2016 DODGE VIPER transmission

WARNING!(Continued)
•Do not allow petroleum based fluid to contaminate
the brake fluid. Brake seal components could be
damaged, causing partial or complete brake failure.
This could result in an accident.
Change Brake Fluid
Brake fluid will tend to absorb moisture from the atmo-
sphere over time. If the fluid becomes contaminated with
water, brake performance will deteriorate. Therefore, the
brake fluid must be changed at the intervals specified in
the “Maintenance Schedule.” Refer to “Maintenance
Schedule” for further information. See your authorized
dealer for service.
Manual Transmission
Transmission Fluid Level Check
Check the fluid in the transmission when performing
other underbody services.
Check the fluid level by removing the fill plug located on
the left side of the transmission. The fluid level should be
approximately 1/4 in (6.4 mm) below the bottom of the
fill hole. Add fluid, if necessary, to maintain the proper
level. Refer to “Fluids, Lubricants, And Genuine Parts” in
“Maintaining Your Vehicle” for further information.
NOTE: DO NOT overfill transmission, damage can
occur.
7
MAINTAINING YOUR VEHICLE 357

CAUTION!
Using a transmission fluid other than the manufac-
turer’s recommended fluid may cause deterioration
in transmission shift quality and/or damage to the
transmission. Refer to “Fluids, Lubricants, And
Genuine Parts” in this section for fluid specifica-
tions.
Change Transmission Fluid
Refer to “Maintenance Schedule” for the proper mainte-
nance intervals. If contaminated with water, change the
fluid immediately. See your authorized dealer for service.
Hydraulic Clutch
Master Cylinder — Clutch Fluid Level Check
The clutch hydraulic system is fed by a segregated
volume of fluid within the brake system master cylinder
reservoir. In the event of leakage or wear, use only themanufacturer’s recommended brake fluid. Refer to “Flu-
ids, Lubricants, And Genuine Parts” in “Maintaining
Your Vehicle” for further information.
Rear Axle
Axle Lubricant Level Check
Check the exterior of the axle for evidence of gear oil
leakage every 12 months or 6,000 miles (10 000 km). This
check should be made with the vehicle level and on the
ground or raised on an axle and wheel type hoist. The
axle lubricant level should be between the bottom of the
filler plug and a point approximately 3/8 inch (9.5 mm)
below the filler plug. If adding axle lubricant, use only
the manufacturer’s recommended axle lubricant. Refer to
“Fluids, Lubricants, And Genuine Parts” in “Maintaining
Your Vehicle” for further information.
358 MAINTAINING YOUR VEHICLE

FLUID CAPACITIES
U.S.Metric
Fuel (Approximate) 16 Gallons60.6 Liters
Engine Oil With Filter
We recommend you use synthetic SAE 0W-40, API Certified. 11 Quarts 10.4 Liters
Transmission
We recommend you use MOPAR ATF+4 Automatic Trans-
mission Fluid. 3.4 Quarts
3.2 Liters
Rear Axle
We recommend you use Castrol SAF-XJ/SAE 75W-140 Syn-
thetic Gear and Axle Lubricant. 1.5 Quarts
1.4 Liters
Cooling System *
We recommend you use MOPAR Antifreeze/Engine Coolant
(OAT coolant conforming to MS.90032) 10 Year/150,000 Mile
Formula or equivalent). 16 Quarts
15 Liters
* Includes heater and coolant recovery bottle filled to MAX level.
380 MAINTAINING YOUR VEHICLE

Chassis
ComponentFluid, Lubricant, or Genuine Part
Transmission We recommend you use MOPAR ATF+4 Automatic
Transmission Fluid.
Rear Axle We recommend you use Castrol SAF-XJ/SAE 75W-140
Synthetic Gear and Axle Lubricant.
Brake/Clutch Master Cylinder We recommend you use MOPAR Brake and Clutch
Fluid DOT 4 Motor Vehicle.
Power Steering Reservoir We recommend you use MOPAR Power Steering Fluid +
4, MOPAR or ATF+4 Automatic Transmission Fluid.
7
MAINTAINING YOUR VEHICLE 383

Once A Month
•Check tire pressure and look for unusual wear or
damage. Rotate tires at the first sign of irregular wear,
even if it occurs before your next scheduled service.
• Inspect the battery, and clean and tighten the terminals
as required.
• Check the fluid levels of the coolant reservoir, brake
master cylinder, power steering, and transmission, and
add as needed.
• Check all lights and all other electrical items for correct
operation. At Each Oil Change
•
Change the engine oil filter.
• Inspect the exhaust system.
NOTE: Also, inspect the exhaust system if you notice a
change in the sound of the exhaust system, or if the
exhaust fumes can be detected inside the vehicle.
• Inspect the brake hoses.
• Inspect the suspension components.
• Lubricate door hinges and check springs.
• Check the engine coolant level, hoses, and clamps.
• Check power steering fluid level.
8
MAINTENANCE SCHEDULES 387

Turn Signal..................... .88, 108, 167
Flash-To-Pass ........................... .109
Flooded Engine Starting ....................240
Fluid Capacities ......................... .380
Fluid Leaks ..............................88
Fluid Level Checks Brake ........................... .355, 383
Capacities ........................... .380
Clutch Fluid .......................... .358
Cooling System ........................ .349
Engine Oil ........................... .337
Manual Transmission .................357, 383
Power Steering ..................... .254, 383
Fluids, Lubricants And Genuine Parts ...........381
Four-Way Hazard Flasher ...................310
Freeing A Stuck Vehicle .....................327
Fuel .................................. .297
Additives ............................ .299Clean Air
............................ .297
Ethanol ............................. .298
Gasoline ............................. .297
Light ............................... .165
Materials Added ....................... .299
Methanol ............................ .298
Octane Rating ..................... .297, 381
Requirements ...................... .297, 380
Tank Capacity ......................... .380
Fuses ................................. .366
Garage Door Opener (HomeLink) ..........123, 130
Gasoline, Clean Air ....................... .297
Gasoline (Fuel) .......................... .297
Gasoline, Reformulated .....................297
General Information ...................... .206
Glass Cleaning .......................... .362
Ground Clearance ........................ .307
10
INDEX 409

Low Fuel............................ .165
Malfunction Indicator (Check Engine) .........158
Parade Mode (Daytime Brightness) ...........111
Park ............................... .166
Passing ............................. .109
Seat Belt Reminder ..................... .148
Security Alarm ........................ .152
Service .......................... .377, 379
Tire Pressure Monitoring (TPMS) .........162, 291
Turn Signal ..................... .88, 108, 167
Vanity Mirror ...........................97
Warning (Instrument Cluster Description) . . .152, 167
Loading Vehicle Tires ............................... .273
Locks ..................................25
Automatic Door .........................27
Auto Unlock ...........................28
Door .................................25
Power Door ............................26 Low Tire Indicator
....................... .291
Low Tire Pressure System ...................291
Lubrication, Body ........................ .345
Lug Nuts ...............................311
Maintenance Free Battery ....................341
Maintenance Procedures ....................337
Maintenance Schedule ...............385, 386, 388
Malfunction Indicator Light (Check Engine) . . .158, 334
Manual, Service ......................... .400
Manual Transmission ...................241, 358
Fluid Level Check ...................357, 383
Lubricant Selection ..................... .383
Shift Speeds .......................... .244
Methanol .............................. .298
Mirrors .................................92
Electric Remote .........................96
Outside ...............................96
Rearview ..............................92
412 INDEX

Supplemental Restraint System - Air Bag.........47
Tilt Steering Column .......................114
Time Delay, Headlight ..................... .106
Tire And Loading Information Placard .......273, 274
Tire Markings ........................... .266
Tires............................ .88, 278, 401
Aging (Life Of Tires) .....................287
Air Pressure .......................... .278
Chains .............................. .290
Compact Spare ........................ .284
General Information .....................278
High Speed .......................... .281
Inflation Pressures ...................... .279
Life Of Tires .......................... .287
Load Capacity ..................... .273, 274
Pressure Monitor System (TPMS) ............291
Pressure Warning Light ...................162
Quality Grading ....................... .401Radial
.............................. .281
Replacement .......................... .288
Rotation ............................. .290
Safety ........................... .266, 278
Sizes ............................... .268
Spinning ............................ .286
Tread Wear Indicators ....................286
Tire Safety Information .....................266
Tire Service Kit .......................... .313
Towing ............................ .306, 329
Disabled Vehicle ....................... .329
Recreational .......................... .306
Towing Vehicle Behind A Motorhome ...........306
Traction ............................ .250, 251
Traction Control ......................... .262
Trailer Towing .......................... .306
Transmission ........................... .357
Fluid ............................... .383
Shifting .......................... .241,

24410
INDEX 417