2016 CHEVROLET CITY EXPRESS CARGO VAN flat tire

Black plate (54,1)Chevrolet City Express Owner Manual (GMNA-Localizing-U.S./Canada-
7707496) - 2015 - CRC - 11/26/14
10-54 Vehicle Care
Warning (Continued)
specification supplied by the
aftermarket manufacturer when
using accessory locking wheel
nuts. SeeCapacities and
Specifications on page 12-2 for
original equipment wheel nut
torque specifications.
{Caution
Improperly tightened wheel nuts
can lead to brake pulsation and
rotor damage. To avoid expensive
brake repairs, evenly tighten the
wheel nuts in the proper
sequence and to the proper
torque specification. See
Capacities and Specifications on
page 12-2 for the wheel nut
torque specification.
Use the wheel wrench to
tighten the nuts firmly. Turn the
wheel wrench clockwise and in
a crisscross sequence, as
shown.
12. Replace the wheel cover, if equipped.
Remove any wheel blocks.
13. Check the tire pressure.
Storing a Flat or Spare Tire
and Tools
{Warning
Storing a jack, a tire, or other
equipment in the passenger
compartment of the vehicle could
cause injury. In a sudden stop or
collision, loose equipment could
strike someone. Store all these in
the proper place.
Reverse the steps for “Removing
the Spare Tire and Tools” to
properly store them.

Black plate (55,1)Chevrolet City Express Owner Manual (GMNA-Localizing-U.S./Canada-
7707496) - 2015 - CRC - 11/26/14
Vehicle Care 10-55
Full-Size Spare Tire
If this vehicle came with a full-size
spare tire, it was fully inflated when
new, however, it can lose air over
time. Check the inflation pressure
regularly. SeeTire Pressure on
page 10-35 andVehicle Load Limits
on page 9-9. For instructions on
how to remove, install, or store a
spare tire, see Tire Changing on
page 10-48.
After installing the spare tire on the
vehicle, stop as soon as possible
and check that the spare is correctly
inflated. The spare tire is made to
perform well at speeds up to
112 km/h (70 mph) at the
recommended inflation pressure, so
you can finish your trip. Have the damaged or flat road tire
repaired or replaced back onto the
vehicle, as soon as possible, so the
spare tire will be available in case it
is needed again.
Do not mix tires and wheels of
different sizes, because they will not
fit. Keep the spare tire and its wheel
together.
Jump Starting
For more information about the
vehicle battery, see
Battery on
page 10-21.
If the vehicle battery has run down,
you may want to use another
vehicle and jumper cables to start
your vehicle. Use the following
steps to do it safely.
{Warning
WARNING: Battery posts,
terminals, and related
accessories contain lead and lead
compounds, chemicals known to
the State of California to cause
cancer and birth defects or other
reproductive harm. Wash hands
after handling. SeeCalifornia
Proposition 65 Warning on
page 10-2.

Black plate (3,1)Chevrolet City Express Owner Manual (GMNA-Localizing-U.S./Canada-
7707496) - 2015 - CRC - 11/26/14
Service and Maintenance 11-3
Maintenance
Schedule
Owner Checks and Services
At Each Fuel Stop
.Check the engine oil level. See
Engine Oil on page 10-8.
Once a Month
.Check the tire inflation
pressures. See Tire Pressure on
page 10-35.
.Inspect the tires for wear. See
Tire Inspection on page 10-39.
.Check the windshield washer
fluid level. See Washer Fluid on
page 10-18.
Oil Change, Tire Rotation, and
Required Services Every
8 000 km/5,000 mi
Rotate the tires, if recommended for
the vehicle, and perform the
following services. See Tire
Rotation on page 10-39.
.Change engine oil and filter. See
Engine Oil on page 10-8.
.Check engine coolant level. See
Engine Coolant on page 10-13.
.Check drive shaft boots.
.Check windshield washer fluid
level. See Washer Fluid on
page 10-18.
.Visually inspect windshield wiper
blades for wear, cracking,
or contamination. See Exterior
Care on page 10-61. Replace
worn or damaged wiper blades.
See Wiper Blade Replacement
on page 10-22.
.Check tire inflation pressures.
See Tire Pressure on
page 10-35.
.Inspect tire wear. See Tire
Inspection on page 10-39.
.Visually check for fluid leaks.
.Inspect engine air cleaner filter.
See Engine Air Cleaner/Filter on
page 10-11.

Black plate (9,1)Chevrolet City Express Owner Manual (GMNA-Localizing-U.S./Canada-
7707496) - 2015 - CRC - 11/26/14
Service and Maintenance 11-9
Shocks and Struts
Shocks and struts help aid in control
for a smoother ride.
.Signs of wear may include
steering wheel vibration, bounce/
sway while braking, longer
stopping distance, or uneven
tire wear.
.As part of the multi-point
inspection, trained dealer
technicians can visually inspect
the shocks and struts for signs
of leaking, blown seals,
or damage, and can advise
when service is needed.Tires
Tires need to be properly inflated,
rotated, and balanced. Maintaining
the tires can save money and fuel,
and can reduce the risk of tire
failure.
.Signs that the tires need to be
replaced include three or more
visible treadwear indicators; cord
or fabric showing through the
rubber; cracks or cuts in the
tread or sidewall; or a bulge or
split in the tire.
.Trained dealer technicians can
inspect and recommend the right
tires. Your dealer can also
provide tire/wheel balancing
services to ensure smooth
vehicle operation at all speeds.
Your dealer sells and services
name brand tires.Vehicle Care
To help keep the vehicle looking like
new, vehicle care products are
available from your dealer. For
information on how to clean and
protect the vehicle’s interior and
exterior, see
Interior Care on
page 10-65 andExterior Care on
page 10-61.

Black plate (6,1)Chevrolet City Express Owner Manual (GMNA-Localizing-U.S./Canada-
7707496) - 2015 - CRC - 11/26/14
13-6 Customer Information
.Model, year, color, and license
plate number of the vehicle.
.Odometer reading, Vehicle
Identification Number (VIN), and
delivery date of the vehicle.
.Description of the problem.
Coverage
Services are provided up to 5 years/
160 000 km (100,000 mi), whichever
comes first.
In the U.S., anyone driving the
vehicle is covered. In Canada, a
person driving the vehicle without
permission from the owner is not
covered.
Roadside Assistance is not a part of
the New Vehicle Limited Warranty.
General Motors North America and
Chevrolet reserve the right to make
any changes or discontinue the
Roadside Assistance program at
any time without notification.
General Motors North America and
Chevrolet reserve the right to limit
services or payment to an owner ordriver if they decide the claims are
made too often, or the same type of
claim is made many times.
Services Provided
.Emergency Fuel Delivery:
Delivery of enough fuel for the
vehicle to get to the nearest
service station.
.Lock-Out Service:
Service to
unlock the vehicle if you are
locked out. A remote unlock may
be available if you have OnStar.
For security reasons, the driver
must present identification
before this service is given.
.Emergency Tow from a Public
Road or Highway: Tow to the
nearest Chevrolet dealer for
warranty service, or if the vehicle
was in a crash and cannot be
driven. Assistance is not given
when the vehicle is stuck in the
sand, mud, or snow.
.Flat Tire Change: Service to
change a flat tire with the spare
tire. The spare tire, if equipped, must be in good condition and
properly inflated. It is the owner's
responsibility for the repair or
replacement of the tire if it is not
covered by the warranty.
.Battery Jump Start:
Service to
jump start a dead battery.
Services Not Included in
Roadside Assistance
.Impound towing caused by
violation of any laws.
.Legal fines.
.Mounting, dismounting,
or changing of snow tires,
chains, or other traction devices.
Service is not provided if a vehicle
is in an area that is not accessible
to the service vehicle or is not a
regularly traveled or maintained
public road, which includes ice and
winter roads. Off-road use is not
covered.

Black plate (1,1)Chevrolet City Express Owner Manual (GMNA-Localizing-U.S./Canada-
7707496) - 2015 - CRC - 11/26/14
INDEX i-1
A
Accessories andModifications . . . . . . . . . . . . . . . . . 10-3
Add-On Electrical Equipment . . . . . . . . . . . . . . . . . . . 9-41
Additional Maintenance and Care . . . . . . . . . . . . . . . . . . . . . 11-7
Adjustments Lumbar, Front Seats . . . . . . . . . . . 3-4
Air Cleaner/Filter, Engine . . . . . 10-11
Air Vents . . . . . . . . . . . . . . . . . . . . . . . 8-3
Airbag System Check . . . . . . . . . . . . . . . . . . . . . . . . 3-29
How Does an AirbagRestrain? . . . . . . . . . . . . . . . . . . . 3-20
Passenger Sensing
System . . . . . . . . . . . . . . . . . . . . . . 3-22
What Makes an Airbag Inflate? . . . . . . . . . . . . . . . . . . . . . . 3-20
What Will You See after an
Airbag Inflates? . . . . . . . . . . . . . 3-20
When Should an Airbag Inflate? . . . . . . . . . . . . . . . . . . . . . . 3-18
Where Are the Airbags? . . . . . . 3-17 Airbags
Adding Equipment to the
Vehicle . . . . . . . . . . . . . . . . . . . . . . 3-29
Passenger Status Indicator . . . 5-10
Readiness Light . . . . . . . . . . . . . . . 5-9
Servicing Airbag-Equipped Vehicles . . . . . . . . . . . . . . . . . . . . . 3-28
System Check . . . . . . . . . . . . . . . . 3-15
Alarm Vehicle Security . . . . . . . . . . . . . . 2-10
All-Season Tires . . . . . . . . . . . . . . 10-27
All-Terrain Tires . . . . . . . . . . . . . . . 10-28
AM-FM Radio . . . . . . . . . . . . . . . . . . . 7-5
Antilock Brake
System (ABS) . . . . . . . . . . . . . . . . 9-22
Warning Light . . . . . . . . . . . . . . . . . 5-15
Appearance Care Exterior . . . . . . . . . . . . . . . . . . . . . 10-61
Interior . . . . . . . . . . . . . . . . . . . . . . 10-65
Armrest Front Seat . . . . . . . . . . . . . . . . . . . . . 3-6
Ashtrays . . . . . . . . . . . . . . . . . . . . . . . . 5-5
Assistance Program, Roadside . . . . . . . . . . . . . . . . . . . . . 13-5
Audio Players . . . . . . . . . . . . . . . . . . 7-7
CD . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-7 Audio System
Fixed Mast Antenna . . . . . . . . . . . 7-6
Radio Reception . . . . . . . . . . . . . . . 7-6
Theft-Deterrent Feature . . . . . . . . 7-2
Automatic Door Locks . . . . . . . . . . . . . . . . . . . . 2-7
Auxiliary Jack . . . . . . . . . . . . . . . . . . . 7-9
B
Back Doors . . . . . . . . . . . . . . . . . . . . . 2-8
Battery . . . . . . . . . . . . . . . . . . . . . . . 10-21
Exterior Lighting BatterySaver . . . . . . . . . . . . . . . . . . . . . . . . 6-5
Jump Starting . . . . . . . . . . . . . . . 10-55
Battery - California Propostion 65 Warning . . . . . . . 10-2
Blade Replacement, Wiper . . . 10-22
Bluetooth Overview . . . . . . . . . . . . . . . . . . . . . 7-10
Brake System Warning Light . . . . . . . . 5-14
Brakes . . . . . . . . . . . . . . . . . . . . . . . . 10-19 Antilock . . . . . . . . . . . . . . . . . . . . . . . 9-22
Fluid . . . . . . . . . . . . . . . . . . . . . . . . 10-19
Parking . . . . . . . . . . . . . . . . . . . . . . . 9-24
Braking . . . . . . . . . . . . . . . . . . . . . . . . . 9-3

Black plate (4,1)Chevrolet City Express Owner Manual (GMNA-Localizing-U.S./Canada-
7707496) - 2015 - CRC - 11/26/14
i-4 INDEX
Engine (cont'd)Exhaust . . . . . . . . . . . . . . . . . . . . . . 9-17
Overheated Protection
Operating Mode . . . . . . . . . . . 10-17
Overheating . . . . . . . . . . . . . . . . 10-16
Pressure Light . . . . . . . . . . . . . . . . 5-18
Running While Parked . . . . . . . . 9-18
Starting . . . . . . . . . . . . . . . . . . . . . . . 9-15
Event Data Recorders . . . . . . . . 13-14
Extender, Safety Belt . . . . . . . . . . 3-13
Exterior Lamp Controls . . . . . . . . . 6-1
Exterior Lamps Off Reminder . . . 6-1
Exterior Lighting Battery Saver . . . . . . . . . . . . . . . . . . . . . . . . . 6-5
F
Filter,
Engine Air Cleaner . . . . . . . . . .10-11
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 6-2
Flashers, Hazard Warning . . . . . . 6-2
Flat Tire . . . . . . . . . . . . . . . . . . . . . . 10-47 Changing . . . . . . . . . . . . . . . . . . . 10-48
Floor Mats . . . . . . . . . . . . . . . . . . . . 10-69
Fluid Brakes . . . . . . . . . . . . . . . . . . . . . . 10-19
Washer . . . . . . . . . . . . . . . . . . . . . 10-18 Folding Mirrors . . . . . . . . . . . . . . . . 2-13
Folding Seatback . . . . . . . . . . . . . . . 3-6
Frequency Statement
Radio . . . . . . . . . . . . . . . . . . . . . . . 13-12
Front Seat Armrest . . . . . . . . . . . . . 3-6
Front Seats Adjustment . . . . . . . . . . . . . . . . . . . . 3-3
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-37 Additives . . . . . . . . . . . . . . . . . . . . . 9-38
Economy Driving . . . . . . . . . . . . . 1-15
Filling a Portable FuelContainer . . . . . . . . . . . . . . . . . . . 9-40
Filling the Tank . . . . . . . . . . . . . . . 9-39
Foreign Countries . . . . . . . . . . . . 9-38
Gauge . . . . . . . . . . . . . . . . . . . . . . . . . 5-8
Low Fuel Warning Light . . . . . . . 5-18
Requirements, California . . . . . 9-38
System Messages . . . . . . . . . . . . 5-20
Full-Size Spare Tire . . . . . . . . . . 10-55
Fuses Engine Compartment
Fuse Block . . . . . . . . . . . . . . . . 10-25
Fuses and Circuit Breakers . . . . . . . . . . . . . . . . . . 10-25
Instrument Panel Fuse
Block . . . . . . . . . . . . . . . . . . . . . . 10-26
G
GaugesFuel . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-8
Odometer . . . . . . . . . . . . . . . . . . . . . . 5-8
Speedometer . . . . . . . . . . . . . . . . . . 5-8
Tachometer . . . . . . . . . . . . . . . . . . . . 5-8
Trip Odometer . . . . . . . . . . . . . . . . . 5-8
Warning Lights andIndicators . . . . . . . . . . . . . . . . . . . . 5-6
General Information Service and Maintenance . . . . . 11-1
Towing . . . . . . . . . . . . . . . . . . . . . . . . 9-41
Vehicle Care . . . . . . . . . . . . . . . . . . 10-2
Glove Box . . . . . . . . . . . . . . . . . . . . . . 4-1
GM Mobility Reimbursement Program . . . . . . . . . . . . . . . . . . . . . . 13-5
H
Halogen Bulbs . . . . . . . . . . . . . . . . 10-23
Hazard Warning Flashers . . . . . . . 6-2
Head Restraints . . . . . . . . . . . . . . . . 3-2
HeadlampsAiming . . . . . . . . . . . . . . . . . . . . . . 10-23
Bulb Replacement . . . . . . . . . . 10-23
Daytime Running
Lamps (DRL) . . . . . . . . . . . . . . . . . 6-2

Black plate (9,1)Chevrolet City Express Owner Manual (GMNA-Localizing-U.S./Canada-
7707496) - 2015 - CRC - 11/26/14
INDEX i-9
T
Tachometer . . . . . . . . . . . . . . . . . . . . . 5-8
Text Telephone (TTY) Users . . . 13-4
Theft-Deterrent Systems . . . . . . . 2-11Immobilizer . . . . . . . . . . . . . . . . . . . 2-11
Time . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-3
Tires . . . . . . . . . . . . . . . . . . . . . . . . . . 10-26 All-Season . . . . . . . . . . . . . . . . . . 10-27
All-Terrain . . . . . . . . . . . . . . . . . . 10-28
Buying New Tires . . . . . . . . . . . 10-41
Chains . . . . . . . . . . . . . . . . . . . . . . 10-46
Changing . . . . . . . . . . . . . . . . . . . 10-48
Designations . . . . . . . . . . . . . . . 10-30
Different Size . . . . . . . . . . . . . . . 10-43
Full-Size Spare . . . . . . . . . . . . . 10-55
If a Tire Goes Flat . . . . . . . . . . 10-47
Inflation Monitor System . . . . 10-37
Inspection . . . . . . . . . . . . . . . . . . 10-39
Messages . . . . . . . . . . . . . . . . . . . . 5-20
Pressure Light . . . . . . . . . . . . . . . . 5-17
Pressure Monitor System . . . 10-36
Rotation . . . . . . . . . . . . . . . . . . . . 10-39
Sidewall Labeling . . . . . . . . . . . 10-28
Terminology andDefinitions . . . . . . . . . . . . . . . . . 10-32 Tires (cont'd)
Uniform Tire Quality
Grading . . . . . . . . . . . . . . . . . . . 10-44
Wheel Alignment and Tire
Balance . . . . . . . . . . . . . . . . . . . 10-45
Wheel Replacement . . . . . . . . 10-45
When It Is Time for New Tires . . . . . . . . . . . . . . . . . . . . . . 10-41
Winter . . . . . . . . . . . . . . . . . . . . . . 10-27
Towing General Information . . . . . . . . . . 9-41
Recreational Vehicle . . . . . . . . 10-59
Vehicle . . . . . . . . . . . . . . . . . . . . . 10-59
Traction Control System
(TCS)/Electronic Stability
Control Light . . . . . . . . . . . . . . . . . 5-16
Traction Control/Electronic Stability Control . . . . . . . . . . . . . . 9-25
Trademarks and License Agreements . . . . . . . . . . . . . . . . . . 7-19
Transmission Continuously Variable . . . . . . . . 9-18
Transmission Fluid
Continuously Variable . . . . . . .10-11
Transportation Program, Courtesy . . . . . . . . . . . . . . . . . . . . . 13-7 Trip Computer . . . . . . . . . . . . . . . . . 5-20
Trip Odometer . . . . . . . . . . . . . . . . . . 5-8
Turn and Lane-Change
Signals . . . . . . . . . . . . . . . . . . . . . . . . 6-3
U
Underseat Storage . . . . . . . . . . . . . 4-1
Uniform Tire QualityGrading . . . . . . . . . . . . . . . . . . . . . 10-44
Using This Manual . . . . . . . . . . . . . . . . iii
V
Vehicle Alarm System . . . . . . . . . . . . . . . . 2-10
Canadian Owners . . . . . . . . . . . . . . . iii
Control . . . . . . . . . . . . . . . . . . . . . . . . 9-3
IdentificationNumber (VIN) . . . . . . . . . . . . . . . 12-1
Load Limits . . . . . . . . . . . . . . . . . . . . 9-9
Personalization . . . . . . . . . . . . . . . 5-21
Security . . . . . . . . . . . . . . . . . . . . . . 2-10
Towing . . . . . . . . . . . . . . . . . . . . . . 10-59