2016 Citroen GRAND C4 PICASSO RHD fuel filter

8
Maintenance - Technical data
Petrol weights 322-323
Diesel   weights  3 26 -327
Running
 
out
 
of
 
fuel,
 
Diesel
 
(

priming pump)
 
3

19
Checking
 
levels
 
2

72-274
-
 
o

il
-
 
b

rake
 
fluid
-
 c

oolant
-
 
s

creenwash
 
fluid
Checking
 
components
 
2

75 -276
-
 
a

ir
 
filter
-
 p

assenger
 c

ompartment
 f

ilter
-
 
o

il
 
filter
-
 
e

lectric
 
parking
 
brake
-
 
b

rake
 
pads
 
/
 
discs
Changing
 bu

lbs
 2

99-307
-
 
f

ront
-
 
r

ear Opening
 
the
 
bonnet
 
2

69
Under
 
the
 
bonnet,
 
petrol
 
2

70
Under
 
the
 
bonnet,
 
Diesel
 
2

71
Petrol
 
engines
 
3

20 -321
Diesel
 
engines
 
3

24-325 Identification
 ma

rkings
 3
29
Dimensions
 3

28
12V
 
battery
 
3

13 -316
Load
 
reduction,
 
economy
 
mode
 
2

63
Engine
 c

ompartment
 
f

uses
 
3

08 -309,
 
312
Over view

10
Limit the causes of excess consumption
Spread loads throughout the vehicle; place the heaviest items in the bottom   of   the   boot,   as   close   as   possible   to   the   rear   seats.
Limit
  the   loads   carried   in   the   vehicle   and   reduce   wind   resistance   (roof  
b

ars,   roof   rack,   bicycle   carrier,   trailer...).   Use   a   roof   box   in   preference.
Remove
  roof   bars   and   roof   racks   after   use.
At
  the   end   of   winter,   remove   snow   tyres   and   refit   your   summer   tyres.
Observe the recommendations
on maintenance
Check the tyre pressures regularly, when cold, referring to the label in the   door   aperture,   driver's   side.
Carry
  out   this   check   in   particular:
-
 
b
efore   a   long   journey,
-
 
a
t   each   change   of   season,
-
 
a
fter   a   long   period   out   of   use.
Don't
  forget   the   spare   wheel   and   the   tyres   on   any   trailer   or   caravan.
Have
  your   vehicle   serviced   regularly   (engine   oil,   oil   filter,   air   filter,  
p

assenger   compartment   filter...)   and   observe   the   schedule   of  
o

perations   recommended   in   the   manufacturer's   service   schedule.
With
  a   BlueHDi   Diesel   engine,   if   the   SCR   system   is   faulty   your   vehicle  
b

ecomes   polluting;   go   to   a   CITROËN   dealer   or   a   qualified   workshop  
w

ithout   delay   to   have   the   emissions   of   nitrogen   oxides   brought   back   to  
t

he   legal   level.
When
  refuelling,   do   not   continue   after   the   third   cut-off   of   the   nozzle   to  
a

void   any   over flow.
At
  the   wheel   of   your   new   vehicle,   it   is   only   after   the   first   1   800   miles  
(

3 000   kilometres)   that   you   will   see   the   fuel   consumption   settle   down   to  
a

  consistent   average.
Eco-driving

274
Coolant level
The coolant level should be close to   the   "MA X"   mark   but   should   never  
e

xceed   it.
In
 
addition,   as   the   cooling   system   is   pressurised,
 w

ait
 
at
 
least   one   hour   after   switching   off   the
 e

ngine
 
before   carrying   out   any   work.
To
 
avoid
 
any   risk   of   scalding,   unscrew   the   cap  
b

y
 
two
 
turns   to   allow   the   pressure   to   drop.  
W

hen
 
the
  pressure   has   dropped,   remove   the  
c

ap
 
and
 
top-up   the   level.
Fluid specification
The coolant must conform to the manufacturer's r ecommendations.
The cooling fan may star t after switching
off the engine: take care with ar ticles and
clothing that might be caught by the fan
blades. When   the   engine   is   warm,   the   temperature   of  
t

he   coolant   is   regulated   by   the   fan.To p p i n g - u p
The reservoir must be topped-up without delay b
y   a   CITROËN   dealer   or   a   qualified   workshop.
Diesel fuel additive level
(Diesel with particle filter)
The additive reservoir low level is indicated   by   fixed   illumination   of   this  
w

arning   lamp,   accompanied   by   an  
a

udible   signal   and   a   message   that  
t

he   particle   filter   additive   level   is  
t

oo low.
The
 
warning   lamp   comes   on   when   the   ignition  
i

s
 
switched   on,   or   every   time   the   stalk   is  
o

perated,
  until   the   reservoir   is   refilled.
Next
 
time
  you   stop,   refill   the   screenwash   /  
h

eadlamp
  wash   reservoir.
Screenwash/headlamp
wash level low
In the case of vehicles fitted with h
eadlamp   washers,   when   the   fluid r

eservoir   low   level   is   reached   this
 w

arning   lamp   comes   on   in   the
 i

nstrument   panel,   accompanied   by   an
 a

udible   signal   and   a   message. Avoid
  prolonged   contact   of   used   oil   or  
f

luids   with   the   skin.
Most
  of   these   fluids   are   harmful   to  
h

ealth   or   indeed   very   corrosive.
Do
  not   discard   used   oil   or   fluids   into  
s

ewers   or   onto   the   ground.
Take
  used   oil   to   a   CITROËN   dealer   or  
a

  qualified   workshop   (France)   or   to   an  
a

uthorised   waste   disposal   site.
Used products
Practical information

277
AdBlue® additive and SCR system
f
or
 
BlueHDi   Diesel   engines
To assure respect for the environment and c
onformity   with   the   new   Euro   6   emissions  
s

tandard,   without   adversely   affecting   the  
p

er formance   or   fuel   consumption   of   Diesel  
e

ngines,   CITROËN   has   taken   the   decision   to  
e

quip   its   vehicles   with   an   effective   system   that  
a

ssociates   SCR   (Selective   Catalytic   Reduction)  
w

ith   a   particle   filter   (FAP)   for   the   treatment   of  
e

xhaust   gases.
Presentation of the SCR system
Using a fluid called AdBlue® containing urea, a c
atalytic
 
converter
 
turns
 
up
 
to   85%   of   nitrogen  
o

xides
 
(NOx)
 
into
 
nitrogen
 
and   water,   which   are  
h

armless
 
to
 
health
 
and
 
the
 
environment. The
  AdBlue
® additive is held in a special t
ank
 
located
  under   the   boot   at   the   rear   of  
t

he
 
vehicle.
 
It   has   a   capacity   of   17   litres:   this  
p

rovides
 
a
 
driving   range   of   about   12   500   miles  
(

20
 
000
 
km),
  after   which   an   alert   is   triggered  
w

arning
 
you
 
when   the   reserve   remaining   is  
e

nough
 
for
 
just   1   500   miles   (2   400   km).
During
 
each
  scheduled   service   of   your   vehicle  
b

y
 
a
 
CITROËN   dealer   or   a   qualified   workshop,  
t

he
 
AdBlue
® additive tank is refilled in order to a
llow
 
normal   operation   of   the   SCR   system.
If
 
the
 
estimated   mileage   between   two   services  
i

s
 
greater
 
than   12   500   miles   (20   000   km),   we  
r

ecommend
  that   you   go   to   a   CITROËN   dealer  
o

r
 
a
 
qualified   workshop   to   have   the   necessary  
t

op-up
 
carried   out. Once
  the   AdBlue
® tank is empty, a s
ystem
 
required
  by   regulations  
p

revents
 
starting
 
of   the   engine.
If the SCR

is faulty, the level of
emissions
 
from
 
your   vehicle   will   no  
l

onger
 
meet
 
the
 
Euro   6   standard:   you  
v

ehicle
 
becomes
 
polluting.
In
 
the
 
event
 
of
 
a
 
confirmed   fault  
w

ith
 
the
 
SCR
 
system,   you   must   go  
t

o
 
a
 
CITROËN
 
dealer   or   a   qualified  
w

orkshop
 
as
 
soon   as   possible:   after  
a

 
running
 
distance   of   650   miles  
(

1 100
 
km),
 
a
 
system   will   be   triggered  
a

utomatically
 
to
 
prevent   engine   starting.
7
Practical information

320
Petrol enginePureTech 110 S&SPureTech 130 S&S
Gearbox Manual
 (

6-speed)Manual
 (

6-speed)EAT6
  automatic   (6 -speed)
Model code 3D
3D...
 3

E...
 3
A...3D...
 3

E...
 3
A...
HNX...
M/1S
  -   M/2SMHNY…
M/1S
  -   M/2SMHNY…
T/1S
  -   T/2S
Cubic capacity (cc) 1
  199
Bore
  x   stroke   (mm) 75
  x   90.5
Max
  power*:   EU   standard   (kW) 96
Max
  power   engine   speed   (rpm) 5
  500
Max
  torque:   EU   standard   (Nm) 230
Max
  torque   engine   speed   (rpm) 1
  750
Fuel Unleaded
Catalytic converter yes
Engine
  oil   capacity,   with   filter   replacement  
(in litres) 4.25
Petrol engines and gearboxes
3D...: 
CITROËN   C4   Picasso   (5 -seat). 3A...:  CITROËN   Grand   C4   Picasso   (7-seat).
3E...:  CITROËN   Grand   C4   Picasso   (5 -seat).
* 
 
T
he   maximum   power   corresponds   to   the   value   type-approved   on   a   test   bed,   under   conditions   defined   in   European   legislation  
(Directive
 1

999/99/EC).
Technical data

321
3D...: CITROËN   C4   Picasso   (5 -seat). 3A...:  CITROËN   Grand   C4   Picasso   (7-seat).
3E...:  CITROËN   Grand   C4   Picasso   (5 -seat).
* 
 
T
he   maximum   power   corresponds   to   the   value   type-approved   on   a   test   bed,   under   conditions   defined   in   European   legislation  
(Directive
 1

999/99/EC).
Petrol engine
THP 150 / 160THP 165 S&S
Gearbox EAT6   automatic   (6 -speed)
EAT6   automatic   (6 -speed)
Model code 3D...
 3
E...
 3
A...
3D...
 3
E...
 3
A...
5GX   -   5GY...
A-A/1-A/2-A/D-
 A/
1D-
 A/
2D-Y-Y/1-Y/2
5G Z T/S
Cubic capacity (cc) 1   598
1   598
Bore   x   stroke   (mm)
77   x   85.8
77   x   85.8
Max   power*:   EU   standard   (kW)
110   /   121
121
Max   power   engine   speed   (rpm)
6   000
6   000
Max   torque:   EU   standard   (Nm)
240 240
Max   torque   engine   speed   (rpm)
1   400
1   400
Fuel UnleadedUnleaded
Catalytic converter yesyes
Engine   oil   capacity   (in   litres)  
(with   filter   replacement)
4.25
4.25
9
Technical data

324
Diesel engines and gearboxes
.../S: e-HDi model fitted with Stop & Start.
3 D...:  CITROËN   C4   Picasso   (5 -seat).3E...: 
CITROËN   Grand   C4   Picasso   (5 -seat).
3A...:  CITROËN   Grand   C4   Picasso   (7-seat).
Diesel engine
HDi 115BlueHDi 100 S&S
Gearbox Manual
 (
6-speed)
Manual
 (
6-speed)
Model code 3D...
 3
E...
 3
A...
3D...
 3
E...
 3
A...
9HC... 8   -   8/1
BHY...
6/1S   -   6/2SM
Cubic capacity (cc) 1   560
1   560
Bore   x   stroke   (mm)
75   x   88.3
75   x   88.3
Max   power*:   EU   standard   (kW)
85 73
Max   power   engine   speed   (rpm)
3   600
3   750
Max   torque:   EU   standard   (Nm)
270 254
Max   torque   engine   speed   (rpm)
1   750
1   750
Fuel DieselDiesel
Catalytic converter yesyes
Particle filter noyes
Engine   oil   capacity,   with   filter   replacement  
(in litres) 3.75
3.75
*   
T
he   maximum   power   corresponds   to   the   value   type-approved   on   a   test   bed,   under   conditions   defined   in   European   legislation  
(Directive
 1

999/99/EC).
Technical data

325
Diesel engines and gearboxes
.../S: e-HDi model fitted with Stop & Start.
3 D...:  CITROËN   C4   Picasso   (5 -seat).3E...: 
CITROËN   Grand   C4   Picasso   (5 -seat).
3A...:  CITROËN   Grand   C4   Picasso   (7-seat).
Diesel engine
BlueHDi 115/120 S&SBlueHDi 135/15 0 S&S
Gearbox Manual
(6-speed) EAT6   automatic  
(

6-speed)
Manual
(6-speed) EAT6   automatic  
(

6-speed)
Model code 3D...
 3
E...
 3
A... 3D...
 3
E...
 3
A... 3D...
 3
E...
 3
A... 3D...
 3
E...
 3
A...
BHZ   -   BHX...
M/S   -   M/1S
BHZ   -   BHX...
T/1S   -   T/2S
AHX-AHR-AHV-AHS...
M/S   -   M/1S
AHX...
T/S   -   T/1S
Cubic capacity (cc) 1   560
1   997
Bore   x   stroke   (mm)
75   x   88.3
85   x   88
Max   power*:   EU   standard   (kW)
85   /   88
11 0
Max   power   engine   speed   (rpm)
3   500
3   750
Max   torque:   EU   standard   (Nm)
300 370
Max   torque   engine   speed   (rpm)
1   750
1   750
Fuel DieselDiesel
Catalytic converter yesyes
Particle filter yesyes
Engine   oil   capacity,   with   filter   replacement  
(in litres) 3.75
6 .1
*   
T
he   maximum   power   corresponds   to   the   value   type-approved   on   a   test   bed,   under   conditions   defined   in   European   legislation  
(Directive
 1

999/99/EC).
9
Technical data