2016 AUDI A7 ad blue

Fuel and Refueling
case, try turning the nozzle before inserting
it in the fuel fi ller neck, use a different fuel
pump or see your authorized Audi dea ler or
authorized repair facility for assistance.
- The fuel filler flap of your vehicle is not
l ocked when you lock the vehicle from the
inside .
Fuel filler door emergency release
If the central locking system is faulty, the fuel
filler door can be unlocked manually.
Fig. 182 Right side tri m in the luggag e compartme nt: re·
mov ing the trim
"' ~ 0
<.:l "'
Fig. 183 Luggage compartment: Fuel filler door emergen­
cy release
Removing the side trim
• To remove the right side tr im, first remove the
retainer from the mounts
r:!.> fig. 182.
• Turn both locking mechanisms 90° to the Left
using a coin or a similar object and remove the
locking mechanisms.
• Tilt the retainer upward and pu ll the tr im out.
Lay the trim down on its side, because there is
an electrical wire for the socket* on the back.
214
Fuel filler door emergency release
• Loosen the strap from its bracket and pull on it
r:!.> fig. 183 r:!.>{2) . You can now open the fuel fill­
er door as usu al
r:!.> page 212.
(D Note
Only pull on the Loop until you feel resistance.
You will not hear it release. Otherwise you
could damage the emergency release mecha­ nism.
Selective catalytic reduction
General information
Applies to vehicles: with selective catalyt ic red uction
In vehicles with selective catalytic reduction, a
urea solution (AdB lue) is injected into the ex­
haust system before a nitrogen oxide catalytic
converter to reduce nitrogen emissions.
The Ad Blue is carried in a separate tank in the ve­
hicle. The Ad Blue usage accounts for approxi­
mately O. 5 % to 2. 5% of the diesel fuel that is
used.
When a message about refilling the AdBlue ap­
pears in the instrument cluster display, you must
refill the Ad Blue yourself or have it refilled by an
authorized Audi dealer or authorized Audi Service
Facility
r:!.> page 215.
{!) Tips
-The instrument cluster d isp lay indicates the
distance remaining that can be driven
r:!.>page 215. If the AdBlue tank is com­
pletely empty, the engine will not start
again after the ignition is switched off.
- Ad Blue is requ ired by law to operate this ve­
hicle.

M N <( I.J "". rl I.O
"' N I.O rl
Messages in the instrument cluster display
Applies to vehicles: with selective catalyt ic reductio n
The display indicates if the Ad Blue level is low or
if there is a system malfunction .
AdBlue level low
You will be informed if the Ad Blue in the tank
drops be low a certain level.
Please refill Ad Blue. Range 1500 mi (2400 km )
This message appea rs whe n there is o nly enoug h
Ad B lue left to dr ive the d ist ance ind icated in the
d river i nfo rmation sys tem . Fill the AdBl ue.
Ad Blue ,0 Refill AdBlue! No restart in 600 mi
( 1000 km)! See owner 's manual
This message appea rs when there is o nly enoug h
Ad Blue left to dr ive the distance indicated in the
d river info rmation system . Fill the Ad Blue . Othe r­
wise the eng ine will not sta rt again if you s top it
once the di stan ce in dicated ha s been driven. You
can also check t he rem ain ing distance in the on­
board comp ute r*.
Refill Ad Blu e! No restart! See own -
er' s manual
This message appea rs whe n the AdBlue tank is
empty . Fill t he AdBl ue. Othe rw ise you w ill not be
ab le to start the engine aga in once yo u stop it.
T he AdBlue must be refi lled when t he amo unt in
the tank has reac hed the m inimum leve l
q page 215, Filling Ad Blue .
Incorrect filling/system malfunction
A message appears if the AdBl ue tank was filled
with a fluid other than AdBlue and the system has detected t hat the ta nk was f illed incor rectly,
or if there is a sys tem ma lf u nction .
Ad Blue -I' Ad Blue: System fault! No restart in
600 mi (1000 km). See owner's manual.
This message appea rs when it is only poss ible to
drive the d istance ind icated in the dr iver informa­
tion system. Drive to the nearest authori zed Audi
dealer or authorized Aud i Service Fac ility to have
the ma lfunction corrected . Otherwise the engine
w ill not start aga in if you stop it once the dis­
tance ind icated has been driven .
Fuel and Refueling
AdBlue: System fault No restart!
See owner's manual
T his mes sage ap pea rs if t he system h as detec ted
t h at the t ank was fi lled incor rectly o r tha t there
is a ma lf u nction . Drive immed iate ly to the near ­
est authorized A udi dealer or autho rized A udi
Se rv ice Facility to have the ma lf u nction co rrect ­
ed. Otherwise yo u will not be ab le to start the en­
gine aga in once you stop it .
Filling AdBlue
Applies to vehicles: with selective catalytic reduction
Fig. 184 Rig ht rea r ve hicle s ide: re m oving t he AdB lu e cap
The Ad Blue filler t ube is located near the diesel
filler t ube . Add at least 1.5 ga llons (5.7 liters) of
AdBl ue. This is the m inimum amount required to
ensure the system detects the refi lling a nd to
start the eng ine . Yo u can add a max imum of ap­
proximate ly 4.5 gallons (17 liters) .
Req uirement: The request to add Ad Blue must
appear in the instrument cluster display .
.. Switch t he ignit ion off .
.. Open the tank door
q page 212.
.,. Turn the tank cap counterclockwise w it h the lug
w rench from the vehicle too l kit to remove it
q fig . 184 .
.,. Fill the Ad Blue with th e bottl e ~ page 216 or
the caniste r<=>
page 216.
.&_ WARNING
Ad Bl ue can irri tate the skin , eye s and respira­
tory sys tem . If the re is con tact with t he flu id,
f lush imme diate ly w ith plenty of water. Co n-
su lt a physicia n if necessary. .,,_
215

Fuel and Refueling
CJ) Note
-Only use Ad Blue that conforms to the
standard ISO 22241-1. Do not mix any addi­
tives with the AdBlue and do not di lute it
with water.
- Do not add Ad Blue to the diesel tank or add diesel fuel to the AdBlue tank. Mixing can
lead to damage to the engine and the Ad Bl­
ue tank system .
- Ad Blue attacks surfaces such as painted ve­
hicle components, plastic and carpet . Re­
move the fluid as quickly as poss ible with a
damp cloth and plenty of cold water. If the
AdBlue has already crysta llized, use warm
water and a sponge. Ad Blue residue that is
not removed will crysta llize and can damage
the affected su rface.
- Do not store refill bottles or canisters per­
manently in the vehicle. If the container
l eaks, the escaping Ad B lue cou ld damage
the vehicle interior.
- Do not allow Ad Blue to come into contact
with clothing. If there is contact with the
fluid, flush immediately with plenty of wa­
ter.
{D) Tips
Follow the Ad Blue manufacturer's instruc­
tions for use and storage.
Refilling AdBlue with a bottle
Applies to veh icles: w ith selective catalyt ic reductio n
"' Remove the cap from the refill bottle c:> .&. in
Filling AdB/ue on page
215, c:> (D in Filling
AdB/ue on page
216.
"' Position the bottle on the filler tube and turn
the bottle clockwise until it stops turning.
"' Press lightly against the bottom of the bottle
to empty it. Continue pressing the bottom of
the bottle unti l it is empty or until fluid stops
flowing into the tank.
"'T urn the bott le to the left without pressing on
the bottom.
"' Close the filler neck
c:> page 217, Completing
AdBlue refill .
216
(D Tips
-You can obtain refill bottles from an author ­
ized Audi dea ler or authorized Audi Service
Facility.
- A refill bottle contains approximately O.S
gallon (1.9 liters) of Ad B lue.
· Refilling Ad Blue with a canister
App lies to vehicles : wit h selective cata lyt ic reduction
®
+®
Fig. 185 Canis te r w ith hose
N ::> "' Remove the cover on the refill canister c:> .&. in
Filling AdBlue on page
215, c:> (D in Filling
AdBlue on page 216.
"'Secure the end of the hose (Don the opening in
the canister @by turning the hose to the right.
"' Remove the cap@from the other end of the
hose @.
"' Posit ion the end of the hose @on the filler
neck in the vehicle and turn the hose to the
r ight to tighten it.
"' Lift the canister up and then tip it. Continue
holding the canister in a tipped position until it
is empty or until no more fluid flows into the
tank.
"' Remove the canister and close the filler neck
c:> page 217, Completing AdBlue refill.
(D Note
Only use ref ill canisters that are approved for
your vehicle. Using other systems can cause Ad Blue to leak .
0) Tips
-An authorized Aud i dealer or authorized
Audi repa ir facility can tell you which refill
canisters are approved for your veh icle.

M N <( (.J
'SI: ,...., \!) 1.1'1
N \!) ,....,
-A re fill canister contains 1.3 gallons ( 5 lit­
e rs) of Ad Bl ue .
Completing AdBlue refill
Applies to vehicles: with selective catalyt ic reduction
Cl osing the filler neck
~ Turn the cap to t he rig ht on the filler nec k with
the whee l wrench until the cap clic ks into p lace.
This t ightens the cap to the specification <=>
A
in Filling AdBlue on page 215, <=>CD in Filling
AdBlue on page 216 .
~ The n press on t he left side of t he tank doo r un-
t il you hear i t loc k.
After filling
The vehicle must be driven . The system may take
up to two mi nutes to detect that the Ad B lue has
been f illed.
~ If there was no AdB lue left in the tank and a
range of
O mi (0 km ) was shown in the d isp lay,
switch the ig nition on for ab out 30 sec onds be­
fore starting the engine .
Fuel and Refueling
217

M N <( I.J "". rl I.O
"' N I.O rl
Fuses
Replacing fuses
A fuse that has blown will have metal strips that have burned through.
Fig. 211 Driver's side of the cockpit : cover
The fuses are located on front left and right of
the cockpit and behind the trim on the right side
of the luggage compartment .
• Switch the ign ition and all electr ical equipment
off.
• Check the following table to see which fuse be­
longs to the equipment.
• Remove the appropriate cover.
• Remove the colored plastic clip from the fuse
panel, if necessary
q page 262, fig. 212 . You
can dispose of the plastic clip.
• Remove the clamp from the rear side of the
cover qfig .
211.
• Remove the fuse using the clamp.
• Replace the blown fuse only with an ident ica l
new one.
• Install the cover.
Fuse color identification
Color Current rating
in amps
Black 1
Purp le 3
Light brown 5
Brown 7.5
Red 10
Blue 15
Yellow 20
White or transparent 25
Fuses
Color Current rating
in amps
green 30
ora nge 40
,&_ WARNING
= -Do not repair fuses and never replace a blown
fuse with one that has a higher amp rating .
This can cause damage to the e lectr ical sys­
tem and a fire.
(D Note
If a new fuse burns out again shortly after you
have installed it, have the electrical system
checked as soon as possible by an authorized
Audi dealer or authorized Audi Service Facili­
ty,
Ci) Tips
- The following table does not list fuse loca­
tions that are not used.
- Some of the equipment listed in the follow­
ing tables applies on ly to certa in model ver­
sions or certain optional equipment.
261

Fuses
Driver side cockpit fuse
assignment
Fig. 212 Driver's side of the cockpit : fuse pa nel w it h plastic
cl ip
Fuse panel @ (black)
No. Equipment
Electromechanical power steer ing, trailer
1 hitch, ionizer, switch strip, seat heating
(rear), electromechanica l park ing brake
Horn, climate control system, Gateway,
2 automatic dimming interior rearview mir-
ror
4 Parking aid, headlight range adjustment
5 Dynamic steering, Electronic Stabilization
Control (ESC)
6 Headlights
7 Adaptive cru
ise control
8 Front passenger's seat sensors, airbag
9 Gateway
10 E
ngine sound, night vision assist, garage
door opener (Homelink), parking aid
11 Video camera image processing
12 Headlights
13 Steering col umn switch module
14 Terminal 15 (luggage compartment)
262
Fuse panel @ (black)
15 Terminal 15 (engine compartment)
16 Starter
Fuse panel @ (brown)
No . Equipment
1 Infotainment
2 Infotainment
3 Front passenger
's seat
5 Airbag, Electron
ic Stabilization Control
(ESC)
6 Anti -theft alarm system
7 Electromechanical parking brake
8 Inter
ior lights
9 Windshie
ld video camera heating , light/
rain sensor
10 Lumbar support (driver's seat)
11 Driver's seat
12 Electronic stabilization control
13 Horn
14 Headlights
15 Front seat heating
16 Dynamic steering
Fuse panel © (red)
No. Equipment
1 Clutch pedal
2 Fuel pump
3 Brake light sensor
4 AdBlue (diesel engine)/engine acoustics
5 Rear door
6 Front
door
7 Electronic stabilization control
8 Windshield wiper motor
9 Headlight washer system
10 Interior lighting, climate control system
11 Headlights
12 Sunroof

M N <( I.J "". rl I.O
"' N I.O rl
Front passenger side
cockpit fuse assignment
F ig. 21 3 Front passenger 's s ide of t he cockp it fuse pa nel
wit h plast ic cl ip
Fuse panel @ (red)
No. Equipment
1 Infotainment, CD changer
2 I nfotain ment (d isplay)
Fuse panel @ (brown)
No . Equipment
1 Climate control system
2 Climate con
trol sys tem (blower)
3 Diagnostic interface
4 Ele ctric al ignit ion loc k
5 Electro nic steer ing colum n lock
6 Steer ing column sw itch modu le
7 Power steering co lumn adjustment
8 Light switch
9 Head-up display
1 0 I
nstrument cluste r
1 1 Infotainment, DVD changer
Fuses
Luggage compartment
fuse assignment
F ig . 214 Lu ggage compa rtm ent: fuse pa nel w ith plastic
cli p
Fuse panel @ (black)
No. Equipment
1 Trailer h
itch/220 vo lt socket
2 Trailer h itch/ climatize d cup holder
3
Trailer h itch/adjusting front passenger's
seat from the rear
4 El ec tromech anical p ar kin g bra ke
5 Electromecha nica l park ing brake
6 Fr ont door (front passenger 's side)
7 Rear exterior lig hti ng
8 Cent ral loc king, closing aid
9 Seat heating (front)
1 1 Seat heating (rear), climate control system
12 Trailer h itch
Fuse panel @ (r ed)
No. Equipment
1 L
eft safety be lt tensioner
2 R ight safety be lt tensione r
3 AdBlue tank (diesel engine)/f uel p ump
4 Ad B lue tank (diese l engi ne)/engine mount
(g asol ine engine)
s
Sensor -co ntrolled luggage compartment
li d
6 Air s uspension, adaptive dam pers
7 Rear door (fro nt passenge r's side)
8 Tail lig hts
9 Luggage compartment lid
263

M N <( (.J
'SI: ,...., \!) 1.1'1
N \!) ,....,
AUTO Automatic headlights . . . . . . . . . . . . . . . . . 43
Four -zone automatic climate control . . . . . 71
Three- zone climate control . . . . . . . . . . . . . 69
Auto Lock . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Automatic belt retractor . . . . . . . . . . . . . . . 138
Automatic post-collision braking system . . 189
Automatic t ransmission . . . . . . . . . . . . . . . . 107
Driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . 109
Emergency mode . . . . . . . . . . . . . . . . . . . . 112
Hill descent control . . . . . . . . . . . . . . . . . . 110
Kick-down . . . . . . . . . . . . . . . . . . . . . . . . . . 111
M anual shift program . . . . . . . . . . . . . . . . 111
Selector lever . . . . . . . . . . . . . . . . . . . . . . . 107
Selector lever emergency release . . . . . . . 113
Automatic wipe/wash system . . . . . . . . . . . . 49
Auto Safety Hotline . . . . . . . . . . . . . . . . . . . 133
Auxiliary heater (four- zone automatic climate
control) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 73
Auxiliary heater (three-zone climate control) 70
Average consumption . . . . . . . . . . . . . . . . . . . 24
Ave rage speed . . . . . . . . . . . . . . . . . . . . . . . . . 24
Avoid damaging the vehicle . . . . . . . . . . . . . 196
B
Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 228
Charge level . . . . . . . . . . . . . . . . . . . . . . . . 194
Charging . . . . . . . . . . . . . . . . . . . . . . . . . . . 230
Energy management . . . . . . . . . . . . . . . . . 194
Important warnings . . . . . . . . . . . . . . . . . 228
Jump starting . . . . . . . . . . . . . . . . . . . . . . . 265
Location . . . . . . . . . . . . . . . . . . . . . . . . . . . 228
Replacing the battery . . . . . . . . . . . . . . . . 231
Win ter operation . . . . . . . . . . . . . . . . . . . . 228
Working on the battery . . . . . . . . . . . . . . . 228
Before driving . . . . . . . . . . . . . . . . . . . . . . . . 126
Belt tensioners . . . . . . . . . . . . . . . . . . . . . . . 141
Blended gasoline . . . . . . . . . . . . . . . . . . . . . 210
Blower (four-zone automatic climate control) .7.2
Blower (three-zone climate control) . . . . . . . 69
Booster seats
Brake fluid 1
7 6
Changing the brake fluid . . . . . . . . . . . . . . 227
Checking the brake fluid level . . . . . . . . . . 227
Brakes Indicator light . . . . . . . . . . . . . . . . . . . . . . . 21
Index
Brake system
Anti- lock braking system . . . . . . . . . . . . . . . 19
Brake booster . . . . . . . . . . . . . . . . . . . . . . . 191
Brake fluid . . . . . . . . . . . . . . . . . . . . . . . . . 227
Br ake fluid specifications for refill and re­
placement . . . . . . . . . . . . . . . . . . . . . . . . . 22 7
Brake power ass ist unit . . . . . . . . . . . . . . . 190
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 190
Electromechanical parking brake . . . . . . . . 78
Fluid reservo ir . . . . . . . . . . . . . . . . . . . . . . 227
Warning/indicator lights . . . . . . . . . . . . . . . 14
Worn brake pads symbo l . . . . . . . . . . . . . . . 19
Braking Brake assist . . . . . . . . . . . . . . . . . . . . . . . . 188
Emergency braking funct ion . . . . . . . . . . . . 79
Braking guard . . . . . . . . . . . . . . . . . . . . . . . . . 8S
Messages . . . . . . . . . . . . . . . . . . . . . . . . . . . 92
Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . 92
Break-in pe riod
Brake pads . . . . . . . . . . . . . . . . . . . . . . . . . 190
Tires
Breaking in New tires
C
196
196
240
California Proposition 65 Warning . . . . . . . 219
Battery specific . . . . . . . . . . . . . . . . . . . . . 229
Capacities . . . . . . . . . . . . . . . . . . . . . . . . . . . 272
AdBlue . . . . . . . . . . . . . . . . . . . . . . . . . . . . 214
Engine oil 220
Car carrier Transporting your vehicle . . . . . . . . . . . . . 268
Care
... .... .. .. .. ............. .... .. 205
Cargo area . . . . . . . . . . . . . . . . . . . . . . . . . . . 132
Cargo net . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
Catalytic converter . . . . . . . . . . . . . . . . . . . . 197
Center armrest Cockpit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
Central locking . . . . . . . . . . . . . . . . . . . . . . . . 31
Emergency locking . . . . . . . . . . . . . . . . . . . . 36
Power windows . . . . . . . . . . . . . . . . . . . . . . 40
Setting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
Sunroof... .. .. .. .. ........... .... .. . 40
Cer tifica tion . . . . . . . . . . . . . . . . . . . . . . . . . 277
Changing engine oil . . . . . . . . . . . . . . . . . . . 223
279