2016 Citroen C4 CACTUS fuel filter

8
Running out of fuel, Diesel (priming pump)  2 19
AdBlue
® additive and SCR system (
BlueHDi   Diesel)  1 76 -182
Maintenance - Technical data
Checking levels 1 71-173
-  o il
-
 
b
rake   fluid
-
 c

oolant
-
 
s
creenwash   fluid
-
 
a
dditive   (Diesel   with   particle   filter)
Checking
  components  
1
74-175
-
 b

attery
-
 
a
ir   /   passenger   compartment   filter
-
 
o
il   filter
-
 
p
article   filter   (Diesel)
-
 
b
rake   pads   /   discs
Changing
 bu

lbs
 1
98-205
-
 
f
ront   lamps
-
 
r
ear   lamps
-
 i

nterior
 l
ighting Dimensions
 2

24
Identification
 ma

rkings
 2
25
Petrol
  weights  
2
21
Diesel   weights  
2
23
Opening   the   bonnet  
1
68
Under
  the   bonnet,   petrol  
1
69
Under
  the   bonnet,   Diesel  
1
70
Petrol
  engines  
2
20
Diesel
  engines  
2
22
12V
  battery  
2
13 -216
Load   reduction,   economy   mode  
1
61
Engine
 c
ompartment
 
f
uses  
2
06 -207,   211-212
Over view

10
Limit the causes of excess consumption
Spread loads throughout the vehicle; place the heaviest items in the bottom   of   the   boot,   as   close   as   possible   to   the   rear   seats.
Limit
  the   loads   carried   in   the   vehicle   and   reduce   wind   resistance   (roof  
b

ars,   roof   rack,   bicycle   carrier,   trailer...).   Use   a   roof   box   in   preference.
Remove
  roof   bars   and   roof   racks   after   use.
At
  the   end   of   winter,   remove   snow   tyres   and   refit   your   summer   tyres.
Observe the recommendations on
maintenance
Check the tyre pressures regularly, when cold, referring to the label in the   door   aperture,   driver's   side.
Carry
  out   this   check   in   particular:
-
 
b
efore   a   long   journey,
-
 
a
t   each   change   of   season,
-
 
a
fter   a   long   period   out   of   use.
Don't
  forget   the   spare   wheel   and   the   tyres   on   any   trailer   or   caravan.
Have
  your   vehicle   serviced   regularly   (engine   oil,   oil   filter,   air   filter,  
p

assenger   compartment   filter...)   and   observe   the   schedule   of  
o

perations   in   the   personalised   servicing   schedule   for   your   vehicle.
With
  a   BlueHDi   Diesel   engine,   if   the   SCR   system   develops   a   fault,  
y

our   vehicle   becomes   polluting;   go   to   a   CITROËN   dealer   or   a   qualified  
w

orkshop   without   delay   to   have   the   emissions   of   nitrous   oxides   brought  
w

ithin   the   limits   set   by   the   directive.
When
  refuelling,   do   not   continue   after   the   third   cut-off   of   the   nozzle   to  
a

void   any   over flow.
At
  the   wheel   of   your   new   vehicle,   it   is   only   after   the   first   1   800   miles  
(3
  000   kilometres)   that   you   will   see   the   fuel   consumption   settle   down   to  
a

  consistent   average.
Eco-driving

173
Coolant level
The coolant level should be close to   the   "MA X"   mark   but   should   never  
e

xceed   it.
In
 
addition,   as   the   cooling   system   is   pressurised,
 w

ait
 
at
 
least   one   hour   after   switching   off   the
 e

ngine
 
before   carrying   out   any   work.
To
 
avoid
 
any   risk   of   scalding,   unscrew   the   cap   by
 t

wo
 
turns
 
to   allow   the   pressure   to   drop.   When   the
 p

ressure
 
has   dropped,   remove   the   cap   and   top
 u

p
 
the
 
level.
Changing the coolant
The coolant does not have to be replaced at routine services.
The cooling fan may star t after switching
off the engine: take care with ar ticles and
clothing that might be caught by the fan
blades. When   the   engine   is   warm,   the   temperature   of  
t

he   coolant   is   regulated   by   the   fan.
Fluid specification
The coolant must conform to the ma
nufacturer's r ecommendations.
Fluid specification
For optimum cleaning and to avoid freezing, this   fluid   must   not   be   topped   up   or   replaced  
w

ith   plain   water.
In
 
w
intry  
c
onditions,  
i
t  
i
s  
r
ecommended  
t
hat  
y
ou  
u

se   an   ethyl   alcohol   or   methanol   based   fluid.
Screenwash fluid level
Top up the level when necessary.
To p p i n g u p
The reservoir must be topped up without delay by   a   CITROËN   dealer   or   a   qualified   workshop.
Diesel fuel additive
level (Diesel with particle
filter)
The additive reservoir low level is indicated   by   fixed   illumination   of  
A
void   prolonged   contact   of   used   oil   or  
f

luids   with   the   skin.
Most   of   these   fluids   are   harmful   to  
h

ealth   or   indeed   very   corrosive.
Do   not   discard   used   oil   or   fluids   into  
s

ewers   or   onto   the   ground.
Take   used   oil   to   a   CITROËN   dealer   or  
a

  qualified   workshop   (France)   or   to   an  
a

uthorised   waste   disposal   site.
Used products
this warning lamp, accompanied by an audible s
ignal   and   a   message   that   the   particle   filter  
a

dditive   level   is   too   low.
7
Practical information

176
AdBlue® additive and SCR system
f
or
 
BlueHDi   Diesel   engines
To assure respect for the environment and c
onformity   with   the   new   Euro   6   emissions  
s

tandard,   without   adversely   affecting   the  
p

er formance   or   fuel   consumption   of   Diesel  
e

ngines,   CITROËN   has   taken   the   decision   to  
e

quip   its   vehicles   with   an   effective   system   that  
a

ssociates   SCR   (Selective   Catalytic   Reduction)  
w

ith   a   particle   filter   (FAP)   for   the   treatment   of  
e

xhaust   gases.
Presentation of the SCR system
Using an additive called AdBlue® containing urea, a
 
catalytic
 
converter
 
turns
 
up
 
to
 
85%   of   nitrous o

xides
 
(NOx)
 
into
 
nitrogen
 
and
 
water,   which   are
 h

armless
 
to
 
health
 
and
 
the
 
environment. Once
  the   AdBlue
® tank is empty, a s
ystem
 
required
 
by   regulations   prevents  
s

tarting
 
of
 
the
 
engine.
If the SCR is faulty, the level of
emissions
 
from
 
your   vehicle   will   no  
l

onger
 
meet
 
the
 
Euro   6   standard:   your  
v

ehicle
 
becomes
 
polluting.
In
 
the
 
event
 
of
 
a
 
confirmed   fault  
w

ith
 
the
 
SCR
 
system,   you   must   go  
t

o
 
a
 
CITROËN
 
dealer   or   a   qualified  
w

orkshop
 
as
 
soon   as   possible:   after   a  
r

unning
 
distance
 
of   650   miles  
(1
 
100
 
km),
 
a
 
system   will   be   triggered  
a

utomatically
 
to
 
prevent   engine   starting.
The
 
AdBlue® additive is held in a special t
ank
 
located
  under   the   boot   at   the   rear   of  
t

he
 
vehicle.
 
It   has   a   capacity   of   17   litres:   this  
p

rovides
 
a
 
driving   range   of   about   12   500   miles  
(

20
 
000
 
km),
  after   which   an   alert   is   triggered  
w

arning
 
you
 
when   the   reserve   remaining   is  
e

nough
 
for
 
just   1   500   miles   (2   400   km).
During
 
each
  scheduled   service   of   your   vehicle  
b

y
 
a
 
CITROËN   dealer   or   a   qualified   workshop,  
t

he
 
AdBlue
® additive tank is refilled in order to a
llow
 
normal   operation   of   the   SCR   system.
If
 
the
 
estimated   mileage   between   two   services  
i

s
 
greater
 
than   12   500   miles   (20   000   km),   we  
r

ecommend
  that   you   go   to   a   CITROËN   dealer  
o

r
 
a
 
qualified   workshop   to   have   the   necessary  
t

op-up
 
carried   out.
Practical information

222
Enginee-HDi 92BlueHDi 100 BlueHDi 100 S&S
Gearbox ETG6
 e

lectronic
(6-speed) Manual
(5-speed) Manual
(5-speed) ETG6
 e

lectronic
(6-speed)
Model code 0B9HP0BBHY 0BBHY
Cubic capacity (cc) 1
  5601
  5601
  560
Bore
  x   stroke   (mm) 75
  x   88.375
  x   88.375
  x   88.3
Max
  power:   EU   standard   (kW)* 6873 73
Max
  power   engine   speed   (rpm) 4
  0003
  7503
  750
Max
  torque:   EU   standard   (Nm) 230254 254
Max
  torque   engine   speed   (rpm) 1
  7501
  7501
  750
Fuel DieselDiesel Diesel
Catalytic converter yesyes yes
Particle filter yesyes yes
Engine
  oil   capacity   with   replacement   of   the   oil  
f

ilter (in litres) 3.75
3.75 3.75
*
  
T
he   maximum   power   corresponds   to   the   value   type   approved   on   a   test   bed,   under   conditions   defined   by   European   legislation  
(Directive
 1

999/99/EC).
Engines and gearboxes - DIESEL
Technical data

290
Earth point, remote ............................... 169,   170
EBA ............................................................. ....92
Eco-driving
 (

advice)
 .......................................... 9
E

conomy   mode  
...............................
..............161
Electronic
  brake   force  
distribution
 (

EBFD)
 ....................................... 92
E

lectronic
 g
earbox
 ...............................
.........131
Emergency
 c

all
 ....................................... 9
1,   226
Emissions
  control   system,   SCR  
.....................20
E

nergy   economy   mode  
.................................16

1
Engine
 c

ompartment
 ............................ 1
69,   170 Hazard
 w

arning
 lam
ps
 ............................ 9
1,   185
Headlamps,   automatic   illumination  
..........8
0,   83
Headlamps,   dipped   beam  
.................7
9,   80,   199
Headlamps,   main   beam  
........... 7
9,   80,   198,   200
Head   restraints,   front  
......................................
51
H
ead   restraints,   rear  
.......................................
53
H
eating
 ................
........................... 9,   58,   60,   62
Hill start assist  
...............................................
13
2
Horn ................................................................. 91
Identification,
 v
ehicle
 ....................................2

25
Ignition
 ................

..................................... 65,   124
F
H
I
Filling the fuel tank ........................154,   156,   157
Filter, air ............... ......................................... 174
Filter, oil
 ......................................................... 1

74
Filter, particle
 ........................................ 17

3 ,
 17
4
Filter,
 p

assenger
 c
ompartment
 .....................1

74
Fitting
  roof   bars  
............................................. 16

5
Fittings,
  boot  
............................................. 7
6,   78
Fittings,
 in

terior
 ......................................... 7

0 -75
Flap, fuel filler
 
...............................
.........15 4,
 15

6
Foglamp,
 r

ear
 ...............................
........... 81,   203
Foglamps,
 f

ront
 .........................8
1,   86,   198,   201
Frequency
  (radio)  
..................................2
42,   243
Fuel ................................................................ 157
Fuel
 c

onsumption
 .............................................. 9
F

uel   tank........................................................ 15 4
Fuses
 ................

.................................... 206,   208
E
DG
DAB (Digital Audio Broadcasting) - 
D igital r adio ......................................... 244,   245
Date
  (setting)  
...............................
....................38
Daytime
  running   lamps  
.......................7
9,   80,   84
Daytime
  running   lamps,   LED  
................19

8,
 19
9
Deactivating
 t

he
 p
assenger
 a
irbag
 .......10

1,
 10
8
Deadlocking
 ...............................

...............42,   45
Defrosting
 ...............................

...................66,   67
Demisting
 ...............................

...................66,   67
Diesel
 ...............................

.............................157
Dimensions
 ..............................

.....................224
Dipstick
 ................

.................................... 27,   171
Direction
 i

ndicators
 .......... 8
2,   84,   198,   200,   203
Doors
 ..............................................................

.46
Driving
 e

conomically ......................................... 9
Dynamic
  stability   control  
(

DSC)
 ................................... 1
6,   18,   92,   94,   96Engine,
  Diesel  ......... 1 4,   157,   170,   219,   222,   223
Engine,
  petrol  ........................ 1 57,   169,   220,   221
Engines
 ..............................

..................220,
 2

22
Environment
 ...............................

.................9,   43
ESC (electronic stability control)
 
....................16G

auge,   fuel.............................................. 11,   155
Gearbox, 
e
lectronic
 .............. 9
,   23,   71,   74,   128,   133,   175
Gearbox,
 
m

anual
 ...............
. 9,   70,   74,   126,   132,   133,   175
Gear
  efficiency   indicator  
...............................12

7
Gear
  lever,   manual   gearbox  
.........................12

6
Glove
  box  
..................................................7

0 -72
Grip control
 
.....................................................95
Alphabetical index

292
Table of weights ....................................221,   223
Tables   of   engines  ............................... ..220, 2
22
Tables of fuses
 
...................................... 2
08,   211
Tank,
  AdBlue
® additive ......................... 1 76,   180
Tank,
 
fuel
 ............................... ........................ 15 4
Technical
 da

ta
 ....................................... 2

20-223
Telephone
 ..................................................... 2

74
Third
 
brake
 
lamp  
........................................... 20

4
Three
 
flashes
 
(direction   indicators)  
................82
T
Radio ............... .............................................. 242
Radio,   digital  
(Digital
  Audio   Broadcasting   -   DAB)  
............24

4
RDS
 ................

............................................... 243
Rear
 s

creen,
 d
emisting/defrosting
 .................67
R

echarging   the   battery  
.........................21

3,
 21
5
Recirculation, air
 ...............................

.. 59,   61,   65
Reduction
  of   electrical   load  
..........................16

1
Regeneration
  of   the   particle   filter  
.................1

74
Reinitialisation
  of   the   under-inflation  
detection
  system  
......................................... 15

2
Reinitialising
  the   remote   control  
.....................43
R

eminder,   lighting   on  
...................................... 8

2
Remote
  control  
................................................ 40
R

emoving   a   wheel  
..............................
..........19 4
Removing
  the   mat  
...............................
............75
Replacing
 bu

lbs
 ..............................
..............198
Replacing
 f

uses
 ..............................
..............206
Replacing
  the   air   filter  
...................................1

74
Replacing
  the   oil   filter  
................................... 1

74
Replacing
 t

he
 p
assenger
 
c

ompartment   filter  
...................................... 1

74Safety,
  children  ............... 1 01,   105 -108,   111-119
Screen,
  cold   climate  
.....................................15

9
Screen, colour
 ................................ 2

9,   234,   235
Screen
  menu   map  
............... 2
36,   238,   240,   250,  
2

52,   256,   264,   274,   276
Screenwash, front
 ........................................... 88
S

creenwash, rear
 ...............................
.............88
SCR (Selective Catalytic Reduction)
 .................................................. 17

6
Seat belts
 ........................................... 9

7- 9 9 ,
 111
S

eat, rear bench
 ..............................
...............52
Seats, front
 ...............................

.......................50
Seats, rear
 ....................................................... 52
S

erial   number,   vehicle  
..................................2

25
Service
 i

ndicator
 .............................................24
S

ervicing
 ...............................
..........................10
Settings,
 e

quipment
 ........................................28
S

ettings
 (
Menus)
 ...............................
............264
Settings,
  system  
...............................
.............271
Sidelamps
 ........................ 7

9,   84,   198,   199,   203
Side
 r

epeater
 ..............................
..................202SR
Snow chains .................................................. 15 8
Socket,   12   V   accessory  ............................7
0 -72
Socket,
  auxiliary  
...............................
.............246
Socket,
  JACK  
...............................
...........73,   246
Sockets,
  audio  
........................................7
3,   246
Speed
 l

imiter
 ...............................
.......... 136,   142
Stability control (ESC) ............................... 16,
  92
Starting
  the   engine  
............................... 12

2,
 12
8
Starting
  using   another   battery  
......................2

14
Station,
 ra

dio
 .........................................2
42,   243
Stay, bonnet
 ...............................

...................168
Steering
  wheel,   adjustment  
............................55
S

topping   the   vehicle  
..................................... 12

2
Stop & Start
 ................................1

5,   36,   66,   133,  
1

46,   154,   168,   174,   213,   216
Stop
  (warning   lamp)  
........................................ 17
St

orage
 ................
...................................... 72,   74
Sun visor
 ................................................... 7

0 -72
Switching
  off   the   engine  
...............................12

2
Synchronising
  the   remote   control  
...................43
P

ressures, tyres ............................ 1
86,
 
191,
 
225
Pre-tensioning
 
seat
 
belts
 ................................ 99
P
riming
 pu

mp
 ...............................

................. 219
Priming
 
the
 
fuel
 
system
 
................................ 2

19
Protecting
 
children
 
.......... 1

01,
 
105 -108,
 
111-119
Protectors
 ...................................................... 18

3
Puncture
 ................

........................................ 18 6Reservoir, screenwash .................................
17
3
Resetting
 
the
 
service
 
indicator
 ....................... 26
R
esetting
 
the
 
trip
 
recorder
 
.............................. 37
R

eversing
 c

amera
 ...............................

.......... 145
Reversing
 lam

p
 ............................................. 20

3
Risk
 
areas
 
(update)
 
....................................... 2

61
Roof bars
 ....................................................... 16

5
Running
 
out
 
of
 
fuel
 
(Diesel)
 
.......................... 2

19
Alphabetical index