2016 DODGE GRAND CARAVAN jacking

WHAT TO DO IN EMERGENCIES
CONTENTS
HAZARD WARNING FLASHERS ...........567
 IF YOUR ENGINE OVERHEATS ............567
 TIRE SERVICE KIT — IF EQUIPPED .........568
▫ Tire Service Kit Storage .................569
▫ Tire Service Kit Components And Operation . .570
▫ Tire Service Kit Usage Precautions ..........571
▫ Sealing A Tire With Tire Service Kit .........573
 WHEEL AND TIRE TORQUE
SPECIFICATIONS ..................... .580
▫ Torque Specifications ...................580 
JACKING AND TIRE CHANGING — IF
EQUIPPED .......................... .581
▫ Jack Location ....................... .582
▫ Spare Tire Removal ....................583
▫ To Access Spare Tire Winch Drive Nut .......583
▫ Spare Tire Tools ...................... .585
▫ Spare Tire Removal Instructions ...........587
▫ Preparations For Jacking ................589
▫ Jacking Instructions ...................589
▫ Securing The Compact Spare Tire ..........596
6

After 25 miles (40 km) check the lug nut/bolt torque to be
sure that all the lug nuts/bolts are properly seated
against the wheel.
WARNING!
To avoid the risk of forcing the vehicle off the jack,
do not tighten the lug nuts fully until the vehicle has
been lowered. Failure to follow this warning may
result in personal injury.
JACKING AND TIRE CHANGING — IF EQUIPPED
WARNING!
•Do not attempt to change a tire on the side of the
vehicle close to moving traffic. Pull far enough off
the road to avoid the danger of being hit when
operating the jack or changing the wheel.
• Being under a jacked-up vehicle is dangerous. The
vehicle could slip off the jack and fall on you. You
could be crushed. Never put any part of your body
(Continued)
Torque Patterns
6
WHAT TO DO IN EMERGENCIES 581

Preparations For Jacking
1. Park the vehicle on a firm, level surface. Avoid ice orslippery areas.
WARNING!
Do not attempt to change a tire on the side of the
vehicle close to moving traffic, pull far enough off
the road to avoid being hit when operating the jack
or changing the wheel.
2. Turn on the Hazard Warning flasher.
3. Set the parking brake.
4. Place the shift lever into PARK.
5. Turn OFF the ignition. 6. Block both the front and rear of the wheel diagonally
opposite of the jacking position. For
example, if changing the right front
tire, block the left rear wheel.
NOTE: Passengers should not remain
in the vehicle when the vehicle is
being jacked.
Jacking Instructions
WARNING!
Carefully follow these tire changing warnings to
help prevent personal injury or damage to your
vehicle:
• Always park on a firm, level surface as far from the
edge of the roadway as possible before raising the
vehicle.
(Continued)
6
WHAT TO DO IN EMERGENCIES 589

CAUTION!
Do not attempt to raise the vehicle by jacking on
locations other than those indicated in the Jacking
Instructions for this vehicle.
NOTE: Refer to the “Compact Spare Tire” section of
“Tires – General Information” for information about the
compact spare tire, its use, and operation.
1. Loosen (but do not remove) the wheel lug nuts by turning them to the left one turn while the wheel is
still on the ground.
2. There are two jack engagement locations on each side of the vehicle body. These locations are on the sill
flange of the vehicle body.
CAUTION!
Do not attempt to raise the vehicle by jacking on
locations other than those indicated.
Jack Locations
6
WHAT TO DO IN EMERGENCIES 591

Rear jack locations are between a pair of down-facing
tabs on the sill flange of the vehicle side body.
Rear Jacking Locations
Rear Jack Engaged
592 WHAT TO DO IN EMERGENCIES

Traction Control System...................495
Electronic Speed Control (Cruise Control) ........235
Electronic Stability Control (ESC) ..............495
Electronic Throttle Control Warning Light ........321
Electronic Vehicle Information Center (EVIC) ......339
Emergency, In Case Of Hazard Warning Flasher ..................567
Jacking .......................... .581, 589
Jump Starting ......................... .600
Overheating .......................... .567
Emission Control System Maintenance ..........615
Engine Air Cleaner .......................... .621
Block Heater ......................... .468
Break-In Recommendations ................118
Checking Oil Level ..................... .618
Compartment ......................... .613
Compartment Identification ................613
Coolant (Antifreeze) ..................630, 661 Cooling
............................. .629
Exhaust Gas Caution .................119,540
Flooded, Starting ...................... .466
Fuel Requirements ...................536, 660
Oil .......................... .618, 660, 661
Oil Filter ............................ .621
Oil Selection ...................... .619, 660
Oil Synthetic ......................... .620
Overheating .......................... .567
Starting ............................. .465
Engine Oil Viscosity ...................... .620
Engine Oil Viscosity Chart ...................620
Enhanced Accident Response Feature ............89
Entry System, Illuminated ....................19
Ethanol ............................ .537, 540
Event Data Recorder ........................92
Exhaust Gas Caution ....................119,540
Exhaust System .......................119,622
10
INDEX 689

Opener, Garage Door (HomeLink).............254
Operator Manual (Owner’s Manual) .............4
Outside Rearview Mirrors ................131, 133
Overhead Console ........................ .250
Overhead Travel Information Center ............250
Overheating, Engine ...................... .567
Owner’s Manual (Operator Manual) ..........4,679
Paint Care ............................. .640
Panic Alarm ..............................25
Parking Brake ........................... .485
ParkSense System, Rear .....................240
Personal Settings ......................... .352
Pets ...................................117
Placard, Tire And Loading Information ..........508
Power Brakes .............................. .488
Door Locks ............................36
Lift Gate ..............................52 Mirrors
............................. .134
Outlet (Auxiliary Electrical Outlet) ...........267
Seats ............................... .184
Sliding Door ...........................44
Steering .......................... .483, 484
Sunroof ............................. .264
Windows ..............................38
Power Steering Fluid ...................... .663
Pregnant Women And Seat Belts ...............70
Preparation For Jacking .....................589
Pretensioners Seat Belts ..............................71
Programmable Electronic Features .............352
Radial Ply Tires ......................... .515
Radiator Cap (Coolant Pressure Cap) ...........633
Radio Operation ......................... .439
Radio Remote Controls .....................437
Rear Air Conditioning ...................445, 455
696 INDEX

Sway Control, Trailer...................... .500
Synthetic Engine Oil ...................... .620
System, Remote Starting .....................30
Telescoping Steering Column .................233
Temperature Control, Automatic (ATC) ..........448
Tilt Steering Column ...................... .233
Tire And Loading Information Placard .......507, 508
Tire Markings ........................... .501
Tires........................... .122, 512, 681
Aging (Life Of Tires) .....................522
Air Pressure .......................... .512
Chains .............................. .524
Changing ............................ .581
Compact Spare ........................ .519
General Information .....................512
High Speed .......................... .515
Inflation Pressures ...................... .513
Jacking .......................... .581, 589Life Of Tires
.......................... .522
Load Capacity ..................... .507, 508
Pressure Monitor System (TPMS) ............527
Pressure Warning Light ...................332
Quality Grading ....................... .681
Radial .............................. .515
Replacement .......................... .523
Rotation ............................. .526
Safety ........................... .501, 512
Sizes ............................... .502
Snow Tires ........................... .517
Spare Tire ............................ .583
Spinning ............................ .521
Trailer Towing ........................ .557
Tread Wear Indicators ....................521
Tire Safety Information .....................501
Tire Service Kit .......................... .568
T

ongue Weight/Trailer Weight ................554
Torque Converter Clutch ....................480
700 INDEX