistent average.
.
Eco-driving

16
Warning lamps
When the engine is running or the vehicle is being driven, illumination of one of the following warning lamps indicates a fault which requires action on
the part of the driver.
Any fault resulting in the illumination of a warning lamp must be investigated further by reading the associated message in the screen.
If you encounter any problems, contact a PEUGEOT dealer or a qualified workshop.Warning


/ indicator lamp State Cause Action


/ Observations
STOP fixed, associated with
another warning lamp. It is associated with the engine
oil pressure or the engine coolant
temperature. Stop as soon as it is safe to do so.
Park, switch off the ignition and call a PEUGEOT
dealer or qualified workshop.
Service on temporarily. Minor faults have occurred for which
there is no specific warning lamp. Identify the fault by reading the message shown in the
screen, such as, for example:
-

s
aturation of the particle emissions filter (Diesel),
-
t

he power steering,
-

a m
inor electrical fault,
-


...
For any other faults, contact a PEUGEOT dealer or
a


qualified workshop.
fixed. Major faults have occurred for which
there is no specific warning lamp. Identify the fault by reading the message shown in
the screen and then contact a PEUGEOT dealer or
qualified workshop.
Monitoring

185
301_en_Chap10_verifications_ed01-2016
Coolant level
The coolant level should be close
to the "MA X" mark but should never
exceed it.
In addition, as the cooling system is
pressurised, wait at least one hour after
switching off the engine before carrying out any
work.
To avoid any risk of scalding, unscrew the cap
by two turns to allow the pressure to drop.
When the pressure has dropped, remove the
cap and top up the level.
Changing the coolant
The coolant does not have to be replaced at
routine services.
Fluid specification
The coolant must conform to the
manufacturer's recommendations. When the engine is warm, the temperature of
the coolant is regulated by the fan.
The cooling fan may star t after switching
off the engine: take care with ar ticles and
clothing that might be caught by the fan
blades.
Fluid specification
For optimum cleaning and to avoid freezing,
this fluid must not be topped up or replaced
with plain water.
In wintry conditions, it is recommended that you
use an ethyl alcohol or methanol based fluid.
Screenwash fluid level
Top up the level when necessary.
To p p i n g u p
This additive must be topped up by a
PEUGEOT dealer or a qualified workshop
without delay.
Diesel additive level (Diesel
engine with particle filter)
A low additive level is indicated by illumination
of the service warning lamp, accompanied
by an audible warning and a message in the
screen (if a display screen is fitted). Avoid prolonged contact of used oil or
fluids with the skin.
Most of these fluids are harmful to
health or indeed very corrosive.
Do not discard used oil or fluids into
sewers or onto the ground.
Take used oil to a PEUGEOT dealer or
a qualified workshop (France) or to an
authorised waste disposal site.
Used products
10
Checks

186
301_en_Chap10_verifications_ed01-2016
Checks
12 V battery
The battery does not require any
maintenance.
However, check regularly that the terminals are
correctly tightened (versions without quick release
terminals) and that the connections are clean.
Particle filter (Diesel)
The start of saturation of the
particle filter is indicated by
the fixed illumination of this warning lamp
accompanied by a warning message in the
screen (if a display screen is fitted).
As soon as the traffic conditions permit,
regenerate the filter by driving at a speed of at
least 40 mph (60 km/h) until the warning lamp
goes off.
If the warning lamp stays on, this indicates a
low additive level.
On a new vehicle, the first particle
filter regeneration operations may be
accompanied by a "burnt" smell, which
is perfectly normal.
Following prolonged operation of the
vehicle at very low speed or at idle,
you may, in exceptional circumstances,
notice the emission of water vapour at
the exhaust on acceleration. This does
not affect the behaviour of the vehicle
or the environment.
Unless otherwise indicated, check these components in accordance with the manufacturer's service schedule and according to your engine.
Other wise, have them checked by a PEUGEOT dealer or a qualified workshop.
Air filter and passenger compartment filter
Refer to the manufacturer's
service schedule for details of the
replacement intervals for these
components.
Oil filter
Replace the oil filter each time the
engine oil is changed.
Refer to the manufacturer's
service schedule for details of
the replacement interval for this
component.
When carrying out any operation on the 12 V
battery, refer to the corresponding section for
details of the precautions to be taken before
starting work.
Depending on the environment (e.g. dusty
atmosphere) and the use of the vehicle (e.g.
city driving), replace them twice as often if
necessary
.
A clogged passenger compartment filter may
have an adverse effect on the per formance
of the air conditioning system and generate
undesirable odours.
Checks

188
301_en_Chap11_caracteristiques-techniques_ed01-2016
EnginePureTech 72 PureTech
82 PureTech
82 S&S V T i 115
Gearbox Manual
(5-speed) ETG
electronic (5-speed) Manual
(5-speed) ETG
electronic (5-speed) Manual
(5-speed) Automatic
(4-speed) E AT 6
automatic (6-speed)
Model code: DD... HMY0 HMY0/PHMZ6HMZ6/PS NFP0
NFP6NFP9 NFPT
Cubic capacity (cc) 1 19 91 19 9 1 19 9 1 587
Bore x stroke (mm) 75 x 90.575 x 90.5 75 x 90.5 78.5 x 82
Max power: EU standard (kW)* 536060 85
Max power engine speed (rpm) 5 5005 750 5 750 6 050
Max torque: EU standard (Nm) 11 0118 118 150
Max torque engine speed (rpm) 3 0002 750 2 750 4 000
Fuel Unleaded 91 RON to
98
RONUnleaded
91 RON to 98 RON Unleaded
91 RON to 98 RON Unleaded 91 RON to 98 RON
Catalytic converter yesyes yes yes
Engine oil capacity in litres
(with filter replacement) 3.25
3.25 3.25 3.5
Petrol engines
* The maximum power corresponds to the value type approved on a test bed, under conditions defined by European legislation (Directive 1999/99/EC).
Technical data

190
301_en_Chap11_caracteristiques-techniques_ed01-2016
EngineHDi 92BlueHDi 100
Gearbox Manual (5-speed)Manual (5-speed)
Model code: DD... 9HJC9HP0BHY6
Cubic capacity (cc) 1 5601 560
Bore x stroke (mm) 75 x 88.375 x 88.3
Max power: EU standard (kW)* 6873
Max power engine speed (rpm) 4 0003 750
Max torque: EU standard (Nm) 230254
Max torque engine speed (rpm) 1 7501 750
Fuel DieselDiesel
Catalytic converter yesyes
Particle filter noyes yes
Engine oil capcity in litres
(with filter replacement) 3.75
3.75
Diesel engines
* The maximum power corresponds to the value type approved on a test bed, under conditions defined by European legislation (Directive 1999/99/EC).
Technical data

246
301_en_Chap13_recherche-visuelle_ed01-2016
Maintenance - Technical data
Petrol weights 189
Diesel weights 1 91
Changing bulbs
1

53-158
-

front
-

rear Running out of fuel, Diesel

1

32
AdBlue
® additive and SCR system
(BlueH D i D iesel) 13 3 -13 9
Opening the bonnet

1
80
Under the bonnet, petrol

1
81
Under the bonnet, Diesel

1
82
Petrol engines

1
88
Diesel engines
1

90Batter y


16 4 -167
Load reduction, economy mode
1

68
Engine compartment fuses
1

59 -160, 163
Checking levels
18

3 -185
-

oil
-

b

rake fluid
-


coolant
-

s

creenwash fluid
-

a

dditive (Diesel with particle filter)
Checking components

1

86 -187
-


battery
-
a

ir / passenger compartment filter
-

o

il filter
-

p

article filter (Diesel)
-

b

rake pads / discs
Identification markings
1

93
Dimensions


192
Visual search

248
301_en_Chap14_index-alpha_ed01-2016
Ignition ............................................................. 66
Immobiliser, electronic ..............................36, 64
Indicator lamps, operation


........................11, 15
I
Dials and gauges ............................................ 10
Diesel ............................................................ 131
Dimensions


................................................... 192
Dipstick
................

.......................................... 183
Direction indicators


.......................10 0, 15 4, 157
Display screen, instrument panel


.............10, 81
Display screen, multifunction (with audio syste m) .......................................................... 29
Door pockets
................................................... 58
D

oors

............................................................... 39
Driving conomically


........................................... 8
Eco-driving
....................................................... 8
Eco-driving (advice)


.......................................... 8
Economy mode


............................................. 168
Electronic brake force distribution (EBFD)


..................................... 105
Emergency braking assistance (EBA)
.......... 10

5
Emergency braking system


..........................105
Emergency warning lamps
........................... 10

0
Emissions control system, SCR
.....................22
Energy economy mode


.................................168
Engine compartment


............................181, 182
Engine, Diesel
......... 1

3, 131, 132, 182, 190, 191
Engine, petrol


................................ 131, 181, 18 8
Engines


......................................... 188, 19 0, 191
Environment
...............................

.................8, 36
ESP/ASR


....................................................... 10 6Gauge, fuel
.................................................... 129
Gearbox, automatic


..................73, 77, 164, 187
Gearbox, electronic


..................69, 82, 164, 187
Gearbox, manual


....................................68, 187
Gear lever
..............................

...........................8
Gear lever, automatic gearbox


........................................73
Gear lever, electronic gearbox


......................................187Hazard warning lamps


..................................10 0
Hazard warning lamps, automatic operation


....................................10 0
Headlamp adjustment


.....................................96
Headlamps


......................................................91
Headlamps, dipped beam


.......................91, 15 5
Headlamps, halogen
..................................... 15

3
Headlamps, main beam
.......................... 9

1, 15 4
Head restraints, front
......................................44
Heating


..................................................8, 51, 53
Horn ............................................................... 10 0
E
F
G
H
Filling the fuel tank .................................1 2 9 -131
Filter, air ............... ......................................... 18 6
Filter, oil


......................................................... 18 6
Filter, particle


........................................ 185, 18 6
Filter, passenger compartment


.....................18 6
Fitting a wheel

...............................
................148
Fitting roof bars


............................................. 178
Fittings, boot
................................................... 61
F

ittings, interior

......................................... 58, 59
Flap, fuel filler

...............................
.........12 9, 13 0
Flashing indicators


................................ 10 0, 15 4
Foglamp, rear
...............................

...........93, 157
Foglamps, front


....................................... 93, 15 6
Fuel ............................................................ 8, 131
Fuel consumption
.............................................. 8
Fu

el tank ........................................................ 13 0
Fusebox, dashboard


..................................... 159
Fusebox, engine compartment


.....................159
Fuses


............................................................. 159Gear lever, manual gearbox
...........................68
Gear shift indicator
.........................................81
Glove box
........................................................59
Alphabetical index