2016 Citroen GRAND C4 PICASSO RHD fuel cap

32
Low fuel levelfixed,   accompanied   by  a
n   audible   signal   and  
a

  message. When
  it   first   comes   on   there   remains  a
pproximately 6 litres of fuel in the
tank.
You
  are   then   using   the   fuel   reserve.You
  must   refuel   as   soon   as   possible   to   avoid   running  o
ut   of   fuel.
Until
  sufficient   fuel   is   added,   this   warning   lamp   will  
c

ome   on   every   time   the   ignition   is   switched   on,  
a

ccompanied   by   an   audible   signal   and   a   message.
This
  audible   signal   and   message   are   repeated  
w

ith   increasing   frequency   as   the   fuel   level   drops  
t

owards "0".
Fuel
  tank   capacity:   approximately   57   litres   (petrol)   or  
5

5   litres   (Diesel).
Never
  continue   to   drive   until   you   run   out   of   fuel   as  
t

his   could   damage   the   emission   control   and   injection  
s

ystems.
Warning / indicator lamp
StateCause Action / Observations
Seat belt(s)
not fastened /
unfastened fixed
or
  flashing  
a

ccompanied   by   an  
a

udible
 s
ignal.A
  seat   belt   has   not   been   fastened   or  
h

as   been   unfastened.Pull
  the   strap   then   insert   the   tongue   in   the   buckle.
Airbags on
  temporarily. This   warning   lamp   comes   on   for   a  
f

ew   seconds   when   you   turn   on   the  
i

gnition,   then   goes   off.
This warning lamp should go off when the engine is started.
I f   it   does   not   go   off,   contact   a   CITROËN   dealer   or   a   qualified  
w

orkshop.
fixed. One   of   the   airbag   or   seat   belt  p
retensioner   systems   has   a   fault.Have
  them   checked   by   a   CITROËN   dealer   or   a  q
ualified w orkshop.
Passenger
airbag system flashing.
The
  passenger   airbag   system   has   a  
f

ault. Do
  not   have   a   passenger   seated   in   the   front  
p

assenger
 sea
t.
Have
  it   checked   by   a   CITROËN   dealer   or   a   qualified  
w

orkshop.
Instruments

255
Fuel
Capacity of the tank: approximately 57 litres (petrol) or 55 litres (Diesel).
Low fuel levelRefuelling
When the low fuel level is reached, t
his   warning   lamp   comes   on   in   the  
i

nstrument   panel,   accompanied   by   an  
a

udible   warning   and   a   message   and  
t

he   last   bar   of   the   fuel   gauge   comes  
o

n   in   orange.
F
 
T
ake   care   to   select   the   pump   that   delivers  
t

he   correct   type   of   fuel   for   your   vehicle.
F
 
I
ntroduce   the   nozzle   so   as   to   push   in   the  
m

etal   non-return   flap   A.
F
 
M
ake   sure   that   the   nozzle   is   pushed   in   as  
f

ar   as   possible   before   starting   to   refuel  
(risk
  of   blowback).
F
 
M
aintain   this   position   throughout   the  
r

efuelling
 ope
ration.
F
 
P
ush   the   fuel   flap   to   close   it.
If you are filling your tank to the top, do
not persist after the 3rd cut- off; this could
cause malfunctions.
A
  label   on   the   inside   of   the   fuel   filler   flap  
r

eminds   you   of   the   type   of   fuel   to   use,  
d

epending   on   your   engine   type.
Additions
  of   fuel   must   be   of   at   least   5   litres   to  
b

e   registered   by   the   fuel   gauge.
When
 
it
 
first   comes   on,   about 6 litres of fuel
remain
 
in
 
the   tank.
Until
 
sufficient   fuel   has   been   added,   this  
w

arning
 
lamp   appears   every   time   the   ignition  
i

s
 
switched   on,   accompanied   by   an   audible  
w

arning
 
and   a   message.   This   audible   warning  
a

nd
 
message   are   repeated   with   increasing  
f

requency
  as   the   fuel   level   drops   towards   "0 ".
Refuel
 
as
 
soon   as   possible   to   avoid   running   out.Opening
  the   filler   flap   may   result   in   an   inrush   of  
a

ir.   This   is   entirely   normal   and   results   from   the  
s

ealing   of   the   fuel   system.
F
 
W
ith   the   vehicle   unlocked,   press   the   rear  
e

dge   of   the   flap   to   open   it   (the   filler   cap   is   a  
p

art   of   it).
With Stop & Start, never refuel with the
system
  in   STOP   mode;   you   must   switch  
o

ff
 
the   ignition   with   the   START/STOP  
b

utton.
7
Practical information

274
Coolant level
The coolant level should be close to   the   "MA X"   mark   but   should   never  
e

xceed   it.
In
 
addition,   as   the   cooling   system   is   pressurised,
 w

ait
 
at
 
least   one   hour   after   switching   off   the
 e

ngine
 
before   carrying   out   any   work.
To
 
avoid
 
any   risk   of   scalding,   unscrew   the   cap  
b

y
 
two
 
turns   to   allow   the   pressure   to   drop.  
W

hen
 
the
  pressure   has   dropped,   remove   the  
c

ap
 
and
 
top-up   the   level.
Fluid specification
The coolant must conform to the manufacturer's r ecommendations.
The cooling fan may star t after switching
off the engine: take care with ar ticles and
clothing that might be caught by the fan
blades. When   the   engine   is   warm,   the   temperature   of  
t

he   coolant   is   regulated   by   the   fan.To p p i n g - u p
The reservoir must be topped-up without delay b
y   a   CITROËN   dealer   or   a   qualified   workshop.
Diesel fuel additive level
(Diesel with particle filter)
The additive reservoir low level is indicated   by   fixed   illumination   of   this  
w

arning   lamp,   accompanied   by   an  
a

udible   signal   and   a   message   that  
t

he   particle   filter   additive   level   is  
t

oo low.
The
 
warning   lamp   comes   on   when   the   ignition  
i

s
 
switched   on,   or   every   time   the   stalk   is  
o

perated,
  until   the   reservoir   is   refilled.
Next
 
time
  you   stop,   refill   the   screenwash   /  
h

eadlamp
  wash   reservoir.
Screenwash/headlamp
wash level low
In the case of vehicles fitted with h
eadlamp   washers,   when   the   fluid r

eservoir   low   level   is   reached   this
 w

arning   lamp   comes   on   in   the
 i

nstrument   panel,   accompanied   by   an
 a

udible   signal   and   a   message. Avoid
  prolonged   contact   of   used   oil   or  
f

luids   with   the   skin.
Most
  of   these   fluids   are   harmful   to  
h

ealth   or   indeed   very   corrosive.
Do
  not   discard   used   oil   or   fluids   into  
s

ewers   or   onto   the   ground.
Take
  used   oil   to   a   CITROËN   dealer   or  
a

  qualified   workshop   (France)   or   to   an  
a

uthorised   waste   disposal   site.
Used products
Practical information

277
AdBlue® additive and SCR system
f
or
 
BlueHDi   Diesel   engines
To assure respect for the environment and c
onformity   with   the   new   Euro   6   emissions  
s

tandard,   without   adversely   affecting   the  
p

er formance   or   fuel   consumption   of   Diesel  
e

ngines,   CITROËN   has   taken   the   decision   to  
e

quip   its   vehicles   with   an   effective   system   that  
a

ssociates   SCR   (Selective   Catalytic   Reduction)  
w

ith   a   particle   filter   (FAP)   for   the   treatment   of  
e

xhaust   gases.
Presentation of the SCR system
Using a fluid called AdBlue® containing urea, a c
atalytic
 
converter
 
turns
 
up
 
to   85%   of   nitrogen  
o

xides
 
(NOx)
 
into
 
nitrogen
 
and   water,   which   are  
h

armless
 
to
 
health
 
and
 
the
 
environment. The
  AdBlue
® additive is held in a special t
ank
 
located
  under   the   boot   at   the   rear   of  
t

he
 
vehicle.
 
It   has   a   capacity   of   17   litres:   this  
p

rovides
 
a
 
driving   range   of   about   12   500   miles  
(

20
 
000
 
km),
  after   which   an   alert   is   triggered  
w

arning
 
you
 
when   the   reserve   remaining   is  
e

nough
 
for
 
just   1   500   miles   (2   400   km).
During
 
each
  scheduled   service   of   your   vehicle  
b

y
 
a
 
CITROËN   dealer   or   a   qualified   workshop,  
t

he
 
AdBlue
® additive tank is refilled in order to a
llow
 
normal   operation   of   the   SCR   system.
If
 
the
 
estimated   mileage   between   two   services  
i

s
 
greater
 
than   12   500   miles   (20   000   km),   we  
r

ecommend
  that   you   go   to   a   CITROËN   dealer  
o

r
 
a
 
qualified   workshop   to   have   the   necessary  
t

op-up
 
carried   out. Once
  the   AdBlue
® tank is empty, a s
ystem
 
required
  by   regulations  
p

revents
 
starting
 
of   the   engine.
If the SCR

is faulty, the level of
emissions
 
from
 
your   vehicle   will   no  
l

onger
 
meet
 
the
 
Euro   6   standard:   you  
v

ehicle
 
becomes
 
polluting.
In
 
the
 
event
 
of
 
a
 
confirmed   fault  
w

ith
 
the
 
SCR
 
system,   you   must   go  
t

o
 
a
 
CITROËN
 
dealer   or   a   qualified  
w

orkshop
 
as
 
soon   as   possible:   after  
a

 
running
 
distance   of   650   miles  
(

1 100
 
km),
 
a
 
system   will   be   triggered  
a

utomatically
 
to
 
prevent   engine   starting.
7
Practical information

278
Freezing of the AdBlue® additive
The
 
AdBlue
® additive freezes at t
emperatures   below   around   -11°C.
The
 
SCR
 
system   includes   a   heater  
f

or
 
the
 
AdBlue
® tank, allowing you to c
ontinue
 
driving   in   very   cold   conditions.
Topping-up the AdBlue®
Filling the AdBlue® tank is an operation i
ncluded
 
in
 
every
 
routine   service   on   your  
v

ehicle
 
by
 
a
 
CITROËN   dealer   or   a   qualified  
w

orkshop.
Nevertheless,
 
given   the   capacity   of   the   tank,   it  
m

ay
 
be
 
necessary
  to   top-up   the   fluid   between  
s

ervices,
 
more
 
particularly   if   an   alert   (warning  
l

amps
 
and
 
a
 
message)   signals   the   requirement.
You
 
can
 
go
 
to
 
a
 
CITROËN   dealer   or   a   qualified  
w

orkshop.
If
 
you
 
envisage
 
topping-up   yourself,   please  
r

ead
 
the
 
following
 
warnings   carefully.Precautions in use
Use only AdBlue® fluid that meets the I
SO 22241
 
standard.
AdBlue® is a urea-based solution. This liquid is n
on-flammable,   colourless   and   odourless   (kept  
i

n
 
a
 
cool   area).
In
 
the
 
event   of   contact   with   the   skin,   wash  
t

he
 
affected   area   with   soap   and   water.   In   the  
e

vent
 
of
  contact   with   the   eyes,   wash   (irrigate)  
t

he
 
eyes   with   large   amounts   of   water   or   with  
a

n
 
eye
 
wash   solution   for   at   least   15   minutes.  
I

f
 
a
 
burning   sensation   or   irritation   persists,   get  
m

edical
  attention.
If
 
swallowed,   immediately   wash   out   the   mouth  
w

ith
 
clean   water   and   then   drink   plenty   of   water.
In
 
certain   conditions   (high   ambient  
t

emperature,   for   example),   the   risk   of   release   of  
a

mmonia   cannot   be   excluded:   do   not   inhale   the  
f

luid.
 
Ammonia   vapour   has   an   irritant   effect   on  
m

ucous
  membranes   (eyes,   nose   and   throat).The
  supply   in   a   non-drip   bottle   simplifies  
t

opping-up.   You   can   obtain   1.89   litre   (half   a   US  
g

allon)   bottles   from   a   CITROËN dealer   or   a  
q

ualified
 w
orkshop.
Never
  dilute   AdBlue
® with water.
N
ever
 
pour
 
AdBlue® into the Diesel fuel
tank.
Never
 
top-up
 
from
 
an   AdBlue
®
dispenser
 
reserved
 
for
 
heavy
 
goods  
v

ehicles.
Keep
 
AdBlue
® out of the reach of
children,
 
in
 
its
  original   bottle.
Never
 
transfer   AdBlue
® to another
container:
 
it
 
would
 
lose
  its   purity.
Practical information

320
Petrol enginePureTech 110 S&SPureTech 130 S&S
Gearbox Manual
 (

6-speed)Manual
 (

6-speed)EAT6
  automatic   (6 -speed)
Model code 3D
3D...
 3

E...
 3
A...3D...
 3

E...
 3
A...
HNX...
M/1S
  -   M/2SMHNY…
M/1S
  -   M/2SMHNY…
T/1S
  -   T/2S
Cubic capacity (cc) 1
  199
Bore
  x   stroke   (mm) 75
  x   90.5
Max
  power*:   EU   standard   (kW) 96
Max
  power   engine   speed   (rpm) 5
  500
Max
  torque:   EU   standard   (Nm) 230
Max
  torque   engine   speed   (rpm) 1
  750
Fuel Unleaded
Catalytic converter yes
Engine
  oil   capacity,   with   filter   replacement  
(in litres) 4.25
Petrol engines and gearboxes
3D...: 
CITROËN   C4   Picasso   (5 -seat). 3A...:  CITROËN   Grand   C4   Picasso   (7-seat).
3E...:  CITROËN   Grand   C4   Picasso   (5 -seat).
* 
 
T
he   maximum   power   corresponds   to   the   value   type-approved   on   a   test   bed,   under   conditions   defined   in   European   legislation  
(Directive
 1

999/99/EC).
Technical data

321
3D...: CITROËN   C4   Picasso   (5 -seat). 3A...:  CITROËN   Grand   C4   Picasso   (7-seat).
3E...:  CITROËN   Grand   C4   Picasso   (5 -seat).
* 
 
T
he   maximum   power   corresponds   to   the   value   type-approved   on   a   test   bed,   under   conditions   defined   in   European   legislation  
(Directive
 1

999/99/EC).
Petrol engine
THP 150 / 160THP 165 S&S
Gearbox EAT6   automatic   (6 -speed)
EAT6   automatic   (6 -speed)
Model code 3D...
 3
E...
 3
A...
3D...
 3
E...
 3
A...
5GX   -   5GY...
A-A/1-A/2-A/D-
 A/
1D-
 A/
2D-Y-Y/1-Y/2
5G Z T/S
Cubic capacity (cc) 1   598
1   598
Bore   x   stroke   (mm)
77   x   85.8
77   x   85.8
Max   power*:   EU   standard   (kW)
110   /   121
121
Max   power   engine   speed   (rpm)
6   000
6   000
Max   torque:   EU   standard   (Nm)
240 240
Max   torque   engine   speed   (rpm)
1   400
1   400
Fuel UnleadedUnleaded
Catalytic converter yesyes
Engine   oil   capacity   (in   litres)  
(with   filter   replacement)
4.25
4.25
9
Technical data

324
Diesel engines and gearboxes
.../S: e-HDi model fitted with Stop & Start.
3 D...:  CITROËN   C4   Picasso   (5 -seat).3E...: 
CITROËN   Grand   C4   Picasso   (5 -seat).
3A...:  CITROËN   Grand   C4   Picasso   (7-seat).
Diesel engine
HDi 115BlueHDi 100 S&S
Gearbox Manual
 (
6-speed)
Manual
 (
6-speed)
Model code 3D...
 3
E...
 3
A...
3D...
 3
E...
 3
A...
9HC... 8   -   8/1
BHY...
6/1S   -   6/2SM
Cubic capacity (cc) 1   560
1   560
Bore   x   stroke   (mm)
75   x   88.3
75   x   88.3
Max   power*:   EU   standard   (kW)
85 73
Max   power   engine   speed   (rpm)
3   600
3   750
Max   torque:   EU   standard   (Nm)
270 254
Max   torque   engine   speed   (rpm)
1   750
1   750
Fuel DieselDiesel
Catalytic converter yesyes
Particle filter noyes
Engine   oil   capacity,   with   filter   replacement  
(in litres) 3.75
3.75
*   
T
he   maximum   power   corresponds   to   the   value   type-approved   on   a   test   bed,   under   conditions   defined   in   European   legislation  
(Directive
 1

999/99/EC).
Technical data