2016 HYUNDAI I20 air condition


*($'!#(%'*
DDiesel engine
Diesel fuel
Diesel engine must be operated only
on commercially available diesel fuel
that complies with EN 590 or compa-
rable standard. (EN stands for
"European Norm"). Do not use
marine diesel fuel, heating oils, or
non-approved fuel additives, as this
will increase wear and cause dam-
age to the engine and fuel system.
The use of non-approved fuels and /
or fuel additives will result in a limita-
tion of your warranty rights.
Diesel fuel of above cetane 51 is
used in your vehicle. If two types of
diesel fuel are available, use summer
or winter fuel properly according to
the following temperature conditions.
• Above -5°C (23°F) ... Summer type
diesel fuel.
• Below -5°C (23°F) ... Winter type diesel fuel.
Watch the fuel level in the tank very
carefully : If the engine stops through
fuel failure, the circuits must be com-
pletely purged to permit restarting.Do not let any petrol or water enter
the tank. This would make it neces-
sary to drain it out and to bleed the
lines to avoid jamming the injection
pump and damaging the engine.
- Diesel Fuel (if equipped with DPF)
It is recommended to use the regu-
lated automotive diesel fuel for diesel
vehicle equipped with the DPF sys-
tem.
If you use diesel fuel including high
sulfur (more than 50 ppm sulfur) and
unspecified additives, it can cause
the DPF system to be damaged and
white smoke can be emitted.
Biodiesel
Commercially supplied Diesel blends
of no more than 7% biodiesel, com-
monly known as "B7 Diesel" may be
used in your vehicle if Biodiesel
meets EN 14214 or equivalent spec-
ifications. (EN stands for "European
Norm"). The use of biofuels exceed-
ing 7% made from rapeseed methyl
ester (RME), fatty acid methyl ester
(FAME), vegetable oil methyl ester
(VME) etc. or mixing diesel exceed-
ing 7% with biodiesel will cause
increased wear or damage to the
engine and fuel system. Repair or
replacement of worn or damaged
components due to the use of non
approved fuels will not be covered by
the manufactures warranty.
• Never use any fuel, whether diesel, B7 biodiesel or otherwise,
that fails to meet the latest petrole-
um industry specification.
• Never use any fuel additives or treatments that are not recom-
mended or approved by the vehi-
cle manufacturer.
NOTICE
NOTICE
NOTICE



Hyundai Motor India Limited here-
inafter called "HMIL", warrants that
each new Hyundai vehicle sold shall
be free from any defects in material
and workmanship, under normal use
and maintenance, subject to the fol-
lowing terms and conditions.
1. Warranty period This warranty shall exist for a period
of
36 months/100,000 kms whichsoever is

earlier from the date
of delivery to the first purchaser.
This warranty is transferab
le to
subsequent owner for the remaining
warranty period. This warranty is
applicable only in India and
not
transferable to any other country.
2. What is covered
Except as provided in paragraph 3
hereof, our Authorized Dealers shall
either repair or replace, any Hyundai
genuine part that is acknowledged
by HMIL to be defective in material or w

orkmanship within the warranty
period stipulated above, at no cost to
the owner of the Hyundai vehicle for
parts or labour. Such defective parts
which have been replaced will
become the property of HMIL.
3. What is not covered
This warranty shall not apply to:
o Normal maintenance services other than the three free services,
including without limitation, clean-
ing and polishing, minor adjust-
ments, engine tuning, oil/fluid
changes, filters replenishment,
fastener retightening, wheel bal-
ancing, wheel alignment and tyre
rotation etc.
o Replacement of parts as a result of normal wear and tear such as
spark plugs, belts, brake pads
and linings, clutch disc/facing, fil-
ters, wiper blades, bulbs, fuses,
etc.
o Damage or failure resulting from: Negligence of proper mainte-
nance as required in this
Owner's Manual and Service
Booklet.
 Misuse, abuse, accident, theft, flooding or fire.
 Use of improper or insufficient
fuel, fluids or lubricants.
 Use of parts other than
Hyundai Genuine Parts.
 Any device and/or accessories
not supplied by HMIL.
 Modifications, alterations,
tampering or improper repair.
 Parts used in applications of
which they were not designed
or not approved by HMIL.
 Slight irregularities not recog-
nised as affecting quality or
function of the vehicle or parts,
such as slight noise or vibra-
tions, or items considered
characteristic of the vehicle.
 Airborne "fallout", Industrial
fall out, acid rain, hail and wind
storms, or other Acts of God.
 Paint scratches, dents or simi-
lar paint or body damage.
 Action of road elements (sand,
gravel, dust or road debris)
which results in stone chipping
of paint or glass.
22
Hyundai Warranty Policy
IBi Eng 2_PA RHD 1.qxd 18-03-2016 16:49 Page 2




o Incidental or consequential dam-ages, including without limitation,
loss of time, inconvenience, loss
of use of vehicle or commercial
loss.
This warranty is the entire warranty
given by HMIL for Hyundai vehicles
and no dealer or its or his agent or
employee is authorized to extend or
enlarge this warranty and no dealer
or its or his agent or employee is
authorized to make any oral warran-
ty on HMIL's behalf.
HMIL reserves the right to make any
change in design or make any
improvement on the vehicle at any
time without any obligation to make
the same change on vehicles previ-
ously sold.
HMIL reserves the right for the final
decision in all warranty matters.Owner's Responsibilities
o Proper use, maintenance and care of vehicle in accordance with
the instructions contained in this
Owner's Manual and Service
Booklet. If the vehicle is subject to
severe usage conditions, such as
operation in extremely dusty,
rough, more repeated short dis-
tance driving or heavy city traffic
during hot weather, maintenance
of vehicle should be done more
frequently as mentioned in this
Owner's Manual and Service
Booklet.
o Retention of maintenance service records. It may be necessary for
the customer to show that the
required maintenance has been
performed, as specified in this
Owner's Manual and Service
Booklet.
o Delivery of the vehicle during reg- ular service business hours to
any authorized Hyundai Dealer to
obtain warranty service.
o In order to maintain the validity of this Basic Warranty, the vehicle
must be serviced by Hyundai
Authorized workshop in accor-
dance to the Owner’s Manual and
Service Booklet. Hyundai Motor India Limited here-
inafter called "HMIL", warrants that
each new Hyundai Genuine replace-
ment part purchased from and
installed by Hyundai Authorized
Dealer shall be free from any defects
in material or workmanship, under
normal use and maintenance, sub-
ject to the following terms and condi-
tions.
1. Warranty period
This warranty shall exist for a period
of 6 months or until the vehicle has
been driven for a distance of 10,000
Kilometers from the date of installa-
tion of replacement part by Hyundai
Authorized Dealer, whichever occurs
first.
2. What is covered
Except as provided in paragraph 3
hereof, our Authorized Dealer who
had sold and installed the replace-
ment part earlier shall either repair or
replace the said Hyundai genuine
part that is acknowledged by HMIL to
be defective in material or workman-
ship within the warranty period stipu-
32
)#+$,(.,--,+').%(&)


IBi Eng 2_PA RHD 1.qxd 18-03-2016 16:49 Page 3
Batteries, Audio Systems, Tyres
and Tubes originally equipped on
Hyundai vehicles are warranted
directly by the respective manufac-
turers and not by HMIL.
Audio Video Navigation System,

(12)
Luckno w (13) Sholapur (For the
v ehicles Manufactured on or after
\f1/\f6/2\f1\f).
(14) Puduchery \b (15) Mathur a\b (16)
vapi \b (17) Jamnagar \b (18)
Ankleshwar\b (19) Hissar\b (2\f)
Bharatpur\b (21) Silvasa\b (22) Daman
& Diu\b (23) Aligarh\b(24)RaeBareilly\b
(25) Unnao\b (26) Karnal\b (27)
Kurukshetra\b (28) Yamunanagar\b
(29 )Valsad\b (3\f) Nizamabad\b(31)
Medak & (3\f) Mehboobnagar (For
the vehicles Manufactured on or
after \f1/1\f/2\f1\f).
The Mass Emissipn Standards (BS
III) shall apply to all the states and
union territories\b except at above. As
and when Govt. of India notifies addi
tional/new cities under Mass
Emission Standards (BS IV)\b Such
cities would be auto matically cov
ered.
Subject to other terms of the warran
ty policy and the conditions and obli
gations laid down hereunder\b
Hyundai Motor India Limited here
inafter called “HMIL”\b certifies that
the components liable to affect the
emission of the gaseous pollutants in
the vehicle in normal use despite the
use to which it may be subjected\b
comply with the provisions of Rule 115(2) of the Central Motor Vehicle
Rules\b 1989 hereinafter referred to
as the “Inuse emission standard”\b
and further warrants that if on exam
ination by a dealer duly authorized
by HMIL\b the vehicle is discovered to
be failing to meet the Inuse emis
sion standard as specified in the said
rule\b our Authorized Dealer shall take
such corrective measures as may be
necessary and shall at its sole dis
cretion either repair or replace free of
charge\b such components of emis
sion control system as are specified
in paragraph 3 hereof.
1. Warranty period
This warranty will be in addition to
and run parallel to the New Vehicle
Warranty and shall exist for a period
of 36 months or until the vehicle has
been driven for a distance of 8\f\b\f\f\f
kilometers from the date of delivery
to the first purchaser\b whichever
occurs first. This warranty is transfer
able to subsequent owner for the
remaining warranty period.
2. What is covered Our Authorized Dealers shall either
repair or replace\b any Hyundai gen
uine part listed in paragraph 3 here
of\b that is acknowledged by HMIL to
be defective in material or workman
ship within the warranty period stipu
lated above\b after examinations car
ried out to confirm that none of the
original settings have been tampered
with\b at no cost to the owner of the
Hyundai vehicle for parts or labour.
Such defective par ts which have
been replaced will become the prop
erty of HMIL.
3. Emission Warranty Parts List
3.1 Engine Control Module System • Engine Control Module
• Crankshaft Position Sensor\bCamshaft Position Sensor\b
Throttle Position Sensor\b MAP
Sensor\b O 2Sensor\b IAT &
ECT Sensor
3.2 Fuel Metering System • Fuel injectors
• Fuel Pumps
3.3 Air Induction System • Air Cleaner Housing Assembly
+$,#-*0-//-,'+0 &*(+


)%5


"&t%'s%st&'!"'%!'&&The air bag modules are located
both in the center of the steering
wheel and in the front passenger's
panel above the glove box. When the
SRSCM detects a sufficiently severe
impact to the front of the vehicle, it
will automatically deploy the front air
bags. Upon deployment, tear seams mold
ed directly into the pad covers will
separate under pressure from the
expansion of the air bags. Further
opening of the covers then allows full
inflation of the air bags.
If any of the following conditions
occurs, this indicates a malfunc
tion of the SRS. We recommend
that the system be inspected by
an authorized HYUNDAI dealer.
•The light does not turn on briefly
when you turn the ignition ON.
•The light stays on after illuminat
ing for approximately 6 seconds.
•The light comes on while the
vehicle is in motion.
•The light blinks when the ignition
switch is in ON position.
WARNING
B240B01L

Driver’s front air bag (1)
B240B02L
Driver’s front air bag (2)

"&t%'s%st&'!"'%!'&&

A fully inflated air bag, in combina
tion with a properly worn seat belt,
slows the driver's or the passenger's
forward motion, reducing the risk of
head and chest injury.
After complete inflation, the air bag
immediately star ts deflating,
enabling the driver to maintain for
ward visibility and the ability to steer
or operate other controls.
B240B03L
Driver’s front air bag (3)
B240B05L
Passenger’s front air bag
•Do not install or place any acces
sories (drink holder, cassette
holder, sticker, etc.) on the front
passenger's panel above the
glove box in a vehicle with a pas
senger's air bag. Such objects
may become dangerous projec
tiles and cause injury if the pas
senger's air bag inflates.
(Continued)
WARNING
(Continued)
•When installing a container of
liquid air freshener inside the
vehicle, do not place it near the
instrument cluster nor on the
instrument panel surface.
It may become a dangerous projectile and cause injury if the pas
senger's air bag inflates.
•If an air bag deploys, there may
be a loud noise followed by a
fine dust released in the vehicle.
These conditions are normal and
are not hazardous the air bags
are packed in this fine powder.
The dust generated during air
bag deployment may cause skin
or eye irritation as well as aggra
vate asthma for some persons.
Always wash all exposed skin
areas thoroughly with cold water
and a mild soap after an acci
dent in which

the air bags were
deployed.
(Continued)
WARNING

 1
"&t%'s%st&'!"'%!'&&

Side impact air bag
(if equipped)
The actual air bags in the vehicle may differ
from the illustration.
Your vehicle is equipped with a side
impact air bag in each front seat. The purpose of the air bag is to pro
vide the vehicle's driver and\for the
front passenger with additional pro
tection than that offered by the seat
belt alone.
The side impact air bags are
designed to deploy only during cer
tain sideimpact collisions, depend
ing on the crash severity, angle,
speed and point of impact. The side
impact air bags are not designed to
deploy in all side impact situations.
OIB034021
OJK032063
Do not allow the passengers to
lean their heads or bodies onto
doors, put their arms on the doors,
stretch their arms out of the win
dow, or place objects between the
doors and passengers when they
are seated on seats equipped with
side and\for curtain air bags.
WARNING
•The side impact air bag is sup
plemental to the driver's and the
passenger's seat belt systems
and is not a substitute for them.
Therefore your seat belts must
be worn at all times while the
vehicle is in motion. The air bags
deploy only in certain side
impact conditions severe
enough to cause significant
injury to the vehicle occupants.
•For best protection from the side
impact air bag system and to
avoid being injured by the
deployin

g side impact air bag,
both front seat occupants should
sit in an upright position with the
seat belt properly fastened. The
driver's hands should be placed
on the steering wheel at the 9:00
and 3:00 positions. The passen
ger's arms and hands should be
placed on their laps.
(Continued)
WARNING


"&t%'s%st&'!"'%!'&&
Why didn’t my air bag go off in a col
lision? (Inflation and noninflation
conditions of the air bag)
There are many types of accidents in
which the air bag would not be
expected to provide additional pro
tection.
These include rear impacts, second
or third collisions in multiple impact
accidents, as well as low speed
impacts.
(1) SRS control module
(2) Front impact sensor (3) Side impact sensor
OIB037023R\fOIB037044R\fOIB03\07024R\fOIB037025\fOIB037026\0
5 DoorCross
Air bag collision sensors