2016 FORD F150 tailgate

Note:
A smooth surface tool can be used
to rotate the stops.
4. Rotate the stops at the underside of the ramp to the open position. 5. Slide the ramp claw onto the tailgate
plate. 6. Pull the location pin outward and
extend the ramp until the pin is seated
in the usage position, then set the ramp
on even ground.
Stowing the Bed Ramp
1. Pick up the ramp. Pull the location pin outward.
2. Slide the ramp into the storage position
until the location pin locks.
Note: Make sure the proper pin location has
been applied for your bed size.
3. Slide the ramp claw off of the tailgate plate.
4. Rotate the stops at the underside of the ramp to the closed position.
250
F-150 (TFC) Canada/United States of America, enUSA, Edition date: 08/2015, First Printing Load CarryingE211150 E194382 E194383

Distance A
The horizontal distance from the license
plate to the center of the ball hitch on the
trailer.
Distance B
The horizontal distance from the center of
the ball hitch to the center of the sticker.
Distance C
The distance from the Rear View Camera
to the center of the sticker.
Distance D
The distance from the tailgate to the
center of the trailer axle (single axle
trailers), or the center of the axles (trailers
with dual axles or more).
Step 5: Enter Measurements Using the
Information Display
Using the recorded measurements, enter
the required data into the system. Follow
the on screen prompts to enter each of the
measurements taken in step 4. When all
four distances have been entered, a
confirmation display will appear. Check
the values are correct before proceeding,
or go back to change any if required. Step 6: Confirming the Sticker Location
Check the Rear View Camera display to
see if the sticker is identified by the system
and marked with a red circle.
Confirm that the red circle is correctly
located over the sticker image in the
display. The on screen prompt will ask you
to confirm this.
Note:
If the system cannot locate the
sticker try cleaning the camera lens, and
also make sure the sticker is within the green
zone as indicated in step 3.
Calibrating the System
To complete setup, drive your vehicle
straight forward between 4 mph (6 km/h)
and 24 mph (39 km/h) following the on
screen prompt.
Note: Check your measurements to make
sure you measured from the correct points.
Note: If you move the steering wheel during
this procedure, the calibration pauses.
Note: We recommend that you do not do
this at night.
A message will be displayed during
calibration and after calibration is
complete.
Using Pro Trailer Backup Assist
To use the system press the button and
select the required trailer from the display.
256
F-150 (TFC) Canada/United States of America, enUSA, Edition date: 08/2015, First Printing TowingE209806
A
B
C
D
D

Measurement C has reached maximum or
minimum value:
•
Make sure that the sticker placement
instructions in step 3 of the setup have
been followed. Stickers placed outside
the allowed zone will adversely affect
the system performance and could
cause improper feature function. If you
have met all the criteria for sticker
placement and you see this message
this sticker is either too far below or too
close to the camera to properly
recognize the sticker. In order for the
system to operate correctly the sticker
height must be lowered if you receive
the minimum warning or the sticker
height must be raised if you receive the
maximum warning.
•Only one sticker can be placed on
the trailer for correct system
function. The previous sticker must
be removed or covered so only one
sticker is visible to the camera.
• Measurement B and C must be
measured again if a new sticker is
placed on the trailer.
Measurement D has reached maximum or
minimum value:
• Make sure that the measurement being
made is the horizontal distance only
from tailgate to the center of the single
axle or the center of all the axles on the
trailer. See step 4 of the setup for
additional measurement instructions.
The TBA system does not support
trailer lengths outside the range
allowed by the information display. System is circling something beside the
sticker or system cannot find the sticker:
•
Make sure the rear camera is clean and
the sticker is clearly visible in the
camera image. Clean the camera and
sticker if necessary.
• The camera system uses the entered
measurements to help locate the
sticker. Inaccurate sticker
measurements will degrade the
system ’s ability to locate the sticker.
Verify the measurements entered into
the system are accurate.
• If you cannot resolve the issue a new
sticker location should be tried. The
sticker location must still meet the
requirements noted in step 3 of the
setup instructions. Only one sticker can
be placed on the trailer for correct
system function. The previous sticker
must be removed or covered so only
one sticker is visible to the camera.
Calibration
The system monitors various vehicle
parameters to ensure your vehicle is being
driven straight and the trailer straight
behind your vehicle. Any steering input or
trailer movement will pause the calibration.
For best results:
• Use a long, straight and smooth road
when attempting to calibrate.
• Drive straight forward.
• Drive between 5 mph (8 km/h) and
25 mph (40 km/h).
System Operation
The following warnings or difficulties may
occur during feature operation. Tips to
resolve them are listed below.
259
F-150 (TFC) Canada/United States of America, enUSA, Edition date: 08/2015, First Printing Towing

Protected components
Fuse amp rating
Fuse or relay number
Not used (spare).
5A
10
Combined sensor module.
5A
11
Climate head module.
7.5A
12
Smart datalink converter.
Cluster.
7.5A
13
SCCM.
Brake.
10A
14
Smart datalink converter.
10A
15
Tailgate release.
15A
16
HUD.
5A
17
Ignition switch and passive-entry passive-
start start stop switch.
5A
18
Key inhibit solenoid.
Tow haul (O/D) cancel for floor or column
shifter.
7.5A
19
Not used.
7.5A
20
HUD.
5A
21
In car temperature with humidity sensor.
EPB.
5A
22
Power seat.
PDRG switch.
10A
23
Inverter.
Driver side window.
Moonroof.
Vista roof.
Central lock/unlock.
20A
24
Driver door control module.
30A
25
Passenger door control module.
30A
26
Vista roof.
30A
27
Moonroof.
Not used.
20A
28
Not used.
30A
29
305
F-150 (TFC) Canada/United States of America, enUSA, Edition date: 08/2015, First Printing Fuses

Replacing Side Marker Bulb
1. Make sure the headlamps are off.
2. With the hood open, locate the side
marker on the top of the headlamp
assembly.
3. Remove the bulb holder from the lamp
assembly by turning it
counterclockwise and pulling it straight
out.
4. Install the new bulb in reverse order.
Replacing Fog Lamp Bulbs (If Equipped) 1. Make sure the fog lamps are off.
2. Disconnect the electrical connector
from the fog lamp bulb.
3. Turn the bulb counterclockwise and remove it from the fog lamp.
4. Install the new bulb in reverse order. Replacing LED Headlamp Bulbs (If
Equipped)
These lamps have LED bulbs. Contact an
authorized dealer.
Replacing LED Direction Indicator
and Side Marker Bulbs
(If Equipped)
These lamps have LED bulbs. Contact an
authorized dealer.
Replacing Brake, Rear, Direction
Indicator and Reverse Lamp Bulbs
1. Make sure the headlamps are off.
2. Open the tailgate to access the rear lamp assemblies 3. Remove the two bolts from the tail
lamp assembly. Then, carefully pull the
lamp assembly from the tailgate pillar
by releasing the two retaining tabs.
4. Disconnect the electrical connector from the bulb.
325
F-150 (TFC) Canada/United States of America, enUSA, Edition date: 08/2015, First Printing MaintenanceE183764 E163826 E187288

Automatic Transmission............................182
Brake-Shift Interlock......................................... 185
If Your Vehicle Gets Stuck In Mud or Snow................................................................... 187
Understanding the Shift Positions of a 6– Speed Automatic Transmission.........182
Understanding your SelectShift Automatic ™ transmission......................... 184
Automatic Transmission Fluid Check..............................................................317
Auto-Start-Stop............................................172 Disabling Auto StartStop................................. 173
Enabling Auto StartStop.................................. 172
Autowipers.......................................................82
Auxiliary Power Points................................162 110 Volt - 400 Watt Capacity AC Power
Outlet................................................................. 162
12 Volt DC Power Point..................................... 162
Locations............................................................... 162
B
Battery See: Changing the 12V Battery...................... 318
Bed Access.....................................................248 Box Side Step...................................................... 248
Bed Extender...................................................70 Grocery Mode.......................................................... 71
Tailgate Mode........................................................ 70
Bed Ramps
....................................................249
Installing the Ramp Holder............................. 251
Stowing the Bed Ramp................................... 250
Using the Bed Ramp........................................ 249
Blind Spot Information System
..............232
Switching the System Off and On..............234
System Errors...................................................... 234
Using the System............................................... 232
Bonnet Lock See: Opening and Closing the Hood..........307
Booster Seats..................................................28 Types of Booster Seats...................................... 28
Brake Fluid Check.........................................318
Brakes...............................................................198 General Information.......................................... 198
Breaking-In......................................................281
Bulb Specification Chart...........................327 C
Cabin Air Filter
................................................145
California Proposition 65..............................11
Capacities and Specifications - 2.7L EcoBoost™.................................................374
Specifications...................................................... 375
Capacities and Specifications - 3.5L................................................................382
Specifications..................................................... 383
Capacities and Specifications - 3.5L Ecoboost™.................................................378
Specifications...................................................... 379
Capacities and Specifications - 5.0L................................................................387
Specifications..................................................... 388
Capacities and Specifications................370
Car Wash See: Cleaning the Exterior.............................. 330
Center Console..............................................164
Changing a Bulb...........................................322 Accessing the Halogen High Beam, Low
Beam and Direction Indicator
Bulbs.................................................................. 323
Lamp Assembly Condensation.................... 323
Replacing Brake, Rear, Direction Indicator and Reverse Lamp Bulbs........................... 325
Replacing Cargo Lamp and High-mount Brake Lamp Bulbs........................................ 326
Replacing Exterior Mounted Mirror Direction Indicator Lamp Bulbs................................... 327
Replacing Fog Lamp Bulbs............................ 325
Replacing LED Brake, Rear, Direction Indicator and Reverse Lamp
Bulbs.................................................................. 326
Replacing LED Cargo Lamp, Spot Lamp and High-mount Brake Lamp Bulbs..............326
Replacing LED Direction Indicator and Side Marker Bulbs................................................... 325
Replacing LED Headlamp Bulbs.................. 325
Replacing Side Marker Bulb........................... 325
Replacing the Halogen High Beam, Low Beam and Direction Indicator
Bulbs.................................................................. 324
Replacing the License Plate Lamp Bulb.................................................................... 326
Changing a Fuse
..........................................306
Fuses...................................................................... 306
492
F-150 (TFC) Canada/United States of America, enUSA, Edition date: 08/2015, First Printing Index

Electric Parking Brake.................................199
Applying the Electric Parking Brake............199
Applying the Electric Parking Brake When
the Vehicle is Moving.................................. 200
Battery With No Charge................................... 201
Releasing the Electric Parking Brake.........200
Electronic Locking Differential................196 Activating the Electronic Locking
Differential....................................................... 196
Electronic Tailgate..........................................67 With the Outside Control Button................... 67
With the Remote Control.................................. 67
Emission Control System...........................179
On-Board Diagnostics (OBD-II)................... 180
Readiness for Inspection/Maintenance (I/M) Testing.................................................... 181
End User License Agreement..................472 VEHICLE SOFTWARE END USER LICENSE
AGREEMENT (EULA) ................................. 472
Engine Block Heater
....................................170
Using the Engine Block Heater........................ 171
Engine Coolant Check.................................313 Adding Engine Coolant..................................... 314
Checking the Engine Coolant......................... 313
Recycled Engine Coolant................................. 314
Severe Climates.................................................. 315
What You Should Know About Fail-Safe Cooling............................................................... 315
Engine Immobilizer See: Passive Anti-Theft System...................... 72
Engine Oil Check...........................................312 Adding Engine Oil................................................ 312
Engine Oil Dipstick........................................312
Engine Specifications
................................370
Drivebelt Routing............................................... 370
Environment......................................................14
EPB See: Electric Parking Brake............................. 199Essential Towing Checks
..........................269
Before Towing a Trailer..................................... 275
Hitches................................................................... 270
Launching or Retrieving a Boat or Personal Watercraft (PWC).........................................276
Safety Chains........................................................ 271
Trailer Brakes......................................................... 271
Trailer Lamps....................................................... 275
Trailer Towing Connector................................ 270
Using a Step Bumper........................................ 275
When Towing a Trailer...................................... 275
Event Data Recording See: Data Recording.............................................. 9
Export Unique Options..................................13
Extended Service Plan (ESP)
..................451
EXTENDED SERVICE PLAN (CANADA
ONLY)................................................................ 452
EXTENDED SERVICE PLAN (U.S. Only)................................................................... 451
Exterior Mirrors
................................................93
360-Degree Camera........................................... 95
Auto-dimming Feature (if equipped)..........95
Blind Spot Information System...................... 96
Clearance Lamps ................................................ 95
Direction Indicator Mirrors ............................... 95
Fold-Away Exterior Mirrors............................... 93
Heated Exterior Mirrors ..................................... 95
Integrated Blind Spot Mirror (If Equipped).......................................................... 96
Memory Mirrors .................................................... 95
Power Exterior Mirrors........................................ 93
Power-Folding Mirrors........................................ 94
Puddle Lamps....................................................... 95
Spot Lamps............................................................ 95
F
Fastening the Seatbelts..............................34 Fastening the Cinch Tongue............................. 35
Rear Inflatable Safety Belt................................ 37
Safety Belt Extension Assembly.................... 38
Safety Belt Locking Modes............................... 36
Using Safety Belts During Pregnancy...........35
Using the Safety Belt with Cinch Tongue (Front Center Seat)........................................ 34
Floor Mats
.......................................................282
Fog Lamps - Front See: Front Fog Lamps........................................ 88
494
F-150 (TFC) Canada/United States of America, enUSA, Edition date: 08/2015, First Printing Index

L
Lane Keeping System................................228
Switching the System On and Off..............229
Lighting Control..............................................84
Headlamp Flasher............................................... 84
High Beams............................................................ 84
Lighting..............................................................84
Load Carrying.................................................241
Load Limit
.......................................................242
Special Loading Instructions for Owners of
Pick-up Trucks and Utility-type
Vehicles............................................................ 248
Vehicle Loading - with and without a Trailer................................................................. 242
Load Retaining Fixtures..............................241 BoxLink ™ Cleats................................................. 241
Locking and Unlocking.................................62 Activating Intelligent Access............................ 63
Autolock and Autounlock................................. 64
Battery Saver......................................................... 64
Illuminated Entry.................................................. 64
Power Door Locks................................................ 62
Remote Control.................................................... 62
Smart Unlock......................................................... 63
Smart Unlocks for Intelligent Access Keys...................................................................... 63
Locks...................................................................62
Lug Nuts See: Changing a Road Wheel........................ 361
M
Maintenance..................................................307 General Information......................................... 307
Manual Climate Control
.............................139
Manual Seats.................................................149
Manual Lumbar .................................................. 150
Moving the Seat Backward and Forward............................................................. 149
Recline Adjustment........................................... 150
Manual Tailgate
...............................................67
Media Hub.....................................................409
Memory Function..........................................152
Easy Entry and Exit Feature............................ 153
Linking a PreSet Position to your Remote Control or Intelligent Access Key.............153
Saving a PreSet Position.................................. 153Message Center
See: Information Displays............................... 108
Mirrors See: Heated Windows and Mirrors..............145
See: Windows and Mirrors................................ 92
Mobile Communications Equipment.......13
Moonroof..........................................................98 Bounce-Back......................................................... 99
Opening and Closing the Moonroof.............98
Motorcraft Parts
............................................371
MyKey Troubleshooting..............................60
MyKey ™.............................................................57
Principle of Operation......................................... 57
N
Normal Scheduled Maintenance..........456 Intelligent Oil-Life Monitor............................. 456
Normal Maintenance Intervals..................... 457
O
Oil Check See: Engine Oil Check....................................... 312
Opening and Closing the Hood..............307
Ordering Additional Owner's Literature.....................................................295
Obtaining a French Owner ’s Manual.........296
Overhead Console.......................................165
P
Parking Aid
.....................................................209
Rear Sensing System....................................... 209
Parking Aids..................................................209
Parking Brake
.................................................198
Passive Anti-Theft System.........................72 SecuriLock ™........................................................... 72
PATS See: Passive Anti-Theft System...................... 72
Pedals..................................................................81
Perchlorate.........................................................11
Personal Safety System ™
..........................42
How Does the Personal Safety System
Work?.................................................................. 42
Post-Crash Alert System..........................290
Power Door Locks See: Locking and Unlocking............................. 62
497
F-150 (TFC) Canada/United States of America, enUSA, Edition date: 08/2015, First Printing Index