2016 FORD POLICE INTERCEPTOR SEDAN power steering

If you see any corrosion on the battery or
terminals, remove the cables from the
terminals and clean with a wire brush. You
can neutralize the acid with a solution of
baking soda and water.
Because your vehicle
’s engine is
electronically controlled by a computer,
some control conditions are maintained
by power from the battery. When the
battery is disconnected or a new battery
is installed, the engine must relearn its idle
and fuel trim strategy for optimum
driveability and performance. Flexible fuel
vehicles (FFV) must also relearn the
ethanol content of the fuel for optimum
driveability and performance.
To restore the settings, do the following:
1. Apply the parking brake.
2. Shift into park (P) or neutral (N).
3. Switch off all accessories.
4. Press the brake pedal and start your vehicle.
5. Run the engine until it reaches normal operating temperature. While the
engine is warming up, complete the
following: Reset the clock. See Audio
System (page 254). Reset the power
windows bounce-back feature. See
Windows and Mirrors
(page 61).
Reset the radio station presets. See
Audio System
(page 254).
6. Allow the engine to idle for at least one
minute.
7. Drive the vehicle at least 10 mi (16 km)
to completely relearn the idle trim and
fuel trim strategy.
Note: If you do not allow the engine to
relearn the idle and fuel trim strategy, the
idle quality of your vehicle may be adversely
affected until the engine computer
eventually relearns the idle trim and fuel
trim strategy. Note:
For flexible fuel vehicles, if you are
operating on E85, you may experience poor
starts or an inability to start the engine and
driveability problems until the fuel trim and
ethanol content have been relearned.
Make sure that you dispose of old batteries
in an environmentally friendly way. Seek
advice from your local authority about
recycling old batteries.
If storing your vehicle for more than 30
days without recharging the battery, we
recommend that you disconnect the
battery cables to maintain battery charge
for quick starting.
Battery Management System
(If
Equipped)
The battery management system monitors
battery conditions and takes actions to
extend battery life. If excessive battery
drain is detected, the system temporarily
disables some electrical systems to
protect the battery.
Systems included are:
• Heated rear window.
• Heated seats.
• Climate control.
• Heated steering wheel.
• Audio unit.
• Navigation system.
A message may appear in the information
displays to alert you that battery
protection actions are active. These
messages are only for notification that an
action is taking place, and not intended to
indicate an electrical problem or that the
battery requires replacement.
186
Police Interceptor (CPH), enUSA, Edition date: 10/2015, First Printing Maintenance

This begins with the letters DOT
and indicates that the tire meets
all federal standards. The next
two numbers or letters are the
plant code designating where it
was manufactured, the next two
are the tire size code and the last
four numbers represent the week
and year the tire was built. For
example, the numbers 317 mean
the 31st week of 1997. After 2000,
the numbers go to four digits. For
example, 2501 means the 25th
week of 2001. The numbers in
between are identification codes
used for traceability. This
information is used to contact
customers if a tire defect requires
a recall.
Tire Replacement
Requirements
Your vehicle is equipped with tires
designed to provide a safe ride
and handling capability.
WARNINGS
Only use replacement tires
and wheels that are the same
size, load index, speed rating and
type (such as P-metric versus
LT-metric or all-season versus
all-terrain) as those originally
provided by Ford. The
recommended tire and wheel size
may be found on either the Safety
Compliance Certification Label
(affixed to either the door hinge
pillar, door-latch post, or the door
edge that meets the door-latch
post, next to the driver's seating
position), or the Tire Label which WARNINGS
is located on the B-Pillar or edge
of the driver ’s door. If this
information is not found on these
labels then you should contact
your authorized dealer as soon as
possible. Use of any tire or wheel
not recommended by Ford can
affect the safety and performance
of your vehicle, which could result
in an increased risk of loss of
vehicle control, vehicle rollover,
personal injury and death.
Additionally the use of
non-recommended tires and
wheels could cause steering,
suspension, axle, transfer case or
power transfer unit failure. If you
have questions regarding tire
replacement, contact your
authorized dealer as soon as
possible. To reduce the risk of serious
injury, when mounting
replacement tires and wheels, you
should not exceed the maximum
pressure indicated on the sidewall
of the tire to set the beads without
additional precautions listed
below. If the beads do not seat at
the maximum pressure indicated,
re-lubricate and try again.
When inflating the tire for
mounting pressures up to 20 psi
(1.38 bar) greater than the
maximum pressure on the tire
sidewall, the following
precautions must be taken to
protect the person mounting the
tire:
216
Police Interceptor (CPH), enUSA, Edition date: 10/2015, First Printing Wheels and Tires

•
A connected Bluetooth-enabled phone
must have adequate network coverage,
battery power and signal strength.
• The vehicle must have battery power
and be located in the U.S., Canada or
in a territory in which 911 is the
emergency number.
In the Event of a Crash
Not all crashes will deploy an airbag or
activate the fuel pump shut-off (the
triggers for 911 Assist). If a connected cell
phone sustains damage or loses its
connection to SYNC during a crash, SYNC
will search for and try to connect to a
previously paired cell phone; SYNC will
then attempt to call the emergency
services.
Before making the call:
• SYNC provides a short window of time
(about 10 seconds) to cancel the call.
If you fail to cancel the call, SYNC
attempts to dial 911.
• SYNC says the following, or a similar
message: "SYNC will attempt to call
911, to cancel the call, press Cancel on
your screen or press and hold the
phone button on your steering wheel."
If you do not cancel the call, and SYNC
makes a successful call, a pre-recorded
message plays for the 911 operator, and
then the occupant(s) in your vehicle is able
to talk with the operator. Be prepared to
provide your name, phone number and
location immediately, because not all 911
systems are capable of receiving this
information electronically. 911 Assist May Not Work If
•
Your cellular phone or 911 Assist
hardware sustains damage in a crash.
• The vehicle's battery or the SYNC
system has no power.
• The phone(s) thrown from your vehicle
are the ones paired and connected to
the system.
911 Assist Privacy Notice
When you turn on 911 Assist, it may
disclose to emergency services that your
vehicle has been in a crash involving the
deployment of an airbag or activation of
the fuel pump shut-off. Certain versions or
updates to 911 Assist may also be capable
of electronically or verbally disclosing to
911 operators your vehicle location or other
details about your vehicle or crash to assist
911 operators to provide the most
appropriate emergency services. If you do
not want to disclose this information, do
not turn the feature on.
Vehicle Health Report (If
Equipped, United States Only) WARNING
Always follow scheduled
maintenance instructions, regularly
inspect your vehicle, and seek repair
for any damage or problem you suspect.
Vehicle Health Report supplements, but
cannot replace, normal maintenance and
vehicle inspection. Vehicle Health Report
only monitors certain systems
electronically monitored by your vehicle
and will not monitor or report the status
of any other system, (such as brake lining
wear). Failure to perform scheduled
maintenance and regularly inspect your
vehicle may result in vehicle damage and
serious injury. Note:
This feature is only available in the
United States.
281
Police Interceptor (CPH), enUSA, Edition date: 10/2015, First Printing SYNC™

A
A/C
See: Climate Control........................................... 79
About This Manual...........................................7
ABS See: Brakes............................................................. 112
ABS driving hints See: Hints on Driving With Anti-Lock
Brakes.................................................................. 112
Accessories See: Replacement Parts
Recommendation............................................. 11
Adjusting the Headlamps..........................187 Horizontal Aim Adjustment........................... 188
Vertical Aim Adjustment.................................. 187
Adjusting the Pedals
.....................................55
Adjusting the Steering Wheel....................53
Airbag Disposal...............................................45
Air Conditioning See: Climate Control........................................... 79
Air Filter See: Changing the Engine Air Filter..............192
Alarm See: Anti-Theft Alarm........................................ 52
All-Wheel Drive
.............................................105
Anti-Theft Alarm............................................52
Alarm System........................................................ 52
Arming the Alarm................................................. 52
Disarming the Alarm........................................... 52
Triggering the Alarm............................................ 52
Appendices....................................................330
Audible Warnings and Indicators.............69 Headlamps On Warning Chime..................... 69
Key in Ignition Warning Chime........................ 69
Parking Brake On Warning Chime.................69
Audio Control
...................................................53
Audio Input Jack...........................................259
Audio System
................................................254
General Information......................................... 254
Audio Unit - Vehicles With: AM/FM/CD/ SYNC/Satellite Radio.............................255
Menu Structure................................................... 257Automatic Transmission
...........................102
Automatic Transmission Adaptive
Learning............................................................ 104
Brake-Shift Interlock......................................... 102
If Your Vehicle Gets Stuck In Mud or Snow.................................................................. 104
Understanding the Positions of Your Automatic Transmission............................. 102
Automatic Transmission Fluid Check - 2.0L EcoBoost™.......................................180
6F35 Transmission............................................ 180
Automatic Transmission Fluid Check - 3.5L Duratec/3.5L Ecoboost™/
3.7L
.................................................................180
6F50/6F55 Transmission............................... 180
Auxiliary Power Points..................................87 12 Volt DC Power Point....................................... 87
Locations................................................................. 87
AWD See: All-Wheel Drive......................................... 105
B
Battery See: Changing the 12V Battery...................... 185
Blind Spot Information System...............123 Switching the System Off and On................125
System Errors....................................................... 124
Using the System................................................ 123
Bonnet Lock See: Opening and Closing the Hood...........170
Booster Seats
..................................................22
Types of Booster Seats...................................... 23
Brake Fluid Check.........................................184
Brakes.................................................................112 General Information............................................ 112
Breaking-In......................................................144
Bulb Specification Chart...........................190
C
Cabin Air Filter.................................................82
California Proposition 65..............................11
Capacities and Specifications - 2.0L EcoBoost™.................................................238
Specifications..................................................... 238
347
Police Interceptor (CPH), enUSA, Edition date: 10/2015, First Printing Index

General Maintenance Information........310
Multi-Point Inspection...................................... 312
Owner Checks and Services............................ 311
Protecting Your Investment............................ 310
Why Maintain Your Vehicle?.......................... 310
Why Maintain Your Vehicle at Your Dealership?...................................................... 310
Getting Assistance Outside the U.S. and Canada..........................................................155
Getting the Services You Need
................152
Away From Home............................................... 152
H
Handbrake See: Parking Brake............................................... 113
Hazard Warning Flashers..........................148
Headlamp Adjusting See: Adjusting the Headlamps...................... 187
Head Restraints
..............................................83
Adjusting the Head Restraint.......................... 84
Tilting Head Restraints ..................................... 84
Heated Windows and Mirrors.....................81 Heated Exterior Mirror......................................... 81
Heated Rear Window.......................................... 81
Heating See: Climate Control........................................... 79
Hints on Controlling the Interior Climate...........................................................80
Cooling the Interior Quickly............................. 80
General Hints........................................................ 80
Heating the Interior Quickly............................. 80
Maximum Cooling Performance in Instrument Panel or Instrument Panel
and Footwell Positions.................................. 81
Recommended Settings for Cooling ............81
Recommended Settings for Heating...........80
Side Window Defogging in Cold Weather............................................................... 81
Vehicle Stationary for Extended Periods During Extreme High Ambient
Temperatures.................................................... 81
Hints on Driving With Anti-Lock Brakes..............................................................112
Hood Lock See: Opening and Closing the Hood...........170 I
Ignition Switch
................................................89
In California (U.S. Only)..............................153
Information Display Control.......................54
Information Displays
.....................................70
General Information............................................ 70
Information Messages
..................................73
AdvanceTrac ™...................................................... 73
Alarm........................................................................\
. 73
AWD
........................................................................\
... 74
Battery and Charging System.......................... 74
Blind Spot Information and Cross Traffic Alert System...................................................... 75
Brake System......................................................... 75
Doors and Locks.................................................... 75
Fuel........................................................................\
.... 76
Maintenance.......................................................... 76
Park Aid.................................................................... 76
Power Steering....................................................... 77
Reminder Messages............................................. 77
Seats........................................................................\
.. 77
Tire Pressure Monitoring System................... 78
Traction Control.................................................... 78
Installing Child Restraints
............................16
Child Seats............................................................... 16
Using Lap and Shoulder Belts.......................... 17
Using Lower Anchors and Tethers for CHildren (LATCH)............................................ 19
Using Tether Straps.............................................. 21
Instrument Cluster........................................65
Instrument Lighting Dimmer
.....................58
Interior Lamps.................................................59 Dome Task Lamp................................................. 60
Front Map Lamps................................................. 59
Interior Luggage Compartment Release...........................................................50
Interior Mirror...................................................63 Auto-Dimming Mirror.......................................... 63
Introduction.........................................................7
J
Jump Starting the Vehicle
.........................149
Connecting the Jumper Cables..................... 149
Jump Starting...................................................... 150
Preparing Your Vehicle..................................... 149
Removing the Jumper Cables........................ 150
350
Police Interceptor (CPH), enUSA, Edition date: 10/2015, First Printing Index

K
Keys and Remote Controls........................46
L
Lighting Control...............................................57
Headlamp Flasher............................................... 58
High Beams............................................................. 57
Spot Lamp Control.............................................. 58
Lighting
...............................................................57
General Information............................................ 57
Load Carrying.................................................130
Load Limit
.......................................................130
Special Loading Instructions for Owners of
Pick-up Trucks and Utility-type
Vehicles.............................................................. 137
Vehicle Loading - with and without a Trailer................................................................. 130
Locking and Unlocking
................................48
Battery Saver......................................................... 49
Hidden Rear Door Locks.................................... 48
Illuminated Entry.................................................. 49
Illuminated Exit..................................................... 49
Locking and Unlocking the Doors with the Key Blade........................................................... 49
Opening a Rear Door From the Inside..........49
Opening the Luggage Compartment...........50
Power Door Locks................................................ 48
Remote Control.................................................... 48
Locks...................................................................48
Lug Nuts See: Changing a Road Wheel........................ 224
M
Maintenance...................................................170 General Information.......................................... 170
Manual Climate Control..............................79
Manual Seats..................................................85 Lumbar Adjustment........................................... 86
Moving the Seat Backward and Forward............................................................... 85
Recline Adjustment............................................. 85
Media Hub......................................................260
Message Center See: Information Displays................................. 70Mirrors
See: Heated Windows and Mirrors.................81
See: Windows and Mirrors................................. 61
Mobile Communications Equipment.......13
Motorcraft Parts - 2.0L EcoBoost™..................................................231
Motorcraft Parts - 3.5L Duratec.............233
Motorcraft Parts - 3.5L Ecoboost™.................................................234
Motorcraft Parts - 3.7L...............................235
N
Normal Scheduled Maintenance............313 Intelligent Oil-Life Monitor™.......................... 313
Normal Maintenance Intervals...................... 314
O
Oil Change Indicator Reset........................176
Oil Check See: Engine Oil Check........................................ 175
Opening and Closing the Hood...............170 Closing the Hood.................................................. 171
Opening the Hood.............................................. 170
Ordering Additional Owner's Literature......................................................156
Obtaining a French Owner ’s Manual...........157
Overhead Console
.........................................88
P
Parking Aids......................................................117 Principle of Operation........................................ 117
Parking Brake
..................................................113
Pedals.................................................................55
Perchlorate.........................................................11
Personal Safety System ™
..........................33
How Does the Personal Safety System
Work?................................................................... 33
Power Door Locks See: Locking and Unlocking............................. 48
Power Seats.....................................................86
Power Steering Fluid Check.....................184
351
Police Interceptor (CPH), enUSA, Edition date: 10/2015, First Printing Index

Speed Control
See: Cruise Control.............................................. 121
Stability Control.............................................115
Principle of Operation........................................ 115
Starter Switch See: Ignition Switch............................................ 89
Starting a Gasoline Engine
.........................89
Cold Weather Starting - Flex Fuel
Vehicles.............................................................. 90
Failure to Start...................................................... 90
Guarding Against Exhaust Fumes.................. 91
Important Ventilating Information.................91
Stopping the Engine When Your Vehicle is Moving.................................................................. 91
Stopping the Engine When Your Vehicle is Stationary........................................................... 91
Starting and Stopping the Engine...........89 General Information........................................... 89
Steering............................................................128 Electric Power Steering.................................... 128
Steering Wheel................................................53
Storage Compartments..............................88
Sun Visors.........................................................64 Slide-on-rod.......................................................... 64
Supplementary Restraints System.........34 Principle of Operation........................................ 34
Symbols Glossary
.............................................7
SYNC™ Applications and Services.......279
911 Assist............................................................... 279
SYNC Services: Traffic, Directions & Information (TDI) (If Equipped, United
States Only).................................................... 283
Vehicle Health Report (If Equipped, United States Only)..................................................... 281
SYNC™ AppLink ™
......................................287
SYNC Mobile Apps............................................ 287
SYNC™.............................................................261 General Information.......................................... 261
SYNC™ Troubleshooting
.........................299
T
Technical Specifications See: Capacities and Specifications............229
The Better Business Bureau (BBB) Auto Line Program (U.S. Only)
........................154 Tire Care
.........................................................206
Glossary of Tire Terminology......................... 207
Information About Uniform Tire Quality Grading............................................................. 206
Information Contained on the Tire Sidewall........................................................... 208
Police Wheels and Tires................................... 219
Temperature A B C............................................ 207
Traction AA A B C............................................... 207
Treadwear............................................................ 206
Tire Inflation When Punctured See: Tire Sealant and Inflator Kit................200
Tire Pressure Monitoring System...........220 Changing Tires With a Tire Pressure
Monitoring System........................................ 221
Understanding Your Tire Pressure Monitoring System ....................................... 222
Tire Repair Kit See: Tire Sealant and Inflator Kit................200
Tire Sealant and Inflator Kit
....................200
First Stage: Reinflating the Tire with Sealing
Compound and Air....................................... 202
General Information.......................................... 201
Second Stage: Checking Tire Pressure........................................................... 203
Tips for Use of the Kit....................................... 201
What to do after the Tire has been Sealed............................................................... 204
What to do when a Tire Is Punctured........202
Tires See: Wheels and Tires..................................... 200
Towing a Trailer.............................................138 Load Placement.................................................. 138
Towing the Vehicle on Four Wheels...........................................................142
Emergency Towing............................................. 142
Recreational Towing.......................................... 143
Towing..............................................................138
Traction Control
.............................................114
Principle of Operation........................................ 114
Transmission Code Designation.............237
Transmission..................................................102
Transmission See: Transmission.............................................. 102
Transporting the Vehicle
............................142
353
Police Interceptor (CPH), enUSA, Edition date: 10/2015, First Printing Index