2016 GMC SIERRA 1500 brake

GMC Sierra Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9234758) - 2016 - crc - 11/9/15
460 Service and Maintenance
(3)Or every four years, whichever
comes first. If driving in dusty
conditions, inspect the filter at each
oil change or more often as needed.
(4) Do not directly power wash the
transfer case and/or front/rear axle
output seals. High pressure water
can overcome the seals and
contaminate the transfer case fluid.
Contaminated fluid will decrease the
life of the transfer case and/or axles
and should be replaced.
(5) Or every five years, whichever
comes first. See Cooling
System 0371.
(6) Or every 10 years, whichever
comes first. Inspect for fraying,
excessive cracking, or damage;
replace, if needed.
(7) Replace brake fluid every five
years. See Brake Fluid 0380.Special Application
Services
.
Vehicles with Dual Wheels:
Check dual wheel nut torque at
160, 1 600 and 10 000 km (100,
1,000 and 6,000 mi) of driving.
Repeat this service whenever a
tire/wheel is serviced or
removed.
. Severe Commercial Use
Vehicles Only: Lubricate chassis
components every 5 000 km/
3,000 mi.
. Have underbody flushing service
performed. See “Underbody
Maintenance” inExterior
Care 0444.
Additional
Maintenance and Care
Your vehicle is an important
investment and caring for it properly
may help to avoid future costly
repairs. To maintain vehicle
performance, additional
maintenance services may be
required.
It is recommended that your dealer
perform these services —their
trained dealer technicians know
your vehicle best. Your dealer can
also perform a thorough
assessment with a multi-point
inspection to recommend when your
vehicle may need attention.
The following list is intended to
explain the services and conditions
to look for that may indicate
services are required.
Battery
The 12-volt battery supplies power
to start the engine and operate any
additional electrical accessories.

GMC Sierra Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9234758) - 2016 - crc - 11/9/15
Service and Maintenance 461
.To avoid break-down or failure to
start the vehicle, maintain a
battery with full cranking power.
. Trained dealer technicians have
the diagnostic equipment to test
the battery and ensure that the
connections and cables are
corrosion-free.
Belts
. Belts may need replacing if they
squeak or show signs of
cracking or splitting.
. Trained dealer technicians have
access to tools and equipment
to inspect the belts and
recommend adjustment or
replacement when necessary.
Brakes
Brakes stop the vehicle and are
crucial to safe driving.
. Signs of brake wear may include
chirping, grinding, or squealing
noises, or difficulty stopping. .
Trained dealer technicians have
access to tools and equipment
to inspect the brakes and
recommend quality parts
engineered for the vehicle.
Fluids
Proper fluid levels and approved
fluids protect the vehicle’s systems
and components. See
Recommended Fluids and
Lubricants 0463 for GM approved
fluids.
. Engine oil and windshield
washer fluid levels should be
checked at every fuel fill.
. Instrument cluster lights may
come on to indicate that fluids
may be low and need to be
filled.
Hoses
Hoses transport fluids and should
be regularly inspected to ensure
that there are no cracks or leaks.
With a multi-point inspection, your
dealer can inspect the hoses and
advise if replacement is needed. Lamps
Properly working headlamps,
taillamps, and brake lamps are
important to see and be seen on
the road.
.
Signs that the headlamps need
attention include dimming, failure
to light, cracking, or damage.
The brake lamps need to be
checked periodically to ensure
that they light when braking.
. With a multi-point inspection,
your dealer can check the lamps
and note any concerns.
Shocks and Struts
Shocks and struts help aid in control
for a smoother ride.
. Signs of wear may include
steering wheel vibration, bounce/
sway while braking, longer
stopping distance, or uneven
tire wear.
. As part of the multi-point
inspection, trained dealer
technicians can visually inspect
the shocks and struts for signs

GMC Sierra Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9234758) - 2016 - crc - 11/9/15
Service and Maintenance 463
Recommended Fluids, Lubricants, and Parts
Recommended Fluids and Lubricants
This maintenance section applies to vehicles with a gasoline engine. If the vehicle has a diesel engine and/or an
Allison Transmission, see the recommended fluids and lubricants section in the Duramax diesel supplement.
Fluids and lubricants identified below by name, part number, or specification can be obtained from your dealer.Usage Fluid/Lubricant
Engine Oil Engine oil meeting the dexos1™ specification of the proper SAE viscosity
grade. AC Delco dexos1 Synthetic Blend is recommended. See Engine
Oil 0363.
Engine Coolant 50/50 mixture of clean, drinkable water and use only DEX-COOL
®coolant.
See Engine Coolant 0373.
Hydraulic Brake System DOT 3 Hydraulic Brake Fluid (GM Part No. 19299818, in Canada 19299819).
Windshield Washer Automotive windshield washer fluid that meets regional freeze protection requirements.
Hydraulic Power Steering System (2500/3500 Series Only) GM Power Steering Fluid (GM Part No. 19329450, in Canada 19329451).
Automatic Transmission (All except 6.2L with 8-Speed transmission) DEXRON
®-VI Automatic Transmission Fluid.
Automatic Transmission (6.2L with 8-Speed transmission) DEXRON
®-HP Automatic Transmission Fluid (GM Part No. 19300536, in
Canada 19300537).
Transfer Case (Four-Wheel Drive) DEXRON
®-VI Automatic Transmission Fluid.

GMC Sierra Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9234758) - 2016 - crc - 11/9/15
Customer Information 481
.Vehicle make, model, and
model year.
. Vehicle Identification
Number (VIN).
. Insurance company and policy
number.
. General description of the
damage to the other vehicle.
Choose a reputable repair facility
that uses quality replacement parts.
See “Collision Parts” earlier in this
section.
If the airbag has inflated, see What
Will You See after an Airbag
Inflates? 077.
Managing the Vehicle Damage
Repair Process
In the event that the vehicle requires
damage repairs, GM recommends
that you take an active role in its
repair. If you have a pre-determined
repair facility of choice, take the
vehicle there, or have it towed there.
Specify to the facility that any
required replacement collision parts
be original equipment parts, either
new Genuine GM parts or recycled original GM parts. Remember,
recycled parts will not be covered by
the GM vehicle warranty.
Insurance pays the bill for the repair,
but you must live with the repair.
Depending on your policy limits,
your insurance company may
initially value the repair using
aftermarket parts. Discuss this with
the repair professional, and insist on
Genuine GM parts. Remember,
if the vehicle is leased, you may be
obligated to have the vehicle
repaired with Genuine GM parts,
even if your insurance coverage
does not pay the full cost.
If another party's insurance
company is paying for the repairs,
you are not obligated to accept a
repair valuation based on that
insurance company's collision policy
repair limits, as you have no
contractual limits with that company.
In such cases, you can have control
of the repair and parts choices as
long as the cost stays within
reasonable limits.
Service Publications
Ordering Information
Service Manuals
Service Manuals have the diagnosis
and repair information on the
engines, transmission, axle,
suspension, brakes, electrical,
steering, body, etc.
Service Bulletins
Service Bulletins give additional
technical service information
needed to knowledgeably service
General Motors cars and trucks.
Each bulletin contains instructions
to assist in the diagnosis and
service of the vehicle.
Owner Information
Owner publications are written
specifically for owners and intended
to provide basic operational
information about the vehicle. The
Owner Manual includes the
Maintenance Schedule for all
models.

GMC Sierra Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9234758) - 2016 - crc - 11/9/15
484 Customer Information
Vehicle Data
Recording and
Privacy
The vehicle has a number of
computers that record information
about the vehicle’s performance and
how it is driven. For example, the
vehicle uses computer modules to
monitor and control engine and
transmission performance, to
monitor the conditions for airbag
deployment and deploy them in a
crash, and, if equipped, to provide
antilock braking to help the driver
control the vehicle. These modules
may store data to help the dealer
technician service the vehicle.
Some modules may also store data
about how the vehicle is operated,
such as rate of fuel consumption or
average speed. These modules may
retain personal preferences, such as
radio presets, seat positions, and
temperature settings.
Event Data Recorders
This vehicle is equipped with an
event data recorder (EDR). The
main purpose of an EDR is to
record, in certain crash or near
crash-like situations, such as an air
bag deployment or hitting a road
obstacle, data that will assist in
understanding how a vehicle’s
systems performed. The EDR is
designed to record data related to
vehicle dynamics and safety
systems for a short period of time,
typically 30 seconds or less. The
EDR in this vehicle is designed to
record such data as:
.How various systems in your
vehicle were operating;
. Whether or not the driver and
passenger safety belts were
buckled/fastened;
. How far (if at all) the driver was
depressing the accelerator and/
or brake pedal; and,
. How fast the vehicle was
traveling. These data can help provide a
better understanding of the
circumstances in which crashes and
injuries occur.
Note
EDR data are recorded by your
vehicle only if a non-trivial crash
situation occurs; no data are
recorded by the EDR under normal
driving conditions and no personal
data (e.g., name, gender, age, and
crash location) are recorded.
However, other parties, such as law
enforcement, could combine the
EDR data with the type of
personally identifying data routinely
acquired during a crash
investigation.
To read data recorded by an EDR,
special equipment is required, and
access to the vehicle or the EDR is
needed. In addition to the vehicle
manufacturer, other parties, such as
law enforcement, that have the
special equipment, can read the
information if they have access to
the vehicle or the EDR.

GMC Sierra Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9234758) - 2016 - crc - 11/9/15
496 Index
IndexA
Accessories andModifications . . . . . . . . . . . . . . . . . . 356
Accessory Power . . . . . . . . . . . . . . . 281
Active Fuel Management
®. . . . . . 285
Add-On Electrical Equipment . . . 349
Adding a Snow Plow or Similar Equipment . . . . . . . . . . . . . 349
Additional Information OnStar
®. . . . . . . . . . . . . . . . . . . . . . 490
Additional Maintenance and Care . . . . . . . . . . . . . . . . . . . . . . 460
Adjustable Throttle and Brake Pedal . . . . . . . . . . . . . . . . . . . 277
Adjustments Lumbar, Front Seats . . . . . . . . . . . . 58
Agreements Trademarks and License . . . . . 240
Air Cleaner/Filter, Engine . . . . . . . 370
Air Filter, Passenger
Compartment . . . . . . . . . . . . . . . . . 254
Air Vents . . . . . . . . . . . . . . . . . . . . . . . 253
Airbag System Check . . . . . . . . . . . . . . . . . . . . . . . . . . 86
How Does an Airbag
Restrain? . . . . . . . . . . . . . . . . . . . . . 77
Passenger Sensing System . . . . 80 Airbag System (cont'd)
What Makes an Airbag
Inflate? . . . . . . . . . . . . . . . . . . . . . . . . 77
What Will You See after an
Airbag Inflates? . . . . . . . . . . . . . . . 77
When Should an Airbag Inflate? . . . . . . . . . . . . . . . . . . . . . . . . 75
Where Are the Airbags? . . . . . . . . 74
Airbags
Adding Equipment to theVehicle . . . . . . . . . . . . . . . . . . . . . . . . 85
Light On-Off . . . . . . . . . . . . . . . . . . 138
On-Off Light . . . . . . . . . . . . . . . . . . 138
On-Off Switch . . . . . . . . . . . . . . . . . . 78
Passenger Status Indicator . . . 139
Readiness Light . . . . . . . . . . . . . . 137
Servicing Airbag-Equipped Vehicles . . . . . . . . . . . . . . . . . . . . . . . 85
System Check . . . . . . . . . . . . . . . . . . 72
Alarm Vehicle Security . . . . . . . . . . . . . . . . 42
All-Season Tires . . . . . . . . . . . . . . . . 400
All-Terrain Tires . . . . . . . . . . . . . . . . . 401
AM-FM Radio . . . . . . . . . . . . . . 193, 195
Antenna Fixed Mast . . . . . . . . . . . . . . . . . . . 199
Multi-band . . . . . . . . . . . . . . . . . . . . 199
Antilock Brake System (ABS) . . . 300

GMC Sierra Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9234758) - 2016 - crc - 11/9/15
Index 497
Antilock Brake System(ABS) (cont'd)
Warning Light . . . . . . . . . . . . . . . . . 143
Appearance Care
Exterior . . . . . . . . . . . . . . . . . . . . . . . 444
Interior . . . . . . . . . . . . . . . . . . . . . . . . 449
Apple CarPlay and Android Auto . . . . . . . . . . . . . . . . . . 232
Assistance Program,
Roadside . . . . . . . . . . . . . . . . . . . . . . 476
Assistance Systems for Driving . . . . . . . . . . . . . . . . . . . . . . . . 312
Assistance Systems for
Parking and Backing . . . . . . . . . . 309
Audio Bluetooth . . . . . . . . . . . . . . . . . . . . . 210
Theft-Deterrent Feature . . . . . . . 185
Audio Players
CD . . . . . . . . . . . . . . . . . . . . . . . . . . . 203
Automatic Dimming Mirrors . . . . . . . . . . . . . . . . 48
Door Locks . . . . . . . . . . . . . . . . . . . . . 39
Headlamp System . . . . . . . . . . . . 177
Transmission . . . . . . . . . . . . . . . . . 286
Transmission Fluid . . . . . . 367, 370
Automatic Transmission Manual Mode . . . . . . . . . . . . . . . . . 289 Automatic Transmission (cont'd)
Shift Lock Control Function
Check . . . . . . . . . . . . . . . . . . . . . . . 386
Auxiliary
Roof Mounted Lamp . . . . . . . . . . 180
Auxiliary Jack . . . . . . . . . . . . . . . . . . . 209
Axle, Front . . . . . . . . . . . . . . . . . . . . . . 383
Axle, Rear . . . . . . . . . . . . . . . . . . . . . . 384
B
Battery Load Management . . . . . . . . . . . . 182
Power Protection . . . . . . . . . . . . . 183
Voltage and ChargingMessages . . . . . . . . . . . . . . . . . . . 153
Battery - North America . . . . 382, 434
Blade Replacement, Wiper . . . . . 387
Blind Spot Mirrors . . . . . . . . . . . . . . . 48
Bluetooth Overview . . . . . . . . 218, 219, 223, 228
Bluetooth Audio . . . . . . . . . . . . . . . . 210
Brake
Pedal and AdjustableThrottle . . . . . . . . . . . . . . . . . . . . . . 277
System Warning Light . . . . . . . . 142
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . 380 Antilock . . . . . . . . . . . . . . . . . . . . . . . 300
Assist . . . . . . . . . . . . . . . . . . . . . . . . . 302 Brakes (cont'd)
Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . 380
Parking . . . . . . . . . . . . . . . . . . . . . . . 301
System Messages . . . . . . . . . . . . 154
Braking . . . . . . . . . . . . . . . . . . . . . . . . . 258
Break-In, New Vehicle . . . . . . . . . . 277
Bulb Replacement . . . . . . . . . . . . . . 391 Center High-MountedStoplamp (CHMSL) and
Cargo Lamp . . . . . . . . . . . . . . . . . 390
Halogen Bulbs . . . . . . . . . . . . . . . . 388
Headlamp Aiming . . . . . . . . . . . . . 388
Headlamps . . . . . . . . . . . . . . . . . . . 388
High Intensity Discharge (HID) Lighting . . . . . . . . . . . . . . . 388
Taillamps, Turn Signal, Stoplamps, and Back-up
Lamps . . . . . . . . . . . . . . . . . . . . . . 389
Buying New Tires . . . . . . . . . . . . . . . 417
C
Calibration . . . . . . . . . . . . . . . . . . . . . . 125
California Fuel Requirements . . . . . . . . . . . 318

GMC Sierra Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
9234758) - 2016 - crc - 11/9/15
500 Index
F
FanEngine . . . . . . . . . . . . . . . . . . . . . . . . 377
Fast Idle System . . . . . . . . . . . . . . . . 280
Features Memory . . . . . . . . . . . . . . . . . . . . . . . . . 13
Filter, Engine Air Cleaner . . . . . . . . . . . 370
Fixed Mast Antenna . . . . . . . . . . . . 199
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 177
Flashers, Hazard Warning . . . . . . 178
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . 423 Changing . . . . . . . . . . . . . . . . . . . . . 424
FlexFuel
E85 . . . . . . . . . . . . . . . . . . . . . . . . . . . 319
Floor Console Storage . . . . . . . . . . 119
Floor Mats . . . . . . . . . . . . . . . . . . . . . . 452
Fluid Automatic
Transmission . . . . . . . . . . . 367, 370
Brakes . . . . . . . . . . . . . . . . . . . . . . . . 380
Four-Wheel Drive Transfer Case . . . . . . . . . . . . . . . 293
Power Steering . . . . . . . . . . . . . . . 378
Washer . . . . . . . . . . . . . . . . . . . . . . . 379
Fog Lamps . . . . . . . . . . . . . . . . . . . . . 179
Folding Mirrors . . . . . . . . . . . . . . . . . . 47 Forward Collision Alert
(FCA) System . . . . . . . . . . . . . . . . . 312
Four-Wheel Drive . . . . . . . . . . 293, 382
Four-Wheel-Drive Light . . . . . . . . . 143
Frequency Statement Radio . . . . . . . . . . . . . . . . . . . . . . . . . 482
Front Axle . . . . . . . . . . . . . . . . . . . . . . 383
Front Fog Lamp
Light . . . . . . . . . . . . . . . . . . . . . . . . . . 147
Front Seats Adjustment . . . . . . . . . . . . . . . . . . . . . 57
Heated and Ventilated . . . . . . . . . . 61
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 317 Additives . . . . . . . . . . . . . . . . . . . . . 319
Economy Driving . . . . . . . . . . . . . . . 30
Filling a Portable FuelContainer . . . . . . . . . . . . . . . . . . . 322
Filling the Tank . . . . . . . . . . . . . . . 320
Foreign Countries . . . . . . . . . . . . 319
Gauge . . . . . . . . . . . . . . . . . . . . . . . . 133
Low Fuel Warning Light . . . . . . . 146
Management, Active . . . . . . . . . . 285
Requirements, California . . . . . 318
System Messages . . . . . . . . . . . . 156
Full-Size Spare Tire . . . . . . . . . . . . 433
Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . 392
Engine Compartment FuseBlock . . . . . . . . . . . . . . . . . . . . . . . . 392 Fuses (cont'd)
Instrument Panel Fuse
Block . . . . . . . . . . . . . . . . . . . 395, 397
G
Garage Door Opener . . . . . . . . . . . 170Programming . . . . . . . . . . . . . . . . . 170
Gauges Engine CoolantTemperature . . . . . . . . . . . . . . . . 135
Engine Oil Pressure . . . . . . . . . . 134
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . 133
Odometer . . . . . . . . . . . . . . . . . . . . . 133
Speedometer . . . . . . . . . . . . . . . . . 133
Tachometer . . . . . . . . . . . . . . . . . . . 133
Trip Odometer . . . . . . . . . . . . . . . . 133
Voltmeter . . . . . . . . . . . . . . . . . . . . . 136
Warning Lights and Indicators . . . . . . . . . . . . . . . . . . . 129
General Information Service and Maintenance . . . . . 453
Towing . . . . . . . . . . . . . . . . . . . . . . . . 322
Vehicle Care . . . . . . . . . . . . . . . . . . 355
Glass Replacement . . . . . . . . . . . . . 388
Glove Box . . . . . . . . . . . . . . . . . . . . . . 117
GM Mobility Reimbursement
Program . . . . . . . . . . . . . . . . . . . . . . . 476