2016 FORD F650 fuel filter

fluid every 3000 miles (4800 kilometers)
or three months, whichever comes first.
This interval can be waived if the axle is
filled with 75W140 synthetic gear fluid
meeting Ford specification
WSL-M2C192-A, part number
F1TZ-19580-B, or equivalent. Add friction
modifier XL-3 (EST-M2C118-A) or
equivalent for complete refill of
Traction-Lok rear axles. See Capacities
and Specifications (page 256).
California Fuel Filter Replacement
If you register your vehicle in California, the
California Air Resources Board has
determined that the failure to perform this
maintenance item does not nullify the
emission warranty or limit recall liability
before the completion of your vehicle's
useful life. Ford Motor Company, however,
urges you to have all recommended
maintenance services performed at the
specified intervals and to record all vehicle
service.
Hot Climate Oil Change Intervals
Vehicles operating in the Middle East,
North Africa, Sub-Saharan Africa or
locations with similar climates using an
American Petroleum Institute (API)
Certified for Gasoline Engines (Certification
mark) oil of SM or SN quality, the normal
oil change interval is 3000 miles (5000
kilometers). If the available API SM or SN oils are not
available, then the oil change interval is
1800 miles (3000 kilometers).
Engine Air Filter Replacement
The life of the engine air filter is dependent
on exposure to dusty and dirty conditions.
Vehicles operated in these conditions
require frequent inspection and
replacement of the engine air filter and
cabin air filter.
Diesel Particulate Filter
The filter may need to be removed for ash
cleaning at approximately 120000 miles
(192000 kilometers) or greater (actual
mileage can vary greatly depending upon
engine and vehicle operating conditions)
and replaced with a new or
re-manufactured (ash cleaned) part. The
filter may need to be replaced at
approximately 250000 miles (400000
kilometers) depending upon engine and
vehicle operating conditions. In both cases,
the engine control system sets a service
light (wrench icon) to inform you to bring
your vehicle to the dealer for service. If
there are any issues with the oxidation
catalyst or particulate filter system, a
service light (wrench or engine icon) sets
by the engine control system to inform you
to bring your vehicle into a dealer for
service.
334
F650750 (TBC), enUSA, First Printing Scheduled Maintenance

Bulb Specification Chart..........................209
C
California Proposition 65.............................13
Capacities and Specifications - 6.7L Diesel..............................................................261
Engine Oil Specifications............................... 268
Specifications..................................................... 263
Capacities and Specifications - 6.8L
................................................................256
Specifications...................................................... 257
Capacities and Specifications.................251
Car Wash See: Cleaning the Exterior.............................. 225
Changing a Bulb..........................................208 Brake Lamp, Rear Lamp, Rear Direction
Indicator, License Plate Lamp and
Reverse Lamp................................................ 209
Front Clearance and Identification Lamp................................................................. 208
Headlamp Bulbs................................................ 208
Changing a Fuse............................................170 Fuses....................................................................... 170
Changing a Road Wheel............................247 Tire Change Procedure..................................... 247
Changing the 12V Battery.........................204 Battery Management System (If
Equipped)....................................................... 205
Changing the Coalescer Filter Element.........................................................189
Changing the Engine Air Filter - 6.7L Diesel...............................................................211
Air Filter Replacement...................................... 212
Air Filter Restriction Gauge............................... 211
Changing the Engine Air Filter - 6.8L.................................................................210
Changing the Engine-Mounted and Diesel Fuel Conditioner Module Fuel
Filters - 6.7L Diesel....................................215
Diesel Fuel Conditioner Module Filter.........215
Engine-mounted Fuel Filter............................ 216
Purging Air from the Fuel System.................217
Changing the Engine Oil and Oil Filter...............................................................188
Engine lubrication for severe service operation.......................................................... 188
Changing the Wiper Blades....................206 Checking the Wiper Blades.....................206
Child Restraint and Seatbelt
Maintenance..................................................37
Child Restraint Positioning
..........................27
Child Safety........................................................17
General Information............................................. 17
Child Safety Locks.........................................28
Cleaning Products.......................................225
Cleaning the Alloy Wheels.......................229
Cleaning the Engine....................................226
Cleaning the Exterior..................................225 Exterior Chrome Parts...................................... 225
Exterior Plastic Parts........................................ 226
Stripes or Graphics............................................ 226
Underbody........................................................... 226
Cleaning the Instrument Panel and Instrument Cluster Lens.........................228
Cleaning the Interior....................................227
Cleaning the Windows and Wiper Blades............................................................227
Climate Control...............................................70
Cold Weather Precautions........................148 Winter Operating Tips for Arctic Operation
-20°F (-29°C) and Below.......................... 149
Coolant Check See: Engine Coolant Check - 6.7L Diesel....195
See: Engine Coolant Check - 6.8L...............190
Cruise Control
..................................................45
Principle of Operation....................................... 134
Cruise control See: Using Cruise Control................................ 134
Customer Assistance
..................................156
D
Data Recording.................................................12 Service Data Recording....................................... 12
Daytime Running Lamps............................48
Diesel Particulate Filter................................87
Direction Indicators.......................................48
DPF See: Diesel Particulate Filter............................ 87
Draining the Fuel Filter Water Trap - 6.7L Diesel
.............................................................203
Draining the Diesel Fuel Conditioner Module
(DFCM)............................................................. 203
Driving Aids
.....................................................136
Driving Hints...................................................146
368
F650750 (TBC), enUSA, First Printing Index

Exterior Mirrors.................................................51
Auxiliary Convex Mirrors...................................... 51
Clearance Lamps................................................. 52
Foldaway Exterior Mirrors...................................51
Heated Exterior Mirrors...................................... 52
Power Exterior Mirrors......................................... 51
Signal Indicator Mirrors...................................... 52
Telescoping Mirrors.............................................. 52
F
Fastening the Seatbelts..............................30 Energy Management Feature.......................... 34
Fastening the Cinch Tongue............................. 32
Lap Belts.................................................................. 32
Safety Belt Extension Assembly.................... 34
Safety Belt Locking Modes............................... 33
Using Safety Belts During Pregnancy...........33
Using the Safety Belt with Cinch Tongue (Front Center and Rear Center Seats
Only)...................................................................... 31
Federal Highway Administration Regulation
.......................................................14
Fifth Wheel Operation................................144 Hook-up................................................................. 145
Un-hook................................................................. 145
Ford Credit
.........................................................13
(U.S. Only)................................................................ 13
Frame and Tow Hook Inspection
...........223
Front Seat Armrest........................................79
Fuel and Refueling
........................................90
Fuel Consumption.......................................102 Calculating Fuel Economy.............................. 103
Filling the Tank.................................................... 102
Fuel Filter - 6.8L...........................................204
Fuel Quality - Diesel
......................................92
Biodiesel.................................................................. 93
Diesel Fuel Additives.......................................... 94
Fuel Requirements - Choosing The Right Fuel: Vehicles Operated Where Ultra Low
Sulfur Diesel Fuel Is Not Required ...........93
Fuel Requirements - Choosing The Right Fuel: Vehicles Operated Where Ultra Low
Sulfur Diesel Fuel Is Required (United
States/Canada/Puerto Rico/U.S. Virgin
Islands And Other Locales) ........................ 92
Fuel Quality - Gasoline.................................91 Choosing the Right Fuel..................................... 91Fuel Shutoff....................................................152
Running Out Of DEF (Diesel Exhaust
Fluid).................................................................. 153
Fuel Tank Selector Switch..........................112
Full Power Brake
...........................................124
Fuses.................................................................162
Fuse Specification Chart...........................162 Passenger Compartment Fuse Panel.........167
Power Distribution Box..................................... 162
G
Gauges...............................................................54 Diesel Engines....................................................... 56
Diesel Exhaust Fluid (DEF) Gauge.................57
Engine Coolant Temperature Gauge............55
Engine Oil Pressure Gauge............................... 55
Fuel Gauge.............................................................. 55
Gasoline Engines.................................................. 54
Gauge Package..................................................... 55
Information Display............................................. 56
Transmission Fluid Temperature Gauge................................................................... 55
General Driving Points
................................146
Backing Up............................................................ 146
General Information.......................................... 146
Parking.................................................................... 147
General Information on Radio Frequencies...................................................38
General Maintenance Information
.........314
Multi-point Inspection..................................... 320
Owner Checks and Services........................... 318
Protecting Your Investment............................ 314
Why Maintain Your Vehicle?........................... 314
Why Maintain Your Vehicle at Your Dealership?...................................................... 314
Getting Assistance Outside the U.S. and Canada..........................................................159
Getting the Services You Need
...............156
Away From Home............................................... 156
H
Handbrake See: Parking Brake............................................... 121
Hazard Warning Flashers...........................152
Headlamp Adjusting See: Adjusting the Headlamps.................... 206
370
F650750 (TBC), enUSA, First Printing Index

Using Voice Recognition............................281
Initiating a Voice Session................................. 281
System Interaction and Feedback..............282
Utilizing the Mediation/Arbitration Program (Canada Only).........................158
V
Vehicle Care...................................................225 General Information.......................................... 225
Vehicle Certification Label.......................255
Vehicle Identification Number................254
Vehicle Inspection Guide.............................171
Vehicle Inspection Information.................171 Trailer....................................................................... 178
Transmission........................................................ 178
Vehicle Storage
.............................................229
Battery................................................................... 230
Body........................................................................\
229
Brakes.................................................................... 230
Cooling system................................................... 230
Engine.................................................................... 230
Fuel system.......................................................... 230
General.................................................................. 229
Miscellaneous..................................................... 230
Removing Vehicle From Storage.................230
Tires........................................................................\
230
Ventilation See: Climate Control........................................... 70
VIN See: Vehicle Identification Number............254
Voice Control
...................................................45 W
Warning Lamps and Indicators................58
Anti-Lock Braking System................................ 58
Automatic Regeneration Control................... 58
Battery...................................................................... 58
Brake System......................................................... 58
Check Fuel Cap (Gasoline Engine Only).................................................................... 58
Check Suspension............................................... 58
Cruise Control........................................................ 58
Diesel Exhaust Fluid (Diesel Engine Only).................................................................... 58
Diesel Particulate Filter (Diesel Engine Only).................................................................... 59
Direction Indicator............................................... 59
Door Ajar.................................................................. 59
Electronic Locking Differential........................ 59
Engine Oil Pressure (Gasoline Engine Only).................................................................... 59
Exhaust Brake On................................................ 59
Fasten Safety Belt............................................... 59
High Beam.............................................................. 59
Hydromax............................................................... 59
Low Fuel Level (Gasoline Engine Only).................................................................... 59
Parking Brake Warning....................................... 59
Powertrain Malfunction/Reduced Power/Electronic Throttle Control
(Gasoline Engine Only)................................ 60
Service Engine Soon........................................... 60
Traction Control (Diesel Engine Only).........60
Trailer Anti-Lock Brake System (ABS).................................................................. 60
Transmission Tow/Haul.................................... 60
Two Speed Axle................................................... 60
Wait to Start (Diesel Engine Only)................60
Water in Fuel (Diesel Engine Only)................61
Washer Fluid Check....................................202
Washers See: Cleaning the Exterior.............................. 225
See: Wipers and Washers................................. 46
Waxing.............................................................226
Wheel Nuts See: Changing a Road Wheel........................ 247
Wheels and Tires.........................................232 Technical Specifications................................. 249
Windows and Mirrors...................................50
375
F650750 (TBC), enUSA, First Printing Index