2016 MAZDA MX5 MIATA transmission

7–27
If Trouble Arises
Overheating
Overheating
If the high engine coolant temperature
warning light illuminates, the vehicle loses
power, or you hear a loud knocking or
pinging noise, the engine is probably too
hot.
WARNING
Pull over to a safe location, then
switch the ignition off and make sure
the fan is not running before attempting
to work near the cooling fan:Working near the cooling fan when it
is running is dangerous. The fan could
continue running indefinitely even if
the engine has stopped and the engine
compartment temperature is high. You
could be hit by the fan and seriously
injured.
Do not remove either cooling
system cap when the engine and
radiator are hot:When the engine and radiator are hot,
scalding coolant and steam may shoot
out under pressure and cause serious
injury.
Open the hood ONLY after steam is no
longer escaping from the engine: Steam from an overheated engine is
dangerous. The escaping steam could
seriously burn you.
If the high engine coolant temperature
warning light illuminates:
1. Drive safely to the side of the road and
park off the right-of-way.
2. Put a vehicle with an automatic
transmission in park (P), a manual
transmission in neutral.
3. Apply the parking brake.
4. Turn off the air conditioner.
5. Check whether coolant or steam is
escaping from the engine compartment.

If steam is coming from the engine
compartment:
Do not go near the front of the vehicle.
Stop the engine.
Wait until the steam dissipates, then
open the hood and start the engine.

If neither coolant nor steam is
escaping:
Open the hood and idle the engine until
it cools.
CAUTION
If the cooling fan does not operate
while the engine is running, the engine
temperature will increase. Stop the
engine and call an Authorized Mazda
Dealer.
6. Make sure the cooling fan is operating,
then turn off the engine after the
temperature has decreased.
7. When cool, check the coolant level.
If it is low , look for coolant leaks from
the radiator and hoses.
MX-5_8EU4-EA-15D_Edition4.indb 272016/01/20 11:07:48

7–30
If Trouble Arises
Emergency Towing
Towing Description
We recommend that towing be done only
by an Authorized Mazda Dealer or a
commercial tow-truck service.
Proper lifting and towing are necessary
to prevent damage to the vehicle.
Government and local laws must be
followed.
A towed vehicle usually should have its
drive wheels (rear wheels) off the ground.
If excessive damage or other conditions
prevent this, use wheel dollies.
Wheel dollies
When towing with the rear wheels on the
ground, release the parking brake.
CAUTION
 Do not tow the vehicle pointed
backward with driving wheels on the
ground. This may cause internal damage
to the transmission.
 Do not tow with sling-type equipment.
This could damage your vehicle. Use
wheel-lift or flatbed equipment.
MX-5_8EU4-EA-15D_Edition3.indb 302015/10/21 16:55:54

7–36
If Trouble Arises
Warning/Indicator Lights and Warning Sounds
*Some models.
SignalWarning
Electric Vacuum Pump Warning
Light The light turns on if the electric vacuum pump system has a problem. Hav\
e your vehicle
inspected at an Authorized Mazda Dealer.
ABS Warning Light
If the ABS warning light stays on while you're driving, the ABS control unit has detected a
system malfunction. If this occurs, your brakes will function normally a\
s if the vehicle had
no ABS.
Should this happen, consult an Authorized Mazda Dealer as soon as possible.
NOTE
When the engine is jump-started to charge the battery, uneven rpm occurs and the ABS
warning light may illuminate. If this occurs, it is the result of the weak battery and does
not indicate an ABS malfunction.
Recharge the battery.
The brake assist system does not operate while the ABS warning light is illuminated.
Check Engine Light
If this light illuminates while driving, the vehicle may have a problem.\
It is important to
note the driving conditions when the light illuminated and consult an Authorized Mazda
Dealer.
The check engine light may illuminate in the following cases:
The fuel tank level being very low or approaching empty.The engine's electrical system has a problem.The emission control system has a problem.The fuel-filler cap is missing or not tightened securely.
If the check engine light remains on, or it flashes continuously , do not drive at high speeds
and consult an Authorized Mazda Dealer as soon as possible.
Automatic
Transmission
Warning Light
*
The light illuminates when the transmission has a problem.
CAUTION
If the automatic transmission warning light illuminates, the transmission has an electrical problem. Continuing to drive your Mazda in this condition could cause
damage to your transmission. Consult an Authorized Mazda Dealer as soon as possible.
Air Bag/Seat Belt Pretensioner System Warning Light A system malfunction is indicated if the warning light constantly flashes, constantly
illuminates or does not illuminate at all when the ignition is switched \
ON. If any of these
occur, consult an Authorized Mazda Dealer as soon as possible. The system may not operate
in an accident.
WARNING
Never tamper with the air bag/pretensioner systems and always have an Authorized Mazda Dealer perform all servicing and repairs:
Self-servicing or tampering with the systems is dangerous. An air bag/pretensioner
could accidentally activate or become disabled causing serious injury or death.
MX-5_8EU4-EA-15D_Edition3.indb 362015/10/21 16:55:58

8–40
Customer Information and Reporting Safety Defects
Tire Information (U.S.A.)
SAMPLE
WARNING
Never Exceed Axle Weight Rating Limits:
Exceeding the Safety Certification Label axle weight rating limits is dangerous and could
result in death or serious injury as a result of substandard vehicle handling, performance,
engine, transmission and/or structural damage, serious damage to the vehicle, or loss of
control.
Always keep the vehicle within the axle weight rating limits.
GCW
MX-5_8EU4-EA-15D_Edition3.indb 402015/10/21 16:56:14

9–4
Specifications
Specifications
Specifications
Engine
ItemSpecification
Type DOHC-16V in-line, 4-cylinder
Bore × Stroke 83.5 × 91.2 mm (3.29 × 3.59 in)
Displacement 1,997.6 ml (1,997.6 cc)
Compression ratio 13.0
Electrical System
ItemClassification
Battery 12V-45Ah/20HR
Spark-plug number Mazda Genuine spark plug
*1PE5R-18-110 or PE5S-18-110
*1 The spark plugs provide the SKYACTIV-G its optimum performance. Consult an Authorized Mazda Dealer for details.
CAUTION
When cleaning the iridium plugs, do not use a wire brush. The fine particulate coating on
the iridium alloy and platinum tips could be damaged.
Lubricant Quality
Lubricant Classification
Engine oil Refer to Recommended Oil on page 6-27.
Coolant FL-22 type
Manual transmission oil Mazda Original Long Life Gear Oil IS
*1
Automatic transmission fluid Mazda Genuine JWS3309
Rear differential oil Mazda Long Life Hypoid Gear Oil SG1
Brake/Clutch fluid SAE J1703 or FMVSS116 DOT-3
*1 Mazda Original Long Life Gear Oil IS is superior oil for optimum shift-feel. Using Mazda Original Long Life Gear Oil IS is recommended. If Mazda Original Long Life Gear Oil IS cannot be obtained, use standard oil (API Service GL-4 (SAE 75W-90)). However, shifting in very low temperatures may become difficult.
NOTE
Refer to Introduction on (page 6-2) for owner's responsibility in protecting your
investment.
MX-5_8EU4-EA-15D_Edition3.indb 42015/10/21 16:56:22

9–5
Specifications
Specifications
Capacities
(Approximate Quantities)
ItemCapacity
Engine oil With oil filter replacement
4.3 L (4.5 US qt, 3.8 Imp qt)
Without oil filter replacement 4.1 L (4.3 US qt, 3.6 Imp qt)
Coolant Manual transmission
6.0 L (6.3 US qt, 5.3 Imp qt)
Automatic transmission 5.9 L (6.2 US qt, 5.2 Imp qt)
Manual transmission oil 2.0 L (2.1 US qt, 1.8 Imp qt)
Automatic transmission fluid 7.2 L (7.6 US qt, 6.3 Imp qt)
Rear differential oil 0.6 L (0.6 US qt, 0.5 Imp qt)
Fuel tank 45.0 L (11.9 US gal, 9.90 Imp gal)
Check oil and fluid levels with dipsticks or reservoir gauges.
Dimensions
U.S.A. and Canada
ItemVehicle specification
Overall length 3,915 mm (154.1 in)
Overall width 1,735 mm (68.3 in)
Overall height 16 inch wheel vehicle
1,235 mm (48.6 in)
17 inch wheel vehicle 1,240 mm (48.8 in)
Front tread 1,495 mm (58.9 in)
Rear tread 1,505 mm (59.3 in)
Wheelbase 2,310 mm (90.9 in)
Mexico
ItemVehicle specification
Overall length 3,915 mm (154.1 in)
Overall width 1,735 mm (68.3 in)
Overall height 16 inch wheel vehicle
1,225 mm (48.2 in)
17 inch wheel vehicle 1,230 mm (48.4 in)
Front tread 1,495 mm (58.9 in)
Rear tread 1,505 mm (59.3 in)
Wheelbase 2,310 mm (90.9 in)
MX-5_8EU4-EA-15D_Edition3.indb 52015/10/21 16:56:22

9–6
Specifications
Specifications
Weights
U.S.A. and Canada
ItemWeight
Manual transmission Automatic transmission
GVWR (Gross Vehicle Weight Rating) 1,245 kg (2,745 lbs)1,265 kg (2,789 lbs)
GAWR (Gross Axle Weight Rating) Front
628 kg (1,384 lbs) 642 kg (1,415 lbs)
Rear 620 kg (1,367 lbs) 626 kg (1,380 lbs)
Mexico
Item Weight
GVW (Gross Vehicle Weight) Total
1,242 kg (2,738 lbs)
Front 627 kg (1,382 lbs)
Rear 615 kg (1,356 lbs)
GAW (Permissible axle load) Front
630 kg (1,389 lbs)
Rear 615 kg (1,356 lbs)
Air Conditioner
The type of refrigerant used is indicated on a label attached to the ins\
ide of the engine
compartment. Check the label before recharging the refrigerant. Refer to Climate Control
System on page 5-2.
Item Classification
Refrigerant Type HFC134a (R-134a)
MX-5_8EU4-EA-15D_Edition3.indb 62015/10/21 16:56:22

10–2
Index
A
Accessory Socket ..............................5-133
Adaptive Front Lighting System
(AFS)................................................... 4-65
Add-On Non-Genuine Parts and
Accessories
.........................................8-18
Advanced Key Advanced keyless entry system
......3-8
Operational range
............................3-9
Air Bag/Seat Belt Pretensioner System
Warning Beep
......................................7-45
Air Bag Systems
.................................2-24
Ambient Temperature Display
............4-13
Antilock Brake System (ABS)
............4-55
Audio Control Switch Adjusting the volume
....................5-55
Seek switch .................................... 5-56
Audio System
......................................5-13
AUX/USB mode
...........................5-57
Antenna
.........................................5-13
Audio control switch
.....................5-55
Audio set
[Type A (non-touchscreen)]
...........5-22
Audio set
[Type B (touchscreen)]
..................5-34
Operating tips for audio system
....5-14
Satellite radio
................................5-46
Automatic Transmission
.....................4-24
Active Adaptive Shift (AAS)
........4-26
Direct mode
...................................4-33
Driving tips .................................... 4-33
Manual shift mode .........................4-27
Shift-lock override
........................4-26
Shift-lock system
...........................4-26
Shift position indication
................4-25
Transmission ranges
......................4-25
Warning light
.................................4-25
B
Back Trim Storage Box .....................5-138
Battery
.................................................6-36
Maintenance
..................................6-38
Replacement
..................................6-38
Specifications
..................................9-4
Battery Runs Out
.................................7-23
Jump-starting
.................................7-23
Blind Spot Monitoring (BSM)
............4-74
Blind Spot Monitoring (BSM) System
Warning Beep
......................................7-48
Bluetooth® ...........................................5-74
Bluetooth® audio (Type A) ..........5-112
Bluetooth® audio (Type B) ..........5-114
Bluetooth® Hands-Free (Type A) ...5-96
Bluetooth® Hands-Free (Type B) ...5-102
Troubleshooting
..........................5-128
Body Lubrication
................................6-32
Brakes Brakes assist
..................................4-53
Foot brake ...................................... 4-51
Pad wear indicator
.........................4-52
Parking brake
................................4-52
Warning light
.................................4-52
Break-In Period
...................................3-43
C
Capacities ..............................................9-5
Carbon Monoxide
...............................3-24
Cell Phones
.........................................8-19
Child Restraint Child-restraint precautions
............2-15
Child-restraint system installation ...2-20
Installing child-restraint systems ...2-21
Climate Control System
........................5-2
Fully automatic type
........................5-9
Gas specifications
............................9-6
Manual type
.....................................5-5
Operating tips
..................................5-2
Vent operation
.................................5-3
Clock
...................................................5-26
MX-5_8EU4-EA-15D_Edition4.indb 22016/01/20 11:08:29