2016 CHEVROLET VOLT heating

Chevrolet VOLT Owner Manual (GMNA-Localizing-U.S/Canada/Mexico-
9159388) - 2016 - crc - 5/20/15
240 Vehicle Care
Caution
If improper coolant mixture,
inhibitors, or additives are used in
the vehicle cooling system, the
engine could overheat and be
damaged. Too much deionized
water or clean drinkable water
can freeze and crack engine
cooling parts. The repairs would
not be covered by the vehicle
warranty. Use only the proper
mixture of engine coolant for the
cooling system. See
Recommended Fluids and
Lubricants0324.
Never dispose of engine coolant by
putting it in the trash, pouring it on
the ground, or into sewers, streams,
or bodies of water. Have the coolant
changed by an authorized service
center, familiar with legal
requirements regarding used
coolant disposal. This will help
protect the environment and your
health.
Checking Coolant
The vehicle must be on a level
surface when checking the coolant
level.
Check to see if coolant is visible in
the coolant surge tank. If the coolant
inside the coolant surge tank is
boiling, do not do anything else until
it cools down. If coolant is visible
but the coolant level is not at or
above the cold fill mark, add GM
Premix DEX-COOL engine coolant
at the coolant surge tank, but be
sure the cooling system is cool
before this is done. See Engine
Overheating 0242.
The coolant reservoir is on the
passenger side of the engine
compartment. See Engine
Compartment Overview 0231.
The coolant level should be at or
above the cold fill line on the
coolant surge tank. If it is not, there
could be a leak in the cooling
system.
How to Add Coolant to the
Coolant Surge Tank
{Warning
You can be burned if you spill
coolant on hot engine parts.
Coolant contains ethylene glycol
and it will burn if the engine parts
are hot enough. Do not spill
coolant on a hot engine.
Caution
This vehicle has a specific
coolant fill procedure. Failure to
follow this procedure could cause
the engine to overheat and be
severely damaged.
{Warning
The electric fans under the hood
can start up even when the
engine is not running and can (Continued)

Chevrolet VOLT Owner Manual (GMNA-Localizing-U.S/Canada/Mexico-
9159388) - 2016 - crc - 5/20/15
242 Vehicle Care
Engine Overheating
The vehicle has an indicator to warn
of engine overheating.
If the decision is made not to lift the
hood when this warning appears,
get service help right away. See
Roadside Assistance Program
0335.
If the decision is made to lift the
hood, make sure the vehicle is
parked on a level surface.
Then check to see if the engine
cooling fan is running. If the engine
is overheating, the fan should be
running. If it is not, do not continue
to run the vehicle, and have the
vehicle serviced.
Caution
Running the engine without
coolant may cause damage or a
fire. Vehicle damage would not be
covered by the vehicle warranty.
Washer Fluid
What to Use
When adding windshield washer
fluid to the vehicle, be sure to read
the manufacturer's instructions
before use. If operating the vehicle
in an area where the temperature
may fall below freezing, use a fluid
that has sufficient protection against
freezing.
Adding Washer Fluid
Open the cap with the washer
symbol on it. Add washer fluid until
the tank is full. See Engine
Compartment Overview 0231 for
reservoir location.
Caution
. Do not use washer fluid that
contains any type of water
repellent coating. This can
cause the wiper blades to
chatter or skip.
. Do not use engine coolant
(antifreeze) in the
windshield washer. It can
damage the windshield
washer system and paint.
. Do not mix water with
ready-to-use washer fluid.
Water can cause the
solution to freeze and
damage the washer fluid
tank and other parts of the
washer system.
. When using concentrated
washer fluid, follow the
manufacturer instructions for
adding water.
. Fill the washer fluid tank
only three-quarters full when
it is very cold. This allows
for fluid expansion if
(Continued)

Chevrolet VOLT Owner Manual (GMNA-Localizing-U.S/Canada/Mexico-
9159388) - 2016 - crc - 5/20/15
Vehicle Care 261
A fuse puller is in the engine
compartment fuse block.
The vehicle may not have all of the
fuses, relays, and features shown.Fuses Usage
F1 Empty
F2 Empty
F3 Empty
F4 Empty
F5 Pedestrian protection
F6 On-board charger module
F7 Front heated seat
F8 Front heated seat
F9 Driver door/Mirror switches
F10 Empty F11 Amplifier
F12 Steering wheel switch backlighting
F13 Empty
F14 Empty Fuses
Usage
F15 Empty
F16 Empty
F17 Empty
F18 Empty
F19 Obstacle detection
F20 Fuel
F21 Rear heated seat
F22 Right power windows
Relays Usage
K1 Empty
K2 Empty
K3 Empty
K4 Empty
K5 EmptyWheels and Tires
Tires
Every new GM vehicle has
high-quality tires made by a
leading tire manufacturer. See
the warranty manual for
information regarding the tire
warranty and where to get
service. For additional
information refer to the tire
manufacturer.
{Warning
.Poorly maintained and
improperly used tires are
dangerous.
.Overloading the tires can
cause overheating as a
result of too much
flexing. There could be a
blowout and a serious
crash. See Vehicle Load
Limits 0168.
(Continued)

Chevrolet VOLT Owner Manual (GMNA-Localizing-U.S/Canada/Mexico-
9159388) - 2016 - crc - 5/20/15
268 Vehicle Care
Treadwear Indicators:Narrow
bands, sometimes called wear
bars, that show across the tread
of a tire when only 1.6 mm
(1/16 in) of tread remains. See
When It Is Time for New Tires
0 275.
UTQGS (Uniform Tire Quality
Grading Standards)
:A tire
information system that provides
consumers with ratings for a
tire's traction, temperature, and
treadwear. Ratings are
determined by tire
manufacturers using
government testing procedures.
The ratings are molded into the
sidewall of the tire. See Uniform
Tire Quality Grading 0277.
Vehicle Capacity Weight
:The
number of designated seating
positions multiplied by
68 kg (150 lbs) plus the rated
cargo load. See Vehicle Load
Limits 0168. Vehicle Maximum Load on the
Tire
:Load on an individual tire
due to curb weight, accessory
weight, occupant weight, and
cargo weight.
Vehicle Placard
:A label
permanently attached to a
vehicle showing the vehicle's
capacity weight and the original
equipment tire size and
recommended inflation pressure.
See “Tire and Loading
Information Label” underVehicle
Load Limits 0168.
Tire Pressure
Tires need the correct amount of
air pressure to operate
effectively. Caution
Neither tire underinflation nor
overinflation is good.
Underinflated tires, or tires
that do not have enough air,
can result in:
.Tire overloading and
overheating which could
lead to a blowout.
.Premature or
irregular wear.
.Poor handling.
.Reduced fuel economy.
Overinflated tires, or tires that
have too much air, can
result in:
.Unusual wear.
.Poor handling.
.Rough ride.
.Needless damage from
road hazards.

Chevrolet VOLT Owner Manual (GMNA-Localizing-U.S/Canada/Mexico-
9159388) - 2016 - crc - 5/20/15
358 Index
Electrical Requirements forBattery Charging . . . . . . . . . . . . . . 218
Electrical System Engine Compartment FuseBlock . . . . . . . . . . . . . . . . . . . . . . . . 252
Instrument Panel Fuse Block . . . . . . . . . . . . . . . . . . . . . . . . 256
Overload . . . . . . . . . . . . . . . . . . . . . 252
Rear Compartment Fuse Block . . . . . . . . . . . . . . . . . . . . . . . . 259
Emergency
OnStar
®. . . . . . . . . . . . . . . . . . . . . . 346
Energy Efficiency Driving . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Energy Information . . . . . . . . . . . . . 127
Engine Air Cleaner/Filter . . . . . . . . . . . . . 235
Check and Service EngineSoon Light . . . . . . . . . . . . . . . . . . 109
Compartment Overview . . . . . . . 231
Coolant . . . . . . . . . . . . . . . . . . . . . . . 239
Coolant Temperature Warning Light . . . . . . . . . . . . . . . .114
Cooling System . . . . . . . . . . 236–238
Cooling System Messages . . . 132
Drive Belt Routing . . . . . . . . . . . . 330
Exhaust . . . . . . . . . . . . . . . . . . . . . . 182
Oil Life System . . . . . . . . . . . . . . . 234 Engine (cont'd)
Oil Messages . . . . . . . . . . . . . . . . . 132
Oil Pressure Light . . . . . . . . . . . . .114
Overheating . . . . . . . . . . . . . . . . . . 242
Running While Parked . . . . . . . . 182
Engine Unavailable Out of Fuel . . . . . . . . . . . . . . . . . . . 179
Entry Lighting . . . . . . . . . . . . . . . . . . . 151
Event Data Recorders . . . . . . . . . . 343
Exit Lighting . . . . . . . . . . . . . . . . . . . . 151
Extended Range Mode . . . . . . . . . 176
Extender, Safety Belt . . . . . . . . . . . . 60
Exterior Lamp Controls . . . . . . . . . 146
F
Filter, Engine Air Cleaner . . . . . . . . . . . 235
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 148
Flashers, Hazard Warning . . . . . . 149
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . 281 Changing . . . . . . . . . . . . . . . . . . . . . 289
Floor Mats . . . . . . . . . . . . . . . . . . . . . . 312
Fluid Brakes . . . . . . . . . . . . . . . . . . . . . . . . 243
Washer . . . . . . . . . . . . . . . . . . . . . . . 242
Folding Mirrors . . . . . . . . . . . . . . . . . . 45
Forward Collision Alert (FCA) System . . . . . . . . . . . . . . . . . 198 Frequency Statement
Radio . . . . . . . . . . . . . . . . . . . . . . . . . 341
Front Automatic Braking (FAB) System . . . . . . . . . . . . . . . . . 200
Front Seats Adjustment . . . . . . . . . . . . . . . . . . . . . 51
Heated . . . . . . . . . . . . . . . . . . . . . . . . . 53
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 219 Additives . . . . . . . . . . . . . . . . . . . . . 221
Filling a Portable FuelContainer . . . . . . . . . . . . . . . . . . . 223
Filling the Tank . . . . . . . . . . . . . . . 221
Foreign Countries . . . . . . . . . . . . 221
Gauge . . . . . . . . . . . . . . . . . . . . . . . . 104
Low Fuel Warning Light . . . . . . . .115
Requirements, California . . . . . 220
System Messages . . . . . . . . . . . . 132
Function Check Electric Drive Unit ShiftLock Control . . . . . . . . . . . . . . . . 247
Fuses
Engine Compartment FuseBlock . . . . . . . . . . . . . . . . . . . . . . . . 252
Instrument Panel Fuse Block . . . . . . . . . . . . . . . . . . . . . . . . 256
Rear Compartment Fuse Block . . . . . . . . . . . . . . . . . . . . . . . . 259

Chevrolet VOLT Owner Manual (GMNA-Localizing-U.S/Canada/Mexico-
9159388) - 2016 - crc - 5/20/15
Index 359
G
GaugesBattery . . . . . . . . . . . . . . . . . . . . . . . 104
Driver Efficiency . . . . . . . . . . . . . . 105
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . 104
Odometer . . . . . . . . . . . . . . . . . . . . . 104
Power Indicator . . . . . . . . . . . . . . . 106
Speedometer . . . . . . . . . . . . . . . . . 104
Trip Odometer . . . . . . . . . . . . . . . . 104
Warning Lights andIndicators . . . . . . . . . . . . . . . . . . . 100
General Information Service and Maintenance . . . . . 314
Towing . . . . . . . . . . . . . . . . . . . . . . . . 223
Vehicle Care . . . . . . . . . . . . . . . . . . 226
Glove Box . . . . . . . . . . . . . . . . . . . . . . . 92
GM Mobility Reimbursement Program . . . . . . . . . . . . . . . . . . . . . . . 334
H
Halogen Bulbs . . . . . . . . . . . . . . . . . . 249
Hatch . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41
Hazard Warning Flashers . . . . . . . 149
Head Restraints . . . . . . . . . . . . . . . . . 50
Headlamps . . . . . . . . . . . . . . . . . . . . . 249Aiming . . . . . . . . . . . . . . . . . . . . . . . . 249
Automatic . . . . . . . . . . . . . . . . . . . . . 148
Bulb Replacement . . . . . . . . . . . . 249 Headlamps (cont'd)
Daytime Running
Lamps (DRL) . . . . . . . . . . . . . . . . 148
Flash-to-Pass . . . . . . . . . . . . . . . . . 148
High-Beam On Light . . . . . . . . . . .115
High/Low Beam Changer . . . . . 147
Lamps On Reminder . . . . . . . . . .116
Heated Rear Seats . . . . . . . . . . . . . . . . . . . . . 56
Steering Wheel . . . . . . . . . . . . . . . . . 95
Heated Front Seats . . . . . . . . . . . . . . 53
Heated Mirrors . . . . . . . . . . . . . . . . . . . 45
Heating and Air Conditioning . . . 154
High Voltage Battery Gauge . . . . 104
High Voltage Devices and Wiring . . . . . . . . . . . . . . . . . . . . . . . . . 251
High-Beam On Light . . . . . . . . . . . . 115
Hill and Mountain Roads . . . . . . . . 166
Hill Start Assist (HSA) . . . . . . . . . . 186
Hold Mode Light . . . . . . . . . . . . . . . . 112
Hood . . . . . . . . . . . . . . . . . . . . . . . . . . . 230
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 96
How to Wear Safety Belts Properly . . . . . . . . . . . . . . . . . . . . . . . . 57
I
Immobilizer . . . . . . . . . . . . . . . . . . . . . . 43
IndicatorVehicle Ahead . . . . . . . . . . . . . . . . .113
Infants and Young Children,
Restraints . . . . . . . . . . . . . . . . . . . . . . 75
Information Energy . . . . . . . . . . . . . . . . . . . . . . . 127
Infotainment . . . . . . . . . . . . . . . . . . . . 153
Infotainment System . . . . . . . . . . . . 344
Instrument Cluster . . . . . . . . . . . . . . 100
Interior Rearview Mirrors . . . . . . . . . 45
Introduction . . . . . . . . . . . . . . . . . . . . . . . 2
J
Jump Starting - North America . . . . . . . . . . . . . . . . . . . . . . . 295
K
Key and Lock Messages . . . . . . . . 133
Keyless EntryRemote (RKE) System . . . . . . . . . 29
Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
L
Labeling, Tire Sidewall . . . . . . . . . . 263
Lamps Daytime Running (DRL) . . . . . . 148
Dome . . . . . . . . . . . . . . . . . . . . . . . . . 150
Exterior Controls . . . . . . . . . . . . . . 146

Chevrolet VOLT Owner Manual (GMNA-Localizing-U.S/Canada/Mexico-
9159388) - 2016 - crc - 5/20/15
Index 361
Messages (cont'd)Door Ajar . . . . . . . . . . . . . . . . . . . . . 131
Electric Drive Unit . . . . . . . . . . . . 131
Engine Cooling System . . . . . . . 132
Engine Oil . . . . . . . . . . . . . . . . . . . . 132
Fuel System . . . . . . . . . . . . . . . . . . 132
Key and Lock . . . . . . . . . . . . . . . . . 133
Lamp . . . . . . . . . . . . . . . . . . . . . . . . . 133
Object Detection System . . . . . 134
Propulsion Power . . . . . . . . . . . . . 135
Ride Control System . . . . . . . . . . 136
Security . . . . . . . . . . . . . . . . . . . . . . 136
Service Vehicle . . . . . . . . . . . . . . . 136
Starting the Vehicle . . . . . . . . . . . 137
Tire . . . . . . . . . . . . . . . . . . . . . . . . . . . 137
Vehicle . . . . . . . . . . . . . . . . . . . . . . . 130
Vehicle Reminder . . . . . . . . . . . . . 138
Vehicle Speed . . . . . . . . . . . . . . . . 138
Mirrors Automatic DimmingRearview . . . . . . . . . . . . . . . . . . . . . . 45
Convex . . . . . . . . . . . . . . . . . . . . . . . . . 44
Folding . . . . . . . . . . . . . . . . . . . . . . . . . 45
Heated . . . . . . . . . . . . . . . . . . . . . . . . . 45
Manual Rearview . . . . . . . . . . . . . . . 45
Power . . . . . . . . . . . . . . . . . . . . . . . . . . 44
Mirrors, Interior Rearview . . . . . . . . 45
Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . 190 Mode (cont'd)
Driver Control . . . . . . . . . . . . . . . . . 190
Electric . . . . . . . . . . . . . . . . . . . . . . . 176
Extended Range . . . . . . . . . . . . . . 176
Hold Light . . . . . . . . . . . . . . . . . . . . .112
Modes Driver Selected . . . . . . . . . . . . . . . 177
Maintenance . . . . . . . . . . . . . . . . . . 180
Monitor System, Tire
Pressure . . . . . . . . . . . . . . . . . . . . . . 269
Mountain Mode Light . . . . . . . . . . . 112
N
Navigation OnStar®. . . . . . . . . . . . . . . . . . . . . . 346
New Vehicle Break-In . . . . . . . . . . . 171
O
Object Detection System Messages . . . . . . . . . . . . . . . . . . . . . 134
Odometer . . . . . . . . . . . . . . . . . . . . . . . 104 Trip . . . . . . . . . . . . . . . . . . . . . . . . . . . 104
Off-Road Recovery . . . . . . . . . . . . . . . . . . . . . 164
Oil Engine . . . . . . . . . . . . . . . . . . . . . . . . 232
Engine Oil Life System . . . . . . . 234
Messages . . . . . . . . . . . . . . . . . . . . 132
Pressure Light . . . . . . . . . . . . . . . . .114 Older Children, Restraints . . . . . . . 74
Online Owner Center . . . . . . . . . . . 334
OnStar . . . . . . . . . . . . . . . . . . . . . . . . . 344
OnStar
®Additional
Information . . . . . . . . . . . . . . . . . . . . 349
OnStar
®Connections . . . . . . . . . . . 347
OnStar®Diagnostics . . . . . . . . . . . . 349
OnStar®Emergency . . . . . . . . . . . . 346
OnStar®Navigation . . . . . . . . . . . . . 346
OnStar®Overview . . . . . . . . . . . . . . 345
OnStar®Security . . . . . . . . . . . . . . . 346
Ordering Service Publications . . . . . . . . . . 340
Out of Fuel/Engine Unavailable . . . . . . . . . . . . . . . . . . . 179
Outlets
Power . . . . . . . . . . . . . . . . . . . . . . . . . . 98
Overheating, Engine . . . . . . . . . . . . 242
P
Park Shifting Into . . . . . . . . . . . . . . . . . . . 174
Shifting Out of . . . . . . . . . . . . . . . . 175
Parking Brake and P (Park)Mechanism Check . . . . . . . . . . 247
Over Things That Burn . . . . . . . 176